Pre-harvest biocontrol of Listeria and Escherichia coli O157 on lettuce and spinach by lactic acid bacteria.

Recent outbreaks linked to contaminated leafy greens underline the need for identifying effective natural approaches to improve produce safety at pre-harvest level. Lactic acid bacteria (LAB) have been evaluated as biocontrol agents in food products. In this study, the efficacy of a cocktail of LAB including Lactococcus lactis, Lactiplantibacillus plantarum, Lactobacillus johnsonii, and Lactobacillus acidophilus as pre-harvest biocontrol agents against Listeria and Escherichia coli O157 on lettuce and spinach was investigated. Bacterial pathogens L. monocytogenes and E. coli O157:H7 and the non-pathogenic surrogates L. innocua and E. coli O157:H12 were used to spray-inoculate cultivars of lettuce and spinach grown in growth chamber and in field, respectively. Inoculated plants were spray-treated with water or a cocktail of LAB. On day 0, 3, and 5 post-inoculation, four samples from each group were collected and bacterial populations were determined by serial dilution and spiral plating on selective agars. LAB treatment exhibited an immediate antimicrobial efficacy against L. monocytogenes and E. coli O157:H7 on "Green Star" lettuce by ~2 and ~ 1 log reductions under growth chamber conditions, respectively (P < 0.05). The effect of LAB against E. coli O157:H7 on "New Red Fire" lettuce remained effective during the 5-day period in growth chamber (P < 0.05). Treatment of LAB delivered an effective bactericidal effect against E. coli O157:H12 immediately after application on the field-grown lettuce plants (P < 0.05). Approximately 1 log L. innocua reduction was observed on "Matador" and "Palco" spinach on day 5 (P < 0.05). Results of this study support that LAB could potentially be applied as biocontrol agents for controlling Listeria and E. coli O157 contamination on leafy greens at the pre-harvest level.

Rapid detection of Salmonella enterica in leafy greens by a novel DNA microarray-based PathogenDx system.

The diverse matrices pose great challenges for rapid detection of low Salmonella level (<10 CFU) in fresh produce. The applicability of microarray-based PathogenDx system for detecting low contamination of Salmonella Newport from leafy greens was evaluated. A pre-PCR preparation protocol including enrichment in universal pre-enrichment broth for 3 h followed by sample concentration using an InnovaPrep bio-concentrator or 6 h enrichment without a concentration step was used for detecting S. Newport from leafy greens with initial inoculum level at ∼6 CFU/25 g. Among 205 samples tested, 98%, 93%, 76%, and 60% of Romaine lettuce, Iceberg lettuce, kale, and spinach samples were tested positive after 3 h of enrichment with sample concentration. After 6 h of enrichment, 100%, 98%, 90%, and 82% of Romaine lettuce, Iceberg lettuce, kale, and spinach samples were positive. The samples were parallelly tested by the FDA bacterial analytical manual (BAM) method and 100% of spiked produce samples were tested positive. The overall analysis time of this methodology was between 8 and 11 h, including all pre-enrichment and concentration steps, in contrast to 4-5 days required for BAM method. The system correctly differentiated all 108 Salmonella strains and 35 non-Salmonella strains used in the study. This novel microarray approach provides a rapid method for detecting Salmonella in leafy greens.

Survivability of Clostridioides difficile spores in fermented pork summer sausage during refrigerated storage.

Background and Aim: Clostridioides difficile is a spore-forming pathogen that causes serious enteric disease in humans. Strains have been isolated from food animals and meat, including pork, which suggest a potential for foodborne transmission. Pork summer sausage is a popular fermented meat product, which is consumed cooked or cooked to a lower internal temperature due to acidification of the product. The effect of acidity and cooking on the viability of C. difficile spores in a fermented meat product has not been determined. Therefore, the aim was to study the survivability of C. difficile spores in fermented pork summer sausage. Materials and Methods: Fermented pork sausages were prepared according to a commercial recipe with or without starter culture and C. difficile spores followed by fermentation at 37°C for ~12 h under 85% relative humidity until pH 5.0 was reached and further processed as cooked (>57°C) or uncooked (≤57°C) and stored at 4°C. C. difficile spores in sausages were enumerated at 1 h following inoculation and on days 0, 1, 7, 14, 21, 30, 60, and 90 of storage. Results: It was observed that C. difficile spore viability in control unfermented treatment was significantly different on day 0 from the fermented, fermented cooked, and control unfermented cooked treatments (p<0.05); however, there was no significant difference among the latter three treatment groups throughout 90 days of storage (p>0.05). On day 90 of storage, the unfermented control sausages yielded ~4.0 log colony-forming unit (CFU)/g of C. difficile spores compared to ~3.5 log CFU/g recovered from fermented samples and the unfermented cooked control samples identifying spore viability in all treatment groups. Conclusion: C. difficile spores were found to survive the acidity and cooking of fermented pork summer sausage and storage at 4°C for 3 months, thereby highlighting the need for effective intervention strategies to reduce the risk of C. difficile contamination in pork products.

