Bacterial community structure and physiological state in a biofilm reactor degrading 4-chloroaniline.

Degradation of 4-chloroaniline in the presence of aniline by a microbial community in a laboratory-scale biofilm reactor was evaluated. The starter inoculum was isolated and reconstructed from a percolating column enrichment of Indonesian agricultural soil. The capacity to mineralise and detoxify 4-chloroaniline in the presence of aniline was demonstrated by the biofilm reactor when operated at high hydraulic retention time (HRT; 0.87 h). At low HRT (0.23 h and 0.39 h) 4-chlorocatechol accumulated in the effluent, accompanied by a decrease in dechlorination and detoxification. When returned to high HRT (2.14 h), the accumulation of 4-chlorocatechol stopped and the extent of dechlorination and detoxification increased. Bacteria other than the original inoculum appeared in the reactor when the operating mode was switched from closed cycle to open cycle. One of these bacteria, identified as Pseudomonas putida R1 by partial 16S rDNA sequencing, subsequently dominated the reactor at every HRT imposed. PCR-based single-strand conformational polymorphism of 16 s rDNA and traditional cultivation procedures indicated that the bacterial composition in the reactor shifted in response to applied HRT. The relationship between the bacterial abundance and the degradation capacity of the reactor is discussed.

Physiology, biochemistry and taxonomy of deep-sea nitrile metabolising Rhodococcus strains.

A collection of nitrile-hydrolysing rhodococci was isolated from sediments sampled from a range of deep coastal, and abyssal and hadal trench sites in the NW Pacific Ocean, as part of our programme on the diversity of marine actinomycetes. Nitrile-hydrolysing strains were obtained by batch enrichments on nitrile substrates with or without dispersion and differential centrifugation pre-treatment of sediments, and were recovered from all of the depths sampled (approximately 1100-6500 m). Two isolates obtained from the Ryukyu (5425 m) and Japan (6475 m) Trenches, and identified as strains of Rhodococcus erythropolis, were chosen for detailed study. Both of the deep-sea isolates grew at in situ temperature (4 degrees C), salinities (0-4% NaCl) and pressures (40-60 MPa), results that suggest, but do not prove, that they may be indigenous marine bacteria. However, the absence of culturable Thermoactinomyces points to little or no run off of terrestrial microbiota into these particular trench sediments. Nitrile-hydrolysis by these rhodococci was catalysed by a nitrile hydratase-amidase system. The hydratase accommodated aliphatic, aromatic and dinitrile substrates, and enabled growth to occur on a much wider range of nitriles than the only other reported marine nitrile-hydrolysing R. erythropolis which was isolated from coastal sediments. Also unlike the latter strain, the nitrile hydratases of the deep-sea rhodococci were constitutive. The possession of novel growth and enzyme activities on nitriles by these deep-sea R. erythropolis strains recommends their further development as industrial biocatalysts.

A GAC biofilm reactor for the continuous degradation of 4-chlorophenol: treatment efficiency and microbial analysis.

Using a continuous enrichment technique, a bacterial consortium capable of degrading 4-chlorophenol (4-CP) was obtained from the rhizosphere of Phragmites australis. A granular activated carbon (GAC) biofilm reactor was established using this consortium, and the degradation of 4-CP was investigated under continuous flow operation using a feed of 20-50 mg l(-1) with a hydraulic residence time of 17 min over a 6-month period. Chloride liberation occurred throughout the operation, and the reactor had 4-CP removal efficiencies of 69-100%. Periods of lower performance were attributed to clogging of the column with biomass and the formation of channels. Subsequently, the immobilized biofilm was subjected to a starvation period of 5 months, after which its degradative capacity was still maintained. The microbial consortium was characterized during the continuous flow experiment and dynamic population changes were observed throughout. One isolate recovered from the biofilm was shown to be capable of degrading 4-CP as a sole carbon and energy source.

Gordonia namibiensis sp. nov., a novel nitrile metabolising actinomycete recovered from an African sand.

