Dietary fat lowers ileal endogenous amino acid losses in broiler chickens.

1. An experiment was conducted to determine the effect of the source of fat (soybean oil or tallow) on the ileal endogenous amino acid (EAA) losses in broilers.2. Three nitrogen (N)-free diets; a control diet with no added fat and test diets with 60 g/kg of either soybean oil or tallow were formulated. Titanium dioxide (5 g/kg) was added to all diets as an indigestible marker. Each diet was assigned to six replicate cages (eight birds per cage) from d 18 to 21 post-hatch. On d 21, the digesta were collected from the lower half of the ileum.3. The endogenous losses of nitrogen and amino acids (AA) were lower (p = 0.08; p = 0.001) in broilers fed diets with soybean oil or tallow, respectively, compared to those fed the diet with no fat. Source of fat had no influence (p > 0.05) on EAA losses.4. The most abundant AA in the ileal endogenous protein was glutamic acid, followed by aspartic acid, threonine, leucine, serine, valine and proline. In general, the concentrations of AA in the endogenous protein were lower (p < 0.05) with added fat. The exceptions were methionine, cysteine, proline and serine, which were unaffected. The effect of fat source on the AA contents of endogenous protein were inconsistent and differed depending on the AA.5. The inclusion of fats decreased EAA losses which implied they have beneficial effects beyond direct energy contribution. It can be proposed that the reduction of EAA flow may be an additional mechanism contributing to the extra-caloric effect of dietary fats.

Metabolizable energy and standardized ileal amino acid digestibility of full-fat soybeans for broilers are influenced by wet-heating, expansion temperature, and autoclaving time.

The influence of wet-heating (WH) and expansion temperature (ET), and autoclaving time (AT) on the nitrogen-corrected apparent metabolizable energy (AMEn) and standardized ileal digestibility (SID) of AA in full-fat soybeans (FFSB) for broilers was examined in 2 experiments. The AMEn and SID AA of FFSB were determined by the difference and direct methods, respectively. In Experiment 1, raw FFSB (K0) were either treated by WH at 80°C for 1 min and expanded at 115°C (K1-115) or 125°C (K1-125), WH at 100°C for 6 min and expanded at 115°C (K2-115) or 125°C (K2-125), or WH at 100°C for 16 min and expanded at 115°C (K3-115) or 125°C (K3-125). Wet-heating and ET significantly (P < 0.001) increased the AMEn in FFSB. Among heat-treated FFSB, K1-115 and K1-125 resulted in the lowest and highest AMEn values, respectively, with all samples wet-heated at 100°C being intermediate. The K3-125 had AMEn values similar (P > 0.05) to K1-125. Among heat-treated FFSB, the highest average SID AA was recorded for K3-125. In Experiment 2, K3-125 from experiment 1 was divided into 9 batches and autoclaved at 110°C for 15 (Z1), 30 (Z2), 45 (Z3), 60 (Z4), 120 (Z5), 180 (Z6), 240 (Z7), 300 (Z8), and 360 (Z9) min. A quadratic (P < 0.01) pattern was observed for the effects of AT on AMEn. The AMEn was unaffected until 300 min AT and then declined at 360 min. The AT quadratically (P < 0.001) affected the average SID AA where the SID increased from K3-125 to Z1, plateaued to Z5, and then declined to Z9. In conclusion, the results demonstrated that WH at 100°C for 16 min followed by expansion at 125°C as the most optimal wet-heating and expansion processing, associated with the highest SID AA. Autoclaving at 110°C for 30 min enhanced energy utilization and AA digestibility in FFSB, suggesting that further advantages may be achieved by short-time autoclaving of previously wet-heated and expanded FFSB samples.

Influence of age and dietary cellulose levels on ileal endogenous energy losses in broiler chickens.

Two experiments were conducted to investigate the influence of age and dietary cellulose levels on the ileal endogenous energy losses (IEEL) in broiler chickens. In experiment 1, a glucose-based purified diet was used to determine the IEEL. Titanium dioxide (5.0 g/kg) was added to the diet as an indigestible marker. Six groups of broiler chickens aged 1 to 7, 8 to 14, 15 to 21, 22 to 28, 29 to 35 or 36 to 42 d posthatch, were utilized. With the exception of 1-7 d, the birds were fed a starter (d 1-21) and/or a finisher (d 22-35) diet before the experimental diet was introduced. The diet was randomly allocated to 6 replicate cages, and the number of birds per cage was 12 (d 1-7), 10 (d 8-14), and 8 (d 15-42). The ileal digesta were collected at the last day of each week (d 7, 14, 21, 28, 35, and 42). Bird age had no effect (P > 0.05) on the IEEL estimates. The IEEL estimates ranged from 263 to 316 kcal/kg dry matter intake (DMI) during weeks 1 to 6. In Experiment 2, 4 glucose-based purified diets were developed using 0, 25, 50 and 75 g/kg cellulose. Titanium dioxide (5.0 g/kg) was added to the diets as an indigestible marker. The diets were randomly allocated to 6 replicate cages (8 birds per cage) and fed from 18 to 21 d posthatch and, ileal digesta were collected on d 21. The IEEL estimates of broiler chickens at 21 d of age showed a quadratic response (P < 0.05) to increasing cellulose contents. The lowest IEEL (88 kcal/kg DMI) was recorded for the diet without cellulose and the highest IEEL (430 kcal/kg DMI) was observed for the diet with 75 g/kg cellulose. Overall, the present findings confirmed that the IEEL in broiler chickens can be quantified by feeding a glucose-based purified diet. Broiler age had no influence on the IEEL estimates. The IEEL increased with increasing dietary cellulose contents and the IEEL determined using a purified diet without cellulose represents a better estimate of IEEL.

