Effects of limestone solubility on the efficacy of a novel consensus bacterial 6-phytase variant to improve mineral digestibility, retention, and bone ash in young broilers fed low-calcium diets containing no added inorganic phosphate.

This study evaluated the effect of limestone solubility on the capacity of a novel consensus bacterial 6-phytase variant (PhyG) to improve phosphorus (P) and calcium (Ca) digestibility, retention, and utilization in low-Ca broiler diets containing no added inorganic phosphate (Pi). Male Ross 308 broilers (n = 1,152) were fed one of 16 experimental diets from 11 to 21 d of age in a randomized complete design (12 birds/cage, 6 cages/treatment). Diets comprised three positive controls (PC3, PC2, and PC1) containing 1.8, 1.2, or 0.6 g/kg MCP-P and 7.7, 7.0, or 6.2 g/kg Ca, respectively, and a negative control (NC) containing no added Pi (4.4 g/kg P; 2.8 g/kg phytate-P) and 5.5 g/kg Ca from either low or high solubility limestone (LSL or HSL, respectively, [with 42% and 97% solubility after 5 min at pH 3.0]), supplemented with 0, 250, 500, 1,000, or 2,000 FTU/kg of PhyG. Fecal samples collected on days 18 to 20 and ileal digesta collected on day 21 were analyzed for titanium dioxide, Ca, P, and phytate (IP6, inositol hexakisphosphate). Tibias (day 21) were analyzed for ash content. Data were analyzed by factorial analysis (2 limestone solubilities × 4 MCP-P levels and 2 limestone solubilities × 5 phytase dose levels) and exponential regression. Increasing dose levels of PhyG resulted in an exponential increase (P < 0.01) in the apparent ileal digestibility (AID) of P, ileal digestible P content of the diet, ileal IP6 content, and IP6 disappearance in birds fed either HSL or LSL diets, but AID Ca and ileal digestible Ca were exponentially increased by the phytase only in HSL diets (P < 0.01). Relative to HSL, the LSL increased AID P, ileal digestible P, and IP6 disappearance (P < 0.05) but reduced AID Ca, ileal digestible Ca, and retainable Ca (P < 0.05), resulting in reduced retainable P and tibia ash. Phytase exponentially increased the apparent total tract digestibility of P, retainable P, and tibia ash in HSL and LSL diets, but at or above 500 FTU/kg values were higher in HSL than LSL (interaction P < 0.05). The findings highlight that phytase dose-response effects on mineral digestibility and utilization are different for high- and low-solubility limestones, and it is therefore recommended to use digestible rather than total Ca content during diet formulation to ensure an optimal balance of Ca and P, especially in low-Ca diets. In diets containing HSL, higher phytase dose levels may be needed to compensate for the low digestible P content of the basal diet.

In broilers, an excess of dietary calcium (Ca) or imbalance with phosphorus (P) can impair mineral digestion and utilization. As a result, diets are being formulated with less Ca, but the quality of the added Ca (that is mainly from limestone) is also important. This study investigated effects of limestone solubility (high [HSL] vs. low [LSL]) on the capacity of a novel consensus bacterial 6-phytase variant, PhyG, to improve P and Ca digestion and utilization in low-Ca diets containing no added inorganic phosphate. Increasing the phytase dose increased ileal P and phytate digestibility and the digestible P content of the diet at 21 d of age regardless of limestone solubility and reduced the negative effects of HSL (relative to LSL). Total tract digestibility of P and Ca, retainable P and Ca, and tibia ash were also increased by phytase, but responses were reduced with LSL relative to HSL. The findings highlight that phytase dose-responses differ in diets containing different limestones and it is therefore recommended to formulate diets based on the content of digestible rather than total Ca to ensure that Ca requirements are met but not exceeded, with optimal phytase efficacy. In diets containing HSL, a higher PhyG dose level is needed to meet the requirement for P.

Effect of two phytases at two doses on performance and phytate degradation in broilers during 1-21 days of age.