A polyphasic approach was used to establish the taxonomic position of two actinomycetes isolated from a Namibian soil and shown to utilise nitrile compounds as growth substrates. The organisms, strains NAM-BN063AT and NAM-BN063B, had chemical and morphological properties consistent with their assignment to the genus Gordonia. Direct 165 rRNA sequencing studies confirmed the taxonomic position of the strains following the generation of phylogenetic trees using four different algorithms. The strains consistently formed a distinct phylogenetic line within the evolutionary radiation occupied by gordoniae and were most closely related to Gordonia rubropertincta DSM 43197T. DNA:DNA relatedness studies indicated that the two organisms belonged to a genomic species that was readily distinguished from G. rubropertincta. The unique phenotypic profile of the strains sharply separated them from representatives of all of the validly described species of Gordonia. The combination of genotypic and phenotypic data indicates that the two strains should be classified in the genus Gordonia as a new species. The name proposed for this taxon is Gordonia namibiensis, the type strain is NAM-BN063AT (= DSM 44568T = NCIMB 13780T).

Search and discovery strategies for biotechnology: the paradigm shift.

Profound changes are occurring in the strategies that biotechnology-based industries are deploying in the search for exploitable biology and to discover new products and develop new or improved processes. The advances that have been made in the past decade in areas such as combinatorial chemistry, combinatorial biosynthesis, metabolic pathway engineering, gene shuffling, and directed evolution of proteins have caused some companies to consider withdrawing from natural product screening. In this review we examine the paradigm shift from traditional biology to bioinformatics that is revolutionizing exploitable biology. We conclude that the reinvigorated means of detecting novel organisms, novel chemical structures, and novel biocatalytic activities will ensure that natural products will continue to be a primary resource for biotechnology. The paradigm shift has been driven by a convergence of complementary technologies, exemplified by DNA sequencing and amplification, genome sequencing and annotation, proteome analysis, and phenotypic inventorying, resulting in the establishment of huge databases that can be mined in order to generate useful knowledge such as the identity and characterization of organisms and the identity of biotechnology targets. Concurrently there have been major advances in understanding the extent of microbial diversity, how uncultured organisms might be grown, and how expression of the metabolic potential of microorganisms can be maximized. The integration of information from complementary databases presents a significant challenge. Such integration should facilitate answers to complex questions involving sequence, biochemical, physiological, taxonomic, and ecological information of the sort posed in exploitable biology. The paradigm shift which we discuss is not absolute in the sense that it will replace established microbiology; rather, it reinforces our view that innovative microbiology is essential for releasing the potential of microbial diversity for biotechnology penetration throughout industry. Various of these issues are considered with reference to deep-sea microbiology and biotechnology.

Rapid characterisation of deep-sea actinomycetes for biotechnology screening programmes.

A continual need in natural product discovery is dereplication, that is the ability to exclude previously tested microorganisms from screening programmes. Whole-cell fingerprinting techniques offer an ideal solution to this problem because of their rapidity and reproducibility, dependence on small samples, and automation. One such technique, Curie-point pyrolysis mass spectrometry (PyMS), has been deployed for the characterisation of a unique collection of actinomycetes recovered from Pacific Ocean sediments approximately 2000 to 6500 m below sea level. This paper addresses the question: to what extent are pyrogroups, defined on the basis of PyMS fingerprinting, related to classifications derived from more conventional microbial systematics? A collection of 44 randomly chosen deep-sea rhodococci were coded and subjected to a double-blind PyMS and numerical taxonomic (NT) analysis; the latter sorted the strains into clusters (taxospecies) using large sets of equally weighted phenotypic data. At the end of the experiment the codes were disclosed and the NT classification shown to generate 6 homogeneous clusters corresponding to different deep-sea sites. The matching of these clusters with the resulting pyrogroups was very high with an overall congruence of nearly 98%. Thus, PyMS characterisation is directly ascribable to the phenotypic variation being sought for biotechnology screens. Moreover, the exquisite discriminatory power of PyMS readily revealed infraspecific diversity in these industrially important bacteria.

Clean technology: industry and environment, a viable partnership?

The industrial sector is becoming increasingly interested in eliminating potential pollution at source and reducing energy use. Biotechnology provides cheaper, cleaner alternatives to a wide range of traditional processes--but its adoption has been slower than expected. If industry is to become truly compatible with the environment, companies and the public will have to be convinced of the ecological and economic value of clean technology.