Composition of chicken gallbladder bile.

1. The proximate composition and, amino acid, fatty acid and mineral profiles of gallbladder bile of 35 d old broiler chickens were determined.2. The dry matter (DM) content of the bile was determined to be 19.8 g/100 g. Fat, protein and ash contents in the bile were 24.9, 23.0 and 6.6 g/100 g DM, respectively.3. The content of total fatty acids (FA) in the bile was determined to be 17.68 g/100 g DM. Unsaturated FA dominated the profile in the bile, with an unsaturated: saturated FA ratio of 1.36. Oleic, linoleic, and arachidonic acids were the main unsaturated FA, whereas palmitic and stearic acids were the major saturated FA.4. A major finding was that the data established taurine as the primary amino acid in chicken bile and not glycine, as previously assumed. Taurine was the dominant amino acid, constituting 62% of bile protein.5. Among the major minerals, sodium (2.56 g/100 g DM) was in the greatest concentration. The concentrations of other major minerals were relatively low.6. The present work provided, for the first time, preliminary data on reference values for nutrients in the chicken gallbladder bile.

Influence of barley inclusion method and protease supplementation on growth performance, nutrient utilisation, and gastrointestinal tract development in broiler starters.

The influence of the method of barley inclusion (fine, coarse and whole barley) in a wheat-based diet and protease supplementation (0 and 0.20 g/kg) on growth performance, nutrient utilisation and gastrointestinal tract development of broilers (d 1 to 21) was evaluated in a 3 × 2 factorial arrangement. Whole barley (WB) grains were ground in a hammer mill to pass through the screen sizes of 2.5 and 8.0 mm to achieve fine (FB) and coarse (CB) barley particle sizes, respectively. A total of 288, one-day-old male broilers were allotted to 36 cages (6 cages/treatment; 8 birds/cage). There was no significant (P > 0.05) interaction between barley inclusion method and protease for any growth performance or nutrient utilisation parameters. Birds fed diets containing CB and WB showed higher (P < 0.05) weight gain, and digestibility of dry matter, nitrogen, calcium, gross energy, and ileal digestible energy compared to those fed FB diets. Compared to the birds fed FB diets, feed per gain was lower (P < 0.05) in birds fed diets made of WB. Fat digestibility of the birds fed CB was higher (P < 0.05) than those fed FB and WB birds. Compared to FB and CB diets, inclusion of WB resulted in heavier (P < 0.05) gizzards but reduced (P < 0.05) gizzard pH. Supplemental protease, however, had no effects (P > 0.05) on growth performance and nutrient utilisation, most likely due to the well balanced digestible amino acids and high inherent digestibility of protein in the basal diet, and/or the presence of exogenous carbohydrase and phytase. In conclusion, the present results showed that the inclusion of coarsely ground and whole barley in a wheat-based diet can enhance nutrient and energy utilisation and is beneficial to the growth performance of young broilers.

An investigation into the influence of age on the standardized amino acid digestibility of wheat and sorghum in broilers.

Standardized ileal digestibility coefficients (SIDC) of nitrogen (N) and amino acids (AA) in wheat and sorghum at 6 different ages (d 7, 14, 21, 28, 35, and 42) of broilers were determined. Two assay diets were formulated to contain 93.8% of each grain as the sole source of AA in the diet. Titanium dioxide (0.5%) was added as an indigestible marker. Each assay diet was fed to 6 replicate cages housing 14 (d 7), 12 (d 14), 10 (d 21), 8 (d 28), 8 (d 35), and 6 (d 42) birds per cage for 4 d prior to ileal digesta collection. The apparent ileal digestibility coefficients (AIDC) were standardized by using the age-appropriate basal endogenous AA losses. In the case of wheat, AIDC of N and all AA increased (linear or quadratic, P < 0.05 to 0.001) with advancing age. No age effect was noticed on the SIDC of N, average of indispensable (IAA) and dispensable AA (DAA), though the average of total AA (TAA) tended (linear, P = 0.09) to increase as birds grew older. In sorghum, the AIDC of N, average of IAA and DAA were unaffected (P > 0.05) by age. The SIDC of N, average SIDC of IAA, DAA and TAA were higher at d 7, reduced at d 14 and then plateaued. Among the IAA, the SIDC of Arg, His, Ile, Leu, Lys, Thr, Val, and the SIDC of all individual DAA (except Cys) decreased with age (linear or quadratic, P < 0.05 to 0.001) with higher values at d 7. The higher SIDC values determined at d 7 were due to higher EAA losses during wk 1. The results showed that broiler age influences AA digestibility and this may need be considered in practical feed formulations. The age effect is variable depending on the grain type and specific AA.

