Effect of nonionic surfactants on Rhizopus homothallicus lipase activity: a comparative kinetic study.

Based on amino-terminal sequencing and mass spectrometry data on the Rhizopus homothallicus lipase extracted using solid (SSF) and submerged state fermentation (SmF) methods, we previously established that the two enzymes were identical. Differences were observed, however, in terms of the specific activity of these lipases and their inhibition by diethyl p-nitrophenyl phosphate (E600). The specific activity of the SSF lipase (10,700 mumol/min/mg) was found to be 1.2-fold that of SmF lipase (8600 mumol/min/mg). These differences might be the result of residual Triton X-100 molecules interacting with the SSF lipase. To check this hypothesis, the SmF lipase was incubated with submicellar concentrations of Triton X-100. The specific activity of the lipase increased after this treatment, reaching similar values to those measured with the SSF lipase. Preincubating SSF and SmF lipases with E600 at a molar excess of 100 for 1 h resulted in 80% and 60% enzyme inhibition levels, respectively. When the SmF lipase was preincubated with Triton X-100 for 1 h at a concentration 100 times lower than the Triton X-100 critical micellar concentration, the inhibition of the lipase by E600 increased from 60% to 80%. These results suggest that residual detergent monomers interacting with the enzyme may affect the kinetic properties of the Rh. homothallicus lipase.

A spectrophotometric method to assay epoxide hydrolase activity.

The Aspergillus niger epoxide hydrolase activity was assayed by spectrophotometric using (rac) p-nitrostryrene oxide (pNSO) as substrate. Both the substrate (pNSO) and the reaction product, p-nitrostryrene diol (pNSD), had a strong absorbance in UV at 280 nm. The assay was based on the measure of the pNSD absorbance of the water phase after extraction of the non-reacted pNSO with a solvent. Among the five solvents tested, chloroform was selected since it extracted more than 99% of the epoxide and only 32% of the produced diol. This extraction yield was independent of the diol and epoxide concentrations and it was fairly reproducible. Using different enzyme amounts, the reaction kinetics were linear for the first 10 min corresponding to degrees of conversion less than 5% for the epoxide. Two controls were run simultaneously, one with the substrate alone (epoxide hydrolysis and non-complete extraction) and one with the enzyme alone (enzyme absorbance at 280 nm). The resulting DeltaOD/min was linear with the amount of enzyme added within a large range from 2 to 80 microg of the EH preparation. The new spectrophotometric assay correlates well with the previous HPLC assay and could be used routinely for an easy and fast evaluation of EH activity. The kinetic parameters of (rac) pNSO hydrolysis by A. niger epoxide hydrolase could be easily determined and K(M) (1.1 mM) compared well with that previously reported (1.0 mM).

Sucrose hydrolysis by thermostable immobilized inulinases from aspergillus ficuum.

The possibility of using thermostable inulinases from Aspergillus ficuum in place of invertase for sucrose hydrolysis was explored. The commercial inulinases preparation was immobilized onto porous glass beads by covalent coupling using activation by a silane reagent and glutaraldehyde before adding the enzyme. The immobilization steps were optimized resulting in a support with 5,440 IU/g of support (sucrose hydrolysis) that is 77% of the activity of the free enzyme. Enzymatic properties of the immobilized inulinases were similar to those of the free enzymes with optimum pH near pH 5.0. However, temperature where the activity was maximal was shifted of 10 degrees C due to better thermal stability after immobilization with similar activation energies. The curve of the effect of sucrose concentration on activity was bi-phasic. The first part, for sucrose concentrations lower than 0.3 M, followed Michaelis-Menten kinetics with apparent K(M) and Vm only slightly affected by immobilization. Substrate inhibition was observed at values from 0.3 to 2 M sucrose. Complete sucrose hydrolysis was obtained for batch reactors with 0.3 and 1 M sucrose solutions. In continuous packed-bed reactor 100% (for 0.3 M sucrose), 90% (1 M sucrose) or 80% sucrose conversion were observed at space velocities of 0.06-0.25 h(-1). The operational half-life of the immobilized inulinases at 50 degrees C with 2 M sucrose was 350 days.

Comparison of hydrolytic activity in water and heptane for thirty-two commercial lipase preparations.

