Safety and efficacy of chimeric yellow Fever-dengue virus tetravalent vaccine formulations in nonhuman primates.

To construct chimeric YF/DEN viruses (ChimeriVax-DEN), the premembrane (prM) and envelope (E) genes of yellow fever (YF) 17D virus were replaced with those of each wild-type (WT) dengue (DEN) virus representing serotypes 1 to 4. ChimeriVax-DEN1-4 vaccine viruses were prepared by electroporation of Vero cells with RNA transcripts prepared from viral cDNA (F. Guirakhoo, J. Arroyo, K. V. Pugachev, C. Miller, Z.-X. Zhang, R. Weltzin, K. Georgakopoulos, J. Catalan, S. Ocran, K. Soike, M. Ratteree, and T. P. Monath, J. Virol. 75:7290-7304, 2001; F. Guirakhoo, K. Pugachev, J. Arroyo, C. Miller, Z.-X. Zhang, R. Weltzin, K. Georgakopoulos, J. Catalan, S. Ocran, K. Draper, and T. P. Monath, Virology 298:146-159, 2002). Progeny viruses were subjected to three rounds of plaque purifications to produce the Pre-Master Seed viruses at passage 7 (P7). Three further passages were carried out using U.S. current Good Manufacturing Practices (cGMP) to produce the Vaccine Lot (P10) viruses. Preclinical studies demonstrated that the vaccine candidates are replication competent and genetically stable and do not become more neurovirulent upon 20 passages in Vero cells. The safety of a tetravalent vaccine was determined and compared to that of YF-VAX in a formal monkey neurovirulence test. Brain lesions produced by the tetravalent ChimeriVax-DEN vaccine were significantly less severe than those observed with YF-VAX. The immunogenicity and protective efficacy of four different tetravalent formulations were evaluated in cynomolgus monkeys following a single-dose subcutaneous vaccination followed by a virulent virus challenge 6 months later. All monkeys developed low levels of viremia postimmunization, and all the monkeys that had received equal concentrations of either a high-dose (5,5,5,5) or a low-dose (3,3,3,3) formulation seroconverted against all four DEN virus serotypes. Twenty-two (92%) of 24 monkeys were protected as determined by lack of viremia post-challenge. This report is the first to demonstrate the safety of a recombinant DEN virus tetravalent vaccine in a formal neurovirulence test, as well as its protective efficacy in a monkey challenge model.

Viremia and immunogenicity in nonhuman primates of a tetravalent yellow fever-dengue chimeric vaccine: genetic reconstructions, dose adjustment, and antibody responses against wild-type dengue virus isolates.

Chimeric yellow fever (YF)-dengue (DEN) viruses (ChimeriVax-DEN) were reconstructed to correct amino acid substitutions within the envelope genes of original constructs described by Guirakhoo et al. (2001, J. Virol. 75, 7290-7304). Viruses were analyzed and compared to the previous constructs containing mutations in terms of their growth kinetics in Vero cells, neurovirulence in mice, and immunogenicity in monkeys as monovalent or tetravalent formulations. All chimeras grew to high titers [ approximately 7 to 8 log(10), plaque-forming units (PFU)/ml] in Vero cells and were less neurovirulent than YF 17D vaccine in mice. For monkey experiments, the dose of DEN2 chimera was lowered to 3 log(10) PFU in the tetravalent mixture in an effort to reduce its dominant immunogenicity. The magnitude of viremia in ChimeriVax-DEN immunized monkeys was similar to that of YF-VAX, but significantly lower than those induced by wild-type DEN viruses. All monkeys developed high levels of neutralizing antibodies against homologous (chimeras) or heterologous (wild-type DEN viruses isolated from different geographical regions) viruses after a single dose of monovalent or tetravalent vaccine. Administration of a second dose of tetravalent vaccine 2 months later increased titers to both homologous and heterologous viruses. A dose adjustment for dengue 2 chimera resulted in a more balanced response against dengue 1, 2, and 3 viruses, but a somewhat higher response against chimeric dengue 4 virus. This indicates that further formulations for dose adjustments need to be tested in monkeys to identify an optimal formulation for humans.

Construction, safety, and immunogenicity in nonhuman primates of a chimeric yellow fever-dengue virus tetravalent vaccine.

