Effectiveness of levulinic acid and sodium dodecyl sulfate employed as a sanitizer during harvest or packing of cantaloupes contaminated with Salmonella Poona.

Freshly harvested Eastern variety cantaloupes (Cucumis melo L. var. reticulatus cv. Athena) were subjected to three different harvest and wash treatments to examine conditions under which the efficacy of the sanitizer, levulinic acid (LV) plus sodium dodecyl sulfate (SDS), could be enhanced to reduce Salmonella contamination. In treatment set one, cantaloupes were spot inoculated with Salmonella enterica serovar Poona (prepared from solid or liquid media cultures) before or after a 1-min dip treatment in LV (2.5, 5.0, 7.5, or 10%) and 2.5% SDS. S. Poona initial populations on rind tissue (4.26-5.04 log CFU/sample) were reduced to detection by enrichment culture when cantaloupes were subsequently exposed to any of the LV/SDS solutions. When S. Poona was introduced after cantaloupes had been dip-treated, greater decreases in pathogen populations at the stem scar were observed when cantaloupes were treated with increasing concentrations of LV. In treatment set two, the response of S. Poona dip-treated with 5% LV/2.5% SDS was compared to a simulated commercial dump tank treatment incorporating 200 ppm chlorine as well as a two-stage treatment employing both the chlorine tank and LV/SDS dip treatments. S. Poona levels (log CFU/sample or # positive by enrichment culture/# analyzed) after treatments were 5.25, 3.07, 7/10, 5/10 (stem scar) and 3.90, 25/40, 28/40, 20/40 (rind) for non-treated, chlorine tank, LV/SDS dip, and tank plus dip treatments, respectively. In treatment set three, freshly harvested cantaloupes were first treated in the field using a needle-free stem scar injection (200 µl, 7.5% LV/1.0% SDS, 60 psi) and a cantaloupe spray (30 ml, 7.5% LV/0.5% SDS). Cantaloupe stem scar and rind tissue were then spot-inoculated with S. Poona using either a liquid or soil-based medium followed by a simulated dump tank treatment incorporating either 200 ppm chlorine or 5% LV/2% SDS. S. Poona inoculated on field-treated cantaloupe rind decreased by 4.7 and 5.31 (liquid) and 3.27 and 3.36 (soil) log CFU/sample after simulated chlorine and LV/SDS tank treatments, respectively. In the case of stem scar tissue, S. Poona populations exhibited a 1.0 log greater reduction when cantaloupes were treated with LV/SDS compared to chlorine in the dump tank (P<0.05). Based on this study, application of multiple hurdles is warranted, as additional decreases in S. Poona populations were obtained when cantaloupes were subjected to a chlorine dump tank followed by a LV/SDS dip treatment.

Construction and characterization of outbreak Escherichia coli O157:H7 surrogate strains for use in field studies.

Escherichia coli O157:H7 has been the causative agent of many outbreaks associated with leafy green produce consumption. Elucidating the mechanism by which contamination occurs requires monitoring interactions between the pathogen and the plant under typical production conditions. Intentional introduction of virulent strains into fields is not an acceptable practice. As an alternative, attenuated strains of natural isolates have been used as surrogates of the virulent strains; however, the attachment properties and environmental stabilities of these attenuated isolates may differ from the unattenuated outbreak strains. In this study, the Shiga toxin (stx1, stx2, and/or stx2c) genes as well as the eae gene encoding intimin of two E. coli O157:H7 outbreak isolates, F4546 (1997 alfalfa sprout) and K4492 (2006 lettuce), were deleted. Individual gene deletions were confirmed by polymerase chain reaction (PCR) and DNA sequencing. The mutant strains did not produce Shiga toxin. The growth kinetics of these mutant strains under nutrient-rich and minimal conditions were identical to those of their wild-type strains. Attachment to the surface of lettuce leaves was comparable between wild-type/mutant pairs F4546/MD46 and K4492/MD47. Adherence to soil particles was also comparable between the virulent and surrogate pairs, although the F4546/MD46 pair exhibited statistically greater attachment than the K4492/MD47 pair (p≤0.05). Wild-type and mutant pairs F4546/MD46 and K4492/MD47 inoculated into wet or dry soils had statistically similar survival rates over the 7-day storage period at 20°C. A plasmid, pGFPuv, containing green fluorescent protein was transformed into each of the mutant strains, allowing for ease of identification and detection of surrogate strains on plant material or soil. These pGFPuv-containing surrogate strains will enable the investigation of pathogen interaction with plants and soil in the farm production environment where the virulent pathogen cannot be used.

