Personal exposure to dust and endotoxin in Robusta and Arabica coffee processing factories in Tanzania.

INTRODUCTION: Endotoxin exposure associated with organic dust exposure has been studied in several industries. Coffee cherries that are dried directly after harvest may differ in dust and endotoxin emissions to those that are peeled and washed before drying. The aim of this study was to measure personal total dust and endotoxin levels and to evaluate their determinants of exposure in coffee processing factories. METHODS: Using Sidekick Casella pumps at a flow rate of 2l/min, total dust levels were measured in the workers' breathing zone throughout the shift. Endotoxin was analyzed using the kinetic chromogenic Limulus amebocyte lysate assay. Separate linear mixed-effects models were used to evaluate exposure determinants for dust and endotoxin. RESULTS: Total dust and endotoxin exposure were significantly higher in Robusta than in Arabica coffee factories (geometric mean 3.41 mg/m(3) and 10 800 EU/m(3) versus 2.10 mg/m(3) and 1400 EU/m(3), respectively). Dry pre-processed coffee and differences in work tasks explained 30% of the total variance for total dust and 71% of the variance for endotoxin exposure. High exposure in Robusta processing is associated with the dry pre-processing method used after harvest. CONCLUSIONS: Dust and endotoxin exposure is high, in particular when processing dry pre-processed coffee. Minimization of dust emissions and use of efficient dust exhaust systems are important to prevent the development of respiratory system impairment in workers.

Microbiological components in mainstream and sidestream cigarette smoke.

BACKGROUND: Research has shown that tobacco smoke contains substances of microbiological origin such as ergosterol (a fungal membrane lipid) and lipopolysaccharide (LPS) (in the outer membrane of Gram-negative bacteria). The aim of the present study was to compare the amounts of ergosterol and LPS in the tobacco and mainstream (MS) and sidestream (SS) smoke of some popular US cigarettes. METHODS: We measured LPS 3-hydroxy fatty acids and fungal biomass biomarker ergosterol in the tobacco and smoke from cigarettes of 11 popular brands purchased in the US. University of Kentucky reference cigarettes were also included for comparison. RESULTS: The cigarette tobacco of the different brands contained 6.88-16.17 (mean 10.64) pmol LPS and 8.27-21.00 (mean 14.05) ng ergosterol/mg. There was a direct correlation between the amounts of ergosterol and LPS in cigarette tobacco and in MS smoke collected using continuous suction; the MS smoke contained 3.65-8.23% (ergosterol) and 10.02-20.13% (LPS) of the amounts in the tobacco. Corresponding percentages were 0.30-0.82% (ergosterol) and 0.42-1.10% (LPS) for SS smoke collected without any ongoing suction, and 2.18% and 2.56% for MS smoke collected from eight two-second puffs. CONCLUSIONS: Tobacco smoke is a bioaerosol likely to contain a wide range of potentially harmful bacterial and fungal components.

Respiratory inflammation among workers exposed to airborne dust with endotoxins in a coffee curing factory.

OBJECTIVE: To study dust exposure and inflammatory reactions in the respiratory tract among coffee curing workers in Tanzania. METHODS: A cross-sectional study was conducted in a Tanzanian coffee curing factory. Coffee workers (n = 15) were compared with unexposed controls (n = 18); all workers were nonsmokers. Exhaled nitric oxide was examined using an electrochemistry-based NIOX MINO device. Personal air samples were analyzed for total dust and endotoxins, using gravimetric analysis and the chromogenic Limulus amebocyte lysate endpoint assay, respectively. RESULTS: Total dust levels ranged from 0.2 to 27.9 mg/m, and endotoxin levels ranged from 42 to 75,083 endotoxin units/m. Concentrations of exhaled nitric oxide, analyzed by linear regression and adjusted for age (ß = 0.57; 95% confidence interval, 0.08 to 1.06; P = 0.02), was higher among coffee workers than among the control group. CONCLUSION: The results indicate a relationship between the coffee dust and signs of respiratory inflammation.

Cigarette smoke extracts promote vascular smooth muscle cell proliferation and enhances contractile responses in the vasculature and airway.

