Effect of high hydrostatic pressure processing on the rennet coagulation kinetics and physicochemical properties of sheep milk rennet-induced gels.

The effects of high hydrostatic pressure on the constituents and coagulation ability and their effect on cheese production of sheep milk have not been studied in detail. The objective of this work was to evaluate the effect of high hydrostatic pressure processing on the coagulation kinetics and physicochemical properties of sheep milk and to explore how such treatment could improve the cheesemaking process. Five batches of milk were tested: 1 untreated control batch and 4 batches each subjected to a different pressure (150, 300, 450, or 600 MPa) for 5 min at 10°C. As treatment pressure increased, values of electrical conductivity and oxidation-reduction potential were found to decrease. However, no significant reduction in pH was recorded. Treatment pressures >300 MPa produced milk with lower lightness (luminosity) and a more yellow and green hue. Pressures >150 MPa resulted in micellar fragmentation, as well as significant increases in particle size, viscosity, and water-holding capacity as a consequence of the denaturing of soluble proteins. High-pressure treatments increased the solubility of colloidal calcium phosphate, leading to a considerable increase in the concentration of minerals in the serum phase. The highest concentrations of calcium and phosphorus in the rennet whey of milk were reached at 300 MPa. Curd coagulation time was reduced by 28% at pressures >300 MPa, and an increase in the curd firming rate was observed. As treatment pressure increased to 450 MPa, the firmness, elasticity, and the percentage creep recovery of gels increased, whereas values of compliance and fracture strain were reduced. Thus, we can conclude that 300 MPa is the optimum treatment pressure for milk intended for cheesemaking by enzymatic coagulation. This pressure produced milk with optimal coagulation kinetics and water-holding properties with the least loss of fat and protein to the whey.

Wine yeast selection in the Iberian Peninsula: Saccharomyces and non-Saccharomyces as drivers of innovation in Spanish and Portuguese wine industries.

Yeast selection for the wine industry in Spain started in 1950 for the understanding of the microbial ecology, and for the selection of optimal strains to improve the performance of alcoholic fermentation and the overall wine quality. This process has been strongly developed over the last 30 years, firstly on Saccharomyces cerevisiae, and, lately, with intense activity on non-Saccharomyces. Several thousand yeast strains have been isolated, identified and tested to select those with better performance and/or specific technological properties. The present review proposes a global survey of this massive ex-situ preservation of eukaryotic microorganisms, a reservoir of biotechnological solutions for the wine sector, overviewing relevant screenings that led to the selection of strains from 12 genera and 22 species of oenological significance. In the first part, the attention goes to the selection programmes related to relevant wine-producing areas (i.e. Douro, Extremadura, Galicia, La Mancha and Uclés, Ribera del Duero, Rioja, Sherry area, and Valencia). In the second part, the focus shifted on specific non-Saccharomyces genera/species selected from different Spanish and Portuguese regions, exploited to enhance particular attributes of the wines. A fil rouge of the dissertation is the design of tailored biotechnological solutions for wines typical of given geographic areas.

Effect of forage type, season, and ripening time on selected quality properties of sheep milk cheese.

The aim of this research was to study changes in the microbial populations, free AA profile, biogenic amine content, and sensory characteristics of ripened cheeses (100 and 180 d) produced in different seasons (summer, autumn, winter, and spring) from pasteurized sheep milk from 8 commercial flocks fed hay or silage diets. Twenty-one individual AA and 6 biogenic amines were determined by ultra-high performance liquid chromatography. Type of conserved forage for sheep feeding did not affect the variables studied, which is of great interest because hay and silage are low-cost ingredients for sheep feeding. Proteolysis led total free AA concentrations ranging between 35,179.26 and 138,063.71 mg/kg of cheese at 180 d of ripening. γ-Aminobutyric acid, which has been associated with beneficial effects on human health, was the second most abundant AA in all cheese samples, accounting for 15% of total free AA. Spring cheeses showed 2-fold higher concentrations of γ-aminobutyric acid than summer and autumn cheeses at the end of ripening. Overall, spring, winter, and autumn cheeses had lower average concentration of biogenic amines (431.99 mg/kg of cheese) than summer cheeses (825.70 mg/kg of cheese) as well as better sensory characteristics. Therefore, this study could provide the dairy industry with useful information for producing cheeses with valuable nutritional and sensory quality for consumers.