Biotic and abiotic variables affecting internalization and fate of Escherichia coli O157:H7 isolates in leafy green roots.

Preharvest internalization of Escherichia coli O157:H7 into the roots of leafy greens is a food safety risk because the pathogen may be systemically transported to edible portions of the plant. In this study, both abiotic (degree of soil moisture) and biotic (E. coli O157:H7 exposure, presence of Shiga toxin genes, and type of leafy green) factors were examined to determine their potential effects on pathogen internalization into roots of leafy greens. Using field soil that should have an active indigenous microbial community, internalized populations in lettuce roots were 0.8 to 1.6 log CFU/g after exposure to soil containing E. coli O157:H7 at 5.6 to 6.1 log CFU/g. Internalization of E. coli O157:H7 into leafy green plant roots was higher when E. coli O157:H7 populations in soil were increased to 7 or 8 log CFU/g or when the soil was saturated with water. No differences were noted in the extent to which internalization of E. coli O157:H7 occurred in spinach, lettuce, or parsley roots; however, in saturated soil, maximum levels in parsley occurred later than did those in spinach or lettuce. Translocation of E. coli O157:H7 from roots to leaves was rare; therefore, decreases observed in root populations over time were likely the result of inactivation within the plant tissue. Shiga toxin-negative (nontoxigenic) E. coli O157:H7 isolates were more stable than were virulent isolates in soil, but the degree of internalization of E. coli O157:H7 into roots did not differ between isolate type. Therefore, these nontoxigenic isolates could be used as surrogates for virulent isolates in field trials involving internalization.

Internalization and fate of Escherichia coli O157:H7 in leafy green phyllosphere tissue using various spray conditions.

In the past decade, leafy greens have been implicated in several outbreaks of foodborne illness, and research has focused on contamination during preharvest operations. Concerns have been raised that internalization of pathogens into the edible tissue occurs where postharvest chemical interventions would be ineffective. This study was initiated to measure the degree and fate of Escherichia coli O157:H7 internalized in the phyllosphere tissue of leafy greens when spray conditions, inoculum level, and type of leafy green were varied. Two spraying treatments were applied: (i) spraying individual spinach or lettuce leaves on plants once with a high dose (7 to 8 log CFU/ml) of E. coli O157:H7 and (ii) spraying spinach, lettuce, or parsley plants repeatedly (once per minute) with a low dose (2.7 to 4.2 log CFU/ml) of E. coli O157:H7 over a 10- to 20-min period. With the high-dose spray protocol, no significant differences in the prevalence of internalization occurred between Shiga toxin-negative E. coli O157:H7 isolates and virulent isolates (P > 0.05), implying that the Shiga toxin virulence factors did not influence internalization or the subsequent fate of those populations under these test conditions. Significantly greater internalization of E. coli O157:H7 occurred in spinach leaves compared with lettuce leaves when leaves were sprayed once with the high-dose inoculum (P < 0.05), whereas internalization was not observed in lettuce leaves but continued to be observed in spinach and parsley leaves following repeated spraying of the low-dose inoculum. Based on these results, it is surmised that a moisture film was generated when spraying was repeated and this film assisted in the mobilization of pathogen cells to plant apertures, such as stomata. E. coli O157:H7 cells that were internalized into spinach tissue using a low-dose repeat-spray protocol were temporary residents because they were not detected 2 days later, suggesting that plant-microbe interactions may be responsible.

Absence of internalization of Escherichia coli O157:H7 into germinating tissue of field-grown leafy greens.

