Influence of cocoa products on rheological, fatty acid profile and quality characteristics of biscuits.

Cocoa products namely cocoa powder (CP), cocoa butter (CB) and cocoa mass (CM) were selected for their utilization in soft dough biscuits. CP was blended with the refined wheat flour (WF-0, 5, 10 and 15% levels) and rheological and quality characteristics of biscuits were studied. The spread ratio decreased (10.1-8.8), density (0.49-0.52 g/cm3) and breaking strength values (1127-1369 g force) increased gradually with increase in CP. Combination of GMS and SSL at 0.25% each improved the quality of biscuits at 10% incorporation of CP. Further the biscuit fat (BF) was replaced with CB (0, 25, 50 and 75%). Later the biscuits with CM were prepared by replacing the flour (15%) and BF (0, 25, 50 and 75%). Acceptability of the CM based biscuits was better when compared to CB based biscuits. The total polyphenol content in control biscuits was 55.55 mg/100 g and was in the range between 81.98 and 102.05 mg/100 g for cocoa based biscuits. The protein content in cocoa based biscuits was marginally higher than the control biscuit. Though there was a wide variation in the fat content and different fatty acids in raw materials, interestingly, the values varied narrowly in biscuits.

Effect of ingredients on rheological, physico-sensory, and nutritional characteristics of omega-3-fatty acid enriched eggless cake.

The effect of defatted soya flour (DS), flax seed powder (FS) in combination (DSFS) with emulsifiers such as glycerol monostearate, GMS (DSFSG) and sodium stearoyl-2-lactylate, SSL (DSFSS) on the rheological, physico-sensory, protein subunit composition by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE), fatty acid profile, and nutritional characteristics of eggless cake was studied. Use of DSFS, DSFSG, and DSFSS increased the amylograph peak viscosity, hot and cold paste viscosities similar to the egg. Addition of DSFS, DSFSG, and DSFSS increased viscosity of eggless cake batter; cake volume and the overall quality score (OQS) of eggless cake. Among these, highest improvement in OQS was brought about by DSFSG. According to SDS-PAGE results, the improvement by DSFSG is due to crosslinking of wheat-soya-flax proteins similar to wheat-egg proteins crosslinking. The eggless cake with DSFSG was found to be rich in omega-3-fatty acid as it contained 0.6% of linolenic acid compared to 0.1% each of cake with egg and eggless cake. PRACTICAL APPLICATIONS: As eggs are significant source of cholesterol, there has been an increased interest in search of ingredients that can replace egg in cakes. Hence, recent trend in the baking industry is to produce eggless cake using a combination of different ingredients and additives. However, there is no scientific information on the interaction of non-egg protein with wheat protein in building up the structure and also to improve the nutritional quality with respect to protein and fatty acids profiles of eggless cake. The information generated on the use of combination of defatted soya flour and flax seed along with emulsifiers will be helpful for the commercial manufacture of omega-3-fatty acid rich eggless cake with desired quality attributes.

Physicochemical characteristics of phytonutrient retained red palm olein and butter-fat blends and its utilization for formulating chocolate spread.

Phytonutrients retained palm olein (PRPOL) was prepared and blended into butterfat at different ratios. The physicochemical characteristics and the phytonutrient composition of blends, as well as its utilization in the preparation of functional chocolate spread were evaluated. The results showed that the redness, yellowness, slip melting point, free fatty acids, peroxide value, iodine value, unsaponifiable matter, diacylglycerol and monoacylglycerol increased while lightness, saponification value, and triacylglycerol significantly decreased upon incorporation of increased quantities of PRPOL into butterfat. The incorporation affected short chain, medium chain and long chain fatty acids content along with variation in the palmitic, stearic, oleic acids content of the blends as compared to butterfat alone. Improvement in carotenoids (6-27 fold), phytotosterols (3-15 fold), tocopherols and tocotrienols (4-17 fold), and squalene (1-6 fold) in blends was observed upon incorporation of PRPOL. Cholesterol level in the blends was reduced (10-50 %) as compared to the butterfat. The blends showed an intermediate solid fat content of PRPOL and butterfat. Moreover, radical scavenging activity of the blends increased with increase in PRPOL quantity. Prepared chocolate spreads showed similar fat, moisture, colour components (L*, a* and b*) and better emulsion stability. The hardness of the spreads was increased upon increasing quantity of PRPOL. The sensory evaluation showed that chocolate prepared by replacing butterfat with 20 % PRPOL had acceptable sensory attributes.