4-Chlorophenol degradation by a bacterial consortium: development of a granular activated carbon biofilm reactor.

A bacterial consortium that can degrade chloro- and nitrophenols has been isolated from the rhizosphere of Phragmitis communis. Degradation of 4-chlorophenol (4-CP) by a consortium attached to granular activated carbon (GAC) in a biofilm reactor was evaluated during both open and closed modes of operation. During the operation of the biofilm reactor, 4-CP was not detected in the column effluent, being either adsorbed to the GAC or biodegraded by the consortium. When 4-CP at 100 mg l-1 was fed to the column in open mode operation (20 mg g-1 GAC total supply), up to 27% was immediately available for biodegradation, the rest being adsorbed to the GAC. Biodegradation continued after the system was returned to closed mode operation, indicating that GAC bound 4-CP became available to the consortium. Biofilm batch cultures supplied with 10-216 mg 4-CP g-1 GAC suggested that a residual fraction of GAC-bound 4-CP was biologically unavailable. The consortium was able to metabolise 4-CP after perturbations by the addition of chromium (Cr VI) at 1-5 mg l-1 and nitrate at concentrations up to 400 mg l-1. The development of the biofilm structure was analysed by scanning electron microscopy and confocal laser scanning microscopy (CLSM) techniques. CLSM revealed a heterogeneous structure with a network of channels throughout the biofilm, partially occupied by microbial exopolymer structures.

Constraints on the transport and glycosylation of recombinant IFN-gamma in Chinese hamster ovary and insect cells.

In this study we compare intracellular transport and processing of a recombinant glycoprotein in mammalian and insect cells. Detailed analysis of the N-glycosylation of recombinant human IFN-gamma by matrix-assisted laser-desorption mass spectrometry showed that the protein secreted by Chinese hamster ovary and baculovirus-infected insect Sf9 cells was associated with complex sialylated or truncated tri-mannosyl core glycans, respectively. However, the intracellular proteins were predominantly associated with high-mannose type oligosaccharides (Man-6 to Man-9) in both cases, indicating that endoplasmic reticulum to cis-Golgi transport is a predominant rate-limiting step in both expression systems. In CHO cells, although there was a minor intracellular subpopulation of sialylated IFN-gamma glycoforms identical to the secreted product (therefore associated with late-Golgi compartments or secretory vesicles), no other intermediates were evident. Therefore, anterograde transport processes in the Golgi stack do not limit secretion. In Sf9 insect cells, there was no direct evidence of post-ER glycan-processing events other than core fucosylation and de-mannosylation, both of which were glycosylation site-specific. To investigate the influence of nucleotide-sugar availability on cell-specific glycosylation, the cellular content of nucleotide-sugar substrates in both mammalian and insect cells was quantitatively determined by anion-exchange HPLC. In both host cell types, UDP-hexose and UDP-N-acetylhexosamine were in greater abundance relative to other substrates. However, unlike CHO cells, sialyltransferase activity and CMP-NeuAc substrate were not present in uninfected or baculovirus-infected Sf9 cells. Similar data were obtained for other insect cell hosts, Sf21 and Ea4. We conclude that although the limitations on intracellular transport and secretion of recombinant proteins in mammalian and insect cells are similar, N-glycan processing in Sf insect cells is limited, and that genetic modification of N-glycan processing in these insect cell lines will be constrained by substrate availability to terminal galactosylation.

Biocatalysts for clean industrial products and processes.

Biocatalysis inherently offers the prospect of clean industrial processing and has become an accepted technology throughout most sectors. The convergence of biology and chemistry has enabled a plethora of industrial opportunities to be targeted, while discoveries in biodiversity and the impact of molecular biology and computational science are extending the range of natural and engineered biocatalysts that can be customised for clean industrial requirements.

Vancomycin production is enhanced in chemostat culture with biomass-recycle.