Apparent metabolizable energy of cereal grains for broiler chickens is influenced by age.

The current study was conducted to investigate the influence of broiler age on the AME and AMEn of 4 common cereal grains (wheat, sorghum, barley, and corn). Four experimental diets with the same inclusion (962 g/kg) of each grain were developed and fed to groups of broiler chickens aged 1 to 7, 8 to 14, 15 to 21, 22 to 28, 29 to 35, or 36 to 42 d post-hatch. Each diet, in pellet form, was randomly allocated to 6 replicate cages in each age group. Except for the 0 to 7 d age group, the birds were fed a starter (d 0-21) and/or a finisher (d 21-35) diet before the introduction of experimental diets. The number of birds per cage were 10 (d 1-7) and 8 (d 8-42). Excreta were collected over the last 4 d of each age period. The AME and AMEn of the grains were determined by the total excreta collection. Bird age influenced (P < 0.001) the AME and AMEn of all cereal grains. The AMEn of wheat declined quadratically (P < 0.01) with advancing age, from 3,461 kcal/kg in wk 1 to 3,219 kcal/kg in wk 2 and then plateaued. The AMEn of sorghum grain declined linearly (P < 0.001) with advancing age, from 3,762 kcal/kg in wk 1 to 3,614 kcal/kg in wk 2, plateaued to wk 5 and then declined to 3,556 kcal/kg in wk 6. A quadratic (P < 0.001) reduction in the AMEn of barley was observed as birds grew older, with the AMEn decreasing between wk 1 (3,286 kcal/kg) and wk 2 (2,988 kcal/kg), increasing in wk 3 (3,117 kcal/kg) and then plateauing. The AMEn of corn declined quadratically (P < 0.05) with advancing broiler age; the highest AMEn was observed in wk 1 and 5, the lowest AMEn in wk 2, with the other weeks being intermediate. In conclusion, the present results showed that broiler age has a substantial impact on the AME and AMEn of cereal grains and the effect varied depending on the cereal grain. These data suggest that age dependent AME and AMEn values may need to be considered when formulating broiler diets to improve the precision of feed formulation and production efficiency.

High steam-conditioning temperature during the pelleting process impairs growth performance and nutrient utilization in broiler starters fed barley-based diets, regardless of carbohydrase supplementation.

The influence of supplemental carbohydrase (Carb) and conditioning temperature (CT) on growth performance, nutrient utilization and intestinal morphometry of broilers (d 1-21) fed barley-based diets was examined in a 2 × 3 factorial arrangement, evaluating 2 levels of Carb (0 and 150 g/tonne of feed) and three CT (60, 74, and 88°C). A total of 288, 1-day-old male broilers (8 birds/cage; 6 cages/treatment) were used. The activities of endo-1,4-ß- glucanase, endo-1,3 (4)-ß-glucanase and endo-1,4-ß-xylanase in the Carb were 800 BGU/g, 700 BGU/g and 2,700 XU/g, respectively. On d 21, ileal digesta was collected for the determination of nutrient digestibility. There was no significant interaction between Carb and CT for any tested parameter. Supplemental Carb, regardless of CT, increased weight gain (WG; P < 0.05) and reduced feed per gain (F/G; P < 0.001) by 30 g/bird and 6.5 points, respectively. Increasing CT to 88°C reduced (P < 0.05) WG, but increased (P < 0.05) F/G compared to the diets conditioned at 60° and 74°C. Regardless of CT, Carb enhanced (P < 0.05) the digestibility of starch and AMEn by 1.15% and 32 kcal/kg, respectively. Compared to the diets conditioned at 60° and 74°C, CT at 88°C reduced (P < 0.05) digestibility of dry matter, nitrogen, phosphorus, gross energy, and AMEn. Birds fed diets conditioned at 88°C showed lower (P < 0.05) starch digestibility compared to those fed diets conditioned at 60°C. Conditioning at 88°C increased (P < 0.05) jejunal digesta viscosity by 10.2% compared to diets conditioned at 60° and 74°C. Overall, Carb supplementation improved WG, F/G, starch digestibility and AMEn in broilers fed barley-based diets, irrespective of CT applied. Conditioning barley-based diets at 88°C impaired the ability of birds to utilize nitrogen, starch, phosphorus and energy, and consequently deteriorated WG and F/G. The lack of significant interactions between Carb and CT indicated that negative impacts caused by high CT on bird performance and nutrient utilization occurred regardless of Carb enzyme supplementation. Supplemental Carb per se could not remedy the adverse effects of high CT.

