Production of a Brassica napus Low-Molecular Mass Acyl-Coenzyme A-Binding Protein in Arabidopsis Alters the Acyl-Coenzyme A Pool and Acyl Composition of Oil in Seeds.

Low-molecular mass (10 kD) cytosolic acyl-coenzyme A-binding protein (ACBP) has a substantial influence over fatty acid (FA) composition in oilseeds, possibly via an effect on the partitioning of acyl groups between elongation and desaturation pathways. Previously, we demonstrated that the expression of a Brassica napus ACBP (BnACBP) complementary DNA in the developing seeds of Arabidopsis (Arabidopsis thaliana) resulted in increased levels of polyunsaturated FAs at the expense of eicosenoic acid (20:1cisΔ11) and saturated FAs in seed oil. In this study, we investigated whether alterations in the FA composition of seed oil at maturity were correlated with changes in the acyl-coenzyme A (CoA) pool in developing seeds of transgenic Arabidopsis expressing BnACBP. Our results indicated that both the acyl-CoA pool and seed oil of transgenic Arabidopsis lines expressing cytosolic BnACBP exhibited relative increases in linoleic acid (18:2cisΔ9,12; 17.9%-44.4% and 7%-13.2%, respectively) and decreases in 20:1cisΔ11 (38.7%-60.7% and 13.8%-16.3%, respectively). However, alterations in the FA composition of the acyl-CoA pool did not always correlate with those seen in the seed oil. In addition, we found that targeting of BnACBP to the endoplasmic reticulum resulted in FA compositional changes that were similar to those seen in lines expressing cytosolic BnACBP, with the most prominent exception being a relative reduction in α-linolenic acid (18:3cisΔ9,12,15) in both the acyl-CoA pool and seed oil of the former (48.4%-48.9% and 5.3%-10.4%, respectively). Overall, these data support the role of ACBP in acyl trafficking in developing seeds and validate its use as a biotechnological tool for modifying the FA composition of seed oil.

High level accumulation of gamma linolenic acid (C18:3Δ6.9,12 cis) in transgenic safflower (Carthamus tinctorius) seeds.

Gamma linolenic acid (GLA; C18:3Δ6,9,12 cis), also known as γ-Linolenic acid, is an important essential fatty acid precursor for the synthesis of very long chain polyunsaturated fatty acids and important pathways involved in human health. GLA is synthesized from linoleic acid (LA; C18:2Δ9,12 cis) by endoplasmic reticulum associated Δ6-desaturase activity. Currently sources of GLA are limited to a small number of plant species with poor agronomic properties, and therefore an economical and abundant commercial source of GLA in an existing crop is highly desirable. To this end, the seed oil of a high LA cultivated species of safflower (Carthamus tinctorius) was modified by transformation with Δ6-desaturase from Saprolegnia diclina resulting in levels exceeding 70% (v/v) of GLA. Levels around 50% (v/v) of GLA in seed oil was achieved when Δ12-/Δ6-desaturases from Mortierella alpina was over-expressed in safflower cultivars with either a high LA or high oleic (OA; C18:1Δ9 cis) background. The differences in the overall levels of GLA suggest the accumulation of the novel fatty acid was not limited by a lack of incorporation into the triacylgylcerol backbone (>66% GLA achieved), or correlated with gene dosage (GLA levels independent of gene copy number), but rather reflected the differences in Δ6-desaturase activity from the two sources. To date, these represent the highest accumulation levels of a newly introduced fatty acid in a transgenic crop. Events from these studies have been propagated and recently received FDA approval for commercialization as Sonova™400.

Oleosin di-or tri-meric fusions with GFP undergo correct targeting and provide advantages for recombinant protein production.