Biocontrol of Listeria monocytogenes and Salmonella enterica on Fresh Strawberries with Lactic Acid Bacteria During Refrigerated Storage.

Small fruits such as strawberries have been increasingly implicated in outbreaks of foodborne illnesses. Salmonella enterica and Listeria monocytogenes may contaminate strawberries leading to potential public health concern. The objective of this study was to investigate the efficacy of a combined lactic acid bacteria (LAB) treatment of Lactobacillus plantarum and Pediococcus pentosaceus for controlling S. enterica and L. monocytogenes on fresh strawberries during storage at 4°C and 10°C. Strawberries purchased from a local grocery store were separately dip inoculated with Salmonella Newport, Salmonella Tennessee, Salmonella Thompson, or a three-strain cocktail of L. monocytogenes at ∼9 log colony-forming unit (CFU)/mL and allowed to air-dry for 1 h. Inoculated strawberries were then divided into three groups: (1) Control (pathogen alone), (2) Man, Rogosa, Sharpe (MRS) control (dipping in MRS broth), and (3) LAB treatment (dipping in a LAB cocktail of L. plantarum and P. pentosaceus). After treatment, strawberries were stored at 4°C or 10°C for 7 d in vented clamshell containers. Surviving Listeria, Salmonella, and LAB populations on strawberries were determined on 0, 1, 3, and 7 d post-treatment by plating on selective agars. At both 4°C and 10°C, LAB treatment significantly decreased Listeria populations by up to 2 log CFU/g compared to controls after 3 d of storage (p < 0.05). When strawberries were stored at 4°C, LAB treatment reduced ∼2.5 log, ∼2.7 log, and ∼2.9 log CFU/g in Salmonella Newport, Salmonella Tennessee, and Salmonella Thompson populations, respectively, compared to control on day 7. Similarly, ∼2.5 log CFU/g reductions of Salmonella populations were observed with LAB treatment at 10°C on day 7. LAB populations remained at ∼7.5 log CFU/g levels on strawberries at both temperatures throughout the entire study. Results of this study suggest that a combined LAB treatment can be potentially used as biocontrol agents against Salmonella and L. monocytogenes on strawberries at postharvest level.

Nanoemulsified Carvacrol as a Novel Washing Treatment Reduces Escherichia coli O157:H7 on Spinach and Lettuce.

ABSTRACT: Fresh produce continues to be the main source of foodborne illness outbreaks in the United States, implicating bacterial pathogens such as Escherichia coli O157:H7 (EHEC). The efficacy of nanoemulsified carvacrol (NCR) as a washing treatment in reducing EHEC on fresh produce was investigated. Fresh baby spinach, romaine lettuce, and iceberg lettuce leaves (2.5-cm-diameter cores) were spot inoculated with a five-strain cocktail of nalidixic acid-resistant EHEC at ∼6 log CFU/cm2. After air drying for 1 h, 20 pieces of each inoculated produce leaf were immersed in water-based treatment solutions (200 mL per group), including water alone, 25 or 50 ppm of free chlorine, and 0.25 or 0.75% NCR for 2 min. Inoculated produce leaves without any treatment served as baseline. Produce leaves were stored at 10°C, and surviving EHEC populations were enumerated on days 0, 2, 7, and 14. The viability of EHEC following NCR treatments on the fresh produce was visualized under a fluorescence microscope. NCR treatment at 0.75% immediately reduced EHEC populations on iceberg lettuce by 1.3 log CFU/cm2 as compared with the produce treated with water alone (P < 0.05). Antimicrobial activity of NCR against EHEC was comparable to chlorine treatments on day 0 for all produce (P > 0.05). After 14 days of storage at 10°C, populations of EHEC on 0.75% NCR-treated romaine lettuce were reduced by 2.3 log CFU/cm2 compared with the recovery from 50 ppm of chlorine-treated samples (P < 0.05). Microscopic images revealed that EHEC cells were observed to be clustered on the baseline samples, indicating the development of cell aggregation, compared with the scattered cells seen on NCR-treated leaf surfaces. Treatments with NCR did not significantly affect the color of the fresh produce leaves during 14 days of storage at 10°C. Results of this study support the potential use of NCR as a water-soluble natural antimicrobial wash treatment for controlling EHEC on fresh produce.