Cigarette smoke exposure is a strong risk factor for cardiovascular and respiratory diseases. However, the knowledge about how cigarette smoke induces damage to vasculature and airway is limited. The present study was designed to examine the effects of cigarette smoke particles extracted by heptane (heptane-soluble smoke particles, HSP), by water (water-soluble smoke particles, WSP) and by DMSO (DMSO-soluble smoke particles, DSP), which represent lipophilic, hydrophilic and ambiphoteric constituents from the cigarette smoke, respectively. Human aortic smooth muscle cell (HASMC) proliferation was assessed in cell culture. Rat resistance artery and airway contractile responses to serotonin, U46619, phenylephrine, noradrenaline, acetylcholine, des-Arg9-bradykinin, bradykinin, sarafotoxin 6c and endothelin-1 were monitored by a sensitive myograph system. Immunocytochemistry and cell-based phosphoELISA assay were used to demonstrate activation of extracellular signal-regulated kinases 1/2 (ERK1/2). For the first time, our results demonstrate that although all the three extracts promote HASMC proliferation, the HSP and DSP effects occur earlier. HSP and DSP, but not WSP, increase the contractile responses to sarafotoxin 6c, U46619 or bradykinin in rat mesenteric artery and/or in bronchi. ERK1/2 is activated by HSP and DSP in HASMCs and inhibition of ERK1/2 abrogated the smoke extracts-induced HASMC proliferation, while blockage of nicotinic receptors had no effects, suggesting that the toxic effects of the smoke extracts occur via activation of intracellular ERK1/2 signalling, but not nicotinic receptors.

Molds and mycotoxins in indoor environments--a survey in water-damaged buildings.

Mycotoxins are toxic, secondary metabolites frequently produced by molds in water-damaged indoor environments. We studied the prevalence of selected, potent mycotoxins and levels of fungal biomass in samples collected from water-damaged indoor environments in Sweden during a 1-year period. One hundred samples of building materials, 18 samples of settled dust, and 37 samples of cultured dust were analyzed for: (a) mycoflora by microscopy and culture; (b) fungal chemical marker ergosterol and hydrolysis products of macrocyclic trichothecenes and trichodermin (verrucarol and trichodermol) by gas chromatography-tandem mass spectrometry; and (c) sterigmatocystin, gliotoxin, aflatoxin B(1), and satratoxin G and H by high performance liquid chromatography-tandem mass spectrometry. Sixty-six percent of the analyzed building materials samples, 11% of the settled dust samples, and 51% of the cultured dust samples were positive for at least one of the studied mycotoxins. In addition, except in the case of gliotoxin, mycotoxin-positive building material samples contained 2-6 times more ergosterol than mycotoxin-negative samples. We show that (a) molds growing on a range of different materials indoors in water-damaged buildings generally produce mycotoxins, and (b) mycotoxin-containing particles in mold-contaminated environments may settle on surfaces above floor level. The mass spectrometry methods used in this study are valuable tools in further research to survey mycotoxin exposure and investigate potential links with health effects.

Identification of bacterial and fungal components in tobacco and tobacco smoke.

The microbiological composition of tobacco products was studied using culture and chemical analysis (of tobacco leaves) or chemical analysis only (tobacco and tobacco smoke). The chemical analyses utilized gas chromatography-tandem mass spectrometry for determining 3-hydroxy fatty acids, muramic acid, and ergosterol as markers of respectively lipopolysaccharide (LPS), peptidoglycan, and fungal biomass. Mesophilic bacteria dominated in both fresh and cured tobacco leaves; a range of additional bacteria and fungi were also found albeit in minor amounts. The peptidoglycan and LPS concentrations were approximately the same in tobacco leaves as in cigarette tobacco. The concentrations of the measured microbial components were much lower in some cigarettes locally produced in China, Korea, and Vietnam than in cigarettes of international brands purchased in the same countries, and the concentrations in the smoke were in general agreement with the concentrations in cigarette tobacco. No differences in microbial load in tobacco of "light" and "full flavor" cigarettes were seen. Storing cigarettes at high humidity resulted in elevated levels of fungi in the cigarette tobacco leading to increased ergosterol concentrations in the smoke. The fact that tobacco smoke is a bioaerosol may help to explain the high prevalence of respiratory disorders among smokers and non-smokers exposed to second hand smoke since the same symptoms are also commonly associated with exposure to bioaerosols.

Elevated concentrations of endotoxin in indoor air due to cigarette smoking.

Exposure to environmental tobacco smoke (ETS) is an important worldwide public health issue. The present study demonstrates that cigarette smoke can be a major source of endotoxin (lipopolysaccharide, LPS) in indoor environments. Gas-chromatography/mass-spectrometry was used to determine 3-hydroxy fatty acids as markers of endotoxin in air-borne house dust in homes of smokers and non-smokers. Air concentrations of endotoxin were 4-63 times higher in rooms of smoking students than in identical rooms of non-smoking students. The fact that cigarette smoke contains large amounts of endotoxin may partly explain the high prevalence of respiratory disorders among smokers and may also draw attention to a hitherto neglected risk factor of ETS.