Effect of forage type in the ovine diet on the nutritional profile of sheep milk cheese fat.

The high nutritional value of sheep milk can be advantageous in the manufacture of cheese, and fat plays an important role in sheep cheese properties. The aim of this study was to investigate the effect of feeding common hay or silage diets used in commercial farms on the nutritional value of sheep cheese fat. We also monitored the effect of cheese ripening period on the fatty acid profile. Cheeses were produced from milk of sheep fed hay and silage diets from 8 farms, on 4 separate occasions (February, May, August, and November) over a 1-yr period. Eighty-four individual fatty acids were determined and identified by gas chromatography. Ripening time (100 and 180 d) significantly reduced moisture, acidity, and water activity of cheeses but did not affect the fatty acid content. However, hay feeding, compared with silage feeding, led to cheeses with 1.5- and 1.3-fold higher contents of vaccenic acid and conjugated linoleic acid, without detrimental changes in saturated and n-3 (omega-3) fatty acid composition. Hay forages could be a low-cost alternative for producing cheese with a fatty acid profile suitable for human health, which is an aspect of great interest to the food industry.

CLA-producing adjunct cultures improve the nutritional value of sheep cheese fat.

The influence of the autochthonous CLA-producing Lactobacillus plantarum TAUL 1588 and Lactobacillus casei subsp. casei SS 1644 strains and the ripening time on the fatty acid (FA) content and sensory characteristics of sheep cheese were investigated. Three cheese types with different cultures and the control cheese were produced in duplicate and ripened for 8 months. 86 individual FA were determined by gas chromatography. Ripening time (2, 90, 180 and 240 days) did not have a significant effect (P > .05) on the FA content. However, the presence of both Lactobacillus CLA-producing strains led to a decrease of the saturated FA content and to 1.30, 1.19 and 1.27 times higher levels of vaccenic acid, CLA and omega-3, respectively, when compared to the control cheese. This combination allowed obtaining sheep milk cheeses with a healthier FA content, without appreciable changes on sensory characteristics. This work could be a promising approach to increase the bioactive fatty acid content of cheeses.

Production of sheep milk cheese with high γ-aminobutyric acid and ornithine concentration and with reduced biogenic amines level using autochthonous lactic acid bacteria strains.

Consumer demand for health-promoting foods is generating the need to develop biofunctional dairy products. Lactic acid bacteria are employed in cheese-making and some of them are able to produce beneficial compounds on human health such as γ-aminobutyric acid (GABA) and ornithine but also to synthetize biogenic amines. The aim was to investigate the effect of four selected autochthonous co-cultures on the free amino acid profile, with special emphasis on GABA and ornithine, and on the biogenic amine content of pasteurized sheep milk cheese during ripening. High average concentrations of GABA (1296.75 mg/kg cheese) and ornithine (2355.76 mg/kg cheese) were found in all the cheese batches at 240 days of ripening. Batch 2, manufactured with the co-culture containing autochthonous Lactococcus lactis strains as starter and Lactobacillus plantarum TAUL1588 as adjunct, showed 2.37 fold reduced biogenic amines concentration with respect to the batch 1 made with the starter during the ripening time. The microstructure and microbiological counts of cheeses were affected (P ≤ 0.001) by the ripening time, without appreciating differences (P ≥ 0.05) in the physico-chemical composition between batches. This study could be a good approach to the development of functional sheep milk cheese.

Use of Schizosaccharomyces strains for wine fermentation-Effect on the wine composition and food safety.