Inhibition of Escherichia coli O157:H7 and Salmonella enterica virulence factors by benzyl isothiocyanate.

Escherichia coli O157:H7 and Salmonella enterica are foodborne pathogens with major public health concern in the U.S. These pathogens utilize several virulence factors to initiate infections in humans. The antimicrobial effect of seven glucosinolate hydrolysis compounds against Salmonella and E. coli O157:H7 was investigated by the disc diffusion assay. Among the tested compounds, benzyl isothiocyanate (BIT), which exerted the highest antimicrobial activity, was evaluated for its anti-virulence properties against these pathogens. The effect of BIT on motility of Salmonella and E. coli O157:H7 and Shiga toxin production by E. coli O157:H7 was determined by the motility assay and ELISA procedure, respectively. Confocal and transmission electron microscopy (TEM) procedures were used to determine bacterial damage at the cellular level. Results revealed that sub-inhibitory concentrations (SICs) of BIT significantly inhibited the motility of both bacteria (P < 0.05). Shiga toxin production by E. coli O157:H7 was decreased by ~32% in the presence of BIT at SICs. TEM results showed the disruption of outer membrane, release of cytoplasmic contents, and cell lysis following BIT treatment. Results suggest that BIT could be potentially used to attenuate Salmonella and E. coli O157:H7 infections by reducing the virulence factors including bacterial motility and Shiga toxin production.

Antibiofilm Efficacy of Peptide 1018 against Listeria monocytogenes and Shiga Toxigenic Escherichia coli on Equipment Surfaces.

Listeria monocytogenes and Shiga toxigenic Escherichia coli (STEC) are important foodborne bacterial pathogens that can form biofilms on equipment surfaces at food processing facilities. Pathogens in biofilms are resistant to conventional antimicrobials and require higher antimicrobial concentrations to be inactivated. In this study, the efficacy of a synthetic innate defense regulator peptide 1018 (peptide 1018) for inactivating L. monocytogenes and STEC (O26, O111, O145, O157) biofilms on stainless steel and polycarbonate surfaces was investigated. Stainless steel and polycarbonate coupons (12 mm in diameter) were used in a Centers for Disease Control and Prevention biofilm reactor containing 400 mL of 10% tryptic soy broth (TSB) that had been inoculated with an individual strain of L. monocytogenes or STEC to obtain 6 log CFU/mL populations. The reactor was set with a constant flow rate at 50 mL/h of 10% TSB for 48 h. After 48 h, coupons were treated with peptide 1018 at 0, 10, 20, or 50 µg/mL in phosphate buffer saline (PBS) for 24 h. Surviving bacterial populations were determined by scraping off the coupons and spiral plating on selective media. Significantly higher levels of pathogens in biofilms formed by certain bacterial strains, including L. monocytogenes F6854, E. coli O157:H7 RM4407 and NADC5713, and non-O157 E. coli NADC3629, were recovered on polycarbonate surfaces than on stainless steel. Antibiofilm efficacy of peptide 1018 against pathogens was concentration-dependent and varied with the type of pathogen and material surfaces. Peptide 1018 at 50 µg/mL significantly inactivated all tested bacterial biofilms on both surfaces compared with the PBS control (P < 0.05). L. monocytogenes was the bacterium most sensitive to peptide 1018; on stainless steel surfaces treated with 50 µg/mL peptide 1018, there was a 3.7- to 4.6-log CFU/cm2 reduction in Listeria populations compared with a 1.0- to 3.5-log CFU/cm2 reduction of STEC. Results suggest that peptide 1018 may be used to inactivate L. monocytogenes and STEC biofilms on equipment surfaces.

In vitro efficacy of sodium selenite in reducing toxin production, spore outgrowth and antibiotic resistance in hypervirulent Clostridium difficile.

