Screening Method to Evaluate Amino Acid-Decarboxylase Activity of Bacteria Present in Spanish Artisanal Ripened Cheeses.

A qualitative microplate screening method, using both low nitrogen (LND) and low glucose (LGD) decarboxylase broths, was used to evaluate the biogenic amine (BA) forming capacity of bacteria present in two types of Spanish ripened cheeses, some of them treated by high hydrostatic pressure. BA formation in decarboxylase broths was later confirmed by High Performance Liquid Chromatography (HPLC). An optimal cut off between 10⁻25 mg/L with a sensitivity of 84% and a specificity of 92% was obtained when detecting putrescine (PU), tyramine (TY) and cadaverine (CA) formation capability, although these broths showed less capacity detecting histamine forming bacteria. TY forming bacteria were the most frequent among the isolated BA forming strains showing a strong production capability (exceeding 100 mg/L), followed by CA and PU formers. Lactococcus, Lactobacillus, Enterococcus and Leuconostoc groups were found as the main TY producers, and some strains were also able to produce diamines at a level above 100 mg/L, and probably ruled the BA formation during ripening. Enterobacteriaceae and Staphylococcus spp., as well as some Bacillus spp. were also identified among the BA forming bacteria isolated.

Fate of Escherichia coli strains inoculated in model cheese elaborated with or without starter and treated by high hydrostatic pressure.

The aim of this research was to study high hydrostatic pressure inactivation of two strains of Escherichia coli (E. coli O59:H21 [CECT 405] and E. coli O157:H7 [CECT 5947]) inoculated in washed-curd model cheese elaborated with and without starter and the ability of these strains for survival, recovery, and growth. Samples were treated at 300, 400, and 500 MPa for 10 min at 20 degrees C and analyzed after the treatment and after 1, 7, and 15 days of storage at 8 degrees C to study the behavior of Escherichia populations. Cheeses elaborated with starter showed the maximum lethality at 400 and 500 MPa, and no significant differences in the baroresistant behavior of either strains were detected, except for E. coli O157:H7 at 400 MPa in cell counts obtained with thin agar layer method medium, where the decrease value was significantly lower. In cheese elaborated without starter, the highest decrease value was observed at 500 MPa, except for E. coli O59:H21 in cell counts obtained with selective culture medium, where the highest decrease value was also found at 400 MPa. The ability to repair and grow was not observed in model cheese elaborated with starter, as cell counts of treated samples decreased after 15 days of storage at 8 degrees C. By contrast, in cheese elaborated without starter, all pressurized samples showed the trend to repair and grow during the storage period in both strains. These results suggest that the presence of starter and low pH values are the main factors that control the ability of Escherichia strains inoculated in this type of cheese and treated by high hydrostatic pressure to recover and grow.

Inactivation of Listeria innocua in milk and orange juice by ultrahigh-pressure homogenization.

The aim of this work was to evaluate the bactericidal efficacy of ultrahigh-pressure homogenization (UHPH) against Listeria innocua ATCC 33090 inoculated into milk and orange juice. We also intended to study the effect of inlet temperature on the lethality and production of sublethal injuries in this microorganism and its ability to survive, repair, and grow in refrigerated storage after UHPH treatment. Samples of ultrahigh-temperature whole milk and ultrahigh-temperature orange juice inoculated at a concentration of approximately 7.0 log (CFU per milliliter) were immediately pressurized at 300 MPa on the primary homogenizing valve and at 30 MPa on the secondary valve, with inlet temperatures of 6.0 +/- 1.0 degrees C and 20 +/- 1.0 degrees C. L. innocua viable counts and injured cells were measured 2 h after UHPH treatment and after 3, 6, and 9 days of storage at 4 degrees C for milk and after 3, 6, 9, 12, 15, 18, and 21 days of storage at 4 degrees C for orange juice. Both the inlet temperature and the food matrix influenced significantly (P < 0.05) the inactivation of L. innocua, which was higher in whole milk at the 20 degrees C inlet temperature. The UHPH treatment caused few or no sublethal injuries in L. innocua. During storage at 4 degrees C after treatments, counts increased by approximately 2 logarithmic units from day 0 to 9 in whole milk, whereas in orange juice counts diminished by approximately 2.5 logarithmic units from day 0 to 18.

Behavior of Yersinia enterocolitica strains inoculated in model cheese treated with high hydrostatic pressure.

The effects of high hydrostatic pressure treatment and the ability for survival, repair, and growth of three human pathogenic serotypes (O:1, O:3, O:8) of Yersinia enterocolitica were investigated in washed-curd model cheese made with pasteurized bovine milk. Samples were treated at 300, 400, and 500 MPa for 10 min at 20 degrees C and analyzed at 0, 1, 7, and 15 days to assess the viability of the Yersinia population. A long-term study (up to 60 days of ripening after high hydrostatic pressure treatment) was also undertaken. Treatments at 400 and 500 MPa caused maximum lethality, and only the treatment at 300 MPa showed significant differences (P < 0.05) between serotypes; the most baroresistant was O:3. Ability to repair and grow was not observed after 15 days of storage at 8 degrees C. Yersinia counts in untreated cheese samples also decreased below the detection limit at day 45 in the long-term study. These results suggest that the cheese environment did not allow recovery of injured cells or growth. A primary contributing factor to this effect seemed to be the low pH resulting from the production of lactic acid during cheese ripening.

Amino acid decarboxylase activity and other chemical characteristics as related to freshness loss in iced cod (Gadus morhua).

Biogenic amine levels and other biochemical indicators were measured to study the safety of and the loss of freshness in iced Atlantic cod. Biogenic amine content exhibited high variability during iced storage of Atlantic cod. Ornithine and lysine decarboxylase activity apparently increased at the end of the storage period. Amino acid activity was probably generated by endogenous amino acid decarboxylases of raw fish. No statistical differences were observed in the total volatile base fraction or in the ammonia or monomethylamine contents during iced storage. However, trimethylamine contents showed a significant exponential relationship with time and sensory score. Cod formed inosine as the major metabolite of IMP. The H and G indices showed a linear relationship with time and sensory score and served as good indicators of cod freshness quality. However, the K, Ki, and P indices showed a logarithmic relationship with time and sensory score. IMP, K, Ki, and P served as indicators of freshness lost during the early stages of chilled storage of cod.