Influence of Pasteurisation (Conventional vs. Radiofrequency) and Chill Storage on Retention of Ascorbic Acid, Tocopherol and Carotenoids in Salmorejo.

Salmorejo, a Mediterranean tomato-oil puree, is considered a dietary source of antioxidant vitamins C and E and carotenoids lycopene and ß-carotene, the latter endowed with provitamin A activity. However, these antioxidants can be degraded in oxidation reactions catalysed or not by enzymes during pasteurisation and storage treatments used to stabilise the salmorejo before consumption. Due to its better penetration, the use of dielectric heating by radiofrequency (RF) may improve results of pasteurisation in this product. The objective was to assess the effects of pasteurisation temperature (70-100 °C, at 5 °C intervals) and storage time (0-5 months, at one-month intervals) on levels of ascorbic acid, α-tocopherol and carotenoids and antioxidant capacity (AC) in salmorejo pasteurised (over 10 s) by conventional (CH) or RF continuous heating. Two successive experiments were conducted to select an adequate pasteurisation temperature for use in the shelf-life study. Pasteurisation upon tested conditions allows a good retention of salmorejo antioxidants. Either CH or RF pasteurisers can be used with similar results. Vitamin C (L-ascorbic + dehydroascorbic acids) was more abundant (15-19 mg 100 g-1) than carotenoids (0.9-2.6 mg 100 g-1) (all-trans + cis lycopene and ß-carotene) and α-tocopherol (0.8-1.2 mg 100 g-1) in the pasteurised product. Using excessively low temperatures (70 °C) resulted in partial losses of the three antioxidants, possibly due to oxidase residual activities. Intensifying thermal treatment improved this issue with minor losses of the thermolabile vitamin C and increased carotenoid content. Using a suitable temperature (80 °C) did not prevent most vitamin C from being degraded by the first month, while α-tocopherol, and, to a lesser extent, carotenoids, showed good retention levels during shelf life under refrigeration. Vitamins C and E and carotenoids, either by degradation, regeneration or releasing, likely contribute to the AC in salmorejo. Phenolic antioxidant response, radical-scavenging activities and redox potential values confirmed this finding. The pasteurised-chilled salmorejo shows good antioxidant properties with potential health implications, a positive nutritional aspect for consumers of this tomato-oil homogenate. The losses of antioxidants and AC due to pasteurization would be of little relevance compared to the losses accumulated during shelf life.

Factors Limiting Shelf Life of a Tomato-Oil Homogenate (Salmorejo) Pasteurised via Conventional and Radiofrequency Continuous Heating and Packed in Polyethylene Bottles.

Salmorejo is a tomato-oil cold puree commercialized as a "fresh-like" product requiring mild pasteurisation and chill storage to reach a suitable shelf lifetime. The objective of this study was to study the factors which limit the shelf life of salmorejo pasteurised via conventional or radiofrequency continuous heating, packed in high-density polyethylene bottles, and kept at refrigeration. The pasteurised-chilled salmorejo reached a long shelf life (4 months) compared to that of pasteurised tomato juices or purees. Mesophilic and pathogenic bacteria were easily inhibited in this acidic product. Salmorejo mainly showed oxidative and subsequent sensory changes. Initial enzyme oxidation was associated with some adverse effects (loss of vitamin C and lipid oxidation) at the first month, although there were no sensory implications. Salmorejo remained stable at the physicochemical and sensory levels for the following 3 months, though colour and viscosity changes could be measured with instruments. Between the fourth and fifth month, salmorejo showed clear signs of deterioration, including changes in appearance (slight browning and loss of smooth surface), odour/flavour (loss of freshness and homogenisation), and consistency (thinning trend). The shelf life of salmorejo is limited by long-term oxidative deterioration and their sensory implications.

Validation of Pasteurisation Temperatures for a Tomato-Oil Homogenate (salmorejo) Processed by Radiofrequency or Conventional Continuous Heating.