Rheology, fatty acid profile and quality characteristics of nutrient enriched pizza base.

Enrichment of thick bread type pizza base (PZB) was done by substituting wheat flour (WF) with 5, 10 and 15 % soya protein isolate (SPI). The rheological characteristics of WF showed that water absorption increased, extensibility and peak viscosity decreased when level of SPI increased from 5 to 15 %. Baking studies showed that spread ratio decreased and hardness values of PZB increased with the increase in amount of SPI from 5 to15 %. Beyond 10 % SPI, the overall quality of PZB was adversely affected. To the optimal blend of 10 % SPI, 5 % psyllium husk (PH) was added and the hydrogenated fat was replaced by canola oil (CAN) in enriched PZB. The enriched PZB treated with combination of additives had 1.7 and 1.6 times more protein and dietary fiber than the control PZB. Fatty acid analysis showed that the enriched PZB had 58.65 % oleic, 6.58 % linolenic acid and 31.28 % polyunsaturated fatty acid and no Trans fat was present.

Omega-3 fatty acids enriched chocolate spreads using soybean and coconut oils.

Chocolate spreads were developed by incorporating two different soybean oil margarines, fat phases prepared using 85 % soybean oil (M1) and 1:1 blend of soybean oil and coconut oil (M2) with commercial palm stearin. Eight formulations were tried by varying skim milk powder (SMP)/fluid skimmed milk (FSM), type of fats (M1, M2, a commercial margarine and a table spread), sugar and cocoa powder and their quality characteristics were compared with a commercial hazelnut cocoa spread. The moisture and fat content were 5-6.1 % and 31.4-32.8 % for formulations with SMP and 21.5-24.7 % and 15.6-21.4 % respectively for those with FSM. Rheological studies of FSM spreads showed higher G″ value (loss modulus) than G' (storage modulus) indicating better spreadability. Descriptive sensory analysis revealed that the products had acceptability score of 8.3 to 10.5 (maximum score: 15). Fat extracted from spreads prepared using M1 and M2 was found to contain 43.9 and 22.3 % linoleic acid and 2.1 and 4.4 % linolenic acid respectively, were free from trans fat while the commercial hazelnut spread had 9.8 % linoleic acid but did not contain linolenic acid. Hence, the developed chocolate spreads have the potential to overcome ω-3 deficiency, ω-6/ω-3 imbalance and to enhance the health standard of people.

Influence of debittered, defatted fenugreek seed powder and flaxseed powder on the rheological characteristics of dough and quality of cookies.

A functional ingredient mix (FIM) comprising debittered and defatted fenugreek seed powder (70%) and flaxseed powder (30%) was used in cookies. Ash, fat and protein, dough development time, resistance to extension and peak viscosity values increased as the level of FIM increased from 10 to 30% in the blend. Beyond 20% of FIM substitution, the quality characteristics of cookies were adversely affected. Use of soya lecithin produced a significant improvement in the overall quality of the cookies with 20% FIM. Linolenic acid and total dietary fiber content of the cookies with 20% FIM and lecithin contained four times the amount of linolenic acid (2.3%) and double the amount of dietary fiber (13.04%) when compared with the control cookies (0.5% and 6.22%) respectively. Surface scanning electron microscopy of cookies with different levels of FIM from 10 to 30% showed that there was a disruption in the matrix.