Fire safety study on high-flow nasal oxygen in shared-airway surgeries with diathermy and laser: simulation based on a physical model.

High-flow nasal oxygen (HFNO) has been used in "tubeless" shared-airway surgeries but whether HFNO increased the fire hazard is yet to be examined. We used a physical model for simulation to explore fire safety through a series of ignition trials. An HFNO device was attached to a 3D-printed nose with nostrils connected to a degutted raw chicken. The HFNO device was set at twenty combinations of different oxygen concentration and gas flow rate. An electrocautery and diode laser were applied separately to a fat cube in the cavity of the chicken. Ten 30 s trials of continuous energy source application were conducted. An additional trial of continuous energy application was conducted if no ignition was observed for all the ten trials. A total of eight short flashes were observed in one hundred electrocautery tests; however, no continuous fire was observed among them. There were thirty-six events of ignition in one hundred trials with laser, twelve of which turned into violent self-sustained fires. The factors found to be related to a significantly increased chance of ignition included laser application, lower gas flow, and higher FiO2. The native tissue and smoke can ignite and turn into violent self-sustained fires under HFNO and continuous laser strikes, even in the absence of combustible materials. The results suggest that airway surgeries must be performed safely with HFNO if only a short intermittent laser is used in low FiO2.

How early warning with the Oxygen Reserve Index (ORi™) can improve the detection of desaturation during induction of general anesthesia?

The Oxygen Reserve Index (ORi™) is a dimensionless parameter with a value between 0 and 1. It is related to the real-time oxygenation status in the moderate hyperoxic range. The purpose of this study is to investigate the added warning time provided by different ORi alarm triggers and the continuous trends of ORi, SpO2, and PaO2. We enrolled 25 patients who were scheduled for elective surgery under general anesthesia with planned arterial catheterization before induction. The participants received standardized preoxygenation, induction, and intubation. The patients remained apneic and ventilation was resumed when the SpO2 fell below 90%. The ORi and SpO2 were recorded every ten seconds and arterial blood was sampled every minute, from preoxygenation to resumed ventilation. Alarm triggers set to the ORi peak and the ORi 0.55 values provided 300 and 145 s of significant added warning time compared to SpO2 (p < 0.0001). The coefficient of determination was 0.56 between the ORi and the PaO2 ≤ 240 mmHg and showed a positive correlation. The ORi enables the clinicians to monitor the patients' oxygen status during induction of general anesthesia and can improve the detection of impending desaturation. However, further studies are needed to assess its clinical potential in the high hyperoxic range.The protocol was retrospectively registered at ClinicalTrials.gov on July 21, 2021 (NCT04976504).