Moisture content and aeration control mineral nutrient solubility in poultry litter.

Poultry litter waste is typically land-applied as a soil amendment but repeated application in the vicinity of poultry houses has led to phosphorus accumulation in soil. Such application can also lead to runoff that causes eutrophication. Most farmers store litter under dry conditions or compost the litter prior to land application, but it is not clear if these approaches are best from a nutrient management-perspective. The objective of this study was to investigate the effects of moisture content and active aeration on soluble mineral forms of nitrogen and phosphorus in poultry litter incubated for roughly one month. Mineral forms of nutrients are immediately plant-available upon field application and also most conducive to low-cost stripping and recovery methods. Litters were incubated at 50% and 70% moisture content with and without active aeration. Litter aeration led to significant ammonia losses and a consequent decline in litter pH but it had no effect on phosphate solubility. Moisture content during litter incubation governed the levels of plant-available phosphate and nitrification. High (70%) moisture led to 41%-78% higher plant-available phosphate (4.2-4.8 mg/g litter) compared to litters with 50% moisture content (2.7-3.0 mg/g litter). In contrast, the 50% moisture litters experienced 5-6 fold higher levels of nitrification (0.11-0.12 mg NO3-N/g litter) than litters with 70% moisture content (0.02 mg NO3-N/g litter), regardless of aeration. The implication is that lower-moisture litter storage is likely best for field application because phosphate is less soluble under neutral-alkaline conditions and therefore less likely to end up in runoff. In contrast, higher-moisture litter storage may be amenable to low-cost processes to leach and recover phosphate from litter.

Leaching and anaerobic digestion of poultry litter for biogas production and nutrient transformation.

Anaerobic digestion of poultry litter is a potentially sustainable means of stabilizing this waste while generating biogas. However, technical challenges remain including seasonality of litter production, low C/N ratios, limited digestibility of bedding, and questions about transformation of nutrients during digestion. This study investigated biogas production and nutrient transformations during anaerobic digestion of poultry litter leachate and whole litter. Use of fresh litter collected from within the house was also compared to waste litter cake that was stored outdoors on the farm. The results showed that litter leachates had higher biomethane potential (0.24-0.30 L/gVS) than whole litter (0.15-0.16 L/gVS) and the insoluble bedding material left after leaching (0.08-0.13 L/gVS). Leachates prepared from waste litter cake had lower uric acid and higher acetic acid concentrations than fresh litter indicating that decomposition had occurred during storage. Consequently, waste litter cake had faster initial biogas production but lower final biogas yields compared to fresh litter. In all reactors, uric and acetic acids were completely consumed during digestion, phosphate levels decreased but ammonium levels increased. The results demonstrate that poultry litter leachate is amenable to digestion despite a low C/N ratio and that the remaining insoluble bedding material has been partially stripped of its nutrients. Moreover, litter can be stored prior to digestion but some losses in biomethane potential should be expected due to decomposition of organics during storage.