Influence of HRT and carbon source on the enhancement of nutrient removal in an Anaerobic-Oxic-Anoxic (AOA) system.

The eutrophication and increase in toxicity promoted by the continuous or abundant supply of nutrients in water bodies threaten the safety of drinking water and human health. In this regard, this study proposes the investigation of wastewater treatment focusing on the simultaneous removal of nitrogen and phosphorus in the anaerobic-oxic-anoxic (AOA) system. The AOA system was operated in three different stages to verify the influence of the external carbon source addition in the anoxic reactor and the reduction of hydraulic retention time (HRT) in the anaerobic and oxic reactors for nutrient removal optimization. Results showed that the best performance of the AOA system on nutrient removal was obtained in Stage 3, with the reduction of the HRT in the anaerobic and oxic reactors (HRT = 4 h) while maintaining HRT of 6.4 h in the anoxic reactor with no addition of the external carbon source. Under these conditions, the average removal efficiencies reached 98% for Chemical Oxygen Demand (COD), 88% for Total Ammonia Nitrogen (TAN), 81% for Total Kjeldahl Nitrogen (TKN), and 70% for Total Phosphorus (TP). The results also demonstrate that the highest phosphorus removal efficiency was achieved in the anoxic reactor, thus indicating the occurrence of denitrifying phosphorous removal by Denitrifying Phosphate Accumulating Organisms (DNPAOs). This configuration was efficient regarding the simultaneous removal of nitrogen and phosphorus; besides, the advantages of this system include robust configuration and excellent performance on the nutrient removal.

Aeration and non-aeration cycles (AE/NA) time: influence in combined organic matter and nitrogen removal and features of biofilm.

This research aimed the performance evaluation of a structured bed reactor with different cycles of Intermittent Aeration (IA)(SBRRIA) in the municipal sewage treatment and the verification of the effect of IA cycles on the total nitrogen (TN) removal and organic matter (COD). Three IA cycles were evaluated: phase I (4 h AE (aeration on) - 2 h NA (aeration off)); II (2 h AE-1 h NA) and III (2 h AE-2 h NA), with Hydraulic Retention Time of 16 h. The best nitrogen removal was obtained during phase II, with the lowest non-aeration time: efficiency of nitrification, denitrification, TN and COD removal of 80 ± 15%, 82 ± 12%, 67 ± 6% and 94 ± 7%, respectively. The mean cell residence time was 19, 26 and 33 d in phases I, II and III, respectively. The statistical analysis applied to the AE/NA profiles showed that the time of AE and NA in the cycles did not influence nitrogen and organic matter removal. Thus, this indicates the recirculation and the gradient formed in the support material facilitate the process of Simultaneous Nitrification and Denitrification. The lowest concentration of nitrifying and denitrifying microorganisms was obtained in effluent and sludge at the end of phase III. From the TP (Total Proteins)/TPS (Total Polysaccharides) ratio obtained (0.8 ± 0.1, 1.3 ± 0.1 e 1.5 ± 0.1 in phases I, II and III), it was possible to conclude that the biofilm in phase I was more porous, with a thin layer if compared to that in phase II and III.

Craft Brewery Wastewater Treatment: a Fixed-Bed Single-Batch Reactor with Intermittent Aeration to Remove COD and TN

Abstract This study evaluated an intermittently aerated, fixed-bed, single-batch reactor, with mini BioBob© as biofilm media support, as an alternative treatment of craft brewery wastewater. In order to remove chemical oxygen demand (COD) and total nitrogen (TN), seven conditions were performed in a central composite experimental design (CCD) with different aeration times (1, 2 and 3 h in a 4 h cycle) and hydraulic retention times (HRT) (12, 16 and 20 h). The results showed that the removal of COD and TN were positively affected by increased aeration time and HRT. The condition that presented the best quality effluent was Condition No. 1 (20 h HRT and 3 h aeration), with 209 ± 28 mg COD L-1; 3.00 ± 0.15 mg TKN L-1 ; and 0.67 ± 0.11 mg NO3-N L-1. Kinetic assays showed that the highest values for the substrate removal rate constant, kCOD = 0.1774 h-1 were obtained with the longest aeration time (3 h). The most probable number (MPN) test showed a higher concentration of denitrifying bacteria (heterotrophic), 3.3 x 106, than for AOB and NOB bacteria (autotrophic), which were 4.9 x 103 and 2.7 x 103, respectively. Moreover, it was possible to verify that correcting the influent alkalinity with 7.14 mg CaCO3 for each 1 mg of TKN resulted in better process efficiency. It was concluded that COD and TN can be removed from craft brewery wastewater using an intermittently aerated, fixed-bed, single-batch reactor with mini Biobob© as biofilm media support.

