A kinetic study of roadside grass pyrolysis and digestate from anaerobic mono-digestion.

The aim of this research is to evaluate the thermogravimetric behaviour of roadside grass and its digestate obtained from mesophilic anaerobic mono-digestion by quantifying its impacts on biomass composition and properties. Thermogravimetric measurements were conducted in a laboratory furnace under nitrogen flowrate of 100 mL/min in the temperature range from 35 to 800 °C at five different heating rates of 2.5, 5, 10, 15 and 20 °C/min. Friedman and Kissinger-Akahira-Sunose differential and integral isoconversional models were applied to determine the distributions of activation energies and modified pre-exponential factors per reacted mass (degree of conversion). The investigation demonstrated that anaerobic digestion of roadside grass can be used to generate biochar-richer material (with significantly greater yield of final residues after pyrolysis) with less energy required for subsequent pyrolysis in comparison with raw roadside grass.

Optimization of coagulation with ferric chloride as a pretreatment for fouling reduction during nanofiltration of rendering plant secondary effluent.

The treatment and reuse of rendering plant wastewater with membrane processes is a poorly investigated area that could result in substantial water savings. Membrane fouling is still the main obstacle when treating secondary effluents (SEs) with high content of effluent organic matter (EfOM). Thus, the optimization of coagulation with ferric(III) chloride (FeCl3) as a pretreatment for nanofiltration was performed to reduce membrane fouling and achieve higher permeate quality. Coagulation was modeled (total carbon, inorganic carbon, dissolved organic carbon (DOC), turbidity, conductivity, and resulting pH) and optimized with response surface methodology (RSM) to remove DOC and turbidity with a pH close to neutral. The effluent after coagulation at optimal conditions (5.58 pH and 26.38 mg L-1 of Fe3+) and sand filtration (SF) was subjected to nanofiltration (NF270, NF, and NF90 membranes). The fouling was compared to evaluate the efficiency of each pretreatment. Coagulation with FeCl3 reduced the flux decline of nanofiltration membranes 4.2 to 19.3 times while SF barely reduced the fouling. Coagulation increased the flux recovery and chemical cleanliness after the membrane washing. In addition to fouling reduction, higher permeate quality was achieved.

High-risk biodegradable waste processing by alkaline hydrolysis.

Biodegradable waste is by definition degraded by other living organisms. Every day, meat industry produces large amounts of a specific type of biodegradable waste called slaughterhouse waste. Traditionally in Europe, this waste is recycled in rendering plants which produce meat and bone meal and fat. However, feeding animals with meat and bone meal has been banned since the outbreaks of bovine spongiform encephalopathy (BSE). In consequence, new slaughterhouse waste processing technologies have been developed, and animal wastes have now been used for energy production. Certain parts of this waste, such as brains and spinal cord, are deemed high-risk substances, because they may be infected with prions. Their treatment is therefore possible only in strictly controlled conditions. One of the methods which seems to bear acceptable health risk is alkaline hydrolysis. This paper presents the results of an alkaline hydrolysis efficiency study. It also proposes reuse of the obtained material as organic fertiliser, as is suggested by the analytical comparison between meat and bone meal and hydrolysate.