Both growth chamber and field studies were conducted to investigate the potential for Escherichia coli O157:H7 to be internalized into leafy green tissue when seeds were germinated in contaminated soil. Internalized E. coli O157:H7 was detected by enrichment in both spinach (Spinacia oleracea L.) and lettuce (Lactuca sativa L.) seedlings when seeds were germinated within the growth chamber in autoclaved and nonautoclaved soil, respectively, contaminated with E. coli O157:H7 at 2.0 and 3.8 log CFU/g, respectively. Internalized E. coli O157:H7 populations could be detected by enumeration within leafy green tissues either by increasing the pathogen levels in the soil or by autoclaving the soil. Attempts to maximize the exposure of seed to E. coli O157:H7 by increasing the mobility of the microbe either through soil with a higher moisture content or through directly soaking the seeds in an E. coli O157:H7 inoculum did not increase the degree of internalization. Based on responses obtained in growth chamber studies, internalization of E. coli O157:H7 surrogates (natural isolates of Shiga toxin-negative E. coli O157:H7 or recombinant [stx- and eae-negative] outbreak strains of E. coli O157:H7) occurred to a slightly lesser degree than did internalization of the virulent outbreak strains of E. coli O157:H7. The apparent lack of internalized E. coli O157:H7 when spinach and lettuce were germinated from seed in contaminated soil (ca. 3 to 5 log CFU/g) in the field and the limited occurrence of surface contamination on the seedlings suggest that competition from indigenous soil bacteria and environmental stresses were greater in the field than in the growth chamber. On the rare occasion that soil contamination with E. coli O157:H7 exceeded 5 log CFU/g in a commercial field, this pathogen probably would not be internalized into germinating leafy greens and/or would not still be present at the time of harvest.

Internalization of Escherichia coli O157:H7 following spraying of cut shoots when leafy greens are regrown for a second crop.

Both spinach and lettuce were grown to harvest, cut, and then regrown after spraying the cut shoots with irrigation water contaminated with Escherichia coli O157:H7. Plant tissue was collected on the day of spraying and again 2 and 14 days later for analysis of total and internalized E. coli O157:H7 populations. Internalization of E. coli O157:H7 occurred on the day of spraying, and larger populations were internalized as the level in the spray increased. Tissue repair was slow and insufficient to prevent infiltration of E. coli O157:H7; internalized E. coli O157:H7 in shoots cut 5 days prior to exposure to E. coli O157:H7-contaminated water were not significantly different from levels in shoots cut on the same day of spraying with contaminated water (P > 0.05). Two days after spraying plants with a high level of E. coli O157:H7 (7.3 log CFU/ml), levels of internalized E. coli O157:H7 decreased by ca. 2.6 and 1.3 log CFU/g in Tyee and Bordeaux spinach, respectively, whereas populations of internalized E. coli O157:H7 decreased very little (ca. 0.4 log CFU/g) in lettuce plants that had been sprayed either on the same day as cutting or 1 day after cutting. When cut plants were sprayed with irrigation water at a lower contamination level (4.5 log CFU/ml), internalized E. coli O157:H7 was not detected in either spinach or lettuce plants 2 days later and therefore would not likely be of concern when the crop was harvested.

Evaluation of levulinic acid and sodium dodecyl sulfate as a sanitizer for use in processing Georgia-grown cantaloupes.

Freshly harvested Georgia-grown cantaloupes (Cucumis melo L. var. reticulatus cv. Athena and Atlantis) were spot inoculated with 100 µl of a five-strain mixture of Salmonella enterica serovar Poona (9 log CFU/ml) at the stem scar and on the netted rind and then subjected to no treatment (control) or a 6-min treatment (tank only) in water, 120 ppm of chlorine (pH 7.0), 1% levulinic acid plus 0.1% sodium dodecyl sulfate (SDS; pH 3.0), or 2% levulinic acid plus 0.2% SDS (pH 3.0). The log reduction for the tank-only treatments was 0.31, 0.59, 1.32, and 1.37 log CFU/g at the stem scar and 0.97, 1.59, 2.06. and 3.37 log CFU/g on the netted rind for water, chlorine, 1% levulinic acid plus 0.1% SDS, and 2% levulinic acid plus 0.2% SDS, respectively. A greater log reduction was observed for the cantaloupe surface tissue with the water, chlorine, and 2% levulinic acid plus 0.2% SDS treatments when additional sanitizer (2 ml) and brushing (to simulate cantaloupes tumbling over brushes on the processing line) were added to the dump tank treatment. The stem scar tissue reductions were 0.90, 1.69, and 1.53 log CFU/g, whereas the netted rind reductions were 1.56, 2.50, and 4.47 log CFU/g after treatment with water, chlorine, and 2% levulinic acid plus 0.2% SDS, respectively. These data suggest that 2% levulinic acid plus 0.2% SDS is effective for reducing Salmonella on the netted rind surface of cantaloupes. However, neither 2% levulinic acid plus 0.2% SDS nor 120 ppm of chlorine substantially reduced Salmonella on stem scar tissue.

Preharvest internalization of Escherichia coli O157:H7 into lettuce leaves, as affected by insect and physical damage.

