Efeito da variação da carga orgânica volumétrica natural na produção de biogás a partir de dejeto suíno em diferentes tempos de retenção hidráulica / The effect of organic loading rate's natural variation on the biogas yields from swine manure digestion at different hydraulic retention time

RESUMO O estudo sobre reatores anaeróbios em laboratório prioriza o controle de determinados parâmetros que são de difícil controle em campo, o que dificulta o processo de scale-up. Entre os parâmetros está a carga orgânica volumétrica (COV). No caso do dejeto suíno, esse parâmetro pode sofrer alterações diárias em função das condições climáticas, das mudanças no manejo, da alimentação dos animais, entre outros. A fim de verificar o impacto dessa variação na produtividade de biogás, foi analisado o comportamento de um reator anaeróbio de mistura completa (CSTR) em dois diferentes tempos de retenção hidráulica (TRHs) - 20 e 30 dias - durante um período total de 180 dias. Os resultados demonstraram que a elevação da COV resulta em piora da eficiência de tratamento, bem como na produção de biogás. O ensaio com TRH de 20 dias obteve uma melhor resposta às alterações de carga orgânica.

ABSTRACT The study of anaerobic digesters at laboratory focuses on the control of certain parameters that are not so easy to control in the field, which makes it difficult to process scale-up. One example is the Organic Loading Rate. To swine manure, this parameter can change daily due to weather conditions, management practices, feeding and others. In order to verify the impact of this fluctuation on biogas yield, the behavior of a CSTR reactor was analyzed in two different Hydraulic Retention Times (20 and 30 days) for a total period of 180 days. The result demonstrated that the increase of OLR result in a decrease of treatment efficiency as well as biogas yields. The study with HRT of 20 days had a better response to changes in organic load.

Biomethane production from vinasse in upflow anaerobic sludge blanket reactors inoculated with granular sludge

ABSTRACT The main objective of this study was to evaluate the anaerobic conversion of vinasse into biomethane with gradual increase in organic loading rate (OLR) in two upflow anaerobic sludge blanket (UASB) reactors, R1 and R2, with volumes of 40.5 and 21.5 L in the mesophilic temperature range. The UASB reactors were operated for 230 days with a hydraulic detection time (HDT) of 2.8 d (R1) and 2.8-1.8 d (R2). The OLR values applied in the reactors were 0.2-7.5 g totalCOD (L d)−1 in R1 and 0.2-11.5 g totalCOD (L d)−1 in R2. The average total chemical oxygen demand (totalCOD) removal efficiencies ranged from 49% to 82% and the average conversion efficiencies of the removed totalCOD into methane were 48-58% in R1 and 39-65% in R2. The effluent recirculation was used for an OLR above 6 g totalCOD (L d)−1 in R1 and 8 gtotalCOD (L d)−1 in R2 and was able to maintain the pH of the influent in R1 and R2 in the range from 6.5 to 6.8. However, this caused a decrease for 53-39% in the conversion efficiency of the removed totalCOD into methane in R2 because of the increase in the recalcitrant COD in the influent. The largest methane yield values were 0.181 and 0.185 (L) CH4 (gtotal COD removed)−1 in R1 and R2, respectively. These values were attained after 140 days of operation with an OLR of 5.0-7.5 g totalCOD (L d)−1 and total COD removal efficiencies around 70 and 80%.

Análise comparativa dos efeitos da carga orgânica e do tempo de detenção hidráulica na digestão anaeróbia mesofílica de lodo adensado de estação de tratamento de esgoto / Comparison of organic loading rate and hydraulic retention time effects on the mesophilic anaerobic digestion of thickened waste activated sludge

RESUMO Esta pesquisa comparou o desempenho de um digestor anaeróbio de lodo sob diferentes estratégias operacionais. Foi avaliada a influência do aumento da carga orgânica volumétrica (COV) (OP I) e o efeito da redução do tempo de detenção hidráulica (TDH) (OP II e OP III) no processo anaeróbio. As cargas aplicadas variaram entre 0,5 e 4,5 kgSV.m-3.d-1 e o TDH foi reduzido de 15 a 5 dias. Produção de gás metano, degradação do material orgânico e a diversidade microbiana foram utilizadas para medição e comparação do desempenho do processo. Foram necessários períodos de aclimatação a cada nova COV aplicada o que levou às instabilidades na remoção de SV e DQO do lodo. A operação com TDH entre 7 e 5 dias apresentou as maiores eficiências de remoção de SV, superiores a 70%, o que influenciou positivamente na estabilidade do processo. As COV aplicadas de 2,5 e 3,5 kgSV.m-3.d-1 resultaram nas maiores produções de metano durante a OP I. Para TDH inferiores a sete dias a produção de CH4 foi prejudicada apesar da existência de microorganismos metanogênicos atuantes no digestor. Comparativamente, a estratégia de redução do TDH resultou em um melhor desempenho do sistema que a fixação da COV. Quanto menor o TDH aplicado, melhor os resultados obtidos na operação do digestor, sugerindo que a eficiência do processo é otimizada em sistemas de alta carga com operação em baixos tempos de detenção hidráulica.

