Comparative assessment of emissions, performance, and economics parameters for a dual-fuel diesel generator operating with rice bran biodiesel and hydrogen.

The first step to achieving an energy transition is partially substituting fossil fuels with other more environmentally friendly alternatives, such as hydrogen gas. The current research aims to evaluate the influence of hydrogen in a diesel generator fueled with rice bran biodiesel. The above encourages the use of hydrogen and biodiesel production from residual raw material. For the development of the research, a diesel engine bench was used, which operated in five load conditions: 20 %, 40 %, 60 %, 80 %, and 100 %, and was fed with three fuels: -100 %, RB-10 %, and RB-10 % + H2(30 %). The results show that the mixture RB-10 % + H2(30 %) causes a 3.14 % reduction in BSFC and a 3.26 % increase in energy conversion efficiency. In addition, it is observed that a 9.90 %, 12.57 %, and 10.99 % decrease in HC, CO, and smoke opacity emissions compared to pure diesel. On the other hand, the mixture RB-10 % + H2(30 %) reduces by 4.44 %, 5.07 %, and 7.06 % the environmental, social, and ecological impact due to CO2, HC, and CO emissions, as well as a 3.93 % reduction in engine operating cost compared to RB-10 % biodiesel. In general, hydrogen injection is a promising alternative to promote the use of rice bran biodiesel due to its increased performance characteristics and reduced pollutant emissions without the need to modify the engine.

Optimization of emulsification conditions with rice bran concentrates for the preliminary formulation of potential vegan dressings and their characterization.

A fraction of rice bran (RB), generated during the brown rice polishing, is utilized to extract oil, resulting in defatted RB (DRB). The aim of this study was to optimize the emulsification conditions to enhance the value of this byproduct by formulating potential vegan dressings and characterizing them. Enzymatic hydrolysis of the starch present in DRB yields the DRB concentrate (DRBC). A central composite design was applied and the results were analyzed using response surface methodology to select optimal conditions for an oil-in-water emulsion formula. Two formulations were chosen: one corresponds to the optimal conditions, with 26.5% of oil and 73.5% of DRBC dispersion (eoptimal), and the other one with 21.7% of oil and 78.3% of dispersion (eED8). The eoptimal formulation exhibited significantly lower mean De Brouckere diameter (D4,3) value and higher viscosity when compared with eED8. For both emulsions, the particle size distribution and D4,3 remained unchanged during storage, whereas viscosity decreased, and backscattering (BS) increased. Initially, both emulsions exhibited solid viscoelastic behavior, which was partially lost during quiescent storage. The increase in BS was attributed to particle disaggregation, ultimately leading to the aforementioned change in rheological behavior. In conclusion, although the designed emulsions underwent microstructural changes, they were stable against gravitational separation. To improve stability during quiescent storage, it is suggested to incorporate a thickening agent. Hence, it is propose to procced with the development of a vegan dressing based on the eoptimal emulsion, as it exhibits superior physicochemical properties.

Pilot Study of Heat-Stabilized Rice Bran Acceptability in Households of Rural Southwest Guatemala and Estimates of Fiber, Protein, and Micro-Nutrient Intakes among Mothers and Children.

Nutrient-dense, acceptable foods are needed in low-resource settings. Rice bran, a global staple byproduct of white rice processing, is rich in amino acids, fibers, and vitamins, when compared to other cereal brans. This pilot study examines the nutritional contribution of rice bran to the daily diets of mother-child pairs in rural southwest Guatemala. Thirty households were screened. Mothers (≥18 years) and children (6 to 24 months) completed 24 h dietary recalls at baseline and after 12 weeks (endline) for diet intake and diversity analyses. During biweekly visits for 12 weeks, households with <5 members received 14 packets containing 60 g of heat-stabilized rice bran, and those with ≥5 members received 28 packets. The macro- and micro-nutrient contributions of rice bran and whole, cooked black beans were included in dietary simulation models with average intakes established between the recalls and for comparison with dietary reference intakes (DRIs). A baseline child food frequency questionnaire was administered. The 27 mothers and 23 children with complete recalls were included in analyses. Daily maternal consumption of 10 g/d of rice bran plus 100 g/d of black beans resulted in all achieving at least 50% of the fiber, protein, magnesium, niacin, potassium, and thiamin DRIs. Daily child consumption of 3 g/d of rice bran plus 10 g/d of black beans resulted in all achieving at least 50% of the magnesium, niacin, phosphorous, and thiamine DRIs. For 15/17 food categories, male children had a higher intake frequency, notably for animal-source foods and coffee. Dietary rice bran coupled with black beans could improve nutritional adequacy, especially for fiber and key micro-nutrients, with broader implications for addressing maternal and child malnutrition in low-resource settings.