Plant oleosins are small proteins embedded within the phospholipid monolayer separating the triacylglycerol storage site of embryo-located oilbodies from the cytoplasm of oilseed cells. The potential of oleosins to act as carriers for recombinant proteins foreign to plant cells has been well established. Using this approach, the recombinant polypeptide is accumulated in oilbodies as a fusion with oleosin. DNA constructs having tandemly arranged oleosins followed by GFP or flanked by oleosins were used to transform Arabidopsis plants. In all cases the green fluorescence revealed that the fusion polypeptide had a native conformation and the recombinant proteins were correctly targeted to seed oilbodies. Mobilization of lipids was not retarded when using homo-dimer or -trimer oleosin fusions, since seed production, germination rates and seedling establishment were similar among all constructs, and comparable to wild-type Arabidopsis plants. Plant physiology and growth of recombinant lines were similar to wild-type plants. The construct specifying two oleosins flanking the GFP polypeptide revealed interesting properties regarding both the accumulation and the relative stability of the oilbody protein assembly. Although expression levels varied among transgenic lines, those transgenes accumulated significantly higher levels of fusion proteins as compared to previously reported values obtained by a single-oleosin configuration, reaching up to 2.3% of the total embryo proteins. These results shows that the expression cassettes comprising three oleosin molecules in frame to the GFP molecule or two oleosins flanking the GFP could be advantageous over the single-oleosin configuration for higher production and better commercialization of this plant biotechnological platform without jeopardizing plant vigour and physiology or oilbody stability.

Expression and recovery of biologically active recombinant Apolipoprotein AI(Milano) from transgenic safflower (Carthamus tinctorius) seeds.

Apolipoprotein AI Milano (ApoAI(Milano) ) was expressed as a fusion protein in transgenic safflower seeds. High levels of expression corresponding to 7 g of ApoAI(Milano) per kilogram of seed have been identified in a line selected for commercialization. The ApoAI(Milano) fusion protein was extracted from seed using an oilbody-based process and matured in vitro prior to final purification. This yielded a Des-1,2-ApoAI(Milano) product which was confirmed by biochemical characterization including immunoreactivity against ApoAI antibodies, isoelectric point, N-terminal sequencing and electrospray mass spectrometry. Purified Des-1,2-ApoAI(Milano) readily associated with dimyristoylphosphatidylcholine in clearance assays comparable to Human ApoAI. Its biological activity was assessed by cholesterol efflux assays using Des-1,2-ApoAI(Milano) :1-palmitoyl-2-oleoyl phosphatidylcholine complexes in vitro and in vivo. This study has established that high levels of biologically functional ApoAI(Milano) can be produced using a plant-based expression system.

Seed-based expression systems for plant molecular farming.

The evolution of the seed system provides enormous adaptability to the gymnosperms and angiosperms, because of the properties of dormancy, nutrient storage and seedling vigour. Many of the unique properties of seeds can be exploited in molecular farming applications, particularly where it is desirable to produce large quantities of a recombinant protein. Seeds of transgenic plants have been widely used to generate a raw material for the extraction and isolation of proteins and polypeptides, which can be processed into valuable biopharmaceuticals. The factors that control high-level accumulation of recombinant proteins in seed are reviewed in the following paragraphs. These include promoters and enhancers, which regulate transcript abundance. However, it is shown that subcellular trafficking and targeting of the desired polypeptides or proteins play a crucial role in their accumulation at economically useful levels. Seeds have proven to be versatile hosts for recombinant proteins of all types, including peptides or short and long polypeptides as well as complex, noncontiguous proteins like antibodies and other immunoglobulins. The extraction and recovery of recombinant proteins from seeds is greatly assisted by their dormancy properties, because this allows for long-term stability of stored products including recombinant proteins and a decoupling of processing from the growth and harvest cycles. Furthermore, the low water content and relatively low bioload of seeds help greatly in designing cost-effective manufacturing processes for the desired active pharmaceutical ingredient. The development of cGMP processes based on seed-derived materials has only been attempted by a few groups to date, but we provide a review of the key issues and criteria based on interactions with Food and Drug Administration and European Medicines Agency. This article uses 'case studies' to highlight the utility of seeds as vehicles for pharmaceutical production including: insulin, human growth hormone, lysozyme and lactoferrin. These examples serve to illustrate the preclinical and, in one case, clinical information required to move these plant-derived molecules through the research phase and into the regulatory pathway en route to eventual approval.

