Towards a general application programming interface (API) for injection molding machines.

Injection molding is a complicated process, and the final part quality depends on many machine and process parameters settings. To increase controllability of the injection molding process, acquisition of the process data is necessary. This paper describes the architecture and development of a prototype of an open application programming interface (API) for injection molding machines (IMMs), which has the potential to be used with different IMMs to log and set the necessary process parameter values. At the moment, the API includes an implementation of EMI data exchange protocol and can be used with ENGEL IMMs with CC300 and RC300 controllers. Data collection of up to 97 machine and process parameters (the number might vary depending on the type of machine at hand), obtained from sensors installed in the machine by the manufacturer is allowed. The API also includes a module for the acquisition of data from additional 3d party sensors. Industrial Raspberry Pi (RevPi) was used to perform analog-to-digital signal conversion and make sensors data accessible via the API prototype. The logging of parameters from the machine and from sensors is synchronized and the sampling frequency can be adjusted if necessary. The system can provide soft real-time communication.

Perioperative aspirin and clonidine and risk of acute kidney injury: a randomized clinical trial.

IMPORTANCE: Acute kidney injury, a common complication of surgery, is associated with poor outcomes and high health care costs. Some studies suggest aspirin or clonidine administered during the perioperative period reduces the risk of acute kidney injury; however, these effects are uncertain and each intervention has the potential for harm. OBJECTIVE: To determine whether aspirin compared with placebo, and clonidine compared with placebo, alters the risk of perioperative acute kidney injury. DESIGN, SETTING, AND PARTICIPANTS: A 2 × 2 factorial randomized, blinded, clinical trial of 6905 patients undergoing noncardiac surgery from 88 centers in 22 countries with consecutive patients enrolled between January 2011 and December 2013. INTERVENTIONS: Patients were assigned to take aspirin (200 mg) or placebo 2 to 4 hours before surgery and then aspirin (100 mg) or placebo daily up to 30 days after surgery, and were assigned to take oral clonidine (0.2 mg) or placebo 2 to 4 hours before surgery, and then a transdermal clonidine patch (which provided clonidine at 0.2 mg/d) or placebo patch that remained until 72 hours after surgery. MAIN OUTCOMES AND MEASURES: Acute kidney injury was primarily defined as an increase in serum creatinine concentration from the preoperative concentration by either an increase of 0.3 mg/dL or greater (≥26.5 µmol/L) within 48 hours of surgery or an increase of 50% or greater within 7 days of surgery. RESULTS: Aspirin (n = 3443) vs placebo (n = 3462) did not alter the risk of acute kidney injury (13.4% vs 12.3%, respectively; adjusted relative risk, 1.10; 95% CI, 0.96-1.25). Clonidine (n = 3453) vs placebo (n = 3452) did not alter the risk of acute kidney injury (13.0% vs 12.7%, respectively; adjusted relative risk, 1.03; 95% CI, 0.90-1.18). Aspirin increased the risk of major bleeding. In a post hoc analysis, major bleeding was associated with a greater risk of subsequent acute kidney injury (23.3% when bleeding was present vs 12.3% when bleeding was absent; adjusted hazard ratio, 2.20; 95% CI, 1.72-2.83). Similarly, clonidine increased the risk of clinically important hypotension. In a post hoc analysis, clinically important hypotension was associated with a greater risk of subsequent acute kidney injury (14.3% when hypotension was present vs 11.8% when hypotension was absent; adjusted hazard ratio, 1.34; 95% CI, 1.14-1.58). CONCLUSIONS AND RELEVANCE: Among patients undergoing major noncardiac surgery, neither aspirin nor clonidine administered perioperatively reduced the risk of acute kidney injury. TRIAL REGISTRATION: clinicaltrials.gov Identifier: NCT01082874.

Aspirin and clonidine in non-cardiac surgery: acute kidney injury substudy protocol of the Perioperative Ischaemic Evaluation (POISE) 2 randomised controlled trial.