The protein content and the rates of hydrolysis of p-nitrophenyl palmitate (pNPP) in water (soluble enzyme and emulsified substrate) and in heptane (soluble substrate and insoluble enzyme) were measured for thirty-two commercial lipase preparations. The protein content of the powders varied in a wide range as well as the activity on emulsified pNPP showing the high heterogeneity of the commercial samples. Activity in heptane also varied but to a lesser extent than that in water. There was no direct correlation between activities in water and in heptane as assayed with the same hydrolytic reaction. The ratio of activity in heptane to that in water, R(O/A) ratio, was introduced to characterize activity in organic media. Six lipases showed R(O/A) values higher than 1 demonstrating a higher activity in organic solvent than in water. A linear correlation of R(O/A) with activity in water (log plot) suggested the strong influence of diffusional limitations on activity of solid enzyme suspended in organic solvents.

Purification and characterization of a thermostable esterase from the moderate thermophile Bacillus circulans.

The thermostable esterase from the moderate thermophile Bacillus circulans was purified to homogeneity using a four-step procedure. Esterase activity was associated with a protein of molecular mass 95 kDa, composed of three identical subunits of 30 kDa. The esterase activity was thermostable with a maximum activity at 55 degrees C using initial rate assay. The half-inactivation temperature was 71 degrees C after a 1-h treatment, which compared favorably to that of other enzymes. Activity at temperatures of 30-37 degrees C was high (about half of maximum), making this new enzyme very attractive for applications in this moderate temperature range. The esterase also showed high activity at a rather alkaline pH (higher than 10). The specificity pattern showed a marked specificity for mid-chain-length fatty acids (3-8 carbon atoms), which classified the enzyme as a carboxylesterase.

H107, a new aminoglycoside anti-Pseudomonas antibiotic produced by a new strain of Spirillospora.

Spirillospora spp. (strain 719) has been the source of several antibiotics. One of these designated H107 is produced as a trace. Compared with other antibiotics produced by the same strain, it was obtained only from the broth filtrate after precipitation with acetic acid followed by extraction with n-butanol. It was a water soluble metabolite active against Gram-negative bacteria and especially Pseudomonas spp., and was identified as an aminoglycoside compound. This is the first report of aminoglycoside anti-Pseudomonas production by Spirillospora.

Cloning and molecular characterization of a soluble epoxide hydrolase from Aspergillus niger that is related to mammalian microsomal epoxide hydrolase.

Aspergillus niger strain LCP521 harbours a highly processive epoxide hydrolase (EH) that is of particular interest for the enantioselective bio-organic synthesis of fine chemicals. In the present work, we report the isolation of the gene and cDNA for this EH by use of inverse PCR. The gene is composed of nine exons, the first of which is apparently non-coding. The deduced protein of the A. niger EH shares significant sequence similarity with the mammalian microsomal EHs (mEH). In contrast to these, however, the protein from A. niger lacks the common N-terminal membrane anchor, in line with the fact that this enzyme is, indeed, soluble in its native environment. Recombinant expression of the isolated cDNA in Escherichia coli yielded a fully active EH with similar characteristics to the fungal enzyme. Sequence comparison with mammalian EHs suggested that Asp(192), Asp(348) and His(374) constituted the catalytic triad of the fungal EH. This was subsequently substantiated by the analysis of respective mutants constructed by site-directed mutagenesis. The presence of an aspartic acid residue in the charge-relay system of the A. niger enzyme, in contrast to a glutamic acid residue in the respective position of all mEHs analysed to date, may be one important contributor to the exceptionally high turnover number of the fungal enzyme when compared with its mammalian relatives. Recombinant expression of the enzyme in E. coli offers a versatile tool for the bio-organic chemist for the chiral synthesis of a variety of fine chemicals.

Purification and characterization of a highly enantioselective epoxide hydrolase from Aspergillus niger.

The epoxide hydrolase from Aspergillus niger was purified to homogeneity using a four-step procedure and p-nitrostyrene oxide (pNSO) as substrate. The enzyme was purified 246-fold with 4% activity yield. The protein is a tetramer composed of four identical subunits of molecular mass 45 kDa. Maximum activity was observed at 40 degrees C, pH 7.0, and with dimethylformamide as cosolvent to dissolve pNSO. Hydrolysis of pNSO was highly enantioselective, with an E value (i.e. enantiomeric ratio) of 40 and a high regioselectivity (97%) for the less hindered carbon atom of the epoxide. This enzyme may be a good biocatalyst for the preparation of enantiopure epoxides or diols.

Characterization of a thermostable esterase activity from the moderate thermophile Bacillus licheniformis.