A 10-kDa acyl-CoA-binding protein (ACBP) from Brassica napus enhances acyl exchange between acyl-CoA and phosphatidylcholine.

The gene encoding a 10-kDa acyl-CoA-binding protein (ACBP) from Brassica napus was over-expressed in developing seeds of Arabidopsis thaliana. Biochemical analysis of T(2) and T(3) A. thaliana seeds revealed a significant increase in polyunsaturated fatty acids (FAs) (18:2(cisDelta9,12) and 18:3(cisDelta9,12,15)) at the expense of very long monounsaturated FA (20:1(cisDelta11)) and saturated FAs. In vitro assays demonstrated that recombinant B. napus ACBP (rBnACBP) strongly increases the formation of phosphatidylcholine (PC) in the absence of added lysophosphatidylcholine in microsomes from DeltaYOR175c yeast expressing A. thaliana lysophosphatidylcholine acyltransferase (AthLPCAT) cDNA or in microsomes from microspore-derived cell suspension cultures of B. napus L. cv. Jet Neuf. rBnACBP or bovine serum albumin (BSA) were also shown to be crucial for AthLPCAT to catalyse the transfer of acyl group from PC into acyl-CoA in vitro. These data suggest that the cytosolic 10-kDa ACBP has an effect on the equilibrium between metabolically active acyl pools (acyl-CoA and phospholipid pools) involved in FA modifications and triacylglycerol bioassembly in plants. Over-expression of ACBP during seed development may represent a useful biotechnological approach for altering the FA composition of seed oil.

Metabolic control analysis is helpful for informed genetic manipulation of oilseed rape (Brassica napus) to increase seed oil content.

Top-down control analysis (TDCA) is a useful tool for quantifying constraints on metabolic pathways that might be overcome by biotechnological approaches. Previous studies on lipid accumulation in oilseed rape have suggested that diacylglycerol acyltransferase (DGAT), which catalyses the final step in seed oil biosynthesis, might be an effective target for enhancing seed oil content. Here, increased seed oil content, increased DGAT activity, and reduced substrate:product ratio are demonstrated, as well as reduced flux control by complex lipid assembly, as determined by TDCA in Brassica napus (canola) lines which overexpress the gene encoding type-1 DGAT. Lines overexpressing DGAT1 also exhibited considerably enhanced seed oil content under drought conditions. These results support the use of TDCA in guiding the rational selection of molecular targets for oilseed modification. The most effective lines had a seed oil increase of 14%. Moreover, overexpression of DGAT1 under drought conditions reduced this environmental penalty on seed oil content.

Transgenic expression and recovery of biologically active recombinant human insulin from Arabidopsis thaliana seeds.

The increased incidence of diabetes, coupled with the introduction of alternative delivery methods that rely on higher doses, is expected to result in a substantial escalation in the demand for affordable insulin in the future. Limitations in the capacity and economics of production will make it difficult for current manufacturing technologies to meet this demand. We have developed a novel expression and recovery technology for the economical manufacture of biopharmaceuticals from oilseeds. Using this technology, recombinant human precursor insulin was expressed in transgenic plants. Plant-derived insulin accumulates to significant levels in transgenic seed (0.13% total seed protein) and can be enzymatically treated in vitro to generate a product with a mass identical to that of the predicted product, DesB(30)-insulin. The biological activity of this product in vivo and in vitro was demonstrated using an insulin tolerance test in mice and phosphorylation assay performed in a mammalian cell culture system, respectively.

Acyl-CoA-binding and self-associating properties of a recombinant 13.3 kDa N-terminal fragment of diacylglycerol acyltransferase-1 from oilseed rape.