Salmorejo is a viscous homogenate based on tomato, olive oil and breadcrumbs commercialised as a "fresh-like" pasteurised-chilled purée. Due to its penetration, dielectric heating by radiofrequency (RF) might improve pasteurisation results of conventional heating (CH). The objective was to validate the pasteurisation temperature (70-100 °C, at 5 °C intervals) for salmorejo processed by RF (operating at 27.12 MHz for 9.08 s) or conventional (for 10.9 s) continuous heating. The main heat-induced changes include: orangeness, flavour homogenisation, loss of freshness, thickening, loss of vitamin C and lipid oxidation. Both CH and RF equivalent treatments allowed a strong reduction of total and sporulated mesophilic microorganisms and an adequate inhibition of the pectin methylesterase, peroxidase and, to a lesser extent, polyphenol oxidase but did not inhibit the polygalacturonase enzyme. Pasteurisation at 80 °C provided a good equilibrium in levels of microbiological and enzymatic inhibition and thermal damage to the product. Increasing this temperature does not improve enzyme inactivation levels and salmorejo may become overheated. A "fresh-like" good-quality salmorejo can be obtained using either conventional or radiofrequency pasteurisers.

Polyphenol Extracts from Sage (Salvia lavandulifolia Vahl) By-Products as Natural Antioxidants for Pasteurised Chilled Yoghurt Sauce.

Sage by-product extracts (SE) are a valuable source of phenolic acids and flavonoids for food applications. The objective was to test two SE as antioxidants in pasteurised chilled yoghurt sauces against oxidation. Two SE of different polyphenol total content and profile were selected: SE38 (37.6 mg/g) and SE70 (69.8 mg/g), with salvianic and rosmarinic acid as the main polyphenols, respectively. Four experimental low-fat yoghurt sauces were formulated: untreated; SE70/2 (0.16 g/kg); SE38 (0.3 g/kg); and SE70 (0.3 g/kg). The stability of phenolic acids, microbiological quality (mesophilic bacteria, moulds and yeasts, and L. monocytogenes), and oxidative stability (lipids, colour, and pH) were studied in the sauces after pasteurisation at 70 °C for 30 min (day 0) and stored by refrigeration (day 42). Pasteurisation and further chilling ensured the microbiological quality and inhibition of microbial growth could not be evidenced, although SE70 showed some antimicrobial potential. Both SE showed good properties as antioxidants for yoghurt sauces. This finding was based on two results: (i) their main polyphenols, salvianic and rosmarinic acids, resisted to mild pasteurisation and remained quite stable during shelf life; and (ii) SE improved radical scavenging capacity, delayed primary and secondary lipid oxidation, and increased colour stability, contributing to sauce stabilisation. SE38 had a better antioxidant profile than SE70; therefore, the selection criteria for SE should be based on both quantity and type of polyphenols. Due to their stability and antioxidant properties, sage polyphenols can be used as natural antioxidants for clean-label yoghurt sauces.

Revalorisation of Sage (Salvia lavandulifolia Vahl) By-Product Extracts as a Source of Polyphenol Antioxidants for Novel Jelly Candies.

Sage (Salvia lavandulifolia Vahl) aqueous extracts (SE) obtained from distillation by-products were assessed as antioxidants for nutritionally enhanced jelly candies. Two experimental SEs with a different content of phenolic acids and flavonoids were tested: (i) SE38 (37.6 mg/g) and (ii) SE70 (69.8 mg/g), with salvianic and rosmarinic acids as main polyphenols, respectively. Flavour alteration, stability of sage polyphenols, physical quality traits and antioxidant capacity (AC) were studied in strawberry candies formulated without sugars and enriched with SEs at 0.25, 0.50 and 0.75 g/kg. Despite their different quantitative composition, SE38 and SE70 provided similar antioxidant properties, which were dose dependent. Salvianic and rosmarinic acids were stable without degrading to candy processing (up to 80 °C), keeping their antioxidant potential. There were no relevant differences in flavour or physical traits (pH, °Brix and CIELab colour) between untreated and SE-enriched strawberry candies. The addition of 0.75 g SE/kg resulted in relevant increases of candy AC: (i) from 30 to 38 mg GAE/100 g (total phenolics); (ii) from 10 to 17 mg TE/100 g (DPPH• radical scavenging assay); (iii) from 5 to 13 mg TE/100 g (ABTS·+ radical scavenging assay); (iv) from 84 to 163 µmol Fe2+/100 g (FRAP capacity) and (v) from to 75 to 83% (inhibition of deoxyribose damage). Sage distillation by-products can be revalorised as a source of natural antioxidants to produce healthier candies.