Basal ileal endogenous amino acid flow in broiler chickens as influenced by age.

The current study was carried out to measure the basal ileal endogenous amino acid (EAA) flow in male broilers (Ross 308) at different ages (d 7, 14, 21, 28, 35, and 42), following the feeding of a nitrogen-free diet. Titanium dioxide (5 g/kg) was included as an indigestible marker. The nitrogen-free diet was offered for four days prior to ileal digesta collection to 6 replicate cages housing 14 (d 3-7), 12 (d 10-14), 10 (d 17-21), 8 (d 24-28), 8 (d 31-35), and 6 (d 38-42) birds per cage. The basal EAA flow was calculated as g/kg DM intake. The amino acid (AA) profile of endogenous protein, expressed as g/100 g protein, was also calculated. The basal endogenous flow of nitrogen and all individual and total AA decreased quadratically (P < 0.05 to 0.001), with flows being higher on d 7, then decreasing on d 14, plateauing until d 35 and decreasing further on d 42. The concentrations of Trp, Cys, and Gly in the endogenous protein increased linearly (P < 0.01 to 0.001) with advancing age, whereas a linear decrease (P < 0.001) was noted for Lys. A quadratic influence (P < 0.05 to 0.001) was observed for the concentrations of Ile, Leu, Met, Val, and Asp. These changes in the endogenous protein profile may be attributed to variations in the contribution of endogenous sources with age but delineating the exact contribution of different sources is complicated. Overall, the current findings suggest that the basal ileal EAA flow is influenced by broiler age and age-specific EAA flows may need to be considered to standardize the AA digestibility.

Measurement of ileal endogenous energy losses and true ileal digestible energy of cereal grains for broiler chickens.

Two experiments were conducted to determine the ileal endogenous energy losses (IEEL) and nitrogen-corrected apparent metabolizable energy (AMEn) and true ileal digestible energy (TIDE) of 4 cereal grains (corn, sorghum, wheat, and barley) for broilers. In experiment 1, a glucose-based purified diet was used to determine the IEEL for correcting the apparent ileal digestible energy (AIDE) values to TIDE. The diet was randomly allocated to 6 replicates (6 birds per replicate) of male broilers and fed from 18 to 21 d after hatch. The jejunal and ileal digesta were collected on day 21. The results showed that glucose absorption continued beyond the jejunum but was complete in the terminal ileum demonstrating that endogenous energy losses can be quantified in the ileal digesta of birds by feeding a glucose-based diet. The IEEL were determined to be 347 ± 29.4 kcal/kg DM intake. In experiment 2, 4 experimental diets with similar inclusion (957 g/kg) of grains were developed to determine the AMEn, AIDE, and TIDE. Titanium dioxide (5.0 g/kg) was added to all diets as an indigestible marker. Each diet was randomly allocated to 6 replicates (8 birds per replicate) and fed from 14 to 21 d after hatch, and the ileal digesta were collected on day 21. The AIDE was corrected to TIDE using the IEEL value determined in experiment 1. The TIDE of corn, sorghum, wheat, and barley were determined to be 3,920, 3,650, 3,138, and 2,885 kcal/kg DM, respectively, and was higher (P < 0.05) than the corresponding AMEn values of 3,439, 3,284, 2,576, and 2,371 kcal/kg DM, respectively. No differences were observed between the AMEn and AIDE. The AMEn:TIDE ratio tended (P = 0.06) to be lower for viscous cereals (wheat and barley) than that for nonviscous cereals (corn and sorghum). The apparent ileal digestibility of DM, nitrogen, and starch was positively correlated (P < 0.001) with TIDE (r = 0.990, 0.703, and 0.705, respectively) and the AMEn (r = 0.873, 0.483, and 0.656, respectively). Further studies are warranted to determine the TIDE of a range of ingredients and to investigate the application of TIDE as a potential available energy system in poultry feed formulations.

Standardized ileal amino acid digestibility of protein sources for broiler chickens is influenced by the feed form.

