Carotenoid content and deposition efficiency in yolks of laying hens fed with dent corn hybrids differing in grain hardness and processing.

Yolk carotenoid profile reflects the hen diet when corn grain is the only source of carotenoids, but corn origin and processing may affect carotenoid utilization. In the present study, 2 commercial dent corn hybrids differing in grain hardness (soft- and hard-type) were dried at low (40°C) and high (85°C) temperature and ground through a 5- and 9-mm sieve to investigate their effects on carotenoid bioavailability in laying hens. With 3 hens per cage, 168 Lohmann Brown laying hens were allocated to 8 dietary treatments (2 hybrids × 2 drying temperatures × 2 grinding sieves) in a completely randomized design (8 treatments × 7 cages). The trial lasted 8 wk, during which eggs were collected for analysis every 3 d until carotenoid content stabilized, and then once a week until the end of the experiment. The carotenoid profile of the experimental diets and yolks was analyzed using an HPLC method and deposition efficiency was calculated based on carotenoid contents, yolk weight, egg production and diet intake. The deposition efficiency for lutein, zeaxanthin, α- and ß-cryptoxanthin, and ß-carotene averaged 27.37, 18.67, 6.29, 3,32, and 0.94%, respectively. As expected, the tested hybrids highly affected the carotenoid content in egg yolk due to their differences in carotenoid profile. Interestingly, hard- and soft-type hybrids differed in the deposition efficiency for all individual carotenoids but not for the total carotenoids. High grain drying temperature tended to increase the bioavailability of lutein and zeaxanthin in both hybrids. For the hard-type hybrid, the content of ß-carotene in egg yolk was higher when grains were dried at a high temperature, while the opposite response was found in the soft-type hybrid. The effect of grinding sieve size was important for the zeaxanthin bioavailability in the soft-type hybrid only. In conclusion, our findings showed that corn hybrid had a primary influence on the carotenoid content in the yolks of laying hens, but grain processing may change the bioavailability of carotenoids.

Carotenoid degradation rate in milled grain of dent maize hybrids and its relationship with the grain physicochemical properties.

Carotenoids in maize grain degrade during storage, but the relationship between their stability and the physicochemical properties of the grain is unclear. Therefore, the carotenoid degradation rate in milled grain of three dent hybrids differing in grain hardness was evaluated at various temperatures (-20, 4 and 22 °C). The carotenoid degradation rate was calculated using first-order kinetics based on the content in the samples after 7, 14, 21, 28, 42, 56, 70 and 90 days of storage and related to the physicochemical properties of the grain. The highest grain hardness was found in the hybrid with the highest zein and endosperm lipid concentration, while the lowest grain hardness was found in the hybrid with the highest amylose content and the specific surface area of starch granule (SSA). As expected, carotenoids in milled maize grain were most stable at -20 °C, followed by storage at 4 and 22 °C. Tested hybrids differed in the degradation rate of zeaxanthin, α-cryptoxanthin and ß-carotene, and these responses were also temperature-dependent. In contrast, all hybrids showed similar degradation rate for lutein and ß-cryptoxanthin regardless of the storage temperature. Averaged over the hybrids, the degradation rate for individual carotenoids ranked as follows: lutein < zeaxanthin < α-cryptoxanthin < ß-cryptoxanthin < ß-carotene. The lower degradation rate for most carotenoids was mainly associated with a higher content of zein and specific endosperm lipids, with the exception of zeaxanthin, which showed an opposite pattern of response. Degradation rate for lutein and zeaxanthin negatively correlated with SSA, but interestingly, small starch granules were positively associated with higher degradation rate for mostcarotenoids. Dent-type hybrids may differ significantly in carotenoid degradation rate, which was associated with specific physicochemical properties of the maize grain.

Bioaccessibility of Tocols in Commercial Maize Hybrids Determined by an In Vitro Digestion Model for Poultry.

Despite the high proportion of maize grain in animal diets, the contribution made by maize phytochemicals is neglected. Tocols and their contribution to the vitamin E content of animal diets are one example, exacerbated by sparse information on the tocol bioaccessibility of commercial hybrids. In this study, the contents of individual and total tocols and their bioaccessibility were determined in the grain samples of 103 commercial hybrids using a standardized INFOGEST digestion procedure. In the studied hybrids, total tocol content ranged from 19.24 to 54.44 µg/g of dry matter. The contents of micellar α-, γ-, δ-tocopherols, γ-tocotrienol, and total tocols correlated positively with the corresponding contents in the grain samples of the studied hybrids. In contrast, a negative correlation was observed between the bioaccessibility of γ- tocopherol, α- and γ-tocotrienol, and total tocols, along with the corresponding contents in the grain of studied hybrids. The highest bioaccessibility was exhibited by γ-tocotrienol (532.77 g/kg), followed by δ-tocopherol (529.88 g/kg), γ-tocopherol (461.76 g/kg), α-tocopherol (406.49 g/kg), and α-tocotrienol (359.07 g/kg). Overall, there are significant differences in the content and bioaccessibility of total and individual tocols among commercial maize hybrids, allowing the selection of hybrids for animal production based not only on crude chemical composition but also on the content of phytochemicals.