Production of Propionic Acid by Propionibacterium acidipropionici from Agroindustrial Effluents

Abstract The purpose of this paper was to evaluate the production of propionic acid from the fermentation of agroindustrial effluents using a Propionibacterium acidipropionici culture. The composition of the substrates was determined by using an experimental design of mixtures, resulting in 10 trials. The substrates were fermented in batch borosilicate glass reactors at a temperature of 35°C, initial pH of 6.5, and 20 mL.L-1 of inoculum suspension. The highest yield of propionic acid production, 0.79 g of product per g of substrate, was obtained with a substrate composed only of corn steep liquor, which showed a productivity of 5.20 mg.L-1h-1 and production of 0.40mL.L-1. These results showed that the corn steep liquor positively influenced performance and productivity. Although the production of acid did not reach high values, the results indicate that it is possible to produce propionic acid by a biotechnological route; however, further studies are required to adapt and optimise these results.

Removal of COD and nitrogen from animal food plant wastewater in an intermittently-aerated structured-bed reactor.

This study evaluated the performance of a continuous flow structured-bed reactor in the simultaneous removal of total nitrogen (TN) and chemical oxygen demand (COD) in the effluent from an animal food plant. The reactor had an intermittent aeration system; hydraulic retention time (HRT) of one day; temperature of 30 °C; and recirculation ratio of five times the flow. An experimental central composite rotational delineation (CCRD) type design was used to define the aeration conditions and nitrogen load (factors) to be studied. Response surface methodology was used to analyse the influence of the factors above the results, the removal of TN and COD. It was observed that the aeration factor showed the greatest significance for the results and that the affluent TKN concentration did not have a significant effect, at a 95% level of confidence, on COD removal. Throughout the experiment, the COD/N ratio remained between 3.2 and 3.8. The best results for COD and TN removal, 80% and 88%, respectively, were obtained with 158 min of aeration on a cycle of 180 min and 255 mg L(-1) of Total Kjeldahl Nitrogen (TKN) in the substrate.

Characterisation of Cassava Bagasse and Composites Prepared by Blending with Low-Density Polyethylene

The main objective of this study was to characterise the cassava bagasse and to evaluate its addition in composites. Two cassava bagasse samples were characterised using physicochemical, thermal and microscopic techniques, and by obtaining their spectra in the mid-infrared region and analysing them by using x-ray diffraction. Utilising sorption isotherms, it was possible to establish the acceptable conditions of temperature and relative humidity for the storage of the cassava bagasse. The incorporation of cassava bagasse in a low-density polyethylene (LDP) matrix was positive, increasing the elasticity modulus values from 131.90 for LDP to 186.2 for 70% LDP with 30% SP bagasse. These results were encouraging because cassava bagasse could serve as a structural reinforcement, as well as having environmental advantages for its application in packaging, construction and automotive parts.

Maize (Zea Mays L) landraces from the southern region of Brazil: contamination by Fusarium sp, zearalenone, physical and mechanical characteristics of the kernels

This work had as objectives the study of the physical and mechanical characteristics of maize kernels in relation to the contamination by Fusarium sp and by zearalenone in twenty landraces of maize from the southern region of Brazil. From the analyzed samples, 60 percent has been considered to have a hard endosperm type and 40 percent an intermediary one. A correlation between the physical and mechanical variables was observed as an indication that the higher is the proportion of hard endosperm, more dense will be the kernel and more force for its rupture will be necessary. The level of contamination by Fusarium sp was between 5.5 and 24.75 percent among the analyzed grains, correlating positively with the flotation index, indicating that the landraces of maize with a softer endosperm can present a higher contamination by this genus. The presence of zearalenone was verified in 75 percent of the samples, in concentrations varying from 50 to 640 µg kg-1.