PURPOSE: This study investigated the efficacy of the essential mineral, selenium (sodium selenite), in reducing the toxin production, spore outgrowth and antibiotic resistance of Clostridium difficile in vitro. METHODOLOGY: Two hypervirulent C. difficile isolates were cultured in brain heart infusion broth with and without a sub-minimum inhibitory concentration (sub-MIC) of sodium selenite, and the supernatant and bacterial pellet were harvested for total toxin quantitation and RT-qPCR analysis of toxin-encoding genes, respectively. Additionally, C. difficile isolates were cultured in brain heart infusion broth containing 0.5 or 1× the minimum inhibitory concentration (MIC) of either ciprofloxacin or vancomycin with or without sub-MICs of sodium selenite. Further, the effect of sodium selenite on C. difficile germination and spore outgrowth was also determined by exposing C. difficile spores to a sub-MIC of sodium selenite in a germination medium and measuring the germination and outgrowth by measuring the optical density at 600 nm. RESULTS: Sodium selenite significantly reduced C. difficile toxin synthesis, cytotoxicity and spore outgrowth. Further, the expression of the toxin production genes, tcdA and tcdB, was downregulated in the presence of sodium selenite, while sodium selenite significantly increased the sensitivity of C. difficile to ciprofloxacin , but not vancomycin, as revealed by decreased bacterial growth in samples containing ciprofloxacin+selenium compared to the antibiotic control. Although the sub-MIC of sodium selenite did not inhibit spore germination, it was capable of completely inhibiting spore outgrowth. CONCLUSION: Our results suggest that sodium selenite could potentially be used to control C. difficile and indicate that future in vivo studies are warranted.

Efficacy of plant-derived antimicrobials for controlling Salmonella Schwarzengrund on dry pet food.

Salmonella enterica is a major human pathogen that is responsible for 23,000 hospitalizations annually in the United States. Contact with contaminated pet food and infected companion animals can transmit salmonellosis to humans. Recent multistate human outbreaks of salmonellosis linked to commercial contaminated dry dog foods underscore the need for controlling the pathogen in pet foods for protecting pet and public health. In this study, the efficacy of five Generally Recognized as Safe (GRAS) status, plant-derived antimicrobials (PDAs), namely trans-cinnamaldehyde (TC), carvacrol (CR), thymol (TY), eugenol (EG), and caprylic acid (CA) applied as a vegetable oil or chitosan based antimicrobial spray on dry pet food for reducing Salmonella Schwarzengrund was investigated. Three hundred gram portions of a commercial dry dog food were inoculated with a two-strain mixture of nalidixic acid (NA) resistant S. Schwarzengrund (~6 log CFU/g), followed by a spray treatment with 0%, 0.5%, 1% or 2% of TC, CR, TY, EG or CA in combination with 5% vegetable oil or 1% chitosan as a carrier. The control and treated dog food samples were stored at 25 °C for 28 days. On days 0, 1, 3, 5, 7, 14, 21, and 28, Salmonella on pet food was enumerated by serial dilution and plating on xylose lysine desoxycholate (XLD) agar. All PDAs at 1% and 2% applied in vegetable oil or chitosan reduced S. Schwarzengrund by at least ~2 log CFU/g on day 3 of storage when compared to control (P < 0.05). No significant reductions in Salmonella were observed on feed sprayed with only vegetable oil or chitosan (P > 0.05). Overall, 2% TC in vegetable oil or chitosan was the most effective treatment, where at least 3 to 3.5 log CFU/g reduction in bacterial populations was observed during storage (P < 0.05). Results suggest that the aforementioned PDAs could potentially be used as an antimicrobial spray to reduce S. Schwarzengrund on dry dog food. However, further studies on the acceptance of PDA-treated dry food by dogs are needed.

Phytochemicals reduce aflatoxin-induced toxicity in chicken embryos.

