Mild microwaves, ultrasonic and alkaline pretreatments for improving methane production: Impact on biochemical and structural properties of olive pomace.

This study aims to investigate the effects of microwaves, ultrasonic and alkaline pretreatments on olive pomace properties and its biomethane potential. Alkaline pretreatment was found to reduce lipid and fiber contents (especially lignin) and to increase soluble matter. The alkali pretreatment at a dose of 8% (w/w TS) under 25 °C and for 1 day removed 96% of initial lipids from the solid olive pomace. Unlike NaOH addition, mild microwaves and ultrasonic pretreatments had no impact on lignin. However, in the case of long microwaves pretreatment (450 W-10 min), cellulose and lignin contents were reduced by 50% and 26% respectively. Similarly, the combination of ultrasonic and alkali reagent showed a positive effect on fiber degradation and lipid solubilization as well as a positive impact on methane production. Statistical analysis highlighted the correlation between NaOH dose, solubilization and methane production. The alkaline pretreatment at ambient temperature appeared the most energetically efficient.

Soft Microwave Pretreatment to Extract P-Hydroxycinnamic Acids from Grass Stalks.

The aim of this article is to provide an analysis of microwave effects on ferulic and coumaric acids (FA and CA, respectively) extraction from grass biomass (corn stalks and miscanthus). Microwave pretreatment using various solvents was first compared to conventional heating on corn stalks. Then, microwave operational conditions were extended in terms of incident power and treatment duration. Optimal conditions were chosen to increase p-hydroxycinnamic acids release. Finally, these optimal conditions determined on corn stalks were tested on miscanthus stalks to underlie the substrate incidence on p-hydroxycinnamic acids release yields. The optimal conditions-a treatment duration of 405 s under 1000 W-allowed extracting 1.38% FA and 1.97% CA in corn stalks and 0.58% FA and 3.89% CA in miscanthus stalks. The different bioaccessibility of these two molecules can explain the higher or lower yields between corn and miscanthus stalks.

Liquid mixing and solid segregation in high-solid anaerobic digesters.

An experimental procedure (Residence Time Distribution technique) was used to characterize the macro-mixing of both liquid and solid phases of a laboratory-scale dry anaerobic digester using appropriate tracers. The effects of the waste origin and total solid content were studied. An increase in TS content from 22% to 30% TS (w/w) induced a macro-mixing mode closer to a theoretical Plug Flow Reactor. The segregation of particles having different densities was investigated regarding the RTD of the solid phase. Segregation of dense particles occurred at low TS content. By using different TS content and waste origins, it was also determined that the yield stress was a key parameter in the mechanism of segregation. At high yield stress, dense particles were more stable and thus less subjected to settling. As a consequence, operating at high TS content may permit to prevent the sedimentation of the denser particles.