The impact of replacing barley by dehydrated orange pulp in finishing pig diets on performance, carcass quality, and gaseous emissions from slurry.

Using agricultural by-products such as dehydrated orange pulp (DOP) in animal feeds is of interest to increase pig sector sustainability. With this aim, an assay was carried out to assess the effects of increasing inclusion levels of DOP in pig diets regarding animal performance, carcass quality, and environmental impact. Four experimental diets were designed, a control diet (T1) and three more diets with increasing levels of DOP with 80, 160, and 240 g/kg of DOP for diets T2, T3, and T4, respectively. One hundred and sixty growing pigs were used in the experiment. Growth performance (average daily gain, ADG; average daily feed intake, ADFI and feed conversion ratio, FCR) and in vivo backfat thickness (BF) and loin depth (LD) gain were recorded during the finishing phase (from 70 to 130 kg BW). Faecal samples were incubated for bacteria enumeration. At slaughter, carcass characteristics and meat quality traits were measured, and subcutaneous fat was sampled to analyse the fatty acid (FA) profile. Additionally, the slurry excreted by the animals was measured, characterised and subjected to a gaseous emission assay during its storage. The final BW and overall ADFI, ADG and FCR were similar among treatments. In vivo final LD and BF gain decreased (P ≤ 0.10) as the inclusion level of DOP increased. No differences were observed in carcass characteristics with the inclusion of DOP, except carcass weight that decreased linearly (P = 0.05) with DOP. Regarding the FA profile of the subcutaneous fat, the ratio of total monounsaturated to saturated FA increased with the inclusion level of DOP. Neither slurry excretion and characterisation nor bacterial counts from faeces showed any significant difference among treatments. The inclusion of DOP led to greater CH4 emissions in mg per L of slurry and hour, whereas these differences disappeared when expressed in mg per animal and day. In all, it has been demonstrated that the inclusion of DOP up to 240 mg/kg in pig diets had minor effects on growth performance, carcass quality traits or gaseous emissions from slurry, favouring the circular economy strategy and pig sector sustainability.

Partially defatted olive cake in finishing pig diets: implications on performance, faecal microbiota, carcass quality, slurry composition and gas emission.

One of the key factors to improve swine production sustainability is the use of agro-industrial by-products in feeds, such as olive by-products. However, it is necessary to assess its effects on the overall production process, including the animal and the environment. With this aim, an experiment was conducted to determine the effects of including a partially defatted olive cake (PDOC) in pig diets on growth performance, faecal microbiota, carcass quality and gas emission from the slurry. Two finishing diets were formulated, a control (C) diet and a diet with PDOC included at 120 g/kg. Eighty finishing male pigs Duroc-Danbred × (Landrace × Large White) of 60.4 ± 7.00 kg BW were divided between these two treatments. During the finishing period (60 to 110 kg BW, 55 days) average daily gain, average daily feed intake and feed conversion ratio were recorded. Faecal samples from the rectum of 16 animals per treatment were incubated for bacteria enumeration. At the end of finishing period, backfat thickness and loin depth (LD) were measured. Animals were slaughtered to obtain carcass weight and carcass composition parameters, and subcutaneous fat was sampled to analyse the fatty acid (FA) profile. In addition greenhouse gas and ammonia emissions were measured during pig slurry storage using the methodology of dynamic flux chambers. An initial slurry characterisation and biochemical methane potential (B0) were also determined. No significant differences between treatments were found in performance, carcass quality and microbial counts with the exception of LD, which was lower in PDOC compared with C animals (45.5 v. 47.5 mm, SEM: 0.62; P = 0.020). The FA profile of the subcutaneous fat did not differ between treatments, but the monounsaturated FA (MUFA) concentration was higher and the polyunsaturated FA was lower in the animals fed PDOC (50.9 v. 48.3, SEM: 0.48, P < 0.001; 17.6 v. 19.3, SEM: 0.30, P < 0.001 in mg/100 g of Total FA, for PDOC and C animals, respectively). The initial pig slurry characterisation only showed differences in ADF concentration that was higher (P < 0.05) in the slurry from PDOC treatment. Regarding gas emission, slurries from both treatments emitted similar amounts of ammonia (NH3), carbon dioxide (CO2), methane (CH4) and nitrous oxide (N2O), as well as B0 values. The results obtained suggest that PDOC may be included in balanced pig diets at rates of up to 120 g/kg without negative effects on performance, carcass quality, gut microflora and slurry gas emission, while improving the MUFA concentration of subcutaneous fat.