Aflatoxins (AF) are toxic metabolites produced by molds, Aspergillus flavus and Aspergillus parasiticus, which frequently contaminate poultry feed ingredients. Ingestion of AF-contaminated feed by chickens leads to deleterious effects, including decreased bird performance and reduced egg production. Moreover, AF residues in fertilized eggs result in huge economic losses by decreasing embryo viability and hatchability. This study investigated the efficacy of 2 generally recognized as safe phytochemicals, namely carvacrol (CR) and trans-cinnamaldehyde (TC), in protecting chicken embryos from AF-induced toxicity. Day-old embryonated eggs were injected with 50 ng or 75 ng AF with or without 0.1% CR or TC, followed by incubation in an incubator for 18 d. Relative embryo weight, yolk sac weight, tibia weight, tibia length, and mortality were recorded on d 18 of incubation. The effect of phytochemicals and methanol (diluent) on embryo viability was also determined. Each experiment had ten treatments with 15 eggs/treatment (n = 150 eggs/experiment) and each experiment was replicated 3 times. Both phytochemicals significantly decreased AF-induced toxicity in chicken embryos. At 75 ng of AF/egg, CR and TC increased the survival of chicken embryo by ∼55%. Moreover, CR and TC increased relative embryo weight by ∼3.3% and 17% when compared to eggs injected with 50 ng or 75 ng AF, respectively. The growth of embryos (tibia length and weight) was improved in phytochemical-treated embryos compared to those injected with AF alone (P < 0.05). Phytochemical and methanol treatments did not adversely affect embryo survival, and other measured parameters as compared to the negative control (P > 0.05). Results from this study demonstrate that CR and TC could reduce AF-induced toxicity in chicken embryos; however, additional studies are warranted to delineate the mechanistic basis behind this effect.

Effect of Dietary Minerals on Virulence Attributes of Vibrio cholerae.

Vibrio cholerae is a water-borne pathogen responsible for causing a toxin-mediated profuse diarrhea in humans, leading to severe dehydration and death in unattended patients. With increasing reports of antibiotic resistance in V. cholerae, there is a need for alternate interventional strategies for controlling cholera. A potential new strategy for treating infectious diseases involves targeting bacterial virulence rather than growth, where a pathogen's specific mechanisms critical for causing infection in hosts are inhibited. Since bacterial motility, intestinal colonization and cholera toxin are critical components in V. cholerae pathogenesis, attenuating these virulence factors could potentially control cholera in humans. In this study, the efficacy of sub-inhibitory concentration (SIC, highest concentration not inhibiting bacterial growth) of essential minerals, zinc (Zn), selenium (Se), and manganese (Mn) in reducing V. cholerae motility and adhesion to intestinal epithelial cells (Caco-2), cholera toxin production, and toxin binding to the ganglioside receptor (GM1) was investigated. Additionally, V. cholerae attachment and toxin production in an ex vivo mouse intestine model was determined. Further, the effect of Zn, Se and Mn on V. cholerae virulence genes, ctxAB (toxin production), fliA (motility), tcpA (intestinal colonization), and toxR (master regulon) was determined using real-time quantitative PCR. All three minerals significantly reduced V. cholerae motility, adhesion to Caco-2 cells, and cholera toxin production in vitro, and decreased adhesion and toxin production in mouse intestine ex vivo (P < 0.05). In addition, Zn, Se, and Mn down-regulated the transcription of virulence genes, ctxAB, fliA, and toxR. Results suggest that Zn, Se, and Mn could be potentially used to reduce V. cholerae virulence. However, in vivo studies in an animal model are necessary to validate these results.

Prevalence of Multidrug-Resistant Bacteria on Fresh Vegetables Collected from Farmers' Markets in Connecticut.

This study determined the prevalence of multidrug-resistant (MDR) Acinetobacter baumannii on fresh vegetables collected from farmers' markets in Connecticut. One hundred samples each of fresh carrots, potatoes, and lettuce were sampled and streaked on selective media, namely Leeds Acinetobacter and MDR Acinetobacter agars. All morphologically different colonies from MDR Acinetobacter agar were identified by using Gram staining, biochemical tests, and PCR. In addition, susceptibility of the isolates to 10 antibiotics commonly used in humans, namely imipenem, ceftriaxone, cefepime, minocycline, erythromycin, colistin-sulfate, streptomycin, neomycin, doxycycline, and rifampin was determined by using an antibiotic disk diffusion assay. The results revealed that only two samples of potato and one sample of lettuce yielded A. baumannii. In addition, all carrot samples were found to be negative for the organism. However, several other opportunistic, MDR human pathogens, such as Burkholderia cepacia (1% potatoes, 5% carrots, and none in lettuce), Stenotrophomonas maltophilia (6% potatoes, 2% lettuce, and none in carrots), and Pseudomonas luteola (9% potatoes, 3% carrots, and none in lettuce) were recovered from the vegetables. Antibiotic susceptibility screening of the isolates revealed high resistance rates for the following: ceftriaxone (6 of 6), colistin-sulfate (5 of 6), erythromycin (5 of 6), and streptomycin (4 of 6) in B. cepacia; colistin-sulfate (11 of 11) and imipenem (10 of 11) in P. luteola; colistin-sulfate (8 of 8), ceftriaxone (8 of 8), cefepime (7 of 8), erythromycin (5 of 8), and imipenem (4 of 8) in S. maltophilia; and imipenem (3 of 3), ceftriaxone (3 of 3), erythromycin (3 of 3), and streptomycin (3 of 3) in A. baumannii. The results revealed the presence of MDR bacteria, including human pathogens on fresh produce, thereby highlighting the potential health risk in consumers, especially those with a compromised immune system.

