From winery waste to bioactive compounds and new polymeric biocomposites: A contribution to the circular economy concept.

The paper aims at optimising and validating possible routes toward the full valorisation of grape agrowaste to produce bioactive molecules and new materials. Starting from Merlot red pomace, phenol complex mixtures were successfully extracted by using two different approaches. Extracts obtained by solvent-based (SE) technique contained up to 46.9 gGAeq/kgDW of total phenols. Depending on the used solvent, the prevalence of compounds belonging to different phenol families was achieved. Pressurized liquid extraction (PLE) gave higher total phenol yields (up to 79 gGAeq/kgDW) but a lower range of extracted compounds. All liquid extracts exerted strong antioxidant properties. Moreover, both SE and PLE extraction solid residues were directly exploited (between 5 and 20% w/w) to prepare biocomposite materials by direct mixing via an eco-friendly approach with PHBV polymer. The final composites showed mechanical characteristics similar to PHVB matrix. The use of pomace residues in biocomposites could therefore bring both to the reduction of the cost of the final material, as a lower amount of costly PHBV is used. The present research demonstrated the full valorisation of grape pomace, an agrowaste produced every year in large amounts and having a significant environmental impact.

The effect of adding berry fruit juice concentrates and by-product extract to sugar solution on osmotic dehydration and sensory properties of apples.

Osmotic dehydration (OD) of apples caused a reduction of normalized water content (NWC) and an increase of normalized solids gain (NSG), independently of the kind of osmotic solution. The use of 22°Brix osmotic solutions with the addition of fruit concentrates or bilberry extract resulted in only slight reduction in the NWC in the samples, i.e. by about 15 and 20%, respectively after 6 and 24 h, against a value up to 80% in case of 65°Brix use. Similarly, larger NSG was achieved at higher solution concentrations, but the differences were smaller. In the case of the use of 80% bilberry press cake extract the NSG was very low but NWC was relatively high. Such a low concentration of slightly concentrated fruit juices is not effective for dehydration of apples, but it may be sufficient to enrich the fruit with the desired colorants. This higher concentration of osmotic solution and a larger addition, especially of the concentrate of chokeberry juice, significantly affected the color changes of dehydrated apples. The apple dehydrated in mixture of 65°Brix sucrose and 15% chokeberry juice concentrate solution exhibited the highest sensory parameters. The addition of berry fruit juices and extract was able to improve the apple sensory quality after 24 h OD in comparison with sucrose solution. Ethanol extract was a good osmotic agent, but not accepted due to taste and overall quality. However, the addition of the extract can be successfully used in conjunction with a sugar solution.

Tailoring bilberry powder functionality through preprocessing and drying.

Berry powders are popular as ingredients in a range of food products, where they naturally provide flavor, color, texture, polyphenols, fiber, and other nutrients. The choices regarding processing techniques and conditions influence the quality attributes of berry powders. The aim of this study was to study the effects on bilberry powder functionalities of applying different preprocessing techniques (purée mixing and juice pressing vs. untreated whole berries) prior to hot air drying and milling. Drying of press cake reduced the drying time by 72% and increased the total apparent phenolic content of the final powder by 44%, as compared to the powder of dried whole berries. The press cake powder showed an easier flowing behavior than the powders from whole berries and puréed berries. Dispersibility (in water and dairy cream) was 60% higher for powders from whole berries and puréed berries, as compared to press cake. The total phenolic content of the dispersed powders was highest for whole berries and puréed berries. Bilberry powder functionality can be modulated through the selection of an appropriate preprocessing technique before drying and milling. This tailors the powder properties into food ingredients ready for different applications, without the need for additives.

Tailoring bilberry powder functionality through processing: Effects of drying and fractionation on the stability of total polyphenols and anthocyanins.

Bilberries are a rich natural source of phenolic compounds, especially anthocyanins. The press cake obtained during the processing of bilberry juice is a potential source of phytochemicals. The objective of this study was to evaluate different drying techniques and the fractionation of bilberry press cake powder toward obtaining phenolic-rich ingredients for incorporation into value-added food products. The derived powders were dispersed in water and dairy cream, to investigate the effects of drying and fractionation on the dispersibility and solubility of phenolic compounds. The drying techniques, hot air drying and microwave drying, applied on bilberry press cake reduced the content of total phenolics and anthocyanins. The degradation was, however, consistently small and similar for both techniques. The major anthocyanins detected in the samples were stable during drying and fractionation treatments. Fractionation of the press cake powder affected the total apparent phenolic content and composition of the different fractions. The highest phenolic content (55.33 ± 0.06 mg g-1 DW) and highest anthocyanin content (28.15 ± 0.47 mg g-1 DW) were found in the fractions with the smallest particle size (<500 µm), with delphinidin-3-O-galactoside being the most abundant anthocyanin. Dispersibility of all dried powder samples was higher in dairy cream than water, and the highest level of anthocyanins was measured in samples from the powder with the smallest particle size (<500 µm), dispersed in cream. The application of drying, milling and fractionation was found to be a promising approach to transform bilberry press cake into stable and deliverable ingredients that can be used for fortification of food products with high levels of phenolic compounds.

A comparative study of infrared and microwave heating for microbial decontamination of paprika powder.

There is currently a need in developing new decontamination technologies for spices due to limitations of existing technologies, mainly regarding their effects on spices' sensory quality. In the search of new decontamination solutions, it is of interest to compare different technologies, to provide the industry with knowledge for taking decisions concerning appropriate decontamination technologies for spices. The present study compares infrared (IR) and microwave decontamination of naturally contaminated paprika powder after adjustment of water activity to 0.88. IR respectively microwave heating was applied to quickly heat up paprika powder to 98°C, after which the paprika sample was transferred to a conventional oven set at 98°C to keep the temperature constant during a holding time up to 20 min. In the present experimental set-up microwave treatment at 98°C for 20 min resulted in a reduction of 4.8 log units of the total number of mesophilic bacteria, while the IR treatment showed a 1 log unit lower reduction for the corresponding temperature and treatment time. Microwave and IR heating created different temperature profiles and moisture distribution within the paprika sample during the heating up part of the process, which is likely to have influenced the decontamination efficiency. The results of this study are used to discuss the difficulties in comparing two thermal technologies on equal conditions due to differences in their heating mechanisms.

Infrared decontamination of oregano: effects on Bacillus cereus spores, water activity, color, and volatile compounds.

Infrared (IR) heating, a novel technology for decontaminating oregano, was evaluated by investigating the reduction of inoculated Bacillus cereus spores and the effect on water activity (a(w)), color, and headspace volatile compounds after exposure to IR treatment. Conditioned oregano (a(w) 0.88) was IR-treated in a closed heating unit at 90 and 100 °C for holding times of 2 and 10 min, respectively. The most successful reduction in B. cereus spore numbers (5.6 log units) was achieved after a holding time of 10 min at 90 °C, while treatment at 100 °C for the same time resulted in a lower reduction efficiency (4.7 log units). The lower reduction at 100 °C was probably due to a reduced aw (aw 0.76) during IR treatment or possibly to the alteration or loss of volatile compounds possessing antimicrobial properties. The green color of oregano was only slightly affected, while the composition of volatile compounds was clearly altered by IR heating. However, two of the key aroma compounds, carvacrol and thymol, were only slightly affected, compared to the effect on the other studied compounds, indicating that the typical oregano aroma can likely be preserved. In conclusion, IR heating shows potential for the successful decontamination of oregano without severe alteration of its color or the key aroma compounds, carvacrol and thymol.