Metalworking fluid bioaerosols at selected workplaces in a steelworks.

BACKGROUND: Exposure to metalworking fluid (MWF) aerosols has been shown to be associated with a variety of respiratory and skin diseases of workers. METHODS: Measurements of particulate aerosols, bacterial bioaerosol, and endotoxins and 3-hydroxy fatty acids (3-OH FAs) content in water-based and straight oil MWFs were done during an 8 hr work shift in the grindery and oil basement sections of a steelworks located in Upper Silesia, Poland. RESULTS: Particulate aerosol concentrations were below NIOSH recommended occupational exposure level. Differences in concentration and taxonomical composition of airborne bacteria between grindery and oil basement were found, due to the more aggressive creation of oil mist during machining operations and different MWF characteristics, which favor growth of different bacterial strains. CONCLUSIONS: The GC-MS analysis of 3-OH FAs as a marker of endotoxin contamination of the MWF and of the air seems to be a promising tool for evaluation of occupational exposure to bacterial bioaerosols.

Heterogeneity in microbial exposure in schools in Sweden, Poland and Jordan revealed by analysis of chemical markers.

We used gas chromatography--tandem mass spectrometry to analyze microbial components in 85 samples of airborne dust from schools in Jordan, Sweden, and Poland. To collect the samples, we allowed dust to settle on plexiglass plates hanging in the breathing zone in school buildings during both summer and winter. In each of the three countries, we conducted such sampling in two schools: one in an urban environment and the other in rural surroundings. The microbial marker profiles differed significantly between the schools and seasons. For example, samples from Jordan contained remarkably low levels of ergosterol (marker of fungal biomass) and high levels of 3-hydroxy acids (markers of lipopolysaccharide) of 10, 12, and 14 carbon chain lengths relative to such acids of 16 and 18 carbons in comparison with samples from Sweden and Poland. This dissimilarity in 3-hydroxy fatty acid distribution indicates significant differences in the populations of Gram-negative bacteria. We also noted that muramic acid (marker of bacterial biomass) exhibited the smallest variation between schools and seasons. In summary, our results demonstrate that exposure to microorganisms in indoor air in school buildings may differ markedly between countries, between seasons, and between urban and rural environments.

Use of gas chromatography-mass spectrometry/solid phase microextraction for the identification of MVOCs from moldy building materials.

Gas chromatography-mass spectrometry/solid phase microextraction (GC-MS/SPME) was applied to identify microbial volatile organic compounds (MVOCs) in water-damaged, mold-infested building materials (gypsum board papers (n=2), mineral wool, and masonite) and in cultivated molds (Aspergillus penicillioides, Stachybotrys chartarum, and Chaetomium globosum). Three SPME fibers (65-microm PDMS-DVB, 75-microm Carboxen-PDMS, and 70-microm Carbowax-stableflex) designed for automated injection were used of which the latter showed best performance. A number of previously reported MVOCs were detected both in the building materials and the cultivated molds. In addition, methyl benzoate was identified both in the S. chartarum and A. penicillioides cultures and in the building materials. SPME combined with GC-MS may be a useful method for the determination of MVOCs emitted from mold-infested building materials.

Urine D-arabinitol/L-arabinitol ratio in diagnosing Candida infection in patients with haematological malignancy and HIV infection.

Adult patients with hematologic malignancies along with HIV infected patients were prospectively studied to determine the performance of urine D-arabinitol/L-arabinitol (DA/LA) ratio in diagnosing invasive candidiasis. Ten evaluable febrile neutropenic patients had proven invasive candidiasis and elevated DA/LA ratios were found in 5. Invasive candidiasis with normal DA/LA ratios was most frequently due to Candida krusei infection. This Candida species is a non-producer of arabinitol. Only 4 of 81 febrile neutropenic patients given either antifungal prophylaxis or empiric antifungal treatment had elevated DA/LA ratios. Only 1 of 15 HIV positive patients with either oropharyngeal or esophageal candidiasis had elevated DA/LA ratios. Widespread use of fluconazole prophylaxis in bone marrow transplantation patients at the study hospital has led to an increased prevalence of C. krusei infection. This is the likely reason for the low sensitivity of the test in proven and suspected invasive Candida infections reported here.