Rice Bran Lipidome Identifies Novel Phospholipids, Glycolipids, and Oxylipins with Roles in Lipid Metabolism of Hypercholesterolemic Children.

SCOPE: The purpose of the study is to characterize the chemical diversity in rice bran (RB) lipidome and determines whether daily RB consumption for 4 weeks may modulate plasma lipid profiles in children. METHODS AND RESULTS: Untargeted and targeted lipidomics via ultra-performance liquid chromatography coupled with high-resolution tandem mass spectrometry (UPLC-MS/MS) are applied to identify bioactive RB lipids from a collection of 17 rice varieties. To determine the impact of RB (Calrose-USA variety) supplementation on plasma lipid profile, a secondary analysis of plasma lipidome is conducted on data recorded in a clinical study (NCT01911390, n = 18 moderately hypercholesterolemic children) before and after 4 weeks of dietary intervention with a control or RB supplemented (15 g day-1 ) snack. Untargeted lipidomic reveals 118 lipids as the core of lipidome across all varieties among which phospholipids are abundant and oxylipins present. Phytoprostanes and phytofurans are quantified and characterized. Lipidome analysis of the children plasma following RB consumption reveals the presence of polar lipids and oxylipins alongside putative modulations in endocannabinoids associated with RB consumption. CONCLUSION: The investigation of novel polar lipids, oxylipins, phytoprostanes, and phytofurans in RB extracts provides support for new health-promoting properties interesting for people at risk for cardiometabolic disease.

Utilização de métodos alternativos como indutor de muda forçada em codornas poedeiras / Use of alternative methods as an inducer of forced molting in laying quail

Objetivou-se avaliar métodos alternativos de restrição alimentar qualitativa e quantitativa em comparação à técnica convencional de muda forçada em codornas japonesas para o segundo ciclo de produção. O período de muda forçada teve duração de 10 dias e dois períodos de 21 dias de pós-muda. Foram utilizadas 72 codornas japonesas fêmeas, emfinal de produção com 72 semanas deidade. As aves foram distribuídas em delineamento inteiramente casualizado com três tratamentos e quatro repetições cada, com seiscodornas por repetição. Os tratamentos experimentais foram:T1 ­aves submetidas a três dias de jejum com posterior fornecimento de ração de postura à vontade por setedias; T2 ­aves que receberam alimentação controlada (10 g/ave/dia) por 10 dias; T3 ­aves que receberam farelo de arroz à vontade por 10 dias. Durante todo o experimento todasas aves foram submetidas a iluminação natural com média de 12 horas de luz diária e água a vontade e após os 10 dias de muda foi fornecido ração de postura a vontade. A utilização do T2 (10 g/ave/dia de ração de postura) e de farelo de arroz como alimentoalternativo no programa de muda forçada foi viável. Mesmo a perda de peso sendo abaixo do recomentado, as aves que receberam 10 g de ração ave/dia e farelo de arroz à vontade apresentaram resultados de desempenho e qualidade do ovo pós muda semelhantes àsaves que ficaram em jejum, além de possibilitar melhores condições de bem-estar animal.(AU)

The objective was to evaluate alternative methods of qualitative and quantitative feed restriction compared to theconventional technique of forced moulting in Japanese quails for the second production cycle. The forced moulting period lasted 10 days and two 21-day post-molt periods. 72 female Japanese quails were used, at the end of production at 72 weeks of age. Thebirds were distributed in a completely randomized design with three treatments and four replications each, with sixquails per replicate. The experimental treatments were: T1 ­birds submitted to three days of fasting with subsequent provision of layingfeed ad libitum for sevendays; T2 ­birds that received controlled feeding (10 g/bird/day) for 10 days; T3 ­birds that received rice bran ad libitum for 10 days. Throughout the experiment, all birds were submitted tonatural lighting with an average of12hours of daily light and water ad libitum and after 10 days of molting, laying feed was provided ad libitum. The use of T2 (10 g/bird/day of laying ration) and ricebran as an alternativefood in the forced molt program was feasible. Even the weight loss being below the recommended, the birds that received 10 g of poultry feed/day and rice bran ad libitum showed similar post-moult performance and egg quality results to birds that were fasted, in addition to enabling better conditions. of animal welfare.(AU)