Inactivation of Listeria monocytogenes, Salmonella spp. and Escherichia coli O157:H7 on cantaloupes by octenidine dihydrochloride.

The efficacy of a new generation disinfectant, octenidine dihydrochloride (OH), as wash and coating treatments for reducing Listeria monocytogenes (LM), Salmonella spp. (SAL), and Escherichia coli O157:H7 (EC) on cantaloupe was investigated. Cantaloupe rind plugs inoculated separately with the three bacterial species (∼8 log CFU/cm(2)) were washed for 1, 3, 5 min at 25 °C in water, or chlorine (200 ppm), ethanol (1%), OH (0.01, 0.05, 0.1%) and surviving populations were measured after treatment. Additionally, inoculated cantaloupe rind plugs were coated with 2% chitosan or chitosan containing OH (0.01, 0.05, 0.1%) and sampled for surviving pathogens. Subsequently, the antimicrobial efficacy of OH wash and coating (0.1, 0.2%) on whole cantaloupes was determined. All OH wash reduced LM, SAL, and EC on cantaloupe rinds by > 5 log CFU/cm(2) by 2 min, and reduced populations to undetectable levels (below 2 log CFU/cm(2)) by 5 min (P < 0.05). Similarly, OH coating on cantaloupe rinds reduced the pathogens by 3-5 log /cm(2) (P < 0.05). Washing and coating whole cantaloupes with OH reduced the three pathogens by at least 5 log and 2 log CFU/cm(2), respectively (P < 0.05). Results suggest that OH could be used as antimicrobial wash and coating to reduce LM, SAL, and EC on cantaloupes.

Potentiating the Heat Inactivation of Escherichia coli O157:H7 in Ground Beef Patties by Natural Antimicrobials.

Escherichia coli O157: H7 (EHEC) is a major foodborne pathogen largely transmitted to humans through the consumption of undercooked ground beef. This study investigated the efficacy of two food-grade, plant-derived antimicrobials, namely rutin (RT), and resveratrol (RV) with or without chitosan (CH) in enhancing EHEC inactivation in undercooked hamburger patties. Further, the effect of aforementioned treatments on beef color and lipid oxidation was analyzed. Additionally, the deleterious effects of these antimicrobial treatments on EHEC was determined using scanning electron microscopy (SEM). Ground beef was inoculated with a five-strain mixture of EHEC (7.0 log CFU/g), followed by the addition of RT (0.05%, 0.1% w/w) or RV (0.1, 0.2% w/w) with or without CH (0.01% w/w). The meat was formed into patties (25 g) and stored at 4°C for 5 days. On days 1, 3, and 5, the patties were cooked (65°C, medium rare) and surviving EHEC was enumerated. The effect of these treatments on meat color and lipid oxidation during storage was also determined as per American Meat Science Association guidelines. The study was repeated three times with duplicate samples of each treatment. Both RT and RV enhanced the thermal destruction of EHEC, and reduced the pathogen load by at least 3 log CFU/g compared to control (P < 0.05). The combination of RT or RV with CH was found to be more effective, and reduced EHEC by 5 log CFU/g (P < 0.05). EHEC counts in uncooked patties did not decline during storage for 5 days (P > 0.05). Moreover, patties treated with RV plus CH were more color stable with higher a(∗) values (P < 0.05). SEM results revealed that heat treatment with antimicrobials (CH + RV 0.2%) resulted in complete destruction of EHEC cells and extrusion of intracellular contents. Results suggest that the aforementioned antimicrobials could be used for enhancing the thermal inactivation of EHEC in undercooked patties; however, detailed sensory studies are warranted.

Controlling Aspergillus flavus and Aspergillus parasiticus growth and aflatoxin production in poultry feed using carvacrol and trans-cinnamaldehyde.