The effect of two microbial phytases at two dose-levels on performance and apparent ileal digestibility (AID) of nutrients in broilers fed European-type diets was studied. A total of 1,200 d-old Ross 308 male broilers were randomly assigned to 5 treatments with 30 birds/pen and 8 pens/treatment. A nutritionally adequate positive control (PC) diet was tested against 4 experimental diets containing reduced total P, retainable P, Ca and Na as per the recommended nutritional contribution for Buttiauxella phytase (Phy B) at 1,000 FTU/kg (-1.87 g/kg, -1.59 g/kg, -1.99 g/kg and -0.4 g/kg vs. PC, respectively). Experimental diets were supplemented with Phy B at 500 FTU/kg or 1,000 FTU/kg, or Citrobacter phytase (Phy C) at 1,000 FTU/kg or 2,000 FTU/kg. Diets were based on corn, soybean meal, rapeseed meal and sunflower meal and formulated by phase (starter 1-10 d, grower 11-21 d) in crumbled or pelleted form. Overall (d 1-21), at 1,000 FTU/kg, birds fed Phy C exhibited lower BWG (-2.7%), FI (-3.4%) and tibia ash (-2.2%) vs. PC (P < 0.05), and reduced BWG (-3.6%), FI (-3.9%) and tibia ash (-1.8%) vs. Phy B (P < 0.05). Phy B at 1,000 FTU/kg and Phy C at 2,000 FTU/kg maintained performance equivalent to the PC. Digestibility of Ca did not differ among phytase treatments but at 1,000 FTU/kg AID P was greater with Phy B than Phy C (72.3% vs. 62.7%, P < 0.05). Ileal phytate (myo-inositol hexakisphosphate, IP6) digestibility was greatest with Phy B at 1,000 FTU/kg which was higher than Phy C at 1,000 FTU/kg (87.6 vs. 60.6%, P < 0.05). The findings indicate a higher phytate degradation rate of Phy B than Phy C at equivalent dose-level and this is correlated to the performance of the broilers.

Full strength and toughness recovery after repeated cracking and healing in bone-like high temperature ceramics.

Bones of humans and animals combine two unique features, namely: they are brittle yet have a very high fracture toughness linked to the tortuosity of the crack path and they have the ability to repeatedly heal local fissures such that full recovery of overall mechanical properties is obtained even if the local bone structure is irreversibly changed by the healing process. Here it is demonstrated that Ti2AlC MAX phase metallo-ceramics also having a bone-like hierarchical microstructure and also failing along zig-zag fracture surfaces similarly demonstrate repeated full strength and toughness recovery at room temperature, even though the (high temperature) healing reaction involves the local formation of dense and brittle alumina within the crack. Full recovery of the fracture toughness depends on the healed zone thickness and process zone size formed in the alumina reaction product. A 3-dimensional finite element method (FEM) analysis of the data obtained from a newly designed wedge splitting test allowed full extraction of the local fracture properties of the healed cracks.

Spatial analysis of soil subsidence in peat meadow areas in Friesland in relation to land and water management, climate change, and adaptation.

Dutch peatlands have been subsiding due to peat decomposition, shrinkage and compression, since their reclamation in the 11th century. Currently, subsidence amounts to 1-2 cm/year. Water management in these areas is complex and costly, greenhouse gases are being emitted, and surface water quality is relatively poor. Regional and local authorities and landowners responsible for peatland management have recognized these problems. In addition, the Netherlands Royal Meteorological Institute predicts higher temperatures and drier summers, which both are expected to enhance peat decomposition. Stakeholder workshops have been organized in three case study areas in the province of Friesland to exchange knowledge on subsidence and explore future subsidence rates and the effects of land use and management changes on subsidence rates. Subsidence rates were up to 3 cm/year in deeply drained parcels and increased when we included climate change in the modeling exercises. This means that the relatively thin peat layers in this province (ca 1 m) would shrink or even disappear by the end of the century when current practices continue. Adaptation measures were explored, such as extensive dairy farming and the production of new crops in wetter conditions, but little experience has been gained on best practices. The workshops have resulted in useful exchange of ideas on possible measures and their consequences for land use and water management in the three case study areas. The province and the regional water board will use the results to develop land use and water management policies for the next decades.

On the synergistic catalytic properties of bimetallic mesoporous materials containing aluminum and zirconium: the Prins cyclisation of citronellal.