Production of the glycopeptide antibiotic vancomycin by Amycolatopsis orientalis ATCC 19795 was examined in phosphate-limited chemostat cultures with biomass-recycle, employing an oscillating membrane separator, at a constant dilution rate (D= 0. 14 h-1). Experiments made under low agitation conditions (600 rpm) showed that the biomass concentration could be increased 3.9-fold with vancomycin production kinetics very similar to that of chemostat culture without biomass-recycle. The specific production rate (qvancomycin) was maximal when the biomass-recycle ratio (R) was 0.13 (D= 0.087 h-1). When the dissolved oxygen tension dropped below 20% (air saturation), the biomass and vancomycin concentrations decreased and an unidentified red metabolite was released into the culture medium. Using increased agitation (850 rpm), used to maintain the dissolved oxygen tension above 20% air saturation, maximum increases in biomass concentration (7.9-fold) and vancomcyin production 1.6-fold (0.6 mg/g dry weight/h) were obtained when R was 0.44 (D= 0.056 h -1) compared to chemostat culture without biomass-recycle. Moreover, at this latter recycle ratio the volumetric vancomycin production rate was 14.7 mg/L/h (a 7-fold increase compared to chemostat culture without biomass-recycle). These observations encourage further research on biomass-recycling as a means of optimising the production of antibiotics.

Sporulation at minimum specific growth rate in Aspergillus nidulans chemostat culture predicted using protein synthesis efficiency estimations.

Ribosomal efficiency (RE) estimates provide a quantitative descriptor of intrinsic growth rate of cell populations using readily-obtainable experimental data. In Aspergillus nidulans chemostat cultures, RE increased linearly with growth rate over the range 25-60% of maximum growth rate (mu max), consistent with increasing ribosomal usage with increased growth rate. Above 60%, RE did not increase significantly, suggesting that all ribosomes were functional at 60% of mu max, further increases in growth rate, presumably resulting from increased polypeptide chain elongation rate. Extrapolating the linear part of the RE/growth rate curve predicted zero RE at a growth rate of 0.04 h-1. Chemostat steady state cultures at 0.04 h-1 contained spores (conidia), apparently undergoing a continuous sporulation/germination cycle. We propose that the RE estimates provide a means of predicting the value of minimum specific growth rate (mu min) below which net growth cannot take place.

Taxonomy and biotransformation activities of some deep-sea actinomycetes.

Deep-sea soft sediments from trench systems and depths in the northwestern Pacific Ocean ranging from less than 300 to 10,897 m in depth have been analyzed for three target genera of actinomycetes: Micromonospora, Rhodococcus, and Streptomyces. Only culturable strains, recovered at atmospheric pressure on selective isolation media, have been examined to date. Maximum recoveries of culturable bacteria were greater that 10(7)/ml wet g sediment, but actinomycetes comprised a small proportion of this population (usually less than 1%). The target actinomycetes were isolated at all depths except from the Mariana Trench sediments. Actinomycete colonies were defined initially on the basis of colony morphologies, and preliminary identification then was made by chemotaxonomic tests. Pyrolysis mass spectrometry (PyMS) of deep-sea mycolic acid-containing actinomycetes gave excellent correspondence with numerical (phenetic) taxonomic analyses and subsequently was adopted as a rapid procedure for assessing taxonomic diversity. PyMS analysis enabled several clusters of deep-sea rhodococci to be distinguished that are quite distinct from all type strains. 16S rRNA gene sequence analysis has revealed that several of these marine rhodococci have sequences that are very similar to certain terrestrial species of Rhodococcus and to Dietzia. There is evidence for the intrusion of terrestrial runoff into these deep trench systems, and the inconsistency of the phenotypic and molecular taxonomies may reflect recent speciatiion events in actinomycetes under the high-pressure conditions of the deep sea. The results of DNA-DNA pairing experiments point to the novelty of Rhodococcus strains recovered from hadal depths in the Izu Bonin Trench. Biotransformation studies of deep-sea bacteria have focused on nitrile compounds. Nitrile-metabolizing bacteria, closely related to rhodococci, have been isolated that grow well at low temperature, high salt concentrations, and high pressures, suggesting that they are of marine origin or have adapted to the deep-sea environment.

