Inactivation of enteric viruses in minimally processed berries and herbs.

Several hepatitis A virus (HAV) and human norovirus (HuNoV) outbreaks due to consumption of contaminated berries and vegetables have recently been reported. Model experiments were performed to determine the effectiveness of freeze-drying, freeze-drying combined with heating, and steam blanching for inactivation of enteric viruses that might be present on the surface of berries and herbs. Inactivation of HAV and inactivation of feline calicivirus, a surrogate for HuNoV, were assessed by viral culturing and quantitative reverse transcription PCR (RT-PCR), whereas HuNoV survival was determined only by quantitative RT-PCR. While freeze-drying barely reduced (<1.3 log(10) units) the amount of HAV RNA detected in frozen produce, a greater decline in HAV infectivity was observed. The resistance of HuNoV genogroup I (GI) to freeze-drying was significantly higher than that of HuNoV GII on berries. Addition of a terminal dry heat treatment at 120 degrees C after freeze-drying enhanced virus inactivation by at least 2 log(10) units, except for HuNoV GII. The results suggest that steam blanching at 95 degrees C for 2.5 min effectively inactivated infectious enteric viruses if they were present in herbs. Our results provide data for adjusting food processing technologies if viral contamination of raw materials is suspected.

Effects of sanitation, freezing and frozen storage on enteric viruses in berries and herbs.

Norovirus (NV) and hepatitis A virus (HAV) are foodborne enteric viruses associated with outbreaks of disease following consumption of fresh or frozen produce. Model experiments were performed to determine the effectiveness of certain commercial processes for the removal of enteric viruses that might be present in berries and herbs. The survival and persistence of HAV, NV, rotavirus (RV) and feline calicivirus (FCV), a surrogate for NV, in frozen produce over time were determined. Survival and inactivation of HAV, RV and FCV were assessed by viral culture and quantitative reverse transcription-PCR (RT-PCR), whereas NV persistence was determined by quantitative RT-PCR only. Freezing did not significantly reduce the viability of any of the viruses except the infectivity of FCV in strawberries. Frozen storage for 3 months had limited effects on HAV and RV survival in all tested food products, whereas in frozen raspberries and strawberries FCV infectivity showed the highest decay rate due to acid pH. To simulate postharvesting conditions, fresh berries and herbs were rinsed with tap, warm or chlorinated water or with a chlorine dioxide (ClO(2)) solution. Available chlorine at a concentration of 200 ppm and ClO(2) at 10 ppm reduced measurable enteric viruses in raspberry and parsley samples by less than 2 log(10) units.

Attachment of enteric viruses to bottles.

Storage of water that was deliberately contaminated with enteric viruses in polyethylene terephthalate (PET) bottles led to a rapid decrease of the apparent viral load, thereby hampering the development of samples for a collaborative evaluation of viral detection methods for bottled water. To determine if this decrease was due to spontaneous inactivation or to adhesion, an elution protocol was developed and combined with a rapid and sensitive real-time reverse transcription-PCR-based method to quantify adsorbed norovirus (NV), hepatitis A virus (HAV), and rotavirus (RV) on bottle walls. The NV retention on PET bottle walls after 20 and 62 days reached an average level of 85% and 95% of the recovered inoculum, respectively. HAV and RV also showed adsorption onto PET bottles, reaching 90% and 80%, respectively, after 20 days of storage. NV and RV attachment was demonstrated to be dependent on the presence of autochthonous flora, whereas HAV adsorption was independent of it. Application of the elution and viral detection protocol to 294 commercially available water bottles obtained from 25 different countries did not give any positive result, thereby providing further evidence that the sources used for this product are free from enteric viruses and support for the theory that bottled water is not a vehicle for viral diseases.

Procedure for rapid concentration and detection of enteric viruses from berries and vegetables.

Several hepatitis A virus (HAV) and norovirus (NV) outbreaks due to consumption of berries and vegetables have been reported during recent years. To facilitate the detection of enteric viruses that may be present on different fresh and frozen products, we developed a rapid and sensitive detection method for HAV, NV, and rotavirus (RV). Initial experiments focused on optimizing the composition of the elution buffer, improving the viral concentration method, and evaluating the performance of various extraction kits. Viruses were extracted from the food surface by a direct elution method in a glycine-Tris (pH 9.5) buffer containing 1% beef extract and concentrated by ultrafiltration. Occasionally, PCR inhibitors were present in the processed berry samples, which gave relatively poor detection limits. However, this problem was overcome by adding a pectinase treatment in the protocol, which markedly improved the sensitivity of the method. After optimization, this concentration method was applied in combination with real-time reverse transcription-PCR (RT-PCR) using specific primers in various types of berries and vegetables. The average detection limits were 1 50% tissue culture infective dose (TCID(50)), 54 RT-PCR units, and 0.02 TCID(50) per 15 g of food for HAV, NV, and RV, respectively. Based on our results, it is concluded that this procedure is suitable to detect and quantify enteric viruses within 6 h and can be applied for surveillance of enteric viruses in fresh and frozen products.

Detection and differentiation of human hepatitis A strains by commercial quantitative real-time RT-PCR tests.

Performance characteristics of two commercial quantitative Hepatitis A virus (HAV) RT-PCR assays, the LightCycler Hepatitis A virus quantification kit (Roche Diagnostics) and the RealArt HAV LC RT PCR kit (artus GmbH) for detection and quantification of HAV were evaluated. Both assays rely on reverse transcription and amplification of extracted RNA. Dilutions of two HAV strains, belonging to different subtypes, were prepared to determine the precision, accuracy, linearity and the detection limit. Both assays were found to be suitable for quantification measurement of HAV RNA, but only the Roche kit was able to distinguish the different HAV strains tested. The linear range for the artus assay was 10(4)-10(6)IU/ml and 2 x 10(4) to 2 x 10(8) RNA copies/ml for the Roche assay. The detection limit of Roche kit was 2 TCID(50)/ml or 500 RNA copies/ml and 5 TCID(50)/ml or 50 IU/ml for the artus kit. Despite these small differences it is concluded that both assays are very suitable for detection and quantification of most prevalent HAV subtypes.

Impedimetric determination of activity of disinfectants and detergents on Listeria: preliminary study.

The efficiency of several disinfectants or detergents against three strains of Listeria monocytogenes, one strain of Listeria innocua and two strains of Streptococcus group D was tested in water as well as in the presence of milk, whey and salt by an impedimetric method using a Bactometer M120. Certain synergistic effects between active agents and matrix could be observed. Differences in sensitivities were noticed amongst the tested strains. Products containing iodine, peroxide or quaternary ammonium as active agents were shown to be efficient, even at relatively low concentrations.