ABSTRACT
The saturated flue gas is difficult to recover and use as low-grade waste heat in a coal-fired power plant. The absorption heat pump is important equipment for recovering low-grade waste heat. In this article, the saturated flue gas waste heat is recovered to reduce the turbine extraction steam of low-pressure heaters. The simulation system is built, and the operational characteristics are analyzed. The feasibility of saturated flue gas waste heat recovered is verified by the absorption heat pump to heat the boiler feedwater. The results show that generator pressure and throttle pressure have significant influence on the operational performance of the absorption heat pump. There is the risk of solution crystallization with the high-concentration dehumidification solution. The equivalent enthalpy drop of the extraction steam is lower in the higher number of heater stages, representing the weaker electricity generation capacity. The waste heat temperature of saturated flue gas can be raised by 30-40 °C, which is used as the low-grade heat source for the absorption heat pump. The feedwater of low-pressure heaters is heated by the absorption heat pump, and its temperature ranges from 59.2 to 83.8 °C. The simulation system can efficiently recover the waste heat of saturated flue gas up to 9.99 MW and achieve additional electricity generation up to 0.56 MW in the coal-fired power plant.
ABSTRACT
Rosin-based fluorescent polyurethane emulsion (FPU) was prepared using isophorone diisocyanate, ester of acrylic rosin and glycidyl methacrylate, 1,5-dihydroxy naphthalene (1,5-DN), and 1,4-butanediol as the raw materials. Then, rosin-based fluorescent polyurethane microspheres (FPUMs) were successfully prepared by suspension polymerization method using FPU as the main material, azodiisobutyronitrile as the initiator, and gelatin as the dispersant. FPUMs were characterized by Fourier transform infrared spectra, thermogravimetric analysis, optical microscopy, scanning electron microscopy and fluorescence spectra, and the response performance of FPUMs to pH was studied. The results showed that FPUMs were successfully prepared. With the increase of the level of 1,5-DN, the particle size of FPUMs increased gradually, and the fluorescence intensity increased first and then decreased. When the level of 1,5-DN was 3 wt.%, the average particle size was 49.3 µm, the particle distribution index (PDI) was 1.05, and the fluorescence intensity was the largest (3662 a.u.). The fluorescence intensity of FPUMs increased linearly with the decrease of pH, which can be used for pH detection in solution. Furthermore, the FPUMs exhibited good thermal stability, anti-interference and recoverability.
ABSTRACT
Here, acidic tumor microenvironment (TME)-responsive nano-Bi2 Se3 @MnCaP, as a near-infrared-II (NIR-II) biowindow-triggered free radical generator for hypoxia-irrelevant phototherapy, is elaborately developed by biomimetic mineralization of MnCaP onto 2, 2'-azobis[2-(2-imidazolin-2-yl)propane] dihydrochloride (AIPH)-loaded mesoporous nano-Bi2 Se3 to form Bi2 Se3 /AIPH@MnCaP (BAM). Surface mineral of MnCaP can be degraded under mild acidity, leading to the release of both Mn2+ and AIPH. The leached Mn2+ not only facilitates chemodynamic therapy (CDT) via hydroxyl radicals (⢠OH) from Mn2+ -mediated Fenton-like reaction but also acts as contrast agent for magnetic resonance imaging. In another aspect, the splendid photothermal conversion capacity of BAM enables a rapid hyperthermia generation under NIR-II laser irradiation for photothermal therapy (PTT). Simultaneously, the local thermal shock can induce the disintegration of AIPH to generate alkyl radicals (⢠R) for thermodynamic therapy (TDT) and accelerate Fenton-like reaction rate to augment CDT efficacy. The strong synergistic effects from cooperative CDT/PTT/TDT are applied to 4T1 tumor suppression with minimal side effects. Importantly, the combination therapy can effectively trigger immunogenetic cell death and enhance antitumor immunity for systemic tumor eradication. Collectively, this proof-of-concept study demonstrates a more efficacious and safer strategy for oxygenation-independent phototherapy, which holds a good potential for clinical translation in cancer management.