Este trabalho teve por objetivos verificar as características físicas, mecânicas, contaminação por Fusarium sp e por zearalenona e suas relações, em vinte variedades crioulas de milho da região sul do Brasil. Verificou-se que das amostras analisadas, 60 por cento foram consideradas como possuidoras de endosperma do tipo duro e 40 por cento com endosperma do tipo intermediário. As variáveis físicas e mecânicas se correlacionaram, indicando que quanto maior a proporção de endosperma vítreo, mais denso e maior a força necessária até a ruptura do grão. A contaminação por Fusarium sp esteve entre 5,5 por cento e 24,75 por cento nos grãos analisados, correlacionando-se positivamente com o índice de flotação, indicando que as variedades crioulas de milho com uma maior proporção de endosperma macio podem apresentar uma maior contaminação por Fusarium sp, sugerindo-se a utilização de variedades crioulas com a textura do endosperma predominantemente vítrea. A presença de zearalenona foi verificada em 75 por cento das amostras, em concentrações que variaram de 50 a 640 µg kg-1.

Use of maize wastewater for the cultivation of the Pleurotus spp. mushroom and optimization of its biological efficiency.

This study evaluated the Pleurotus spp. mushroom production process using an effluent from the maize agroindustrial process as a carbon and nitrogen source and as a wetting agent. A complete experimental design based on factorial planning was used to optimize the biological efficiency and evaluate the effect of the concentration of effluent, pH and species of Pleurotus. The results indicated that the effluent affects the biological efficiency for the production of both species of mushrooms at all pH values studied. The maximum biological efficiency predicted by the model (81.36%) corresponded to the point defined by the effluent contents (X(1)=1), pH (X(2)=-1) and fungus species (X(3)=1), specifically 50%, 5.0 and P. floridae, respectively. The results demonstrated that the effluent is a good alternative for the production of Pleurotus mushrooms.

Effect of temperature on two-phase anaerobic reactors treating slaughterhouse wastewater

The effectiveness of the anaerobic treatment of effluent from a swine and bovine slaughterhouse was assessed in two sets of two-phase anaerobic digesters, operated with or without temperature control. Set A, consisting of an acidogenic reactor with recirculation and an upflow biological filter as the methanogenic phase, was operated at room temperature, while set B, consisting of an acidogenic reactor without recirculation and an upflow biological filter as the methanogenic phase, was maintained at 32°C. The methanogenic reactors showed COD (Chemical Demand of Oxygen) removal above 60 percent for HRT (Hydraulic Retention Time) values of 20, 15, 10, 8, 6, 4, and 2 days. When the HRT value in those reactors was changed to 1 day, the COD percentage removal decreased to 50 percent. The temperature variations did not have harmful effects on the performance of reactors in set A.

Avaliou-se a eficiência do tratamento anaeróbio de efluente de matadouro de suínos e bovinos em dois conjuntos de biodigestores anaeróbios de duas fases, operados com e sem controle de temperatura. O conjunto A, formado por um reator acidogênico com recirculação e um filtro biológico de fluxo ascendente, foi operado a temperatura ambiente e o conjunto B, formado por um reator de fluxo ascendente e um filtro biológico de fluxo ascendente, foi mantido a 32°C. Os reatores metanogênicos apresentaram remoção de DQO acima de 60 por cento para os TRHs de 20, 15, 10, oito, seis, quatro e dois dias. Quando o TRH destes reatores foi mudado para um dia observou-se uma queda da porcentagem de remoção de DQO para 50 por cento. As variações de temperatura parecem não ter prejudicado o desempenho dos reatores do conjunto A.