A new esterase activity from Bacillus licheniformis was characterized from an Escherichia coli recombinant strain. The protein was a single polypeptide chain with a molecular mass of 81 kDa. The optimum pH for esterase activity was 8-8.5 and it was stable in the range 7-8.5. The optimum temperature for activity was 45 degrees C and the half-life was 1 h at 64 degrees C. Maximum activity was observed on p-nitrophenyl caproate with little activity toward long-chain fatty acid esters. The enzyme had a KM of 0.52 mM for p-nitrophenyl caproate hydrolysis at pH 8 and 37 degrees C. The enzyme activity was not affected by either metal ions or sulfydryl reagents. Surprisingly, the enzyme was only slightly inhibited by PMSF. These characteristics classified the new enzyme as a thermostable esterase that shared similarities with lipases. The esterase might be useful for biotechnological applications such as ester synthesis.

Activity of Pseudomonas cepacia lipase in organic media is greatly enhanced after immobilization on a polypropylene support.

The purified lipase from Pseudomonas cepacia was used as free and immobilized enzyme preparation for hydrolysis of p-nitrophenyl palmitate (pNPP) and p-nitrophenyl acetate (pNPA) in organic media. The free enzyme was mixed with bovine serum albumin and lyophilized. Immobilization was on porous polypropylene. Conditions where diffusional limitations of the substrate were not limiting the reaction rate were defined. The specific activity of the lipase was greatly enhanced upon immobilization: 16.5- and 7.8-fold for pNPP and pNPA respectively. Both the free and immobilized lipases followed Michaelis-Menten kinetics in organic solvent despite the heterogeneity (solid/liquid) of the reaction mixture. For pNPP, the activation factor upon immobilization came mainly from a reduction in Km)app while kcat was increased for pNPA.

Properties of free and immobilized lipase from Pseudomonas cepacia.

The purified lipase from Pseudomonas cepacia (PS, Amano) was immobilized on a commercially available microporous polypropylene support. The enzyme was rapidly and completely adsorbed on the support. Special attention was devoted to the demonstration of the lack of diffusional limitations, either internal or external, when a soluble substrate (p-nitrophenylacetate, pNPA) was used. The activity yield was high (100%) with pNPA and very low (0.4%) with p-nitrophenylpalmitate (pNPP). These values clearly showed that the immobilized enzyme was fully active as soon as activity was assayed on a soluble substrate rather than an insoluble one. With the latter one, the low activity was due mainly to a slow rate of substrate diffusion inside the porous support. The same diffusional phenomenon could explain the complete change of fatty acid specificity of the immobilized lipase. After immobilization, the lipase was mainly specific for short chain fatty acid esters, whereas the free enzyme was mainly specific for long chain esters. The activity-versus-temperature profiles were not greatly affected by immobilization with maximal reaction rates in the range 45 degrees to 50 degrees C for both enzyme preparations. However, immobilization increased enzyme stability mainly by decreasing the sensitivity to temperature of the inactivation reaction. Half-lives at 80 degrees C were 11 and 4 min for the immobilized and free enzymes, respectively. (c) 1997 John Wiley & Sons, Inc. Biotechnol Bioeng 56: 181-189, 1997.

Microbiological Transformations. 33. Fungal Epoxide Hydrolases Applied to the Synthesis of Enantiopure Para-Substituted Styrene Oxides. A Mechanistic Approach.

The biohydrolysis of differently para-substituted styrene oxide derivatives was studied, using whole cells of the fungi Aspergillus niger or Beauveria sulfurescens. These microorganisms proved to be equipped with epoxide hydrolases which are able to achieve these hydrolyses with high enantioselectivity. This allowed the preparation of the optically active epoxides and of the corresponding vicinal diols which were obtained with good to excellent enantiomeric purity. These two microorganisms proved to be enantiocomplementary. A mechanistic study, carried out using a crude lyophilized enzymatic extract from A.niger, indicated via Hammet coefficient plotting that this hydrolysis is very probably due to a general base-catalyzed process.

D-Cycloserine biases enrichment for auxotrophic mutants of Zymomonas mobilis.

Contrary to its effect on rich medium, D-cycloserine showed no bactericidal effect on Zymomonas mobilis cells cultured on mineral medium. Addition of a mixture of glycine and glutamic acid to the mineral medium restored its bactericidal action. However, mutant enrichments run in these conditions were biased, with mostly methionine mutants isolated. A decrease of the D-cycloserine concentration only reduced the bias.

Isolation and Properties of Mutants of Zymomonas mobilis Deficient in Sugar Assimilation.

An enrichment method using d-cycloserine was designed for the isolation of spontaneous mutants of Zymomonas mobilis deficient in glucose or fructose utilization. The mutants could easily be isolated since they represented 80 to 90% of the population after two and three enrichment cycles. Glucokinase and fructokinase activities in the mutants were affected.