Mineral Content (Essential and Toxic Elements) of Squid Flesh Is Affected by Maceration with Sodium Salts and Vacuum-Cooking.

Maceration with sodium salts is applied to irmprove water holding capacity in squid-based products. The aim of this work was to determine how the mineral content of squid flesh is affected by maceration and further vacuum-cooking. Atlantic squids (Loligo vulgaris) from two fisheries (FAO areas No. 47 and 34) were sampled. Macrominerals (g/100 g) present in raw flesh were Na, Mg, P, S, K and Ca, while microminerals accounting for >1 mg/kg were Zn, Si, Sr, Fe, Cu, Al and Mn. As a result of maceration (3 + 1.5% w: w NaCl+ Na citrate) and vacuum-cooking (at 65 °C for 20 min), some squid minerals was removed. The levels of Cd and As were reduced by half, while Na content increased from 0.28 to 0.49 g/100 g. Maceration with sodium salts generally led to minerals leaching (except for Na) with the medium. Further cooking produced additional losses of most of the minerals present in macerated squid (except Pb and Cd). Squid microminerals were hardly removed with the cooking juice. The consumption of macerated-cooked squid covered > 10% of the recommended dietary intake for Na, P, Zn, Mg and Mn, while health risks were almost negligible and mainly concerned Cd (up to 14% of the probable tolerable weekly intake). The combination of both treatments involves certain loss of most of the essential minerals but also contributes to reducing toxicological risks related to mineral intake through squid products.

Assessment of a Diterpene-Rich Rosemary (Rosmarinus officinalis L.) Extract as a Natural Antioxidant for Salmon Pâté Formulated with Linseed.

The use of natural plant extracts with standardised antioxidant properties is a growing strategy to stabilise food products. The use of a rosemary lipophilic extract (RLE), obtained from the by-product of high-yield selected plants and rich in polyphenols (334 mg/g, with diterpenes such as carnosic acid and carnosol as main compounds), is here proposed. Four RLE doses (0, 0.21, 0.42 and 0.63 g/kg) were tested in a salmon pâté formulated with sunflower oil and linseed, which was pasteurised (70 °C for 30 min) and subjected to storage at 4 °C and 600 lux for 42 days. Rosemary diterpenes resisted pasteurisation without degrading and showed antioxidant activities during the shelf-life of pasteurised pâté. RLE addition led to increased peroxide value (from 3.9 to 5.4 meq O2/kg), but inhibited formation of secondary oxidised lipids such as malondialdehyde (from 1.55 to 0.89 mg/g) and cholesterol oxidation products (from 286 to 102 µg/100 g) and avoided discolouration (slight brownness) in the refrigerated pâté. However, this did not entail relevant changes in fatty acid content or in the abundance of volatile organic compounds from oxidised lipids. Increasing the RLE dose only improved its antioxidant efficacy for some oxidation indexes. Thus, the oxidative deterioration of these types of fish emulsion can be naturally controlled with rosemary extracts rich in diterpenes.

Rosemary Extracts Improved the Antioxidant Status of Low-Fat Yoghurt Sauces Enriched with Inulin.