We previously reported construction of a chimeric yellow fever-dengue type 2 virus (YF/DEN2) and determined its safety and protective efficacy in rhesus monkeys (F. Guirakhoo et al., J. Virol. 74:5477-5485, 2000). In this paper, we describe construction of three additional YF/DEN chimeras using premembrane (prM) and envelope (E) genes of wild-type (WT) clinical isolates: DEN1 (strain PUO359, isolated in 1980 in Thailand), DEN3 (strain PaH881/88, isolated in 1988 in Thailand), and DEN4 (strain 1228, isolated in 1978 in Indonesia). These chimeric viruses (YF/DEN1, YF/DEN3, and YF/DEN4) replicated to ~7.5 log(10) PFU/ml in Vero cells, were not neurovirulent in 3- to 4-week-old ICR mice inoculated by the intracerebral route, and were immunogenic in monkeys. All rhesus monkeys inoculated subcutaneously with one dose of these chimeric viruses (as monovalent or tetravalent formulation) developed viremia with magnitudes similar to that of the YF 17D vaccine strain (YF-VAX) but significantly lower than those of their parent WT viruses. Eight of nine monkeys inoculated with monovalent YF/DEN1 -3, or -4 vaccine and six of six monkeys inoculated with tetravalent YF/DEN1-4 vaccine seroconverted after a single dose. When monkeys were boosted with a tetravalent YF/DEN1-4 dose 6 months later, four of nine monkeys in the monovalent YF/DEN groups developed low levels of viremia, whereas no viremia was detected in any animals previously inoculated with either YF/DEN1-4 vaccine or WT DEN virus. An anamnestic response was observed in all monkeys after the second dose. No statistically significant difference in levels of neutralizing antibodies was observed between YF virus-immune and nonimmune monkeys which received the tetravalent YF/DEN1-4 vaccine or between tetravalent YF/DEN1-4-immune and nonimmune monkeys which received the YF-VAX. However, preimmune monkeys developed either no detectable viremia or a level of viremia lower than that in nonimmune controls. This is the first recombinant tetravalent dengue vaccine successfully evaluated in nonhuman primates.

Phenotypic and molecular analyses of yellow fever 17DD vaccine viruses associated with serious adverse events in Brazil.

The yellow fever (YF) 17D virus is one of the most successful vaccines developed to data. Its use has been estimated to be over 400 million doses with an excellent record of safety. In the past 3 years, yellow fever vaccination was intensified in Brazil in response to higher risk of urban outbreaks of the disease. Two fatal adverse events temporally associated with YF vaccination were reported. Both cases had features similar to yellow fever disease, including hepatitis and multiorgan failure. Two different lots of YF 17DD virus vaccine were administered to the affected patients and also to hundreds of thousands of other individuals without any other reported serious adverse events. The lots were prepared from the secondary seed, which has been in continuous use since 1984. Nucleotide sequencing revealed minor variations at some nucleotide positions between the secondary seed lot virus and the virus isolates from patients; these differences were not consistent across the isolates, represented differences in the relative amount of each nucleotide in a heterogeneous position, and did not result in amino acid substitutions. Inoculation of rhesus monkeys with the viruses isolated from the two patients by the intracerebral (ic) or intrahepatic (ih) route caused minimal viremia and no clinical signs of infection or alterations in laboratory markers. Central nervous system histological scores of rhesus monkeys inoculated ic were within the expected range, and there were no histopathological lesions in animals inoculated ih. Altogether, these results demonstrated the genetic stability and attenuated phenotype of the viruses that caused fatal illness in the two patients. Therefore, the fatal adverse events experienced by the vaccinees are related to individual, genetically determined host factors that regulate cellular susceptibility to yellow fever virus. Such increased susceptibility, resulting in clinically overt disease expression, appears to be extremely rare.

Elucidation of conditions allowing conversion of penicillin G and other penicillins to deacetoxycephalosporins by resting cells and extracts of Streptomyces clavuligerus NP1.

Using resting cells and extracts of Streptomyces clavuligerus NP1, we have been able to convert penicillin G (benzylpenicillin) to deacetoxycephalosporin G. Conversion was achieved by increasing by 45x the concentration of FeSO4 (1.8 mM) and doubling the concentration of alpha-ketoglutarate (1.28 mM) as compared with standard conditions used for the normal cell-free conversion of penicillin N to deacetoxycephalosporin C. ATP, MgSO4, KCl, and DTT, important in cell-free expansion of penicillin N, did not play a significant role in the ring expansion of penicillin G by resting cells or cell-free extracts. When these conditions were used with 14 other penicillins, ring expansion was achieved in all cases.