The aim of present study was to determine the influence of the feed form (FF) on standardized ileal digestibility (SID) of nitrogen (N) and amino acids (AA) in 3 protein sources (PS) for broiler chickens. Six diets were tested in a 3 × 2 factorial arrangement of treatments involving 3 PS (meat and bone meal [MBM], soybean meal [SBM], and canola meal [CM]) in mash and pelleted forms. The basal endogenous N and AA losses were determined by offering a N-free diet in the mash form. From day 1 to 18, the birds were offered a broiler starter diet. The diets and the N-free diet were randomly assigned to 6 replicate cages (8 birds per cage) and fed from day 19 to 23. The ileal digesta were collected on day 23. The SID of N was higher (P < 0.05) in SBM followed by MBM and CM. The average SID of AA in SBM and MBM were similar (P > 0.05), and greater (P < 0.05) than that in CM. The FF had no influence (P > 0.05) on the SID of indispensable AA, the only exception being His, which was reduced (P < 0.05) by pelleting. Pelleting, however, resulted in reduction (P < 0.001) in the SID of all dispensable AA and average of AA. The AA most affected by pelleting was Cys, with a 15.4% decrease in the SID. The standardized ileal digestible contents of protein and the average of indispensable AA and dispensable AA were higher in MBM than in SBM, with CM being the lowest. Pelleting decreased (P < 0.05) the digestible protein and total digestible AA contents. These findings reveal that the FF has a substantial impact on AA digestibility estimates of feed ingredients and it must be considered in AA digestibility assays of ingredients with high protein and AA contents.

The interactive influence of barley particle size and enzyme supplementation on growth performance, nutrient utilization, and intestinal morphometry of broiler starters.

The influence of barley particle size and enzyme supplementation on performance, nutrient and energy utilization, and intestinal morphometry of broiler starters (day 1-21) fed pelleted barley-based diets was evaluated. Two barley particle sizes (fine and coarse) and 4 enzyme treatments (nonsupplemented [control], carbohydrase [0.15 g/kg of feed; Carb], phytase [0.10 g/kg; Phy] and combination of carbohydrase and phytase [0.15 and 0.10 g/kg, respectively; Carb + Phy]) were evaluated in a 2 × 4 factorial arrangement. Fine and coarse barley particles were achieved by grinding whole barley in a hammer mill to pass through 2.0 and 8.0 mm screens, respectively. A total of 384, 1-day-old male broilers (8 birds/cage; 6 cages/treatment) were used. Supplemental enzymes tended (P = 0.056) to increase the weight gain of birds with a synergetic effect from Carb + Phy. The response of feed intake to supplemental enzymes interacted (P < 0.05) with barley particle size, as Phy increased feed intake only in fine barley diets. Both coarse particles and supplemental Carb, either individually or in combination with Phy, reduced feed per gain (P < 0.001). Digestibility of DM, nitrogen, and fat was greater in birds fed coarse barley diets (P < 0.05). Dry matter, starch, fat, and phosphorus digestibility values were improved by supplemental enzymes (P < 0.05). Coarse barley (P < 0.05) and Carb (P < 0.001), either individually or in combination, increased the AMEn. Coarse barley reduced the gizzard pH (P < 0.001). Birds fed diets with supplemental enzymes had shorter jejunum (P < 0.05). Neither the barley particle size nor supplemental enzymes (P > 0.05) affected the jejunal digesta viscosity. In summary, feeding coarse barley particles and supplemental Carb improved the feed efficiency and nutrient and energy utilization. The effects of barley particle size on measured parameters suggest that the particle size effect was preserved even after pelleting. The combination of Carb and Phy tended to improve the weight gain but caused no further improvements in nutrient utilization.

Feed acidification and steam-conditioning temperature influence nutrient utilization in broiler chickens fed wheat-based diets.

Two experiments were conducted to examine the effects of conditioning temperature (CT) and the interactive influence of feed acidification (FA) and CT on the performance, coefficient of apparent ileal digestibility (CAID) of nitrogen (N), starch, fat calcium (Ca) and phosphorus (P), and AME in broilers. In both experiments, each treatment was randomly allocated to 6 cages (8 birds per cage) and fed from 1 to 21 D posthatch. In experiment 1, the effect of CT was evaluated using a wheat-based diet at 3 CT: unconditioned, conditioned at 60°C or 90°C. All the diets by-passed the pellet press and collected in mash form. Birds fed the diet conditioned at 90°C consumed more (P < 0.05) feed and tended (P = 0.087) to have higher feed per gain (F:G) than those fed the unconditioned diet but similar to those fed the diet conditioned at 60°C. A tendency was noted for CT to affect the CAID of N (P = 0.071) and starch (P = 0.093), with reduced digestibility values in the diet conditioned at 90°C. Conditioning at 90°C resulted in lower (P < 0.05) AME. In experiment 2, three inclusions of an acidifier (0.0, 7.0, and 10 g/kg) and 2 CT of 60°C and 90°C were evaluated in a 3 × 2 factorial arrangement of treatments using pelleted diets. Neither the main effects nor the interaction between acidifier addition and CT was significant for weight gain, feed intake, and F:G. The FA increased (P < 0.05) the CAID of N, fat, and P at both inclusion levels and of starch at 10 g/kg. Conditioning at 90°C reduced (P < 0.05) the CAID of starch, fat, and Ca, regardless of FA level. Overall, the present data showed that the application of high CT for broiler feed manufacture can impair nutrient utilization and, consequently the feed efficiency in broilers. Feed acidification imparts some benefits to nutrient digestibility in broilers fed pelleted wheat-based diets.

