ABSTRACT
Quesillo is an artisanal Honduran cheese made from raw milk. During fabrication, curd melting is considered a killing step for pathogenic bacteria. This work was aimed at determining the survival of Salmonella enterica and Listeria monocytogenes on inoculated curd packaged in plastic bags and immersed in a water bath at 48, 54, 60, 65, and 70°C for predetermined times. Survival counts of each pathogen were used to estimate D values by linear regression, and z values were estimated by the linear regression of the D values. S. entericaD values ranged from 4.5 min at 60°C to 0.80 min at 70°C (z = 10.7°C). For L. monocytogenes, D values ranged from 6.08 min at 60°C to 0.90 min at 70°C (z = 11.3°C). Validation of 7-log reduction was performed on inoculated curd heated at 65°C for 34.7 min, and recovering enrichment procedures were used for each pathogen. Neither S. enterica nor L. monocytogenes cells were recovered after the enrichment of samples. The results obtained in this study could be applied by Honduran quesillo processors to improve the safety of their products.
ABSTRACT
Achieving the U. S. Department of Agriculture, Food Safety and Inspection Service (USDA-FSIS) stabilization microbiological performance standards for cooling procedures proves to be challenging for processors of large, whole-muscle meat products. This study was conducted to determine if slower cooling times than those provided by USDA-FSIS guidance will comply with the performance standard for Clostridium perfringens. Large (9 to 12 kg) cured bone-in hams (n = 110) and large (8 to 13 kg) uncured beef inside rounds (n = 100) were used. Stabilization treatments extended times to reduce internal product temperature from 54.4 to 26.7°C (hams and rounds) and from 26.7 to 7.2°C (for hams) and 26.7 to 4.4°C (for rounds). Control treatments, defined by current USDA-FSIS Appendix B guidelines, and a "worst-case scenario" treatment, in which products were cooled at room temperature (approximately 22.8°C) until internal product temperature equilibrated, were used. For both hams and rounds, stabilization showed less than 1-log growth of C. perfringens for all treatments, with the exception of the worst-case scenario for rounds. As expected for products cooled at room temperature, there was >1-log growth of C. perfringens reported for rounds, and the addition of curing ingredients to hams had an inhibitory effect on the growth of C. perfringens. The results demonstrate that industry may have increased flexibility associated with cooling large, whole-muscle cuts while still complying with the required stabilization microbiological performance standards.
Subject(s)
Clostridium perfringens/growth & development , Cold Temperature , Food Handling/methods , Meat Products/microbiology , Animals , Consumer Product Safety , Food Microbiology , Humans , Meat Products/standards , Risk Assessment , SwineABSTRACT
The effect of low-dose electron beam (e-beam) radiation on the reduction of Escherichia coli O157:H7 and Salmonella in spinach was studied. Fresh baby spinach (Spinacia oleracea) was inoculated with a bacterial cocktail containing multiple strains of rifampin-resistant E. coli O157:H7 and rifampin-resistant Salmonella. Inoculated samples were exposed to e-beam radiation from a linear accelerator and tested for counts of both E. coli O157:H7 and Salmonella. Irradiated spinach was also stored for 8 days at 4 degrees C, and counts were made at 2-day intervals to determine if there was any effect of radiation on the survival trend of both pathogens. When no pathogens were detected on plates, additional enrichment plating was conducted to verify total destruction. Respiration rates were measured on spinach samples exposed to e-beam radiation. Each dose of e-beam radiation significantly reduced the numbers of E. coli O157:H7 and Salmonella from initial levels of 7 log CFU/g. Treatment by e-beam radiation at a dose of 0.40 kGy resulted in a reduction in populations of E. coli O157:H7 and Salmonella of 3.7 and 3.4 log cycles, respectively. At 0.70 kGy, both pathogens were reduced by 4 log. All doses above 1.07 kGy showed reductions greater than 6 log and decreased to undetectable levels when stored for 8 days. The respiration rate of spinach showed no changes after irradiation up to 2.1 kGy. These results suggest that low-dose e-beam radiation may be a viable tool for reducing microbial populations or eliminating E. coli O157:H7 and Salmonella from spinach without product damage.
