Expression of Genes by Aflatoxigenic and Nonaflatoxigenic Strains of Aspergillus flavus Isolated from Brazil Nuts.

The aims of the present study were to monitor the production of aflatoxin B1 (AFB1) and mycelial growth, and to evaluate the expression of genes directly and indirectly involved in the biosynthesis of aflatoxins by Aspergillus flavus isolated from Brazil nuts. Six previously identified A. flavus strains were grown on coconut agar at 25°C for up to 10 days. Mycotoxins were separated by high-performance liquid chromatography and fungal growth was measured daily using the diametric mycelial growth rate. Transcriptional analysis was performed by real-time polymerase chain reaction (PCR) after 2 and 7 d of incubation using specific primers (aflR, aflD, aflP, lipase, metalloprotease, and LaeA). Three (50%) of the six A. flavus isolates produced AFB1 (ICB-1, ICB-12, and ICB-54) and three (50%) were not aflatoxigenic (ICB-141, ICB-161, and ICB-198). Aflatoxin production was observed from d 2 of incubation (1.5 ng/g for ICB-54) and increased gradually with time of incubation until d 10 (15,803.6 ng/g for ICB-54). Almost all A. flavus isolates exhibited a similar gene expression pattern after 2 d of incubation (p > 0.10). After 7 d of incubation, the LaeA (p < 0.05) and metalloprotease (p < 0.05) genes were the most expressed by nonaflatoxigenic strains, whereas aflatoxigenic isolates exhibited higher expression of the aflR (p < 0.05) and aflD genes (p < 0.05). Our results suggest that the expression of aflR and aflD is correlated with aflatoxin production in A. flavus and that overexpression of aflR could affect the transcriptional and aflatoxigenic pattern (ICB-54). Elucidation of the molecular mechanisms that regulate the secondary metabolism of toxigenic fungi may permit the rational silencing of the genes involved and consequently the programmed inhibition of aflatoxin production. Knowledge of the conditions, under which aflatoxin genes are expressed, should contribute to the development of innovative and more cost-effective strategies to reduce and prevent aflatoxin contamination in Brazil nuts.

Molecular and mycotoxigenic biodiversity of Aspergillus flavus isolated from Brazil nuts.

The objective of this study was to carry out a transcription analysis of eight genes belonging to the aflatoxin (AF) and cyclopiazonic acid (CPA) biosynthesis pathway, and to detect aflatoxin B1 (AFB1) and CPA production in Aspergillus flavus strains isolated from Brazil nuts. Additionally, these genes were correlated with the different mycotoxigenic profiles of the same strains. Four previously identified A. flavus strains (ICB-01, ICB-151, ICB-161, and ICB-165) were grown on Brazil nut agar at 25°C for 10days. Mycotoxins were separated by high-performance liquid chromatography. Transcriptional analysis was performed by real-time RT-PCR using specific primers designed based on the conserved regions of two regulatory genes (aflR and aflS), three structural genes of the AFB1 biosynthesis pathway (aflH, aflJ and aflP), and three structural genes of the CPA biosynthesis pathway (maoA, dmaT and pks-nrps). The expression of most genes in the A. flavus isolates varied according to the mycotoxin profile of each strain. The most expressed genes in the aflatoxigenic strain ICB-151 were aflJ (77.11%) and aflH (32.75%), while the CPA-producing strain ICB-161 mainly expressed dmaT (100%), maoA (63.72%), aflS (43.52%), and aflR (42.63%). The ICB-01 isolate was a producer of AFB1 and CPA and the most expressed genes were aflS (47.79%), dmaT (42.77%), aflP (39.5%), and aflR (38.02%). ICB-198 did not produce any mycotoxin and exhibited lower expression of almost all genes analyzed. Furthermore, the ratio of aflS/aflR expression was correlated with the biosynthesis of AF and CPA in A. flavus strains producing exclusively AF or CPA or producing both AF and CPA. The ratio of aflS/aflR expression therefore seems to be related to the production of mycotoxins in Brazil nuts. Our results provide important data for the development of innovative and more cost-effective strategies to reduce and prevent AFB and CPA contamination in Brazil nuts.

Effects of Gamma and Electron Beam Radiation on Brazil Nuts Artificially Inoculated with Aspergillus flavus.