Yoghurt sauces are considered fatty products which are quite susceptible to oxidation and must be stabilised using antioxidants. Novel formulations for yoghurt sauces often involve replacement of fat with dietary fibres and use of natural preservatives. The aim of the present research was to design healthier formulations for yoghurt sauces based on the replacement of sunflower oil (SO) with chicory inulin (IN) and the use of rosemary extracts (RE) as natural antioxidants. Different sauces were developed by adding IN at 2 and 5% w: w and/or 300 mg/kg lipo- and/or water-soluble rosemary extracts (RLE and/or RWE) containing 120 and 146 mg polyphenols per g extract, respectively. Nutritional value (proximate composition and caloric contribution), some physical properties (pH and CIELab colour) and antioxidant status (deoxyribose, DPPH radical scavenging, Rancimat, lipid peroxidation and linoleic acid assays) were assessed in the sauces. Replacement of SO with IN (5%) reduced fat content by 30%, roughly 15% low calories, thereby obtaining healthier sauces. As expected, the RLE was more effective than the RWE in improving antioxidant activity in lipidic environment. Using RLE enhanced the antioxidant capacity of lipid peroxidation by 44%. In the Rancimat test, this increased the oxidative protection of the sauce made with and without IN (5%) by around 20% or 45%, respectively. Similarly, using RLE doubled protection against linoleic acid oxidation. Application of IN in yoghurt sauce has nutritional (replacement of lipids with dietary fibre) and technological interest (foaming agent) and can be combined with RE of high polyphenol content as a potential functional ingredient capable of stabilising the sauces against oxidation.

Combined Effect of Temperature and Oil and Salt Contents on the Variation of Dielectric Properties of a Tomato-Based Homogenate.

Tomato-based processed foods are a key component of modern diets, usually combined with salt and olive oil in different ratios. For the design of radiofrequency (RF) and microwave (MW) heating processes of tomato-based products, it is of importance to know how the content of both ingredients will affect their dielectric properties. Three concentrations of olive oil and salt were studied in a tomato homogenate in triplicate. The dielectric properties were measured from 10 to 3000 MHz and from 10 to 90 °C. Interaction effects were studied using a general linear model. At RF frequencies, the dielectric constant decreased with increasing temperature in samples without added salt, but this tendency was reversed in samples with added salt. The addition of salt and oil increased the frequency at which this reversion occurred. At MW frequencies, the dielectric constant decreased with increasing temperature, salt, and oil content. The loss factor increased with increasing salt content and temperature, except in samples without added salt at 2450 MHz. Penetration depth decreased with increasing frequency and loss factor. Salt and oil contents have a significant effect on the dielectric properties of tomato homogenates and must be considered for the design of dielectric heating processes.

Contribution of Green Propolis to the Antioxidant, Physical, and Sensory Properties of Fruity Jelly Candies Made with Sugars or Fructans.

Enrichment with phenolic compounds is proposed as a strategy to obtain more stable and healthier candy products. A green propolis ethanolic dry extract (PEE) from Braccharis dracunculifolia (Brazilian Alecrim-do Campo) was assessed as an antioxidant in jelly candies. Three levels (0, 0.01, and 0.02% w/w) of PEE were tested in jelly candies alternatively made with two carbohydrate bases (sugars or fructans) and three fruity dyes and flavours (menthe, orange, or strawberry). Propolis polyphenol content (identified by HPLC-MS and quantified by HPLC-DAD/UV-Vis), antioxidant capacity (total phenolics and radical scavenging activity), physical properties (moisture, pH, CIELab colour, and texture profile analysis), and flavour were studied in candies. PEE was rich in polyphenols (>8.7%), including several prenylated p-coumaric, caffeoylquinic and diterpenic acids, and flavonoids, with Artepillin-C (3.4%) as the main bioactive compound. The incorporation of PEE into the hot liquor at 80 °C for 5 min before moulding allowed a good retention of propolis polyphenols in the final product (recovery percentages of up to 97.4% for Artepillin-C). Jelly candies made with sugars or dietetic fructans have poor antioxidant properties, which depend on the dyes and flavours used. Using PEE (at 0.02%) strongly improved the antioxidant capacity (relative increases of up to 465%) of candies without altering the pH, colour, or texture, although off-flavour may appear. Propolis, due to its good antioxidant properties, has potential for use as a functional ingredient in jelly candies.

Assessment of Rosemary (Rosmarinus officinalis L.) Extract as Antioxidant in Jelly Candies Made with Fructan Fibres and Stevia.