Comparison between biofloc technology system and aquamimicry in the cultivation of Litopenaeus vannameiin lined ponds in Southern Brazil / Comparação entre o sistema de bioflocos e aquamimicry no cultivo de Litopenaeus vannamei em viveiros revestidos no sul do Brasil

This work compared biofloc technology and aquamimicry technologies in Litopenaeus vannamei lined ponds, using a density of 60 shrimp·m-2. The experiment lasted 120 days, with two treatments, bioflocs (TBio) and aquamimicry (TMi), and three replications for each. In both treatments, the average values of the water quality parameters were as follows: temperature was 24.0 ± 0.32 °C, dissolved oxygen was 8.00 ± 0.45 mg·L-1, pH was 8.40 ± 0.20, and alkalinity was 240.01 ± 37.15 mg·L-1. The control of water quality was effectively maintained in both treatments, indicating the aquamimicry system's capability to efficiently recycle the nutrients found in the lined ponds' water. Furthermore, both treatments demonstrated efficiency in shrimp production, and the shrimp from the TMi treatment reached an average final weight of 11.73 ± 2.21 g, average survival of 53.3 ± 15.2%, and productivity of 3.56 ± 0.15-ton·ha-1. The TBio shrimp reached a final weight of 11.48 ± 1.25 g, survival of 63.3 ± 8.16%, and productivity of 4.08 ± 1.10-ton·ha-1. The present study demonstrated that TMi treatment ponds presented zootechnical performances close to those of TBio treatment ponds. The results achieved can contribute to the improvement of this cultivation system to use it in higher stocking densities.(AU)

Este trabalho comparou as tecnologias sistema de bioflocos e aquamimicry em viveiros revestidos de Litopenaeus vannamei,usando densidade de 60 camarões·m-2. O experimento teve duração de 120 dias e envolveu dois tratamentos, bioflocos (TBio) e aquamimicry (TMi), e três repetições para cada um. Em ambos os tratamentos, os valores médios dos parâmetros de qualidade da água foram os seguintes: temperatura = 24,0 ± 0,32 °C, oxigênio dissolvido = 8,00 ± 0,45 mg·L-1, pH = 8,40 ± 0,20, e alcalinidade = 240,01 ± 37,15 mg·L- 1. O controle da qualidade da água foi efetivamente mantido em ambos os tratamentos, indicando a capacidade do sistema aquamimicry de reciclar eficientemente os nutrientes encontrados na água dos tanques revestidos. Além disso, ambos os tratamentos demonstraram eficiência na produção de camarões. Os camarões procedentes do tratamento TMi atingiram peso final médio de 11,73 ± 2,21 g, sobrevivência média de 53,3 ± 15,2% e produtividade de 3,56 ± 0,15 ton·ha-1. Os camarões do TBio alcançaram peso final de 11,48 ± 1,25 g, sobrevivência de 63,3 ± 8,16% e produtividade de 4,08 ± 1,10 ton·ha-1. O presente estudo demonstrou que viveiros do tratamento TMi apresentaram desempenhos zootécnicos próximos aos dos viveiros do tratamento TBio. Os resultados alcançados podem contribuir para o aprimoramento desse sistema de cultivo com o objetivo de utilizá-lo em densidades de estocagens mais elevadas.(AU)

The Effect of Stabilized Rice Bran Addition on Physicochemical, Sensory, and Techno-Functional Properties of Bread.

Rice bran (RB) is a valuable byproduct derived from rice milling that represents an excellent opportunity for dietary inclusion. Bioactive components with antioxidant potential have been reported in RB, gaining the considerable attention of researchers. However, RB requires a stabilization process after milling to prevent it from becoming rancid and promote its commercial consumption. The aim of this study was to evaluate the effects of substituting stabilized rice bran (SRB) for wheat flour at levels of 10, 15, 20 and 25% on the proximate composition, dietary fiber, dough rheology, antioxidant properties, content of bioactive compounds, and sensory attributes of white wheat-based bread. Results indicated that the incorporation of SRB increased the bread's insoluble dietary fiber, phytic acid, total polyphenol content, γ-oryzanol, γ-aminobutyric acid, and antioxidant properties, while decreased its water absorption capacity, elasticity, volume, ß-glucans, and soluble dietary fiber content. Moreover, substituting wheat flour for SRB at levels higher than 15% affected sensory attributes, such as color, odor, flavor, and softness. This study highlights the potential application of SRB flour in bread-making to increase nutritional, and functional properties of white wheat bread.