INTRODUCTION: Perioperative Ischaemic Evaluation-2 (POISE-2) is an international 2×2 factorial randomised controlled trial of low-dose aspirin versus placebo and low-dose clonidine versus placebo in patients who undergo non-cardiac surgery. Perioperative aspirin (and possibly clonidine) may reduce the risk of postoperative acute kidney injury (AKI). METHODS AND ANALYSIS: After receipt of grant funding, serial postoperative serum creatinine measurements began to be recorded in consecutive patients enrolled at substudy participating centres. With respect to the study schedule, the last of over 6500 substudy patients from 82 centres in 21 countries were randomised in December 2013. The authors will use logistic regression to estimate the adjusted OR of AKI following surgery (compared with the preoperative serum creatinine value, a postoperative increase ≥26.5 µmol/L in the 2 days following surgery or an increase of ≥50% in the 7 days following surgery) comparing each intervention to placebo, and will report the adjusted relative risk reduction. Alternate definitions of AKI will also be considered, as will the outcome of AKI in subgroups defined by the presence of preoperative chronic kidney disease and preoperative chronic aspirin use. At the time of randomisation, a subpopulation agreed to a single measurement of serum creatinine between 3 and 12 months after surgery, and the authors will examine intervention effects on this outcome. ETHICS AND DISSEMINATION: The authors were competitively awarded a grant from the Canadian Institutes of Health Research for this POISE-2 AKI substudy. Ethics approval was obtained for additional kidney data collection in consecutive patients enrolled at participating centres, which first began for patients enrolled after January 2011. In patients who provided consent, the remaining longer term serum creatinine data will be collected throughout 2014. The results of this study will be reported no later than 2015. CLINICAL TRIAL REGISTRATION NUMBER: NCT01082874.

Effect of high perioperative oxygen fraction on surgical site infection and pulmonary complications after abdominal surgery: the PROXI randomized clinical trial.

CONTEXT: Use of 80% oxygen during surgery has been suggested to reduce the risk of surgical wound infections, but this effect has not been consistently identified. The effect of 80% oxygen on pulmonary complications has not been well defined. OBJECTIVE: To assess whether use of 80% oxygen reduces the frequency of surgical site infection without increasing the frequency of pulmonary complications in patients undergoing abdominal surgery. DESIGN, SETTING, AND PATIENTS: The PROXI trial, a patient- and observer-blinded randomized clinical trial conducted in 14 Danish hospitals between October 2006 and October 2008 among 1400 patients undergoing acute or elective laparotomy. INTERVENTIONS: Patients were randomly assigned to receive either 80% or 30% oxygen during and for 2 hours after surgery. MAIN OUTCOME MEASURES: Surgical site infection within 14 days, defined according to the Centers for Disease Control and Prevention. Secondary outcomes included atelectasis, pneumonia, respiratory failure, and mortality. RESULTS: Surgical site infection occurred in 131 of 685 patients (19.1%) assigned to receive 80% oxygen vs 141 of 701 (20.1%) assigned to receive 30% oxygen (odds ratio [OR], 0.94; 95% confidence interval [CI], 0.72-1.22; P = .64). Atelectasis occurred in 54 of 685 patients (7.9%) assigned to receive 80% oxygen vs 50 of 701 (7.1%) assigned to receive 30% oxygen (OR, 1.11; 95% CI, 0.75-1.66; P = .60), pneumonia in 41 (6.0%) vs 44 (6.3%) (OR, 0.95; 95% CI, 0.61-1.48; P = .82), respiratory failure in 38 (5.5%) vs 31 (4.4%) (OR, 1.27; 95% CI, 0.78-2.07; P = .34), and mortality within 30 days in 30 (4.4%) vs 20 (2.9%) (OR, 1.56; 95% CI, 0.88-2.77; P = .13). CONCLUSION: Administration of 80% oxygen compared with 30% oxygen did not result in a difference in risk of surgical site infection after abdominal surgery. TRIAL REGISTRATION: clinicaltrials.gov Identifier: NCT00364741.