Enrichment with rosemary antioxidants is proposed as a possible strategy to obtain healthier jelly candies. Two aqueous rosemary extracts (RE) containing 73.9 (RE74) and 145.6 (RE146) mg polyphenols per g fresh weight were assessed as antioxidants in jelly candies based on fructooligosaccharides, inulin and stevia. Up to 15 phenolic acids, flavonoids and diterpenes were determined in the extracts, with rosmarinic acid as the main active compound. Sensory tolerance, physical properties, rosmarinic acid recovery, polyphenol content, and antioxidant capacity were determined in jelly candies. The threshold of sensory detection was established at 0.26 g RE146/kg of raw candy, below which rosemary off-flavours were avoided without altering pH, brix, texture, CIELab colour, and consumer acceptance. Adding 0.26 g RE146 per kg increased (p < 0.001) polyphenol content from 197 to 411 µg GAE/g and the antioxidant capacity from 1.77 to 4.14 µmol Trolox/g. Rosemary polyphenols resulted in being resistant to cooking, acted as secondary antioxidants and showed good interaction with the other jelly ingredients. Aqueous extracts from rosemary distillation by-products can be incorporated at acceptable levels to jelly candy formulations leading to higher oxidative stability and an increased content of dietary polyphenols.

The Combined Effect of Mediterranean Shrubland Pasture and the Dietary Administration of Sage By-Products on the Antioxidant Status of Segureña Ewes and Lambs.

The objective of this study was to determine if the combined effect of ewe grazing and the incorporation of sage by-products in the lamb feed enhances the Segureña ewe and lamb antioxidant status. For that, the endogenous (related to blood antioxidant enzymes) and exogenous (plasma antioxidant activity) antioxidant systems of ewes and lambs were studied at the physiological stages of lactation, after weaning and at the end of the fattening period. Major results indicated that grazing improved the enzymatic antioxidant defense of ewes during the stressful period of lamb weaning, and also, the antioxidant status of the ewe plasma at both physiological stages: lactation and after lamb weaning. With regards to the lambs, ewe grazing stimulated the antioxidant enzymatic defense during lactation, but not the antioxidant capacity of the plasma. At the end of the fattening period, the inclusion of sage by-products in the lamb diet (10% w/w) enhanced both the enzymatic cascade and antioxidant capacity of the lamb plasma. The antioxidant capacity of the lamb meat was also studied and the benefits of sage were detected in samples from the deltoideus muscle. Thus, Mediterranean grazing stimulated the antioxidant defense in ewes, while the inclusion of sage by-products in the lamb diets enhanced the antioxidant status of both blood and meat.

Incorporating rosemary diterpenes in lamb diet to improve microbial quality of meat packed in different environments.

The dietary use of phytochemicals may contribute to improving lamb meat preservation under different packing atmospheres. The objective was to test the preservative potential of a dietary rosemary extract (RE) containing carnosic acid and carnosol (at 1:1 w:w) in chilled lamb patties packed in air, vacuum and 70/30 O2 /CO2 modified atmosphere. Three experimental diets, (C) control, (RE) C plus 600 mg RE/kg feed and (E) C plus 600 mg vitamin E/kg, were given to fattening lambs. Unlike the C- and E-diets, the RE-diet had a double antimicrobial and antioxidant effect on the lamb patties packed in all the environments studied. The RE-diet inhibited total viable and lactic acid bacteria and Enterobacteriaceae, but not Brochothrix thermosphacta and Pseudomonas spp. and also improved oxidative stability (measured as CIE Lab color and thiobarbituric reagent substances), appearance and odor. The E-diet had a better antioxidant effect than the RE-diet but had no antimicrobial effects. Escherichia coli and Salmonella spp. were not detected. The dietary use of RE was most suitable for preserving vacuum-packed meat, which is more exposed to spoilage by anaerobic bacteria, while the use of dietary vitamin E allowed better control of oxidation in the meat packed in a bacteriostatic and oxidizing environment.

Stabilisation of red fruit-based smoothies by high-pressure processing. Part II: effects on sensory quality and selected nutrients.