A Randomized Controlled Trial of Dietary Rice Bran Intake on Microbiota Diversity, Enteric Dysfunction, and Fecal Secretory IgA in Malian and Nicaraguan Infants.

BACKGROUND: Malnutrition and diarrhea are leading causes of death in children aged <5 y. Rice bran is a nutrient-dense prebiotic available globally. OBJECTIVES: The objective of this secondary analysis was to evaluate the effects of daily rice bran supplementation on environmental enteric dysfunction (EED) markers, total fecal secretory IgA (sIgA), and microbiota in infants at high risk of malnutrition. METHODS: Six-month-old Malian and Nicaraguan infants were randomly assigned to control or daily rice bran supplementation cohorts (1 to 5 g/d). Feces were collected monthly for 6 mo to evaluate fecal sIgA, markers of EED, and microbiota diversity. Statistical methods included linear mixed models, generalized mixed models, Spearman correlation, and Wilcoxon rank-sum tests. RESULTS: Six-month-old Malian infants had significantly elevated sIgA (4.0× higher, P < 0.001), fecal myeloperoxidase (31.6× higher, P < 0.001), fecal α1-antitrypsin (1.8× higher, P = 0.006), and lower fecal neopterin (0.13× higher, P < 0.001) than the age-matched Nicaraguan infants. In the Nicaraguan rice bran cohort from 6 to 12 mo of age, there was a significant decrease in sIgA concentrations (0.4×, P < 0.05) and a correlation between sIgA and the EED marker α1-antitrypsin (0.523, P < 0.0001) at 12 mo of age. In Malian infants, daily rice bran ingestion resulted in decreased EED scores (0.71×, P = 0.02) and a stable sIgA concentration over time. The rice bran group of Malian infants also had correlation between sIgA and the EED marker neopterin (0.544, P < 0.001) at 12 mo of age and a significant (P < 0.05) increase in microbiota α-diversity at a younger age (9 mo with rice bran compared with 10 mo in control group), which supports earlier microbiota maturation. CONCLUSIONS: These results support rice bran as a functional food ingredient targeting gut mucosa in children at high-risk of malnutrition.

Rice (Oryza sativa L.) bran preserves cardiac function by modulating pro-inflammatory cytokines and redox state in the myocardium from obese rats.

PURPOSE: This study aimed to evaluate the effect of rice bran (RB) supplementation to a high-sugar fat (HSF) diet on cardiac dysfunction in an experimental obesity model. METHODS: Male Wistar rats were distributed into three groups: control, high-sugar fat, and high-sugar fat supplemented with 11% RB for 20 weeks. RESULTS: HSF diet promoted obesity and metabolic complications. Obese rats showed cardiac structural and functional impairment associated with high levels of interleukin-6, tumoral necrosis factor alpha, and malondialdehyde, and decreased activity of superoxide dismutase and catalase in the myocardium. RB supplementation was able to mitigate obesity and its metabolic alterations in HSF diet-fed animals. Moreover, the RB also prevented structural and functional damage, inflammation, and redox imbalance in the heart of these animals. CONCLUSION: This study suggests that RB supplementation prevents cardiac dysfunction in rats fed on HSF by modulating systemic metabolic complications and inflammation and oxidative stress in the myocardium, representing potential alternative therapy.

Daily Rice Bran Consumption for 6 Months Influences Serum Glucagon-Like Peptide 2 and Metabolite Profiles without Differences in Trace Elements and Heavy Metals in Weaning Nicaraguan Infants at 12 Months of Age.