The effect of graded inclusions of waxy starch hull-less barley and a multi-component exogenous carbohydrase on the growth performance, nutrient digestibility and intestinal morphometry of broiler chickens.

1. A 21-d experiment was conducted to investigate the effect of graded inclusions of waxy starch hull-less (WSHL) barley and a multi-component exogenous carbohydrase on the growth performance, nutrient digestibility and intestinal morphometry of broiler chickens. Five levels of WSHL barley inclusion (0, 65, 130, 195 and 260 g/kg) in a wheat-based diet, and two levels of enzyme supplementation (0 and 150 g/tonne of feed) were evaluated in a 5 × 2 factorial arrangement of 10 dietary treatments. All diets were equivalent in metabolisable energy and digestible amino acid content. A total of 400, one-d-old male broilers (five cages/treatment; eight birds/cage) were used in the experiment. 2. Regardless of enzyme supplementation, feed intake declined (P < 0.001) with increasing inclusion of WSHL barley. Increasing levels of WSHL barley (P < 0.001) and supplemental enzyme (P < 0.01) increased gain to feed ratio. 3. Birds fed diets with 0 g/kg WSHL barley showed the lowest (P < 0.001 to 0.01) digestibility for all nutrients except starch. Only starch digestibility was improved (P < 0.05) by enzyme supplementation. The nitrogen-corrected apparent metabolisable energy improved with increasing inclusion of WSHL barley (P < 0.001) and supplemental enzyme (P < 0.001). Increasing inclusion of WSHL barley increased the relative weight of gizzard (P < 0.001) and reduced jejunal digesta viscosity (P < 0.01). Supplemental enzyme (P < 0.001) reduced digesta viscosity. 4. All levels of WSHL barley inclusion improved digestibility of dry matter, nitrogen and fat, whilst energy utilisation improved at inclusions of 130 g/kg WSHL and above, probably due to lowered digesta viscosity and better development of the gizzard. Gain to feed ratio, starch digestibility, energy utilisation and jejunal digesta viscosity can benefit from carbohydrase supplementation in wheat-based diets, regardless of barley inclusion level.

Influence of inclusion level of barley in wheat-based diets and supplementation of carbohydrase on growth performance, nutrient utilisation and gut morphometry in broiler starters.

1. The influence of barley inclusion level and supplementation of a multi-component non-starch polysaccharide degrading enzyme on performance and nutrient utilisation in broilers was investigated. Normal-starch hulled barley was evaluated with five levels of inclusion (0, 141, 283, 424 and 565 g/kg) in a wheat-based diet and two levels of enzyme supplementation (0 and 150 g/tonne of feed; a 5 × 2 factorial arrangement of 10 dietary treatments). All diets were equivalent in metabolisable energy and digestible amino acid contents. A total of 400, one-d old male broilers (five cages/treatment; eight birds/cage) were used in the experiment.2. Regardless of enzyme supplementation, weight gain (WG) increased up to 283 g/kg of barley and was reduced afterwards (P < 0.01). Increasing levels of barley resulted in greater (P < 0.001) gain per feed (G/F). Enzyme addition increased WG (P < 0.05) and G/F (P < 0.001) at each barley inclusion level.3. Birds fed diets with 0 and 565 g/kg barley showed the lowest and highest (P < 0.001to 0.05) digestibility for all nutrients measured, respectively. Digestibility of all nutrients was improved by enzyme supplementation at each barley inclusion level (P < 0.05). The nitrogen-corrected apparent metabolisable energy improved with increasing inclusion of barley (P < 0.001) and supplemental enzyme (P < 0.01). Increasing inclusion of barley increased the relative weight of gizzard (P < 0.001) and reduced jejunal digesta viscosity (P < 0.001). Supplemental enzyme (P < 0.001) reduced digesta viscosity.4. The optimum inclusion level of barley, with respect to growth performance, was 283 g/kg of diet. Increasing barley inclusion improved nutrient and energy utilisation, possibly through lowered digesta viscosity and better function of the gizzard. Feed efficiency and nutrient and energy utilisation can benefit from carbohydrase supplementation in barley-based diets, regardless of barley inclusion level.

Nutritional evaluation of two barley cultivars, without and with carbohydrase supplementation, for broilers: metabolisable energy and standardised amino acid digestibility.