BACKGROUND: Non-thermal pasteurisation by high-pressure processing (HPP) is increasingly replacing thermal processing (TP) to maintain the properties of fresh fruit products. The resulting products need to be validated from a sensory and nutritional standpoint. The objective was to assess a mild HPP treatment to stabilise red fruit-based smoothies in a wide (sensory quality and major nutrients) study. RESULTS: HPP (350 MPa/ 10 °C/ 5 min) provided 'fresh-like' smoothies, free of cooked-fruit flavours, for at least 14 days at 4 °C, although their sensory stability was low compared with the TP-smoothies (85 °C/ 7 min). In HPP-smoothies, the loss of fresh fruit flavour and reduced sliminess were the clearest signs of sensory deterioration during storage. Furthermore, HPP permitted the higher initial retention of vitamin C, although this vitamin and, to a lesser extent, total phenols, had a higher degradation rate during storage. The content of sugar present was not affected by either processing treatment. CONCLUSION: Mild HPP treatment did not alter the sensory and nutritional properties of smoothies. The sensory and nutritional losses during storage were less than might be expected, probably due to the high antioxidant content and the natural turbidity provided by red fruits. © 2016 Society of Chemical Industry.

Stabilization of red fruit-based smoothies by high-pressure processing. Part A. Effects on microbial growth, enzyme activity, antioxidant capacity and physical stability.

BACKGROUND: Non-thermal pasteurization by high-pressure processing (HPP) is increasingly replacing thermal processing (TP) to maintain the properties of fresh fruit products. However, most of the research on HPP-fruit products only partially addresses fruit-pressure interaction, which limits its practical interest. The objective of this study was to assess the use of a mild HPP treatment to stabilize red fruit-based smoothies (microbial, enzymatic, oxidative and physical stability). RESULTS: HPP (350 MPa/10 °C/5 min) was slightly less effective than TP (85 °C/7 min) in inactivating microbes (mesophilic and psychrophilic bacteria, coliforms, yeasts and moulds) in smoothies kept at 4 °C for up to 28 days. The main limitation of using HPP was its low efficacy in inactivating oxidative (polyphenol oxidase and peroxidase) and hydrolytic (pectin methyl esterase) enzymes. Data on antioxidant status, colour parameters, browning index, transmittance, turbidity and viscosity confirmed that the HPP-smoothies have a greater tendency towards oxidation and clarification, which might lead to undesirable sensory and nutritional changes (see Part B). CONCLUSION: The microbial quality of smoothies was adequately controlled by mild HPP treatment without affecting their physical-chemical characteristics; however, oxidative and hydrolytic enzymes are highly pressure-resistant, which suggests that additional strategies should be used to stabilize smoothies. © 2016 Society of Chemical Industry.

Relationship between antioxidant status and oxidative stability in lamb meat reinforced with dietary rosemary diterpenes.

The relationship between the antioxidant status of fresh meat and oxidative stability of chilled-packed meat obtained from lambs fed on a diet supplemented with two different doses of a rosemary extract containing carnosic acid and carnosol was studied. The incorporation of rosemary extract in the lamb diet led to the deposition of functional levels of the diterpenic metabolite C19H22O3 in meat, which improved its stability against oxidation. The antioxidant status could be assessed through both the radical scavenging capacity (DPPH and TEAC) and the ferric reducing antioxidant power (FRAP). In general, antioxidant status values correlated better (P < 0.05) with the changes in CIELAB colour, malondialdehyde and sensory scoring than with the changes in hexanal and protein carboxylation measured in the lamb cuts kept under protective atmosphere for up to 14 days. The FRAP and DPPH assays were more suitable than the TEAC assay for predicting meat oxidation and any resulting discolouration and rancidity.

Antioxidant and antimicrobial effects of dietary supplementation with rosemary diterpenes (carnosic acid and carnosol) vs vitamin E on lamb meat packed under protective atmosphere.

The antioxidant and antimicrobial effects on lamb meat of the dietary use of rosemary diterpenes and vitamin E were compared. Thirty fattening lambs were assigned to three diets: (C) control; (R) C plus 600 mg kg(-1) carnosic acid and carnosol at 1:1 w:w; or (E) C plus 600 mg kg(-1) α-tocopherol. The deposition of the dietary supplements in the muscle was determined. Microbial quality (total viable counts, Lactic Acid Bacteria, Enterobacteriaceae, Escherichia coli and Salmonella spp), oxidative stability (CIELab color, malondialdehyde and total carbonyls) and sensory attributes (appearance and odor) were determined in loin stored at 2°C under 70% O2/30% CO2 atmosphere. Microbial quality was ensured by packaging and chilling. The E-diet was more effective (P ≤ 0.05) than the R-diet in preventing meat oxidation, although the latter had antimicrobial effects on meat. The shelf life of lamb (assessed as the loss of freshness) could be increased by 5 (R-diet) or 10 (E-diet) days.

