Yield, Insect-Derived Ear Injury, and Aflatoxin Among Developmental and Commercial Maize Hybrids Adapted to the North American Subtropics.

The development of maize (Zea mays L.) hybrids that are adapted to subtropical areas of North America should consider yield potential under heat and moisture stress, and reduced susceptibility to insect herbivory and disease. To aid in this process, maize hybrids (43 developmental and seven non-Bt commercial hybrids) were evaluated for severity of ear injury to Helicoverpa zea (Boddie) and Spodoptera frugiperda (J. E. Smith) (Lepidoptera: Noctuidae), susceptibility to Aspergillus flavus (Link) (Deuteromycetes: Moniliales), and yield. In subtropical Corpus Christi and College Station, TX, field experiments conducted over three years revealed significant differences among maize hybrids with the rank of the selected measurements differing across the two locations. When the location by maize hybrid interaction was not significant, variation across the main factors of maize hybrid genetics (in all cases) and location (in some cases) was detected. In 2014, a significant location by maize hybrid interaction in yield but not aflatoxin and ear injury were likely associated with differences in weather between locations. In Corpus Christi in 2015, a location by maize hybrid interaction was detected for ear injury only. Overall, experimental maize hybrids, containing the inbred line Tx777, displayed partial resistance to insect derived ear injury in both locations, and some hybrid testcrosses exhibited low rates of aflatoxin accumulation while maintaining relatively high yields. Tx777 was selected from populations originating in Bolivia and adapted to subtropical climates. The most promising hybrid testcrosses had lower ear injury and aflatoxin accumulation, and good yield under varying heat and moisture stress at the two subtropical maize growing areas in this study.

Association of Insect-Derived Ear Injury With Yield and Aflatoxin of Maize Hybrids Varying in Bt Transgenes.

Environmental factors have been associated with the production of aflatoxin in maize, Zea mays L., and it is inconclusive whether transgenic, Bacillus thuringiensis (Bt), maize has an impact on aflatoxin accumulation. Maize hybrids differing in transgenes were planted in two locations from 2014 to 2017. Yield, aflatoxin, and ear injury caused by corn earworm, Helicoverpa zea (Boddie), and fall armyworm, Spodoptera frugiperda (J. E. Smith) (Lepidoptera: Noctuidae), were measured across three groups of hybrids differing in transgenes including near-isogenic hybrids, and water-stressed conditions. The hybrid groups consisted of non-Bt hybrids with no Bt transgenes, a second group with one or more Cry-Bt transgenes, and the third group with vegetative insecticidal Bt protein and Cry-Bt transgenes (Cry/Vip-Bt). Across the six data sets derived from 11 experiments, the Cry-Bt and Cry/Vip-Bt hybrids had less ear injury and aflatoxin on average than non-Bt hybrids. The effects of ear injury on yield and aflatoxin were more prominent and consistent in Corpus Christi, TX, where hybrids experienced more water-limited conditions than in College Station, TX. The trend of increased aflatoxin among hybrids with increased ear injury was further resolved when looking at Cry-Bt and Cry/Vip-Bt isogenic hybrids in Corpus Christi. The results supported that the maize hybrids with the inclusion of Cry-Bt and Cry/Vip-Bt transgenes warrant further investigation in an integrated approach to insect and aflatoxin management in sub-tropical rain-fed maize production regions. Research outcomes may be improved by focusing on areas prone to water-stress and by using hybrids with similar genetic backgrounds.