Aflatoxins (AF) are toxic metabolites primarily produced by molds, Aspergillus flavus and Aspergillus parasiticus. Contamination of poultry feed with AF is a major concern to the poultry industry due to severe economic losses stemming from poor performance, reduced egg production, and diminished egg hatchability. This study investigated the inhibitory effect of 2 generally regarded as safe (GRAS), natural plant compounds, namely carvacrol (CR) and trans-cinnamaldehyde (TC), on A. flavus and A. parasiticus growth and AF production in potato dextrose broth (PDB) and in poultry feed. In broth culture, PDB supplemented with CR (0%, 0.02%, 0.04% and 0.08%) or TC (0%, 0.005%, 0.01% and 0.02%) was inoculated with A. flavus or A. parasiticus (6 log CFU/mL), and mold counts and AF production were determined on days 0, 1, 3, and 5. Similarly, 200 g portions of poultry feed supplemented with CR or TC (0%, 0.4%, 0.8%, and 1.0%) were inoculated with each mold, and their counts and AF concentrations in the feed were determined at 0, 1, 2, 3, 4, 8, and 12 weeks of storage. Moreover, the effect of CR and TC on the expression of AF synthesis genes in A. flavus and A. parasiticus (aflC, nor1, norA, and ver1) was determined using real-time quantitative PCR (RT-qPCR). All experiments had duplicate samples and were replicated 3 times. Results indicated that CR and TC reduced A. flavus and A. parasiticus growth and AF production in broth culture and chicken feed (P<0.05). All tested concentrations of CR and TC decreased AF production in broth culture and chicken feed by at least 60% when compared to controls (P<0.05). In addition, CR and TC down-regulated the expression of major genes associated with AF synthesis in the molds (P<0.05). Results suggest the potential use of CR and TC as feed additives to control AF contamination in poultry feed.

Reducing Colonization and Eggborne Transmission of Salmonella Enteritidis in Layer Chickens by In-Feed Supplementation of Caprylic Acid.

Salmonella Enteritidis (SE) is a major foodborne pathogen responsible for causing gastrointestinal infections in humans, predominantly due to the consumption of contaminated eggs. In layer hens, SE colonizes the intestine and migrates to various organs, including the oviduct, thereby leading to egg yolk and shell contamination. This study investigated the efficacy of caprylic acid (CA), a medium-chain fatty acid, in reducing SE colonization and egg contamination in layers. Caprylic acid was supplemented in the feed at 0%, 0.7%, or 1% (vol/wt) from day 1 of the experiment. Birds were challenged with 10(10) log colony-forming units (CFU)/mL of SE by crop gavage on day 10, and re-inoculated (10(10) log CFU/mL) on day 35. After 7 days post first inoculation, eggs were collected daily and tested for SE on the shell and in the yolk separately. The birds were sacrificed on day 66 to determine SE colonization in the ceca, liver, and oviduct. The consumer acceptability of eggs was also determined by triangle test. The experiment was replicated twice. In-feed supplementation of CA (0.7% and 1%) to birds consistently decreased SE on eggshell and in the yolk (p<0.05). Supplementation of CA at 1.0% decreased SE population to ≈14% on the shell and ≈10% in yolk, when compared to control birds, which yielded ≈60% positive samples on shell and ≈43% in yolk. Additionally, SE populations in the cecum and liver were reduced in treated birds compared to control (p<0.05). No significant difference in egg production, body weight, or sensory properties of eggs was observed (p>0.05). The results suggest that CA could potentially be used as a feed additive to reduce eggborne transmission of SE.

Efficacy of fumigation with Trans-cinnamaldehyde and eugenol in reducing Salmonella enterica serovar Enteritidis on embryonated egg shells.

This study investigated the efficacy of two GRAS (generally regarded as safe)-status, plant-derived antimicrobials (PDAs), namely trans-cinnamaldehyde (TC) and eugenol (EUG) applied as a fumigation treatment in reducing SE on embryonated egg shells. Egg shells of day-old embryonated eggs were spot inoculated with a 4-strain mixture of SE (∼6.5 log CFU/egg) and subjected to fumigation with the aforementioned PDAs (0 or 1% concentration) for 20 minutes in a hatching incubator. SE on the shell and embryo was enumerated on days 1, 3, 6, 9, 13, 16 and 18. On day 13, the eggs were re-inoculated, followed by fumigation treatment for 20 minutes. Since the two PDAs were dissolved in ethanol (final concentration 0.04%), eggs fumigated with ethanol were included as a control.Approximately 6 log CFU/egg of SE were recovered from the shell of untreated, inoculated eggs on days 1 and 13. The fumigation of embryonated egg shells with the two PDAs was more effective in reducing SE on the shell and embryo compared to controls (P < 0.05). On day 18, the eggs fumigated with ethanol were SE positive on the shell, whereas no pathogen was detected on eggs subjected to fumigation with TC and EUG. Similarly, although the embryos of eggs subjected to fumigation with ethanol yielded 1 log CFU/egg of SE on day 18, the embryos of TC and EUG treated eggs were devoid of the pathogen. This study demonstrated that TC and EUG dissolved in 0.04% ethanol could potentially be used as a fumigation treatment for reducing SE on embryonated egg shell, however, quality traits of eggs, including the hatchability need to be ascertained.