Bimetallic three-dimensional amorphous mesoporous materials, Al-Zr-TUD-1 materials, were synthesised by using a surfactant-free, one-pot procedure employing triethanolamine (TEA) as a complexing reagent. The amount of aluminium and zirconium was varied in order to study the effect of these metals on the Brønsted and Lewis acidity, as well as on the resulting catalytic activity of the material. The materials were characterised by various techniques, including elemental analysis, X-ray diffraction, high-resolution TEM, N(2) physisorption, temperature-programmed desorption (TPD) of NH(3), and (27) Al MAS NMR, XPS and FT-IR spectroscopy using pyridine and CO as probe molecules. Al-Zr-TUD-1 materials are mesoporous with surface areas ranging from 700-900 m(2) g(-1), an average pore size of around 4 nm and a pore volume of around 0.70 cm(3) g(-1). The synthesised Al-Zr-TUD-1 materials were tested as catalyst materials in the Lewis acid catalysed Meerwein-Ponndorf-Verley reduction of 4-tert-butylcyclohexanone, the intermolecular Prins synthesis of nopol and in the intramolecular Prins cyclisation of citronellal. Although Al-Zr-TUD-1 catalysts possess a lower amount of acid sites than their monometallic counterparts, according to TPD of NH(3), these materials outperformed those of the monometallic Al-TUD-1 as well as Zr-TUD-1 in the Prins cyclisation of citronellal. This proves the existence of synergistic properties of Al-Zr-TUD-1. Due to the intramolecular nature of the Prins cyclisation of citronellal, the hydrophilic surface of the catalyst as well as the presence of both Brønsted and Lewis acid sites synergy could be obtained with bimetallic Al-Zr-TUD-1. Besides spectroscopic investigation of the active sites of the catalyst material a thorough testing of the catalyst in different types of reactions is crucial in identifying its specific active sites.

Zr-TUD-1: a Lewis acidic, three-dimensional, mesoporous, zirconium-containing catalyst.

A three-dimensional, mesoporous, silicate containing zirconium, Zr-TUD-1, was synthesized by a direct hydrothermal treatment method with triethanolamine as a complexing and templating reagent to ensure that zirconium was incorporated as isolated atoms. The mesoporosity of Zr-TUD-1 was confirmed by X-ray diffraction (XRD), N(2) sorption and high-resolution transmission electron micrograph (HR-TEM) studies. The nature and strength of the Lewis acid sites present in Zr-TUD-1 were evaluated by FTIR studies of pyridine adsorption and temperature-programmed desorption of ammonia. FTIR, X-ray photoelectron spectroscopic (XPS) and UV/Vis spectroscopic studies showed that, at Si/Zr ratios of 25 and higher, all the zirconium was tetrahedrally incorporated into the mesoporous framework, while at low Si/Zr ratios, a small part of the zirconium was present as ZrO(2) nanoparticles. Zr-TUD-1 is a Lewis acidic, stable and recyclable catalyst for the Meerwein-Ponndorf-Verley (MPV) reaction and for the Prins reaction.

Pyrococcus furiosus 4Fe-ferredoxin, chemisorbed on gold, exhibits gated reduction and ionic strength dependent dimerization.

Pyrococcus furiosus ferredoxin is a small metalloprotein that shuttles electrons between redox enzymes. In its native 4Fe-4S form the protein is highly thermostable. In addition to three cluster-ligating cysteines, two surface cysteine residues (C21 and C48) are present. We used the reactivity of these surface thiols to directly immobilize ferredoxin on a bare gold electrode, with an orientation in which the cluster is exposed to solution. Voltammetry, X-ray photoelectron spectroscopy (XPS), and atomic force microscopy (AFM) studies established the immobilization of the 4Fe form. Native and recombinant wild-type ferredoxins were compared with the C48S, C21S, and C21S/C48S mutants. The variants with one and two surface cysteines can be directly chemisorbed on bare gold. Cyclic voltammetry demonstrated that the reduction potentials are similar to those in solution. The interfacial electron transfer kinetics revealed that the reduction is gated by the interconversion between two oxidized species. AFM images showed that dimers are chemisorbed at low ionic strength, while monomers are present at high ionic strength. XPS spectra revealed the presence of S, Fe, C, N, and O at the surface, which are assigned to the corresponding atoms in the peptide and the cofactor. Analysis of the sulfur spectrum corroborates that both C21 and C48 form gold-thiolate bonds. Moreover, two inorganic sulfide and two iron species were identified, suggesting an inhomogeneous charge distribution in the 4Fe-4S cluster. In conclusion, P. furiosus ferredoxin can be directly and vectorially chemisorbed on gold with retention of its properties. This may provide a biocompatible electrode surface with docking sites for redox enzymes.