Effect of micellized natural (D-α-tocopherol) vs. synthetic (DL-α-tocopheryl acetate) vitamin E supplementation given to turkeys on oxidative status and breast meat quality characteristics.

This study evaluates the effect of vitamin E supplementation source (micellized natural vs. the synthetic form) and dosage (40, 80, or 120 mg/kg) on α-tocopherol concentration in plasma and muscle, antioxidant capacity, and breast meat quality in turkeys. Three hundred female turkeys were randomly selected at an average live weight 63.2 g±0.5 and distributed into 7 groups. One group (control) was fed a standard diet without vitamin E supplementation and the other 6 were given mixed diets supplemented with the natural (d-α-tocopherol) or synthetic (dl-α-tocopheryl acetate) form of vitamin E in 3 dosages (40, 80, or 120 mg/kg). Following 11 wk feeding, results showed that performance parameters were not modified either by source or dosage of vitamin E supplementation to the turkeys. Plasma and muscle α-tocopherol at d 9 of refrigerated storage were higher when turkeys were supplemented with the natural form at higher doses. Losses in the concentration of α-tocopherol in meat between the beginning and the end of the 9 d refrigerated storage were greater in the groups supplemented with the synthetic form of vitamin E compared to those receiving the natural supplementation. The relationship between plasma α-tocopherol and the Trolox equivalent antioxidant capacity followed a different trend depending on the vitamin E source. Intramuscular fat was not significantly affected by the vitamin E source supplementation; however the slope of the linear regression equation was lower for the natural form than for the synthetic form. Turkeys given the natural form had higher C18:1n-9 but lower C15:1, C17:1, C20:5n-3, and C22:6n-3 in breast muscle. Meat samples from turkeys supplemented with natural vitamin E had higher deoxymyoglobin at d 3, 6, and 9 and lower metmyoglobin at d 9 of refrigerated storage than those receiving the synthetic form. Dietary supplementation with medium doses (80 mg/kg) micellized d-α-tocopherol is an interesting feeding strategy for ensuring antioxidant status and improving meat quality.

The impact of a specific blend of essential oil components and sodium butyrate in feed on growth performance and Salmonella counts in experimentally challenged broilers.

Essential oils (EO) and short-chain fatty acids have potential antimicrobial activity in broilers. This study aimed to investigate the effect of a specific blend of EO and a combination of this blend of EO with sodium-butyrate on growth performance and Salmonella colonization in broilers. A total of 480 one-day-old male broilers were distributed into 5 treatments (8 pens per treatment and 12 birds per pen) and reared during 42 d in experimental conditions. Dietary treatments consisted of the addition of different doses of EO (0 mg/kg, control; 50 mg/kg, EO50 and 100 mg/kg, EO100) or a combination of EO with 1 g/kg of sodium-butyrate (B; EO50 + B, EOB50 and EO100 + B, EOB100) to a basal diet. All birds were orally infected with 10(8) cfu of Salmonella Enteritidis on d 7 of study. Individual BW and feed intake per pen were measured at arrival and on a weekly basis. The prevalence and enumeration of Salmonella in feces was determined per treatment at 72 h postinfection and on d 23 and 37 of study. At slaughter, cecal content and liver samples from 16 birds per treatment were cultured for Salmonella and cecal pH was measured. No differences were observed on growth performance among treatments. All fecal samples analyzed were positive for Salmonella from d 10 to the end of the rearing period. At slaughter, Salmonella contamination (positive samples) in cecum was lower in birds fed EOB50 compared with the other treatments (P < 0.05), whereas birds fed the control diet showed the highest colonization rates. The pH of the cecal content was not different among treatments. Thus, EO or its combination with sodium-butyrate did not affect growth performance. However, a clear effectiveness of these products was observed in Salmonella control, especially when low doses of EO were combined with sodium-butyrate (EOB50).