Schizosaccharomyces was initially considered as a spoilage yeast because of the production of undesirable metabolites such as acetic acid, hydrogen sulfide, or acetaldehyde, but it currently seems to be of great value in enology.o ced Nevertheless, Schizosaccharomyces can reduce all of the malic acid in must, leading to malolactic fermentation. Malolactic fermentation is a highly complicated process in enology and leads to a higher concentration of biogenic amines, so the use of Schizosaccharomyces pombe can be an excellent tool for assuring wine safety. Schizosaccharomyces also has much more potential than only reducing the malic acid content, such as increasing the level of pyruvic acid and thus the vinylphenolic pyranoanthocyanin content. Until now, few commercial strains have been available and little research on the selection of appropriate yeast strains with such potential has been conducted. In this study, selected and wild Sc. pombe strains were used along with a Saccharomyces cerevisiae strain to ferment red grape must. The results showed significant differences in several parameters including non-volatile and volatile compounds, anthocyanins, biogenic amines and sensory parameters.

Biocheese: a food probiotic carrier.

This review describes some aspects related to the technological barriers encountered in the development and stability of probiotic cheeses. Aspects concerning the viability of probiotic cultures in this matrix are discussed and the potential of cheese as a biofunctional food carrier is analyzed, outlying some points related to health and safety. In general, the manufacture of probiotic cheese should have little change when compared with the elaboration of cheese in the traditional way. The physicochemical and technological parameters influencing the quality of these products have also to be measured so as to obtain a process optimization.

Microbiological, physico-chemical and proteolytic changes in a Spanish blue cheese during ripening (Valdeón cheese).

The aim of this work was to study the microbiological, physico-chemical and proteolytic changes in Valdeón blue-veined cheese during ripening. Eight replicas of cheese were produced and a total of 48 cheeses were analysed. Lactic acid bacteria, mainly lactococci, were the predominant flora during the early stages of ripening, gradually being replaced by moulds and yeasts (8 log units). Enterococci and Enterobacteriaceae counts were very low or zero. This variety was characterised by a total solids content of 61.80g per 100g(-1) of cheese, a salt/moisture ratio of 8.92g salt per 100g(-1) moisture, a pH of 6.4-7.6 and a water activity of 0.917. At the end of ripening, primary and secondary proteolysis were very high, which resulted in an almost total degradation of αs1- and ß-casein (approximately 90%). The peptide profile of the aqueous soluble extracts at pH 4.6 showed great complexity during ripening.

Effect of autochthonous starter cultures on the biogenic amine content of ewe's milk cheese throughout ripening.

Cheese is among the most commonly implicated foods associated with biogenic amines poisoning. The aim of this study was to evaluate the effects of the type of autochthonous starter culture and ripening time on the concentration of biogenic amines (histamine, tyramine, putrescine, cadaverine, tryptamine, ß-phenylethylamine, spermine and spermidine) in cheeses made from pasteurized ewe's milk. 4 cheese batches were made, in duplicate, and ripened for 7 months. The biogenic amines of 40 cheeses were analysed by high performance liquid chromatography. The predominant biogenic amines determined at the end of the ripening time were phenylethylamine, spermine and tryptamine. Together, these accounted for 81% of the total of biogenic amines studied. The type of starter culture used to make the ewe's cheese had a significant effect (p < 0.001) on the content of biogenic amines throughout ripening time. It was lower in the batches made with an autochthonous starter culture made up entirely of Lactococcus lactis subsp. lactis and L. lactis subsp. cremoris or of the same in combination with Lactobacillus plantarum.

Molecular study of Geotrichum strains isolated from Armada cheese.

