ABSTRACT
Purple glutinous rice bran (Kum Doi Saket rice (KUM)) contains high content of edible polysaccharides and anthocyanins and has an excellent antioxidant activity. This research aimed to optimize the extraction of crude polysaccharides from defatted purple glutinous rice bran using an ultrasonic-assisted extraction (UAE) and compared with a hot water extraction (HWE). Results showed that optimal extraction condition was as follows: a defatted rice bran to water ratio of 1:20 w/v, extraction temperature and time of 70 °C for 20 min. Under the optimal extraction condition, the yield of polysaccharide of UAE (4%) was significantly higher than that obtained from the HWE (0.8%). Additionally, antioxidant activities of extracted polysaccharide including IC50 value DPPH, IC50 value ABTS, and FRAP value were 1.09 mg/mL, 2.80 mg/mL and 197 µM Fe2+/g, respectively. It is suggested that the UAE process is promising method to decrease the processing time and to enhance extracted polysaccharide yields by 4 times.
Subject(s)
Antioxidants/chemistry , Oryza , Plant Extracts/chemistry , Polysaccharides/chemistry , UltrasonicsABSTRACT
Waste flour from the noodle industry was used to produce films, which were plasticized with 40% w/w glycerol:sorbitol at 2:1, 3:1, and 4:1 w/w and formulated with 200 ppm potassium sorbate. Henderson's equation was found to be the best estimator for moisture sorption isotherm of the films stored at 5, 25, and 45°C, and then, equilibrated at 0.11, 0.23, 0.32, 0.43, 0.58, 0.64, 0.76, 0.84, and 0.93 water activity. Developed flour films (plasticized with 2:1 w/w glycerol:sorbitol/formulated with 20% w/w potassium sorbate), with the best mechanical properties (tensile strength of 1.05 MPa; elongation at break of 73.01%), were used to cover fresh strawberries on a polystyrene foam tray. It was found that higher average phenolic contents, antioxidant activity, and firmness were found in strawberries wrapped in plasticized/formulated films, when compared against both films without potassium sorbate and without film (control). Furthermore, a lower average total microorganism count was found for fresh strawberries wrapped in the plasticized/formulated films, when compared with films without potassium sorbate.
ABSTRACT
The near-critical water gasification of dairy industry waste in the form of Whey, a product composed of mixtures of carbohydrates (mainly lactose) and amino acids such as glycine and glutamic acid, has been studied. The gasification process involved partial oxidation with hydrogen peroxide in the presence of NaOH. The reactions were studied over the temperature range from 300°C to 390°C, corresponding pressures of 9.5-24.5 MPa and reaction times from 0 min to 120 min. Hydrogen production was affected by the presence of NaOH, the concentration of H(2)O(2), temperature, reaction time and feed concentration. Up to 40% of the theoretical hydrogen gas production was achieved at 390°C. Over 80% of the Whey nitrogen content was found as ammonia, mainly in the liquid effluent.
Subject(s)
Alkalies , Dairying , Gases , Industrial Waste , Water Pollutants/chemistry , Hot Temperature , Hydrogen Peroxide/chemistry , Kinetics , Oxidation-Reduction , Sodium Hydroxide/chemistryABSTRACT
The gasification of some selected components of food wastes using H(2)O(2) as the oxidant and in the presence of NaOH has been investigated under subcritical water conditions. Hydrogen production was enhanced when both NaOH and H(2)O(2) were used compared to when either NaOH or H(2)O(2) alone was used or in their absence. Results indicated that the H(2)O(2) acted to partially oxidize the samples while NaOH significantly increased hydrogen gas yields by promoting the water-gas shift reaction with subsequent CO(2) capture. In the presence of NaOH, the main components were Na(2)CO(3), CH(3)COONa and CH(3)COONa.3H(2)O. Char and tar production were suppressed in the presence of NaOH.