BACKGROUND: Environmental enteric dysfunction (EED) is associated with chronic gut inflammation affecting nutrient absorption and development of children, primarily in low- and middle-income countries. Several studies have shown that rice bran (RB) supplementation provides nutrients and modulates gut inflammation, which may reduce risk for undernutrition. OBJECTIVE: The aim was to evaluate the effect of daily RB dietary supplementation for 6 mo on serum biomarkers in weaning infants and associated changes in serum and stool metabolites. METHODS: A 6-mo randomized-controlled dietary intervention was conducted in a cohort of weaning 6-mo-old infants in León, Nicaragua. Anthropometric indices were obtained at 6, 8, and 12 mo. Serum and stool ionomics and metabolomics were completed at the end of the 6-mo intervention using inductively coupled plasma MS and ultra-high performance LC-tandem MS. The ɑ1-acid glycoprotein, C-reactive protein, and glucagon-like peptide 2 (GLP-2) serum EED biomarkers were measured by ELISA. RESULTS: Twenty-four infants in the control group and 23 in the RB group successfully completed the 6-mo dietary intervention with 90% dietary compliance. RB participants had higher concentrations of GLP-2 as compared with control participants at 12 mo [median (IQR): 743.53 (380.54) pg/mL vs. 592.50 (223.59) pg/mL; P = 0.04]. Metabolite profiles showed significant fold differences of 39 serum metabolites and 44 stool metabolites from infants consuming RB compared with control, and with significant metabolic pathway enrichment scores of 4.7 for the tryptophan metabolic pathway, 5.7 for polyamine metabolism, and 5.7 for the fatty acid/acylcholine metabolic pathway in the RB group. No differences were detected in serum and stool trace elements or heavy metals following daily RB intake for 6 mo. CONCLUSIONS: RB consumption influences a suite of metabolites associated with growth promotion and development, while also supporting nutrient absorption as measured by changes in serum GLP-2 in Nicaraguan infants. This clinical trial was registered at https://clinicaltrials.gov as NCT02615886.

Development of a freeze-dried symbiotic obtained from rice bran.

This study aimed to assess the growth potential of L.acidophilus and L.plantarum in rice bran, a co-product from the food industry, and subsequently develop a freeze-dried symbiotic. Furthermore, phytochemicals and antioxidant properties were analysed. The growth was measured using growth kinetics over 72 h. The total phenolic compounds were analysed by the Folin-Ciocalteau method and antioxidant potential by DPPH and ABS methods. Freeze-drying process occurred using a pilot-scale equipment (Liotop LP510), verification and quantification of probiotics occurred through molecular analyses, as DNA extraction and qPCR. As a result, there was a good growth in rice bran (p = 0.04), suggesting its prebiotic potential. Rice bran also showed significant concentrations of phenolic compounds (3.69 mgEAG/mL ± 0.04) and antioxidant activity according ABTS (8.35 µmol ET/mL ± 0.106) and DPPH (24.71 µmol ET/mL ± 7.90) methods. The bacteria concentration decreased significantly when submitted to the freeze-drying process (p = 0.001), however, they remained by the minimum concentration required for a product to be considered a symbiotic. Therefore, it was concluded that rice bran and these analysed bacteria proved to be effective for a symbiotic formulation.

Metabolomics of Pigmented Rice Coproducts Applying Conventional or Deep Eutectic Extraction Solvents Reveal a Potential Antioxidant Source for Human Nutrition.

Rice bran (RB) corresponds to the outer layers of whole grain rice and contains several phenolic compounds (PCs) that make it an interesting functional food ingredient. PC richness is enhanced in pigmented RB varieties and requires effective ways of extraction of these compounds. Therefore, we investigated conventional and deep eutectic solvents (DES) extraction methods to recover a wide array of PCs from red and black RB. The RB were extracted with ethanol/water (60:40, v/v) and two DES (choline chloride/1.2-propanediol/water, 1:1:1 and choline chloride/lactic acid, 1:10, mole ratios), based on Generally Recognized as Safe (GRAS) components. Besides the quantification of the most typical phenolic acids of cereals, nontargeted metabolomic approaches were applied to PCs profiling in the extracts. Globally, metabolomics revealed 89 PCs belonging to flavonoids (52%), phenolic acids (33%), other polyphenols (8%), lignans (6%) and stilbenes (1%) classes. All extracts, whatever the solvents, were highly concentrated in the main phenolic acids found in cereals (37-66 mg/100 g in black RB extracts vs. 6-20 mg/100 g in red RB extracts). However, the PC profile was highly dependent on the extraction solvent and specific PCs were extracted using the acidic DES. The PC-enriched DES extracts demonstrated interesting DPPH scavenging activity, which makes them candidates for novel antioxidant formulations.

Differences in the Compositions of Vitamin E Tocochromanol (Tocopherol and Tocotrienol) in Rice Bran Oils Produced in Japan and Other Countries.

