Non-instrumental immunochemical tests for rapid ochratoxin A detection in red wine.

Gel-based and membrane-based flow-through immunoassay formats were investigated for rapid ochratoxin A (OTA) detection in red wine. The flow-through set-up consisted of an antibody containing gel or membrane placed at the bottom of a standard solid-phase extraction column (i.e. the flow-through column), combined with a clean-up column. Different clean-up methods were studied for red wine clarification and purification. The optimal method consisted of passing wine, diluted with an aqueous solution containing 1% polyethylene glycol (PEG 6000) and 5% sodium hydrogencarbonate, through strong anion exchange (SAX) silica. An immunoassay for OTA detection in red wine was optimized and a cut-off level at 2 microg L(-1) according to EU legislation was achieved with both formats. A more significant colour difference between blank and spiked samples was observed for the gel-based assay making this superior to the membrane-based assay. The proposed rapid gel-based test was compared with a standard immunoaffinity column-high-performance liquid chromatography-fluorescent detection (IAC-HPLC-FLD) method and a good correlation of the results was obtained for naturally contaminated wine samples.

Immunocompetence in organically fed finishing pigs: effect of corn cob mix.

Two consecutive experiments were performed to evaluate the effects on the immune response of corn cob mix (CCM) in an organic pig diet. The immunoglobulin (Ig) M, IgA and IgG responses against an intramuscularly injected model antigen, bovine thyroglobulin, were used as indicator. The experiments were performed in an organic barn with nine pens of four crossbred pigs (two barrows and two sows) from 45 kg to slaughter. In the first experiment, the organic concentrate was mixed with organic CCM-silage to obtain three concentrate: CCM ratios of 100:0, 80:20 and 60:40 (w:w). In the second experiment, three concentrates were produced to obtain diets with equal nutrient levels on a dry matter basis after 0%, 20% and 40% CCM inclusion. Higher inclusion rates of CCM in the ration were accompanied by lower thyroglobulin-specific IgG responses. These effects could not be attributed to one specific component of the CCM, such as fatty acid composition, although there was a degree of correlation with lower vitamin A concentrations. Mycotoxin concentrations were absent or minimal. The study indicated that dietary ingredient composition may affect immunocompetence.

Approach for ochratoxin A fast screening in spices using clean-up tandem immunoassay columns with confirmation by high performance liquid chromatography-tandem mass spectrometry (HPLC-MS/MS).

An approach for ochratoxin A (OTA) fast cost-effective screening based on clean-up tandem immunoassay columns was developed and optimized for OTA detection with a cut-off level of 10 microg kg(-1) in spices. Two procedures were tested and applied for OTA detection. Column with bottom detection immunolayer was optimized for OTA determination in Capsicum ssp. spices. A modified clean-up tandem immunoassay procedure with top detection immunolayer was successfully applied for all tested spices. Its main advantages were decreasing of the number of analysis steps and quantity of antibody and also minimizing of matrix effects. The total duration of the extraction and analysis was about 40 min for six samples. Chilli, red pepper, pili-pili, cayenne, paprika, nutmeg, ginger, white pepper and black pepper samples were analyzed for OTA contamination by the proposed clean-up tandem immunoassay procedures. Clean-up tandem immunoassay results were confirmed by HPLC-MS/MS with immunoaffinity column clean-up. Among 17 tested Capsicum ssp. spices, 6 samples (35%) contained OTA in a concentration exceeding the 10 microg kg(-1) limit discussed by the European Commission. All tested nutmeg (n=8), ginger (n=5), white pepper (n=7) and black pepper (n=6) samples did not contain OTA above this action level.

Novel developments in rapid mycotoxin detection.

Rapid antibody-based mycotoxin screening techniques are designed to be used outside a laboratory environment, at the place of sampling. Results are expected immediately, so that commodities can be further processed without delay. Because they are used for mycotoxin analysis, very low levels (ppb and ppt range) should be detected. A further requirement is that the obtained results are accurate with a false negative rate of <5% at the level of interest.At first, plastic microtiter plates were used as solid phase materials for immobilizing antibodies (enzyme-linked immunosorbent assays). However, to increase speed and user-friendliness, plastics were replaced by microporous membranes. As an example a flow-through enzyme immunoassay for the detection of fumonisins in cornflakes with a cut-off value of 275 µg/kg is described. No false negative results were observed and the false positive rate was 18%. However, enzyme labels, used to enable visual evaluation of results, did not seem to be completely satisfactory in terms of stability and repeatability of the generated signal. Therefore microparticle labels such as colloidal gold particles are used more and more,e.g. in a lateral flow dipstick immunoassay. When applied to the detection of aflatoxin B1 in pig feed a cut-off value of 5 µg/kg could be reached with no false negative results and a false positive rate of only 10%. Sample pretreatment for screening techniques should be rapid and simple. Preferably a simple solvent extraction is used, followed by a filtration and dilution step. However, for strongly coloured or complex food matrices, this did not seem to work. The combination of clean-up and detection in one single test device is a new approach. When using this clean-up tandem assay column for the detection of ochratoxin A in roasted coffee, a cut-off value of 6 µg/kg was reached. No false positive results were obtained, however, the false negative rate was 8%.