Enantioselective hydrolysis of p-nitrostyrene oxide by an epoxide hydrolase preparation from Aspergillus niger.

The epoxide hydrolase activity of Aspergillus niger was synthesized during growth of the fungus and was shown to be associated with the soluble cell fraction. An enzyme preparation was worked out which could be used in place of the whole mycelium as biocatalyst for the hydrolysis of epoxides. The effect of four different cosolvents on enzyme activity was investigated. Consequently, dimethylsulfoxide (DMSO) was selected for epoxide solubilization. The effect of temperature on both reaction rate and enzyme stability was studied in the presence of DMSO (0.2 volume ratio). A temperature of 25 degrees C was selected for the reaction of bioconversion. With a substrate concentration of 4.5 mM a batch reactor showed that the enzyme preparation hydrolyzed para-nitrostyrene oxide with very high enantioselectivity. The (S) enantiomer of the epoxide remained in the reaction mixture and showed an enantiomeric excess higher than 99%. The substrate concentration could be increased to 20 mM without affecting the enantiomeric excess and degree of conversion. Therefore, the method is potentially useful for the preparative resolution of epoxides. Application are in the field of chiral synthons which are important building blocks in organic synthesis.

Overexpression of extracellular sucrase (SacC) of Zymomonas mobilis in Escherichia coli.

The extracellular sucrase (SacC) gene of Zymomonas mobilis was overexpressed in Escherichia coli BL21 using the T7 polymerase expression system. A low cell density induction method was designed to have maximum expression, and the conditions (IPTG concentration, ampicillin addition) were optimised to overexpress to the level of more than 60% of the total cellular protein representing SacC protein.

Molecular cloning and characterization of the extracellular sucrase gene (sacC) of Zymomonas mobilis.

The Zymomonas mobilis gene sacC that encodes the extracellular sucrase (protein B46) was cloned and expressed in Escherichia coli. The gene was found to be present downstream to the already described levansucrase gene sacB in the cloned chromosomal fragment of Z. mobilis. The expression product was different from SacB and exhibited sucrase but not levansucrase activity; therefore, SacC behaves like a true sucrase. Expression of sacC in E. coli JM109 and XL1 was very low; overexpression was observed in E. coli BL21 after induction of the T7 polymerase expression system with IPTG. Subcellular fractionation of the E. coli clone carrying plasmid pLSS2811 showed that more than 70% of the sucrase activity could be detected in the cytoplasmic fraction, suggesting that the enzyme was soluble and not secreted in E. coli. The nucleotide sequence analysis of sacC revealed an open reading frame 1239bp long coding for a 413 amino acid protein with a molecular mass of 46 kDa. The first 30 deduced amino acids from this ORF were identical with those from the N-terminal sequence of the extracellular sucrase (protein B46) purified from Z. mobilis ZM4. No leader peptide sequence could be identified in the sacC gene. The amino acid sequence of SacC showed very little similarity to those of other known sucrases, but was very similar to the levansucrases of Z. mobilis (61.5%), Erwinia amylovora (40.2%) and Bacillus subtilis (25.6%).

Cloning and expression in Escherichia coli of a phoA gene encoding a phosphate-irrepressible alkaline phosphatase of Zymomonas mobilis.

The Zymomonas mobilis phoA gene, encoding a phosphate-irrepressible alkaline phosphatase (ZAPase), was cloned and its expression was studied in phoA mutants of Escherichia coli. The ZAPase was recovered in the soluble fraction of E. coli. The enzyme was synthesized constitutively and its synthesis not repressed by phosphate, unlike the phoA gene of E. coli. The phoA gene of Z. mobilis was mutagenized by Mini Mu PR13 and the mutated gene crossed into Z. mobilis in order to obtain phoA mutants by reverse genetics. Although Z. mobilis mutants with Mini Mu PR13 integrated in the chromosome were obtained, none had an allele replacement for none was defective in ZAPase.

Batch fermentation kinetics of sugar beet molasses by Zymomonas mobilis.

A new osmotolerant mutant strain of Zymomonas mobilis was successfully used for ethanol production from beet molasses. Addition of magnesium sulfate to hydrolyzed molasses allowed repeated growth without the need of yeast extract addition. The kinetics and yields parameters of fermentation on media with different molasses concentrations were calculated. The anabolic parameters (specific growth rate, mu, and biomass yield, Y(X/S)) were inhibited at elevated molasses concentrations while the catabolic parameters (specific ethanol productivity, q(p), and ethanol yield, Y(p/s)) were not significantly affected. In addition to ethanol and substrate inhibition, osmotic pressure effects can explain the observed results.