Influence of Glycomacropeptide on Rehydration Characteristics of Micellar Casein Concentrate Powder.

Glycomacropeptide (GMP) shows potential for enhancing the rehydration properties of high-protein dairy powders due to its hydrophilic nature. This study involved formulating micellar casein concentrate (MCC) solutions (8.6% final protein content) with 0, 10, and 20% GMP as a percentage of total protein, and investigated the physicochemical and rehydration properties of the resultant freeze-dried powders (P-MCC-0G, P-MCC-10G, and P-MCC-20G, respectively). The surface charges of caseins in the control MCC and 10 or 20% GMP blended solutions were -25.8, -29.6, and -31.5 mV, respectively. Tablets prepared from P-MCC-10G or P-MCC-20G powders displayed enhanced wettability with contact angle values of 80.6° and 79.5°, respectively, compared with 85.5° for P-MCC-0G. Moreover, blending of GMP with MCC resulted in faster disintegration of powder particles during rehydration (i.e., dispersibility) compared to P-MCC-0G. Faster and more extensive release of caseins from powder particles into solution was evident with the increasing proportion of GMP, with the majority of GMP released within the first 15 min of rehydration. The results of this study will contribute to further development of formulation science for achieving enhanced solubility characteristics of high-protein dairy powder ingredients, such as MCC.

Influence of herd diet on the metabolome of Maasdam cheeses.

The untargeted metabolic profiles of ripened Maasdam cheese samples prepared from milk derived from three herd groups, fed: (1) indoors on total mixed ration (TMR), or outdoors on (2) grass only pasture (GRA) or (3) grass and white clover pasture (CLO) were studied using high resolution nuclear magnetic resonance (1H NMR), high resolution magic angle spinning nuclear magnetic resonance (1H HRMAS NMR) and headspace (HS) gas chromatography mass spectrometry (GC-MS). A total of 31 compounds were identified using 1H NMR and 32 volatile compounds including 7 acids, 5 esters, 4 alcohols, 4 ketones, 4 sulfur compounds, 2 aldehydes, 3 hydrocarbons, 2 terpenes and a lactone were identified using GC-MS in Maasdam cheeses ripened for 97-d. On comparing the 1H NMR metabolic profiles, TMR-derived cheese had higher levels of citrate compared to GRA-derived cheese. The toluene content of cheese was significantly higher in GRA or CLO compared to TMR cheeses and dimethyl sulfide was identified only in CLO-derived cheese samples as detected using HS GC-MS. These compounds are proposed as indicator compounds for Maasdam cheese derived from pasture-fed milk. Clear differences between outdoor or indoor feeding systems in terms of cheese metabolites were detected in the lipid phase, as indicated by principal component analysis (PCA) from 1H HRMAS NMR spectra, although differences based on PCA of all 1H NMR spectra and HS-GC-MS were less clear. Overall, this study presented the metabolite profile and identified specific compounds which may be useful for discriminating between ripened Maasdam cheese and related cheese varieties manufactured from indoor or outdoor herd-feeding systems.

Response surface methodology modeling of protein concentration, coagulum cut size, and set temperature on curd moisture loss kinetics during curd stirring.

The effects of the independent variables protein concentration (4-6%), coagulum cut size (6-18 mm3), and coagulation temperature (28-36°C) on curd moisture loss during in-vat stirring were investigated using response surface methodology. Milk (14 kg) in a cheese vat was rennet coagulated, cut, and stirred as per semihard cheesemaking conditions. During stirring, the moisture content of curd samples was determined every 10 min between 5 and 115 min after cutting. The moisture loss kinetics of curds cut to 6 mm3 followed a logarithmic trend, but the moisture loss of curds from larger cut sizes, 12 or 18 mm3, showed a linear trend. Response surface modeling showed that curd moisture level was positively correlated with cut size and negatively correlated with milk protein level. However, coagulation temperature had a significant negative effect on curd moisture up to 45 min of stirring but not after 55 min (i.e., after cooking). It was shown that curds set at the lower temperature had a slower syneresis rate during the initial stirring compared with curds set at a higher temperature, which could be accelerated by reducing the cut size. This study shows that keeping a fixed cut size at increasing protein concentration decreased the level of curd moisture at a given time during stirring. Therefore, to obtain a uniform curd moisture content at a given stirring time at increasing protein levels, an increased coagulum cut size is required. It was also clear that breakage of the larger curd particles during initial stirring can also significantly influence the curd moisture loss kinetics. Both transmission and scanning electron micrographs of cooked curds (i.e., after 45 min of stirring) showed that the casein micelles were fused at a higher degree in curds coagulated at 36°C compared with 28°C, which confirmed that coagulation temperature causes a marked change in curd microstructure during the earlier stages of stirring. The present study showed the dynamics of curd moisture content during stirring when using protein-concentrated milk at various set temperatures and cut sizes. This provides the basis for achieving a desired curd moisture loss during cheese manufacture using protein-concentrated milk as a means of reducing the effect of seasonal variation in milk for cheesemaking.

Influence of protein concentration and coagulation temperature on rennet-induced gelation characteristics and curd microstructure.

This study characterized the coagulation properties and defined the cutting window (CW; time between storage modulus values of 35 and 70 Pa) using rheometry for milk standardized to 4, 5, or 6% protein and set at 28, 32, or 36°C. Milks were standardized to a protein-to-fat ratio of approximately 1 by blending ultrafiltration retentate, skim milk, and whole milk. The internal curd microstructure for selected curd samples was analyzed with transmission electron microscopy and scanning electron microscopy. Lowering the coagulation temperature caused longer rennet coagulation time and time to reach storage modulus of 35 Pa, translating into a wider CW. It also led to a lower maximum curd-firming rate (MCFR) with lower firmness at 40 min at a given protein level. Increasing protein levels resulted in the opposite effect, although without an effect on rennet coagulation time at a given temperature. On coagulation at 28°C, milk with 5% protein resulted in a similar MCFR (∼4 Pa/min) and CW (∼8.25 min) compared with milk with 4% protein at 32°C, which reflects more standard conditions, whereas increasing milk to 6% protein resulted in more than doubling of the curd-firming rate (MCFR = 9.20 Pa/min) and a shorter CW (4.60 min). Gels set at 28°C had lower levels of rearrangement of protein network after 40 min compared with those set at 36°C. Protein levels, on the other hand, had no influence on the levels of protein network rearrangement, as indicated by loss tangent values. The internal structure of curd particles, as investigated by both scanning electron microscopy and transmission electron microscopy, appeared to have less cross-linking and smaller casein aggregates when coagulated at 28°C compared with 36°C, whereas varying protein levels did not show a marked effect on aggregate formation. Overall, this study showed a marked interactive effect between coagulation temperature and protein standardization of milk on coagulation properties, which subsequently requires adjustment of the CW during cheesemaking. Lowering of the coagulation temperature greatly altered the curd microstructure, with a tendency for less syneresis during cutting. Further research is required to quantify the changes in syneresis and in fat and protein losses to whey due to changes in the microstructure of curd particles arising from the different coagulation conditions applied to the protein-fortified milk.