1. Two experiments were conducted to assess the nitrogen-corrected apparent metabolisable energy (AMEn; Exp. 1; 288 Ross 308 male broilers at d 14; 36 cages with eight birds each) and coefficient of standardised ileal digestibility (CSID) of amino acids (AA; Exp. 2; 336 Ross 308 male broilers at d 21; 42 cages with eight birds each) of two barley cultivars for broilers in comparison to wheat, without or with a multi-component non-starch polysaccharide (NSP) degrading enzyme. A 3 × 2 factorial arrangement of treatments was used in both experiments with three types of grains (normal starch hulled barley [NSH], waxy starch hull-less barley [WSHL], and wheat) and two levels of enzyme supplementation (0 and 200 g/tonne of feed). Enzyme supplemented diets contained 406 and 128 of endo-1, 4-ß-xylanase and endo-1, 3 (4)-ß-glucanase units per kg of feed, respectively. 2. Analysis showed that the starch content was higher in NSH (610 g/kg) than in wheat (537 g/kg) and WSHL (554 g/kg), and the composition of starch differed markedly among the grain types. The ß-glucan content was considerably higher in WSHL (68.6 g/kg) compared to NSH (38.5 g/kg) and wheat (7.74 g/kg). The contribution of soluble fraction to the total non-starch polysaccharides was higher in WSHL (38.2%) compared to NSH and wheat (17.1% and 13.3%, respectively). 3. A significant (P < 0.01) interaction was observed between the grain type and enzyme supplementation for AMEn. The WSHL, with the highest content of ß-glucan, showed the greatest response to enzyme supplementation for AMEn. 4. Birds fed wheat- and WSHL-based diets had the highest and lowest CSID of nitrogen and most of AA, respectively, with NSH diets being intermediate. Regardless of grain type, enzyme supplementation increased (P < 0.05) the CSID of nitrogen. 5. These data suggest that ß-glucan content plays an important role in determining the digestibility of nutrients in barley for broilers, resulting in a better feeding value for NSH over WSHL. Supplementation of a multi-component NSP-degrading enzyme can improve the feeding value of barley in broiler diets by increasing the digestibility with the effect being more pronounced in WSHL barley.

Influence of high dose of phytase and an emulsifier on performance, apparent metabolisable energy and nitrogen retention in broilers fed on diets containing soy oil or tallow.

The effects of high dose of microbial phytase and an emulsifier on the performance, apparent metabolisable energy (AME) and nitrogen (N) retention in broilers fed on diets containing different fat sources were examined in a 5-week trial. Two fat sources (soy oil and tallow), two inclusion levels of E. coli phytase (500 or 1000 phytase units (FTU)/kg diet) and two inclusion levels of lysolecithin emulsifier (0 or 3.5 g/kg of diet) were evaluated in a 2 × 2 × 2 factorial arrangement of treatments. Throughout the 5-week trial, soy oil supplementation improved weight gain and feed per gain compared with tallow, but had no effect on feed intake. The high dose of phytase increased the weight gain and feed intake and lowered the feed per gain during d 1-21, but had no effect on performance parameters over the whole trial period. An effect of emulsifier was observed for feed intake during d 1-21 and over the whole trial period. Addition of emulsifier increased feed intake compared with diets without emulsifier. During weeks 1, 2, 3 and 5, birds fed on soy oil-based diets had higher nitrogen-corrected AME (AMEN) compared with those fed on tallow-based diets. During weeks 2, 3 and 5, the effect of phytase was significant for AMEN, with the high dose increasing the AMEN. During week 2, AMEN was increased with emulsifier addition. During weeks 1, 2, 3 and 5, birds fed on soy oil-based diets had higher fat retention compared with those fed on tallow-based diets. The high dose of phytase improved the retention of fat during week 5 and the addition of emulsifier resulted in higher fat retention during week 1. During weeks 2, 3 and 5, an interaction between fat source × phytase × emulsifier was observed for N retention. In soy oil-based diets, emulsifier plus 1000 FTU/kg phytase increased N retention compared with other groups, while in tallow-based diets, emulsifier addition increased N retention in diets with 500 FTU/kg, but not in 1000 FTU/kg diet. Overall, the present data suggest that the dietary fat source influenced performance, AMEN and fat retention in broiler chickens. There is opportunity to improve bird performance during d 1-21, AMEN and fat retention with higher doses of microbial phytase. Addition of the emulsifier increased the AMEN during week 2 and tract retention of fat during week 1, but this effect was not translated into improvements in performance.

Digestion of fat and fatty acids along the gastrointestinal tract of broiler chickens.