ABSTRACT This study compared the performance of a pilot anaerobic sludge digester under different operating strategies. The influence of increasing organic loading rate - OLR (OP I) and the effect of hydraulic retention time - HRT reduction (OP II and OP III) in anaerobic process were evaluated. The applied loads ranged between 0.5 and 4.5 kgSV.m-3.d-1; HRT was reduced from 15 to 5 days. Production of methane, organic matter degradation and microbial diversity were used to measure and compare the system´s performance. Acclimation periods were taken for each new OLR applied, leading to instabilities in sludge VS and COD removals. The experimental time with HRT between 7 and 5 days showed the highest VS efficiency removals (higher than 70%), which positively influenced process stability. The applied OLR of 2.5 and 3.5 kgVS.m-3.d-1 resulted in higher yields of methane during OP I. CH4 production showed impaired with HRT lower than 7 days, although it was observed active methanogenic microorganisms in the digester. Comparatively, HRT reduction resulted in a better system performance than the increasing OLR approach. The lower HRT applied, the better the results obtained in the operation of the digester, suggesting that the process efficiency is optimized with high load operation at low hydraulic retention times.

Reator anaeróbio compartimentado para o tratamento de águas residuárias de suinocultura / Anaerobic baffled reactor for treatment of swine wastewater

A poluição da água e do solo causada pela suinocultura provoca impactos ambientais severos nas regiões produtoras. Uma alternativa eficiente para atenuar esse problema pode ser a utilização de reatores anaeróbios de alta taxa. Neste trabalho, avaliou-se o efeito das águas residuárias de suinocultura com concentrações de sólidos suspensos totais em torno de 6.000 mg.L−1 no desempenho do reator anaeróbio compartimentado, com três câmaras. O volume da primeira câmara foi de 210 L e da segunda e terceira de 160 L. O reator anaeróbio compartimentado foi submetido a tempos de detenção hidráulica de 56, 28 e 18 horas e a cargas orgânicas volumétricas de 5,0 a 10,1 g DQOtotal (L.d)−1. As maiores remoções de demanda química de oxigênio total, de 42 a 68%, e das produções volumétricas de metano, de 0,261 a 0,454 L CH4 (L reator d)−1, ocorreram na segunda câmara.

Water and soil pollution caused by the waste from the swine production causes severe environmental impacts in producing areas. An efficient alternative to reduce these impacts can be the use of high-rate anaerobic reactors. In this work, it was evaluated the effect of the swine wastewater with total suspended solids concentrations around 6.000 mg.L−1 in the anaerobic baffled reactor with three compartments. The volume of the first compartment was 210 L and of the second and third ones of 160 L. The anaerobic baffled reactor was submitted at hydraulic detention times of 56, 28 and 18 hours and to organic load rates of 5.0 to 10.1 g total COD (L.d)−1. The highest total COD removals, of 42 to 68%, and volumetric methane productions, of 0.261 to 0.454 L CH4 (L reactor d)−1, occurred in the second compartment.

Effect of temperature on the anaerobic digestion of palm oil mill effluent

Two continuous stirred tank reactors (CSTRs) each fed with palm oil mill effluent (POME), operated at 37ºC and 55ºC, respectively, were investigated for their performance under varies organic loading rates (OLRs). The 37ºC reactor operated successfully at a maximum OLR of 12.25 g[COD]/L/day and a hydraulic retention time (HRT) of 7 days. The 55ºC reactor operated successfully at the higher loading rate of 17.01 g[COD]/L/day and had a HRT of 5 days. The 37ºC reactor achieved a 71.10% reduction of chemical oxygen demand (COD), a biogas production rate of 3.73 L of gas/L[reactor]/day containing 71.04% methane, whereas the 55ºC reactor achieved a 70.32% reduction of COD, a biogas production rate of 4.66 L of gas/L[reactor]/day containing 69.53% methane. An OLR of 9.68 g[COD]/L/day, at a HRT of 7 days, was used to study the effects of changing the temperature by 3ºC increments. The reactor processes were reasonably stable during the increase from 37ºC to 43ºC and the decrease from 55ºC to 43ºC. When the temperature was increased from 37ºC to 46ºC, the total volatile fatty acid (TVFA) concentration and biogas production was 2,059 mg as acetic acid/L and 1.49 L of gas/L[reactor]/day at day 56, respectively. When the temperature was reduced from 55ºC to 40ºC, the TVFA concentration and biogas production was 2,368 mg as acetic acid/L and 2.01 L of gas/L[reactor]/day at day 102, respectively. By first reducing the OLR to 4.20 g[COD]/L/day then slowly increasing the OLR back to 9.68 g[COD]/L/day, both reactors were restored to stable conditions at 49ºC and 37ºC respectively. The initial 37ºC reactor became fully acclimatized at 55ºC with an efficiency similar to that when operated at the initial 37ºC whereas the 55ºC reactor also achieved stability at 37ºC but with a lower efficiency.