Improving the sensory and oxidative stability of cooked and chill-stored lamb using dietary rosemary diterpenes.

Two dietary rosemary extracts (DREs) containing diterpenes (carnosic acid and carnosol at 1:1 and 2:1 w:w) were tested in fattening lambs to stabilize the sensory quality of cooked and chill-stored patties. A total of 63 lambs were fed freely for 80 ± 5 d with a basal diet supplemented or not with DRE. Minced leg meat from each lamb was used to make patty batches. The patties were cooked at 72 ºC for 2 min, aerobically packed, kept at 2 ºC for up to 4 d and then reheated. Sensory traits (color, odor, flavor, and texture), CIELab color, and lipid oxidation (assessed as TBARS) were determined. In a first experiment, the lamb diet was supplemented with 600 mg of 1:1-DRE or 2:1-DRE kg(-1) feed. The 1:1-DRE diet delayed discoloration, flavor deterioration, and rancidity, while the 2:1-DRE diet was ineffective in this respect. In a second experiment, 4 supplementation levels of 1:1-DRE (0, 200, 400, and 600 mg kg(-1) feed) were compared. Flavor deterioration was delayed when the lamb diet was supplemented with at least 400 mg 1:1-DRE kg(-1) feed. The effects of the diet on the odor, flavor, and color were corroborated by differences in TBARS and CIELab. The results obtained suggest that rosemary diterpenes and/or their active secondary compounds deposited in muscle can act as endogenous antioxidants in cooked lamb. The carnosol intake seems crucial in the antioxidant actions achieved through DRE. The use of rosemary antioxidants in animal feeding would allow meat-based dishes to be preserved longer without adding preservatives.

Relevance of the carnosic acid/carnosol ratio for the level of rosemary diterpene transfer and for improving lamb meat antioxidant status.

The aim of the present work was to evaluate whether the relation between the concentrations of the two major diterpenes present in two typified rosemary extracts affects their levels of deposition and antioxidant capacity in different lamb tissues. The composition of the extracts expressed as percentage of weight/weight was 1:1 (14-16)% and 2:1 (25-11)% (carnosic acid-carnosol), respectively. Thirty weaned lambs were assigned randomly to three homogeneous groups. One group was fed a basal diet as a control and the diets of the other two were enriched with rosemary extracts 1:1 and 2:1, respectively. HPLC-ESI-MS/TOF identified a metabolite (C19H22O3) described for the first time in lamb tissues, along with carnosol, carnosic acid, rosmanol and carnosol-p-quinone. The results obtained corroborate the importance of the presence of carnosol in the dietary administration of rosemary extract as a way of improving the stability of the diterpene fraction during feed manufacturing and the level of deposition and antioxidant efficacy of diterpenes after ruminal fermentation.

Shelf life of meat from lambs given essential oil-free rosemary extract containing carnosic acid plus carnosol at 200 or 400 mg kg⁻¹.

The use of dietary rosemary extract (DRE) at low doses is proposed as a nutritional strategy to improve meat preservation. Lamb diet was supplemented with 0, 200 or 400mg DRE (containing carnosic acid and carnosol at 1:1 w:w) per kg feed during the fattening stage. Meat quality was evaluated in lamb fillets packed under protective atmosphere and kept in retail conditions for up to 14 days. The effects of diet and storage time were determined on different physical-chemical (L*a*b* color, pH, TBARS, protein oxidation and volatiles from lipid oxidation), microbial (total viable and psychrophilic bacteria, Enterobacteriaceae, molds and yeasts) and sensory (appearance and odor) characteristics of the meat. The antioxidant and antimicrobial effects of DRE on meat were demonstrated. DRE delayed lean and fat discoloration, lipid oxidation, odor deterioration and microbial spoilage, extending the shelf life time of fillets from around 9 to 13 days. Both DRE doses provided similar shelf life extension.