Effect of starch properties and zein content of commercial maize hybrids on kinetics of starch digestibility in an in vitro poultry model.

BACKGROUND: The kinetics of starch digestion is a key determinant of poultry performance. Research so far has shown that starch digestibility kinetics depends on the molecular structure of starch but also on the properties of the complex matrix in which starch granules are embedded in most feedstuffs. However, the manner in which genotype differences in the same plant affect starch digestibility kinetics has not yet been addressed. The present study explored the extent to which the starch digestibility rate in commercial high-yielding maize hybrids depended on amylose / amylopectin content, starch granule size and shape, and zein in total starch (TS) content. RESULTS: Hybrids differed in all the traits examined, giving the following ranges: amylose content, 165-207 g kg-1 DM; zein in TS content, 70-89 g kg-1 DM; starch granule equivalent diameter, 11.5-12.3 µm, and in vitro starch digestion rate, 1.22-1.44 h-1 . The starch digestion rate correlated negatively with zein in TS content (r = -0.36) and positively with equivalent diameter (r = 0.45). The negative correlation between starch digestion rate and zein in TS suggests that some zein remained after grinding and pepsin incubation and acted as a barrier to amylolytic enzymes. CONCLUSIONS: When starch granules are embedded in a complex protein matrix, zein limits their accessibility to enzymes and affects the starch digestibility rate. Surprisingly, our results suggest that when enzymes reach starch granules, they digest a greater proportion of the starch when the granules are larger. © 2019 Society of Chemical Industry.

Carotenoid content and antioxidant activity of hexane extracts from selected Croatian corn hybrids.

Carotenoids, which occur naturally in corn grains, have been associated with reduced risk of degenerative diseases. The aim of this research was to measure the carotenoid content of hexane extracts of six commercial high-yield corn hybrids and determine the relationship between carotenoid content and antioxidant activity. Levels of lutein, zeaxanthin, ß-cryptoxanthin and ß-carotene in hexane extracts were determined using HPLC, and antioxidant activity was assayed using the TEAC system based on the 2,2'-azinobis(3-ethylbenzothiazoline-6-sulphonic acid) radical cation (ABTS(+)), and the TBARS system based on a linoleic acid emulsion. Corn hybrids varied in carotenoid content and antioxidant activity in both assays. Lutein and zeaxanthin were the predominant carotenoids; their levels were 15-fold higher than those of ß-cryptoxanthin and ß-carotene. Antioxidant activity in both assays increased linearly with total carotenoid content. Lutein and ß-carotene were the primary contributors to TEAC activity, while lutein, ß-cryptoxanthin and ß-carotene were primary contributors to TBARS activity.

Assaying Total Carotenoids in Flours of Corn and Sweetpotato by Laser Photoacoustic Spectroscopy.

This study describes the application of the laser photoacoustic spectroscopy (PAS) for quantification of total carotenoids (TC) in corn flours and sweetpotato flours. Overall, thirty-three different corn flours and nine sweetpotato flours were investigated. All PAS measurements were performed at room temperature using 488-nm argon laser radiation for excitation and mechanical modulation of 9 and 30 Hz. The measurements were repeated within a run and within several days or months. The UV-Vis spectrophotometry was used as the reference method. The concentration range that allows for the reliable analysis of TC spans a region from 1 to 40 mg kg(-1) for corn flours and from 9 to 40 mg kg(-1) for sweetpotato flours. In the case of sweetpotato flours, the quantification may extend even to 240 mg kg(-1) TC. The estimated detection limit values for TC in corn and sweetpotato flours were 0.1 and 0.3 mg kg(-1), respectively. The computed repeatability (n = 3-12) and intermediate precision (n = 6-28) RSD values at 9 and 30 Hz are comparable: 0.1-17.1% and 5.3-14.7% for corn flours as compared with 1.4-9.1% and 4.2-23.0% for sweetpotato flours. Our results show that PAS can be successfully used as a new analytical tool to simply and rapidly screen the flours for their nutritional potential based on the total carotenoid concentration.