Biochemical characterization of a haloalcohol dehalogenase from Arthrobacter erithii H10a.

Arthrobacter erithii H10a possesses two enzymes capable of catalyzing the dehalogenation of vicinal halohydrins which have been designated as dehalogenases DehA and DehC. The DehA dehalogenase demonstrated greater activity toward 1,3-dichloro-2-propanol (1,3-DCP) while the DehC dehalogenase showed higher activity toward 3-chloro-1,2-propanediol (3-CPD) and brominated alcohols. The DehA dehalogenase was composed of two non-identical subunits (relative molecular mass of 31.5 and 34 kDa) which probably associate with other proteins to form a large catalytically active protein of 200 kDa. The two subunits were purified and the amino acid sequence of their tryptic digests determined. The DehA enzyme catalyzed the conversion of vicinal halohydrins to epoxides and the reverse reaction in the presence of an excess of halogen. This enzyme had maximum activity at 50 degrees C and a broad pH optimum over the range 8.5-10.5. The apparent K(m) and Vmax values for dehalogenation of 1,3-DCP and 3-CPD were 0.105 mM and 223 mumol min-1 mg-1; and 2.366 mM and 1.742 mumol min-1 mg-1, respectively. The enzyme was inhibited by 2-chloroacetic acid (MCA) and 2,2-dichloroacetic acid (DCA). The inhibition pattern suggested a mixed type inhibition which was predominantly uncompetitive. Amino acid modification experiments demonstrated that one or more cysteine and arginine residues are likely to be involved in catalysis or play an important role in the maintenance of the enzyme structure. The characteristics of the DehA enzyme are compared to those of previously reported haloalcohol dehalogenases and discussed in terms of diversity of this type of dehalogenase.

Novel rhodococci and other mycolate actinomycetes from the deep sea.

A large number of mycolate actinomycetes have been recovered from deep-sea sediments in the NW Pacific Ocean using selective isolation methods. The isolates were putatively assigned to the genus Rhodococcus on the basis of colony characteristics and mycolic acid profiles. The diversity among these isolates and their relationship to type strains of Rhodococcus and other mycolate taxa were assessed by Curie point pyrolysis mass spectrometry (PyMS). Three major (A, C, D) and two minor (B, E) groups were defined by PyMS. Cluster A was a large group of isolates recovered from sediment in the Izu Bonin Trench (2679 m); Cluster C comprised isolates from both the Izu Bonin Trench (6390 and 6499 m) and from the Japan Trench (4418, 6048 and 6455 m). These Cluster C isolates showed close similarity to Dietzia maris and this was subsequently confirmed using molecular methods. Cluster D contained isolates recovered from a sediment taken from a depth of 1168 m in Sagami Bay and were identified as members of the terrestrial species Rhodococcus luteus. Clusters B and E had close affinities with members of the genera Gordonia and Mycobacterium. The presence of Thermoactinomyces in certain of the deep-sea sediments studied was indicative of the movement of terrestrial material into the ocean depths. 16S ribosomal RNA gene sequence analyses produced excellent definition of most genera of the mycolata, and indicated that the among the deep sea isolates (1) were novel species of Corynebacterium, Gordonia and Mycobacterium, and (2) a Sea of Japan isolate the phylogenetic depth of which suggests the possibility of a new genus. Polyphasic taxonomic analysis revealed considerable diversity among the deep sea rhodococci and evidence for recently diverged species or DNA groups.

Monitoring recombinant human interferon-gamma N-glycosylation during perfused fluidized-bed and stirred-tank batch culture of CHO cells.