Microbial examination of anaerobic sludge adaptation to animal slurry.

The objective of this study was to evaluate changes in the microbial population of anaerobic sludge digesters during the adaptation to pig slurry (PS) using quantitative real-time polymerase chain reaction (qPCR) and qualitative scanning electron microscopy (SEM). Additionally, the relationship between microbial parameters and sludge physicochemical composition and methane yield was examined. Results showed that the addition of PS to an unadapted thermophilic anaerobic digester caused an increase in volatile fatty acids (VFA) concentration, a decrease in removal efficiency and CH4 yield. Additionally, increases in total bacteria and total archaea were observed using qPCR. Scanning electron micrographs provided a general overview of the sludge's cell morphology, morphological diversity and degree of organic matter degradation. A change in microbial morphotypes from homogeneous cell morphologies to a higher morphological diversity, similar to that observed in PS, was observed with the addition of PS by SEM. Therefore, the combination of qPCR and SEM allowed expanding the knowledge about the microbial adaptation to animal slurry in thermophilic anaerobic digesters.

Process performance of anaerobic co-digestion of raw and acidified pig slurry.

The effect of incorporating different ratios of acidified pig slurry on methane yield was evaluated in two scales of anaerobic digesters: Thermophilic (50 °C) pilot scale digester (120 l), operating with an average hydraulic retention time of 20 days and thermophilic (52 °C) full-scale digesters (10 and 30 m(3)), operating with an average hydraulic retention time of 30 days. In the lab-scale digester, different inclusion levels of acidified slurry (0-60%) were tested each 15 days, to determine the maximum ratio of acidified to non-acidified slurry causing inhibition and to find process state indicators helping to prevent process failure. In the full-scale digesters, the level of inclusion of the acidified slurry was chosen from the ratio causing methane inhibition in the pilot scale experiment and was carried on in a long-term process of 100 days. The optimal inclusion level of acidified pig slurry in anaerobic co-digestion with conventional slurry was 10%, which promoted anaerobic methane yield by nearly 20%. Higher inclusion levels caused methane inhibition and volatile fatty acids accumulations in both experiments. In order to prevent process failure, the most important traits to monitor in the anaerobic digestion of acidified pig slurry were found to be: sulfate content of the slurry, alkalinity parameters (especially partial alkalinity and the ratio of alkalinity) and total volatile fatty acids (especially acetic and butyric acids).

Increasing energy and lysine in diets for growing-finishing pigs in hot environmental conditions: consequences on performance, digestibility, slurry composition, and gas emission.

The influence of dietary nutrient concentration on growth performance, manure composition, and gas emission was studied in pigs in hot environmental conditions. A total of 64 intact males and 64 females [(Landrace × Large White) × Pietrain] weighing 63.1 ± 9.7 kg were divided into 2 dietary treatments: high (HD: 14.39 MJ of DE/kg and 1.11% Lys) and low (LD: 13.97 MJ of DE/kg and 1.01% Lys) in energy and Lys contents. Pigs were allocated to 32 split-sex pens with 4 pigs/pen and 16 pens/treatment. Average productive performance was recorded for 41 d (phase 1). After phase 1, 12 females of 103.3 ± 3.15 kg (6 per treatment) were selected and housed individually, and feces and slurry were collected during 3 and 4 consecutive days, respectively, to calculate nutrient digestibility and measure gas emissions (phase 2). For gas emission measurements, slurry was pooled by treatment and stored for 76 d. Initial composition of slurry and pH were analyzed. Maximum and minimum temperatures registered in the barn throughout the growing period were 35.1 and 18.1°C, respectively. Animals fed the HD diet grew more efficiently than pigs fed the LD diet (G:F, 0.43 vs. 0.40; SEM = 0.01; P < 0.05). Fat digestibility was greater in HD compared with LD pigs (88.0 vs. 84.9%; SEM = 0.9; P < 0.05). Slurry from pigs fed the LD diet showed greater DM, OM, total N, and VFA contents than slurry from pigs fed the HD diet. Cumulative NH(3), CO(2), and especially CH(4) emissions were greater in the HD slurry compared with the LD slurry (192.4 vs. 210.g of NH(3)/m(3); 2,712 vs. 3,210 g of CO(2)/m(3); 1,502 vs. 2,647 mL of CH(4)/kg of OM). Increasing feed density in the present study led to a more efficient growth, a decreased nutrient concentration in the slurry, and a greater gas emission.