The aim of this study was to evaluate the effects of gamma radiation (GR) and electron beam (EB) on Brazil nut samples contaminated with Aspergillus flavus. Fifty samples were spread with an A. flavus suspension and incubated at 30°C and a relative humidity of 93%. After 15 days of incubation, mycobiota and aflatoxin analysis were performed. The samples were divided into three groups (control, group 1, and group 2) that received radiation doses of 0 kGy (control) and 5 and 10 kGy each of GR and EB (groups 1 and 2). Noninoculated samples were irradiated with the same doses for sensory evaluation. The results showed that after 15 days of incubation, the average water activity of the samples was 0.80. The irradiation with GR and EB at doses of 5 and 10 kGy was able to eliminate A. flavus in Brazil nut samples. Aflatoxin analysis showed that EB doses of 5 and 10 kGy reduced aflatoxin B1 levels by 53.32 and 65.66%, respectively, whereas the same doses of GR reduced the levels of this toxin by 70.61 and 84.15% compared with the level in the control groups. Sensory evaluation demonstrated that the texture and odor of irradiated Brazil nut samples were acceptable. The taste evaluation indicated that 5 kGy of GR was judged acceptable. The results highlight that both irradiation processes (5- and 10-kGy doses) showed efficiency in A. flavus and aflatoxin elimination. GR and EB treatments resulted in some alterations in the sensory attributes of samples with the doses used in this study; however, Brazil nut samples irradiated with 5-kGy GR doses were considered acceptable.

Optimized nested polymerase chain reaction for antemortem detection of Mycobacteria in Amazon parrots (Amazona aestiva) and orange-winged Amazons (Amazona amazonica).

The objectives of this study were to optimize nested polymerase chain reaction (PCR) for Mycobacterium avium complex and Mycobacterium tuberculosis complex and apply them on samples from parrots. Results were negative for the presence of these Mycobacterium in the samples, and nested PCR was specific, faster, and more sensitive than other tests, thereby justifying its use in antemortem diagnosis.

Monitoring and determination of fungi and mycotoxins in stored Brazil nuts.

Brazil nut (Bertholletia excelsa) is an important commodity from the Brazilian Amazon, and approximately 37,000 tons (3.36 × 107 kg) of Brazil nuts are harvested each year. However, substantial nut contamination by Aspergillus section Flavi occurs, with subsequent production of mycotoxins. In this context, the objective of the present investigation was to evaluate the presence of fungi and mycotoxins (aflatoxins and cyclopiazonic acid) in 110 stored samples of cultivated Brazil nut (55 samples of nuts and 55 samples of shells) collected monthly for 11 months in Itacoatiara, State of Amazonas, Brazil. The samples were inoculated in duplicate onto Aspergillus flavus and Aspergillus parasiticus agar and potato dextrose agar for the detection of fungi, and the presence of mycotoxins was determined by high-performance liquid chromatography. The most prevalent fungi in nuts and shells were Aspergillus spp., Fusarium spp., and Penicillium spp. A polyphasic approach was used for identification of Aspergillus species. Aflatoxins and cyclopiazonic acid were not detected in any of the samples analyzed. The low water activity of the substrate was a determinant factor for the presence of fungi and the absence of aflatoxin in Brazil nut samples. The high frequency of isolation of aflatoxigenic Aspergillus section Flavi strains, mainly A. flavus, and their persistence during storage increase the chances of aflatoxin production on these substrates and indicates the need for good management practices to prevent mycotoxin contamination in Brazil nuts.

Polyphasic approach to the identification of Aspergillus section Flavi isolated from Brazil nuts.

The aim of this study was to use a polyphasic approach to identify Aspergillus section Flavi isolated from Brazil nuts collected in the Amazon forest: investigation of macro- and microscopic morphology, production of extrolites, heat-resistance fungi, and sequencing of DNA regions. The following Aspergillus section Flavi species were identified: Aspergillus flavus (75.5%), Aspergillus nomius (22.3%), and Aspergillus parasiticus (2.2%). All A. nomius and A. parasiticus isolates produced aflatoxins B and G, but not cyclopiazonic acid (CPA). A. flavus isolates were more diversified and a high frequency of mycotoxigenic strains was observed. The polyphasic approach permitted the reliable identification of section Flavi species. The rate of mycotoxigenic strains was high (92.7%) and mainly included A. flavus strains producing elevated levels of aflatoxins and CPA. These results highlight the possibility of co-occurrence of both toxins, increasing their potential toxic effect in this commodity.