The aim of this work was the genetic characterization at the strain level of 39 presumed Geotrichum candidum isolates isolated throughout the artisanal manufacturing and ripening of Armada cheese and tentatively identified at genus and/or species level by phenotypic characteristics. The molecular identification of the strains included among others the amplification and sequencing of the D1/D2 domains of the 26S rRNA gene. A restriction fragment length polymorphism (RFLP) analysis with the ITS1-5.8S-ITS2 PCR amplicons and a randomly amplified polymorphic DNA (RAPD) analysis with five different primers were carried out. The bands pattern profile obtained through RFLP by enzymatic restriction with HinfI was the same for all the strains studied, which confirmed the classification of the strains at species level. A RAPD-PCR analysis with three different primers was applied to assess the intraspecific diversity, in this way 16 band profiles were obtained for the 39 strains studied by the combined use of primers Ari1 and Omt1. This study contributes to know the occurrence and genotypic biodiversity of G. candidum in Armada cheese.

Factors influencing variation of fatty acid content in ovine milk.

Between January 2006 and December 2007, a total of 4,579 test-day observations for contents of milk fatty acids (FA) were obtained from 2,218 lactations of 1,109 ewes belonging to 14 Churra dairy flocks. The 36 analyzed FA were quantified as grams per 100 g of total FA and were grouped as 18 dependent variables: 10 FA, 6 groups of FA, and 2 FA indexes. Flock, day of testing within flock (TD), ewe age, stage of lactation, and season effects contributed significantly to variations in FA. The 2 most important variation factors were flock (3 to 30% of total variance) and TD (35 to 70% of total variance). The percentage of variance explained by the TD effect for conjugated linoleic acid (CLA, C18:2 cis-9, trans-11) and linolenic acid (C18:3 cis-9, cis-12, cis-15) was particularly high: 60.7 and 68.2%, respectively. The season effect was also a very important variation factor, closely linked to feeding. The most significant seasonal variations were observed in polyunsaturated FA, with the highest values occurring in spring and summer and the lowest in winter. More specifically, CLA and linolenic acid contents were 44 and 30% higher in spring-summer than in winter. As the age of the ewe increased, the monounsaturated and polyunsaturated FA decreased and the short- and medium-chain saturated FA increased. The CLA and the CLA/C18:1 trans-11 Delta(9)-desaturase index increased significantly throughout lactation. The correlation coefficient between rumenic acid (CLA) and vaccenic acid was high (0.47) because of the precursor-product relationship via the Delta(9)-desaturase enzyme. The correlation coefficients were high between C10:0 and C12:0 (0.79), C12:0 and C14:0 (0.73), and C14:0 and C16:0 (0.29), probably because of their similar metabolic origin. Positive correlations were also obtained among the C(18) FA family. All the studied factors of FA variation would be considered as fixed effects in the statistical models used for estimation of genetic and phenotypic parameters from test-day records of commercial flocks.

Study of Enterobacteriaceae throughout the manufacturing and ripening of hard goats' cheese.

The evolution of the counts and the species of Enterobacteriaceae as well as some physico-chemical parameters (pH, aw and NaCl and moisture contents) during manufacturing and ripening of a hard Spanish goats' cheese of the Armada-Sobado variety were studied. Enterobacteriaceae (mean log counts 4.45 g-1 in milk) increased 0.71-2.18 log units in curd and afterwards decreased until they disappeared after 2-4 weeks of ripening. This premature disappearance seems to be due to the decrease in aw values and in moisture contents. However, the low pH values, reached from the beginning of the ripening process, could also contribute to this phenomenon. The most abundant species in milk was Serratia liquefaciens (57.5% of isolates), followed by Morganella morganii (27.5%), Hafnia alvei (5%), Klebsiella oxytoca (5%) and Yersinia enterocolitica (5%). Yersinia enterocolitica was not subsequently isolated from either curd or in cheese. Hafnia alvei numbers increased in curd and in 1-week-old cheese where this micro-organism was the most abundant (47.5% and 75% of the isolates respectively). Escherichia coli, which was not isolated from milk, curd or 1-week-old cheese, was the predominant organism in 2-week-old cheese (57.8% of isolates). This confirms the finding of other authors who have shown that it is one of the most resistant species in ripening cheeses.