In-feed supplementation of trans-cinnamaldehyde reduces layer-chicken egg-borne transmission of Salmonella enterica serovar enteritidis.

Salmonella enterica serovar Enteritidis is a major foodborne pathogen in the United States, causing gastroenteritis in humans, primarily through consumption of contaminated eggs. Chickens are the reservoir host of S. Enteritidis. In layer hens, S. Enteritidis colonizes the intestine and migrates to various organs, including the oviduct, leading to egg contamination. This study investigated the efficacy of in-feed supplementation with trans-cinnamaldehyde (TC), a generally recognized as safe (GRAS) plant compound obtained from cinnamon, in reducing S. Enteritidis cecal colonization and systemic spread in layers. Additionally, the effect of TC on S. Enteritidis virulence factors critical for macrophage survival and oviduct colonization was investigated in vitro. The consumer acceptability of eggs was also determined by a triangle test. Supplementation of TC in feed for 66 days at 1 or 1.5% (vol/wt) for 40- or 25-week-old layer chickens decreased the amounts of S. Enteritidis on eggshell and in yolk (P<0.001). Additionally, S. Enteritidis persistence in the cecum, liver, and oviduct in TC-supplemented birds was decreased compared to that in controls (P<0.001). No significant differences in feed intake, body weight, or egg production in birds or in consumer acceptability of eggs were observed (P>0.05). In vitro cell culture assays revealed that TC reduced S. Enteritidis adhesion to and invasion of primary chicken oviduct epithelial cells and reduced S. Enteritidis survival in chicken macrophages (P<0.001). Follow-up gene expression analysis using real-time quantitative PCR (qPCR) showed that TC downregulated the expression of S. Enteritidis virulence genes critical for chicken oviduct colonization (P<0.001). The results suggest that TC may potentially be used as a feed additive to reduce egg-borne transmission of S. Enteritidis.

Inhibiting Microbial Toxins Using Plant-Derived Compounds and Plant Extracts.

Many pathogenic bacteria and fungi produce potentially lethal toxins that cause cytotoxicity or impaired cellular function either at the site of colonization or other locations in the body through receptor-mediated interactions. Various factors, including biotic and abiotic environments, competing microbes, and chemical cues affect toxin expression in these pathogens. Recent work suggests that several natural compounds can modulate toxin production in pathogenic microbes. However, studies explaining the mechanistic basis for their effect are scanty. This review discusses the potential of various plant-derived compounds for reducing toxin production in foodborne and other microbes. In addition, studies highlighting their anti-toxigenic mechanism(s) are discussed.

Effect of chlorine exposure on the survival and antibiotic gene expression of multidrug resistant Acinetobacter baumannii in water.

Acinetobacter baumannii is a multidrug resistant pathogen capable of causing a wide spectrum of clinical conditions in humans. Acinetobacter spp. is ubiquitously found in different water sources. Chlorine being the most commonly used disinfectant in water, the study investigated the effect of chlorine on the survival of A. baumannii in water and transcription of genes conferring antibiotic resistance. Eight clinical isolates of A. baumannii, including a fatal meningitis isolate (ATCC 17978) (~108 CFU/mL) were separately exposed to free chlorine concentrations (0.2, 1, 2, 3 and 4 ppm) with a contact time of 30, 60, 90 and 120 second. The surviving pathogen counts at each specified contact time were determined using broth dilution assay. In addition, real-time quantitative PCR (RT-qPCR) analysis of the antibiotic resistance genes (efflux pump genes and those encoding resistance to specific antibiotics) of three selected A. baumannii strains following exposure to chlorine was performed. Results revealed that all eight A. baumannii isolates survived the tested chlorine levels during all exposure times (p > 0.05). Additionally, there was an up-regulation of all or some of the antibiotic resistance genes in A. baumannii, indicating a chlorine-associated induction of antibiotic resistance in the pathogen.