Quantification of Salmonella Infantis transfer from transport drawer flooring to broiler chickens during holding.

Transportation is a potential point of cross-contamination before broiler chickens arrive at the processing plant for slaughter. Previous studies have associated the use of uncleaned transport containers with the introduction of pathogenic bacteria onto uncontaminated broilers. The objective of this study was to quantify the transfer of Salmonella from transport drawer perforated flooring to broiler chickens during different holding times. For traceability, the flooring of each drawer was inoculated with fecal content slurry containing a marker strain of Salmonella Infantis. Three drawers per treatment were used, and each drawer was subjected to one of the following treatments: pressure wash, disinfectant, and pressure wash (A), pressurized steam followed by forced hot air (B), or no cleaning (C). Drawers were classified as top, middle, or bottom based on their relative position with each other. After treatment, broilers were introduced to each drawer and held for 2, 4, or 6 h. At each timepoint, broilers were removed from drawers, euthanized, and carcasses rinsed to obtain Salmonella counts. Samples under the limit of direct plating detection were enriched, plated, and later confirmed positive or negative. Differences were observed per treatment, holding time, and drawer relative position (P < 0.0001). Broilers placed in transport containers that underwent a cleaning procedure (A or B) had lower levels of Salmonella when compared to broilers placed in noncleaned containers (C). However, most of the samples below the limit of detection were positive after enrichment, indicating that both procedures evaluated need improvement for efficient pathogen inactivation. A decrease in Salmonella transfer was observed after 6 h in rinsates obtained from broilers placed in noncleaned containers (C). Rinsates obtained from top drawers had less Salmonella than the middle or bottom drawers when broilers were placed in transport containers that underwent a cleaning procedure (A and B). The application of pressurized steam and forced hot air was comparable to the use of water washes and disinfectant indicating a potential role in cleaning poultry transport containers.

Application of pressurized steam and forced hot air for cleaning broiler transport container flooring.

In the United States, cleaning poultry transport containers prior to arrival at the broiler grow-out farm is not currently a widely adopted practice in the industry. However, previous studies have shown that transport containers have an important role in cross-contamination before the broilers arrive at the processing plant. The objective of this study was to evaluate the efficacy of pressurized steam followed by forced hot air to clean transport container flooring and compare it to conventional cleaning procedures. Fiberglass and plastic flooring were cut into even pieces and inoculated with chicken intestinal contents containing Salmonella Infantis or Campylobacter jejuni. The cleaning treatments were pressurized steam, forced hot air, pressurized steam followed by forced hot air, water pressure washing, water pressure washing before and after disinfectant, and no cleaning. Counts for Salmonella, Campylobacter, Escherichia coli, coliforms, and aerobic bacteria were assessed. All reductions were made in comparison to noncleaned samples. Forced hot air applied by itself was not efficient in reducing Campylobacter, coliforms, and E. coli; and limited reductions (less than 1 log10 CFU/cm2) were observed for Salmonella and aerobic bacteria. Then, for all bacteria types evaluated, pressurized steam by itself showed reductions of 2.4 to 3.5 log10 CFU/cm2. Samples that were cleaned with a single-pressure water wash showed reductions of 4.0 to 4.6 log10 CFU/cm2 for all bacteria types. For Salmonella, Campylobacter, and E. coli, the greatest reductions were observed when samples were cleaned with pressurized steam followed by forced hot air (4.3-6.1 log10 CFU/cm2) or water washed before and after disinfectant (4.5-6.2 log10 CFU/cm2), and these treatments did not differ from each other. Pressurized steam followed by forced hot air was shown to be an efficient cleaning procedure to reduce poultry-associated pathogens on transport cage flooring, with the benefit of using less water than conventional water cleaning. Processors may be able to adapt this process to reduce potential cross-contamination and lessen the level of pathogens entering the processing plant.

Buffering Capacity Comparison of Tris Phosphate Carbonate and Buffered Peptone Water Salmonella Pre-Enrichments for Manufactured Feed and Feed Ingredients.

Various culture-based methods to detect Salmonella in animal feed have been developed due to the impact of this bacterium on public and animal health. For this project, tris phosphate carbonate (TPC) and buffered peptone water (BPW) buffering capacities were compared as pre-enrichment mediums for the detection of Salmonella in feed ingredients. A total of 269 samples were collected from 6 feed mills and mixed with the pre-enrichments; pH was measured before and after a 24 h incubation. Differences were observed when comparing pH values by sample type; DDGS and poultry by-product meal presented lower initial pH values for TPC and BPW compared to the other samples. For both TPC and BPW, meat and bone meal presented higher final pH values, while soybean meal and peanut meal had lower final pH values. Furthermore, for BPW, post cooling, pellet loadout, and wheat middlings reported lower final pH values. Additionally, most feed ingredients presented significant differences in pH change after 24 h of incubation, except DDGS. From meat and bone meal samples, four Salmonella isolates were recovered and identified: three using BPW and one using TPC. TPC provided greater buffer capacity towards neutral pH compared to BPW, but BPW was more effective at recovering Salmonella.

Production of recombinant Salmonella flagellar protein, FlgK, and its uses in detection of anti-Salmonella antibodies in chickens by automated capillary immunoassay.

Conventional immunoblot assays are a useful tool for specific protein identification, but tedious, labor-intensive and time-consuming. A capillary electrophoresis-based immunoblot assay so-called "Simple Western" was developed to enable the protein identification in an automatic manner. This communication describes the use of Simple Western for detecting anti-Salmonella FlgK antibodies from chicken sera.