BACKGROUND: Diacylglycerol acyltransferase (DGAT, EC 2.3.1.20) catalyzes the acyl-CoA-dependent acylation of sn-1, 2-diacylglycerol to generate triacylglycerol and CoA. The deduced amino acid sequence of cDNAs encoding DGAT1 from plants and mammals exhibit a hydrophilic N-terminal region followed by a number of potential membrane-spanning segments, which is consistent with the membrane-bound nature of this enzyme family. In order to gain insight into the structure/function properties of DGAT1 from Brassica napus (BnDGAT1), we produced and partially characterized a recombinant polyHis-tagged N-terminal fragment of the enzyme, BnDGAT1(1-116)His6, with calculated molecular mass of 13,278 Da. RESULTS: BnDGAT1(1-116)His6 was highly purified from bacterial lysate and plate-like monoclinic crystals were grown using this preparation. Lipidex-1000 binding assays and gel electrophoresis indicated that BnDGAT1(1-116)His6 interacts with long chain acyl-CoA. The enzyme fragment displayed enhanced affinity for erucoyl (22:1cisDelta13)-CoA over oleoyl (18:1cisDelta9)-CoA, and the binding process displayed positive cooperativity. Gel filtration chromatography and cross-linking studies indicated that BnDGAT1(1-116)His6 self-associated to form a tetramer. Polyclonal antibodies raised against a peptide of 15 amino acid residues representing a segment of BnDGAT1(1-116)His6 failed to react with protein in microsomal vesicles following treatment with proteinase K, suggesting that the N-terminal fragment of BnDGAT1 was localized to the cytosolic side of the ER. CONCLUSION: Collectively, these results suggest that BnDGAT1 may be allosterically modulated by acyl-CoA through the N-terminal region and that the enzyme self-associates via interactions on the cytosolic side of the ER.

The accumulation of oleosins determines the size of seed oilbodies in Arabidopsis.

We investigated the role of the oilbody proteins in developing and germinating Arabidopsis thaliana seeds. Seed oilbodies are simple organelles comprising a matrix of triacylglycerol surrounded by a phospholipid monolayer embedded and covered with unique proteins called oleosins. Indirect observations have suggested that oleosins maintain oilbodies as small single units preventing their coalescence during seed desiccation. To understand the role of oleosins during seed development or germination, we created lines of Arabidopsis in which a major oleosin is ablated or severely attenuated. This was achieved using RNA interference techniques and through the use of a T-DNA insertional event, which appears to interrupt the major (18 kD) seed oleosin gene of Arabidopsis and results in ablation of expression. Oleosin suppression resulted in an aberrant phenotype of embryo cells that contain unusually large oilbodies that are not normally observed in seeds. Changes in the size of oilbodies caused disruption of storage organelles, altering accumulation of lipids and proteins and causing delay in germination. The aberrant phenotypes were reversed by reintroducing a recombinant oleosin. Based on this direct evidence, we have shown that oleosins are important proteins in seed tissue for controlling oilbody structure and lipid accumulation.

Membrane topology and sequence requirements for oil body targeting of oleosin.

Oleosin protein is targeted to oil bodies via the endoplasmic reticulum (ER) and consists of a lipid-submerged hydrophobic (H) domain that is flanked by cytosolic hydrophilic domains. We investigated the relationship between oleosin ER topology and its subsequent ability to target to oil bodies. Oleosin variants were created to yield differing ER membrane topologies and tagged with a reporter enzyme. Localisation was assessed by fractionation after transient expression in embryonic cells. Membrane-straddled topologies with N-terminal sequence in the ER lumen and C-terminal sequence in the cytosol were unable to target to oil bodies efficiently. Similarly, a translocated topology with only ER membrane and lumenal sequence was unable to target to oil bodies efficiently. Both topology variants accumulated proportionately higher in ER microsomal fractions, demonstrating a block in transferring from ER to oil bodies. The residual oil body accumulation for the inverted topology was shown to be because of partial adoption of native ER membrane topology, using a reporter variant, which becomes inactivated by ER-mediated glycosylation. In addition, the importance of H domain sequence for oil body targeting was assessed using variants that maintain native ER topology. The central proline knot motif (PKM) has previously been shown to be critical for oil body targeting, but here the arms of the H domain flanking this motif were shown to be interchangeable with only a moderate reduction in oil body targeting. We conclude that oil body targeting of oleosin depends on a specific ER membrane topology but does not require a specific sequence in the H domain flanking arms.