Increased sow nutrition during midgestation affects muscle fiber development and meat quality, with no consequences on growth performance.

Pregnant sow nutrition has potential effects on the muscle fiber development of progeny in utero. A total of 199 Landrace x Large White sows from parities 0 to 6 and their offspring were used to evaluate the effects of increasing the feeding amount during midpregnancy on the muscle tissue, growth performance, and meat quality of the progeny. The experiment was divided into 2 study replicates, and in each replicate, sows were assigned to 1 of the 2 treatments: 1) sows in the control group (C sows) were fed 2.5 to 3.0 kg/d (feed: 12.1 MJ of ME/kg and 0.62% lysine) throughout gestation; and 2) sows in the high group (H sows) received an extra feed allowance of 1.5 kg/d for gilts and 2.0 kg/d for multiparous sows above the C amount from d 45 to 85 of gestation (period of secondary muscle fiber formation). Sow backfat was recorded on d 40 and 85 of gestation. Sow performance (litter size and piglet BW) at farrowing and on d 18 of lactation was measured. At weaning, pigs were divided into 5 BW groups/treatment, and progeny growth performance was measured during the nursery (n = 958) and the growing-finishing (n = 636) periods. At slaughter, carcass and meat quality traits (lean content, main cut weight, pH, Minolta color, and drip loss) were recorded from the second lightest group at weaning (BW group 4; n = 90), and samples from the longissimus thoracis muscle were taken to study muscle fiber characteristics (n = 70). The extra nutrition from d 45 to 85 of gestation did not lead to differences in litter size or piglet BW at farrowing and on d 18 of lactation. Pigs born to H mothers had fewer muscle fibers and fewer estimated primary and secondary fibers than did pigs born to C mothers (P < 0.05). However, postnatal growth performance was not consistently affected by the maternal treatment. The smaller number of muscle fibers found in the H group of pigs was associated with fewer type IIB fibers (P < 0.05) with greater cross-sectional areas (P < 0.10), which might be related to the significantly greater meat pH at 24 h postmortem and the smaller L* (lightness) values recorded in the H group of pigs. Results from the present study confirm the existence of effects of maternal nutrition on fetal development, at least in terms of muscle tissue development and meat quality, although with no beneficial effects were found for the postnatal growth performance of the progeny.

How many muscle samples are required to obtain reliable estimations of muscle fibre characteristics from pig longissimus muscle?

In order to investigate the reliability of muscle fibre trait estimations of pig longissimus muscle and to derive the minimum number of samples required per muscle cross-section and animal, intraclass correlation coefficients (ICC, ϑˆ) were obtained by one-way analysis of variance. From each of 23 market weight pigs five samples, evenly distributed over the muscle cross-sectional area at the 12th/13th rib level, were taken and analyzed for various muscle fibre traits. The number of samples required per muscle cross-section was found to be different between selected fibre traits, ranging from a minimum of three (for number of muscle fibres) to a maximum of five or more (for mean fibre area, fibre type composition and relative area occupied by each fibre type). These findings should be taken as a recommendation, but their usefulness will depend upon the goal and conditions of future experiments.