Environmental pests may serve as reservoirs and vectors of zoonotic pathogens to leafy greens; however, it is unknown whether insect pests feeding on plant tissues could redistribute these pathogens present on the surface of leaves to internal sites. This study sought to differentiate the degree of tissue internalization of Escherichia coli O157:H7 when applied at different populations on the surface of lettuce and spinach leaves, and to ascertain whether lettuce-infesting insects or physical injury could influence the fate of either surface or internalized populations of this enteric pathogen. No internalization of E. coli O157:H7 occurred when lettuce leaves were inoculated with 4.4 log CFU per leaf, but it did occur when inoculated with 6.4 log CFU per leaf. Internalization was statistically greater when spinach leaves were inoculated on the abaxial (underside) than when inoculated on the adaxial (topside) side, and when the enteric pathogen was spread after surface inoculation. Brief exposure (∼18 h) of lettuce leaves to insects (5 cabbage loopers, 10 thrips, or 10 aphids) prior to inoculation with E. coli O157:H7 resulted in significantly reduced internalized populations of the pathogen within these leaves after approximately 2 weeks, as compared with leaves not exposed to insects. Surface-contaminated leaves physically injured through file abrasions also had significantly reduced populations of both total and internalized E. coli O157:H7 as compared with nonabraded leaves 2 weeks after pathogen exposure.

Surface and internalized Escherichia coli O157:H7 on field-grown spinach and lettuce treated with spray-contaminated irrigation water.

Numerous field studies have revealed that irrigation water can contaminate the surface of plants; however, the occurrence of pathogen internalization is unclear. This study was conducted to determine the sites of Escherichia coli O157:H7 contamination and its survival when the bacteria were applied through spray irrigation water to either field-grown spinach or lettuce. To differentiate internalized and surface populations, leaves were treated with a surface disinfectant wash before the tissue was ground for analysis of E. coli O157:H7 by direct plate count or enrichment culture. Irrigation water containing E. coli O157:H7 at 10(2), 10(4), or 10(6) CFU/ml was applied to spinach 48 and 69 days after transplantation of seedlings into fields. E. coli O157:H7 was initially detected after application on the surface of plants dosed at 10(4) CFU/ml (4 of 20 samples) and both on the surface (17 of 20 samples) and internally (5 of 20 samples) of plants dosed at 10(6) CFU/ml. Seven days postspraying, all spinach leaves tested negative for surface or internal contamination. In a subsequent study, irrigation water containing E. coli O157:H7 at 10(8) CFU/ml was sprayed onto either the abaxial (lower) or adaxial (upper) side of leaves of field-grown lettuce under sunny or shaded conditions. E. coli O157:H7 was detectable on the leaf surface 27 days postspraying, but survival was higher on leaves sprayed on the abaxial side than on leaves sprayed on the adaxial side. Internalization of E. coli O157:H7 into lettuce leaves also occurred with greater persistence in leaves sprayed on the abaxial side (up to 14 days) than in leaves sprayed on the adaxial side (2 days).

Infrequent internalization of Escherichia coli O157:H7 into field-grown leafy greens.

Several sources of contamination of fresh produce by Escherichia coli O157:H7 (O157) have been identified and include contaminated irrigation water and improperly composted animal waste; however, field studies evaluating the potential for internalization of O157 into leafy greens from these sources have not been conducted. Irrigation water inoculated with green fluorescent plasmid-labeled Shiga toxin-negative strains (50 ml of 10(2), 10(4), or 10(6) CFU of O157 per ml) was applied to soil at the base of spinach plants of different maturities in one field trial. In a second trial, contaminated compost (1.8 kg of 10(3) or 10(5) CFU of O157 per g) was applied to field plots (0.25 by 3.0 m) prior to transplantation of spinach, lettuce, or parsley plants. E. coli O157:H7 persisted in the soil up to harvest (day 76 posttransplantation) following application of contaminated irrigation water; however, internalized O157 was not detected in any spinach leaves or in roots exposed to O157 during the early or late growing season. Internalized O157 was detected in root samples collected 7 days after plants were contaminated in mid-season, with 5 of 30 samples testing positive for O157 by enrichment; however, O157 was not detected by enrichment in surface-disinfected roots on days 14 or 22. Roots and leaves from transplanted spinach, lettuce, and parsley did not internalize O157 for up to 50 days in the second trial. These results indicate that internalization of O157 via plant roots in the field is rare and when it does occur, O157 does not persist 7 days later.