Characterization of cDNAs encoding diacylglycerol acyltransferase from cultures of Brassica napus and sucrose-mediated induction of enzyme biosynthesis.

cDNAs encoding acyl-CoA:diacylglycerol acyltransferase (DGAT, EC 2.3.1.20), designated BnDGAT1 and BnDGAT2, were obtained from a microspore-derived cell suspension culture of oilseed rape (Brassica napus L. cv Jet Neuf). BnDGAT2 shares a very high level of identity with BnDGAT1, but is a smaller protein lacking the relatively hydrophilic N-terminal segment found in BnDGAT1. Both transcripts were produced in the cell suspension cultures and the cDNAs were functionally expressed in transformed yeast (Pichia pastoris) cells. Sucrose-mediated changes in triacylglycerol (TAG) metabolism and expression of BnDGAT1 were examined in the cell suspension cultures following transfer of cells from media containing 6% (w/v) sucrose to media containing 14% sucrose. TAG content and DGAT activity of the cells increased transiently within the first 12 h after transfer (HAT). The rapid decline in TAG content observed at 12 HAT was inversely related to an increase in TAG lipase (EC 3.1.1.3) activity. The transient increases in TAG content and DGAT activity correlated with the elevated amounts of BnDGAT1 polypeptide. Transcript levels were also induced, but levels of mRNA encoding BnDGAT1 were not tightly correlated with DGAT activity and amount of polypeptide suggesting some control of expression at the post-transcriptional level. In general, the rapid changes in TAG content were closely associated with the changes in the activity of TAG-metabolizing enzymes and expression of BnDGAT1.

Membrane protein topology of oleosin is constrained by its long hydrophobic domain.

Oleosin proteins from Arabidopsis assume a unique endoplasmic reticulum (ER) topology with a membrane-integrated hydrophobic (H) domain of 72 residues, flanked by two cytosolic hydrophilic domains. We have investigated the targeting and topological determinants present within the oleosin polypeptide sequence using ER-derived canine pancreatic microsomes. Our data indicate that oleosins are integrated into membranes by a cotranslational, translocon-mediated pathway. This is supported by the identification of two independent functional signal sequences in the H domain, and by demonstrating the involvement of the SRP receptor in membrane targeting. Oleosin topology was manipulated by the addition of an N-terminal cleavable signal sequence, resulting in translocation of the N terminus to the microsomal lumen. Surprisingly, the C terminus failed to translocate. Inhibition of C-terminal translocation was not dependent on either the sequence of hydrophobic segments in the H domain, the central proline knot motif or charges flanking the H domain. Therefore, the topological constraint results from the length and/or the hydrophobicity of the H domain, implying a general case that long hydrophobic spans are unable to translocate their C terminus to the ER lumen.

Root induction in Pinus ayacahuite by co-culture with Agrobacterium tumefaciens strains.

Transformation of in-vitro-derived shoots of Pinus ayacahuite Ehrenb. was achieved by co-culture with an oncogenic strain (A281 x 200) of Agrobacterium tumefaciens. During co-culture rooting also occurred; however, this rooting was not induced by genetic transformation of host cells, because a "disarmed" strain of A. tumefaciens (EHA101) also induced rooting. Furthermore, direct contact between shoots and bacterial cells was not required. Rooting occurred in agar-solidified medium and in a soilless substrate (9:1 vermiculite:peat mix). We conclude that A. tumefaciens strains induced rooting in P. ayacahuite through a change in the rhizosphere, probably by producing some root-inducing compound(s), and not through transformation of host cells.