Chinese hamster ovary cells producing recombinant human interferon-gamma were cultivated for 500 h attached to macroporous microcarriers in a perfused, fluidized-bed bioreactor, reaching a maximum cell density in excess of 3 x 10(7) cells (mL microcarrier)-1 at a specific growth rate (mu) of 0.010 h-1. During establishment of the culture, the N-glycosylation of secreted recombinant IFN-gamma was monitored by capillary electrophoresis of intact IFN-gamma proteins and by HPLC analysis of released N-glycans. Rapid analysis of IFN-gamma by micellar electrokinetic capillary chromatography resolved the three glycosylation site occupancy variants of recombinant IFN-gamma (two Asn sites occupied, one Asn site occupied and nonglycosylated) in under 10 min per sample; the relative proportions of these variants remained constant during culture. Analysis of IFN-gamma by capillary isoelectric focusing resolved at least 11 differently sialylated glycoforms over a pI range of 3.4 to 6.4, enabling rapid quantitation of this important source of microheterogeneity. During perfusion culture the relative proportion of acidic IFN-gamma proteins increased after 210 h of culture, indicative of an increase in N-glycan sialylation. This was confirmed by cation-exchange HPLC analysis of released, fluorophore-labeled N-glycans, which showed an increase in the proportion of tri- and tetrasialylated N-glycans associated with IFN-gamma during culture, with a concomitant decrease in the proportion of monosialylated and neutral N-glycans. Comparative analyses of IFN-gamma produced by CHO cells in stirred-tank culture showed that N-glycan sialylation was stable until late in culture, when a decline in sialylation coincided with the onset of cell death and lysis. This study demonstrates that different modes of capillary electrophoresis can be employed to rapidly and quantitatively monitor the main sources of glycoprotein variation, and that the culture system and operation may influence the glycosylation of a recombinant glycoprotein.

Some biochemical properties and the classification of a range of bacterial haloalkane dehalogenases.

Multivariate analyses and experimental data have been used to evaluate the relationships between eight bacterial hydrolytic haloalkane dehalogenases. The results indicate that seven of the dehalogenases investigated can confidently be placed into two Classes [sensu Slater, Bull and Hardman (1995) Biodegradation 6, 181-189] according to their substrate profiles. The remaining enzyme, isolated from Rhodococcus erythropolis CP9, appears to represent a third Class of haloalkane dehalogenases.

Monitoring proteolysis of recombinant human interferon-gamma during batch culture of Chinese hamster ovary cells.

Proteolytic cleavage of recombinant human interferon-gamma (IFN-gamma) expressed in Chinese hamster ovary (CHO) cells during batch fermentation has been monitored by mass spectrometric peptide mapping. IFN-gamma was purified from cell-free culture supernatant by immunoaffinity chromatography and cleaved by endoprotease Asp-N. Peptide fragments were resolved by reverse-phase HPLC and identified by a combination of matrix-assisted laser desorption/ionization time-of-flight (MALDI-TOF) mass spectrometry (MS) and automated N-terminal peptide sequencing. Using this approach, a peptide was identified as the C-terminal fragment of the IFN-gamma polypeptide. Analysis of this peptide by MS indicated that the recombinant IFN-gamma polypeptide secreted by CHO cells was truncated by at least ten amino acids, initially at Gln133-Met134. No full length (143 amino acids) polypeptide molecules were observed at any stages of the fermentation. Additional proteolytic cleavages at basic amino acids N-terminal of Gln133 occurred during the later stages of the culture resulting in a heterogeneous IFN-gamma polypeptide with "ragged" C-termini.

Biodehalogenation of low concentrations of 1,3-dichloropropanol by mono- and mixed cultures of bacteria.

The degradation of low concentrations of 1,3-dichloro-2-propanol (1,3-DCP) and related halohydrins by whole cells and cell-free extracts of soil bacteria has been investigated. Three bacteria (strains A1, A2, A4), isolated from the same soil sample, were distinguished on the basis of cell morphology, growth kinetics and haloalcohol dehalogenase profiles. Strain A1, probably an Agrobacterium sp., dehalogenated 1,3-DCP with the highest specific activity (0.33 U mg protein-1) and also had the highest affinity for 1,3-DCP (Km, 0.1 mM). Non-growing cells of this bacterium dehalogenated low concentrations of 1,3-DCP with a first-order rate constant (kl) of 1.13 h-1. The presence of a non-dehalogenating bacterium, strain G1 (tentatively identified as Pseudomonas mesophilius), did not enhance the dehalogenation rate of low 1,3-DCP concentrations. However, the mixed-species consortium of strains A1 and G1 had greater stability than the mono-species culture at DCP concentrations above 1.0 gl-1.