Two experiments were conducted. The first experiment investigated the digestion of fat and fatty acids (FA) from soybean oil and tallow along the gastrointestinal tract of broiler chickens. The second experiment was conducted to determine endogenous fat and FA losses and the FA profile of chicken bile. In experiment 1, 2-wk-old broilers were fed corn-soy diets supplemented with 50 g/kg of soybean oil or tallow for 7 d and digesta were collected from the duodenum, upper jejunum, upper ileum, and lower ileum. Apparent digestibility coefficients were calculated using the titanium marker ratio in diets, and digesta. Digestibility of fat was determined to be negative in the duodenum, indicating marked net secretion of fat into this segment. Fat was rapidly digested in the jejunum, with digestibility coefficients of 0.60 to 0.64 being determined at the end of the jejunum. The digestion of fat continued in the upper ileum. The apparent digestibility coefficient of fat determined at lower ileum in soybean oil diets was higher (P < 0.05) than that in tallow diets (0.82 vs. 0.74). Linoleic acid was digested throughout the intestinal tract, whereas the digestion of palmitic, stearic, and oleic acids started only in the jejunum. Measurements at the lower ileal level showed that the unsaturated FA (linoleic and oleic acids) were well digested (0.90 to 0.94), irrespective of the source of fat. In contrast, the digestibility of saturated FA (palmitic and stearic acids) was influenced (P < 0.05) by the fat source. Digestibility coefficients of palmitic and stearic acids at lower ileum were markedly higher (P < 0.05) in the diet containing soybean oil (0.77 to 0.85) compared with that containing tallow (0.58 to 0.68). In experiment 2, ileal endogenous fat loss was determined to be 1,714 mg/kg of DM intake. Endogenous fat was composed mainly of palmitic (75 g/kg), stearic (131 g/kg), oleic (73 g/kg), linoleic (133 g/kg), and arachidonic (60 g/kg) acids. Fatty acid profile of endogenous fat was found to be remarkably similar to that of the bile, suggesting that the reabsorption of fat and FA from the bile was incomplete in growing broiler chickens.

Influence of a microbial phytase on the performance and the utilisation of energy, crude protein and fatty acids of young broilers fed on phosphorus-adequate maize- and wheat-based diets.

1. The effects of microbial phytase on the performance and nutrient utilisation in broilers fed on phosphorus-adequate starter diets were examined in this study. The effect of phytase on the apparent ileal digestibility of fatty acids was of particular interest. Two grain types (maize and wheat) and two inclusion concentrations of a phytase enzyme from Escherichia coli expressed in Schizosaccaromyces pombe (0 or 500 phytase units (FTU)/kg of feed) were evaluated in a 2 × 2 factorial arrangement of treatments. 2. Supplemental phytase improved the weight gain and feed per gain, but had no effect on the feed intake of young broilers receiving phosphorus-adequate diets. 3. Phytase supplementation improved the apparent ileal digestibility of nitrogen and phosphorus in both diet types. Phytase supplementation tended to improve the apparent ileal digestible energy in wheat-based diets, but had no effect on the apparent metabolisable energy in both diet types. 4. Supplementation of phytase increased the apparent ileal digestibility of fat, with similar effects for the different fatty acids measured. Increments on ileal fat digestibility due to phytase were not dependent on the type of diet. 5. Dietary supplementation of microbial phytase enhanced not only the digestibility of phosphorus, but also that of nitrogen and fat, exhibiting increased ileal digestibility for all fatty acids in P-adequate maize- and wheat-based diets.

Influence of whole wheat inclusion and a blend of essential oils on the performance, nutrient utilisation, digestive tract development and ileal microbiota profile of broiler chickens.

1. The aim of the present experiment was to examine the influence of whole wheat inclusion and a blend of essential oils (EO; cinnamaldehyde and thymol) supplementation on the performance, nutrient utilisation, digestive tract development and ileal microbiota profile of broiler chickens. 2. The experimental design was a 2 × 2 factorial arrangement of treatments evaluating two wheat forms (ground wheat [GW] and whole wheat [WW]; 100 and 200 g/kg WW replacing GW during starter [1 to 21 d] and finisher [22 to 35 d] diets respectively) and two levels of EO inclusion (0 or 100 g/tonne diet). All dietary treatments were supplemented with 2000 xylanase units/kg feed. Broiler starter and finisher diets based on wheat and soybean meal were formulated and each diet fed ad libitum to 6 pens of 8 male broilers. 3. During the trial period (1-35 d), wheat form had no significant effect on weight gain or feed intake. However, WW inclusion tended (P = 0.06) to improve feed per gain. Essential oil supplementation significantly improved weight gain in both diets, but the improvements were greater in the GW diet as indicated by a significant wheat form × EO interaction. 4. Main effects of wheat form and EO on the relative weight, length and digesta content of various segments of the digestive tract were not significant. Significant interactions, however, were found for relative gizzard and caecal weights. Essential oil supplementation significantly increased the relative gizzard weight and lowered relative caecal weight in birds fed on the GW based diet, but had no effect in those fed on the WW based diet. 5. Whole wheat inclusion and EO supplementation significantly improved apparent ileal nitrogen digestibility. Apparent ileal digestible energy was not significantly influenced by the dietary treatments. 6. Ileal microbiota profiling, using denaturing gradient gel electrophoresis, showed that the ileal microbiota composition was influenced by feed form. The mean numbers of bacterial species in the ileal contents of birds fed on the GW diet supplemented with EO tended (P = 0.07) to be higher than those of the ileal contents of birds fed on unsupplemented GW based diet. 7. The present data suggested that dietary addition of EO improves broiler weight gain and ileal nitrogen digestibility both in GW and WW based diets, but that the magnitude of the response to EO for weight gain was greater in GW based diet. Whole wheat feeding was found to be beneficial in terms of feed efficiency.