In this study, we investigated the compositions of vitamin E tocochromanol [tocopherol (Toc) and tocotrienol (T3)] in crude and refined rice bran oil (RBO) produced in Japan and other countries, including Brazil, Thailand, and Vietnam, based on high-performance liquid chromatography analysis. All RBO analyzed contained α-, ß- and γ-Toc and α-, γ- and δ-T3. Japanese crude RBO, although not refined RBO, also contained ß-T3. Furthermore, total Toc contents in both Japanese crude and refined oils were found to be higher than those in the crude and refined RBO from other countries. Total T3 contents in Japanese crude RBO were similar to those in the crude RBO from Brazil and Vietnam. The α-Toc and α-T3 contents in Japanese crude and refined RBO were considerably higher than those in the crude and refined RBO produced in other countries, whereas in contrast, γ-Toc and γ-T3 contents in Japanese crude and refined RBO were lower. Consequently, the ratios of total α-Toc and α-T3 contents to total γ-Toc and γ-T3 contents in Japanese crude and refined RBO (1.75 and 1.91, respectively) were notably higher than those in the crude and refined RBO produced in other countries. Similarly, the ratios of total Toc to total T3 in Japanese crude and refined RBO were higher than those in the crude and refined RBO produced in other countries. These results accordingly indicate that the ratio of total α-Toc and α-T3 contents to γ-Toc and γ-T3 contents could be used as an effective index to discriminate between the RBO produced in Japan and that produced in other countries.

Defatted Rice Bran as a Potential Raw Material to Improve the Nutritional and Functional Quality of Cakes.

Cakes are the most popular bakery items around the world because they are easy to consume and affordable. Their baking characteristics and consumers' healthy habits have driven the adoption of new ingredients and technologies to improve their functionality. This study aimed to develop cakes in which wheat flour was replaced by different amounts of defatted rice bran and to evaluate their physicochemical composition, nutritional and technological properties, and sensory profile. The use of defatted rice bran in cakes promoted an increase in fiber content, phenolic compounds and antioxidant capacity, besides decreasing their energy value. The formulation with 30% defatted rice bran exhibited high acceptance and 35% of the judges declared that they would consume the product at least once a week, if it could be found on the market. Results showed that defatted rice bran is a potential raw material that could be used in bakery products, as a cheap way to improve their nutritional quality without affecting consumer acceptability.

Dermatite associada ao consumo de farelo de arroz desengordurado em bovinos na região sul do Estado do Rio Grande do Sul / Dermatitis associated with the intake of defatted rice bran by cattle in the Southern region of the state of Rio Grande do Sul

Background: Dermatitis associated with defatted rice bran (DRB) seems to be an underdiagnosed disease in Brazilian confined herds, characterized by localized skin lesions that develop mainly on hind limbs, and can affect any animal category. In this context, the goal of the present study was to describe an outbreak of dermatitis associated with the consumption of defatted rice bran on a property in the State of Rio Grande do Sul, demonstrating the clinical, hematological and epidemiological characteristics of the animals, as well as alternatives for the definitive diagnosis. Cases: Clinical and epidemiological data were obtained by anamnesis with the technician responsible for the property. Aberdeen Angus and crossbred males, with 24 to 36 months of age, with an average of 413 kg, from a property in the interior of the state of Rio Grande do Sul were analyzed. From a batch of 45 cattle, from 24 to 36 months of age, 20 presented lesions on hind limbs 8-17 days after supplementation of a commercial feed containing defatted rice bran. To assist in the diagnosis, blood samples were drawn into vacuum tubes with 10% EDTA, for a complete blood count with the investigation of hemoparasites, and without anticoagulant, for liver function tests. In addition, lesion tissue samples were also collected for bacteriological, mycological and histopathological examination and the ration offered to the animals, for intradermal tests. There were no significant hematological and biochemical changes in animals that developed DRB dermatitis, except when they have an associated secondary infection. The fungal research was negative. The bacterial culture revealed a growth of Staphylococcus aureus, possibly due to secondary infection resulting from the lesions. In histopathological examination, lesions were characterized by areas of alopecia, thickening of the epidermis, forming dry, thick crusts, and some ulcerative and serosanguineous lesions. Histologically, lesions were characterized by marked hyperkeratosis, ulceration, and in the superficial dermis, intense inflammatory infiltrate of eosinophils and lymphocytes. Histologic changes, although not pathognomonic, are typically described in this disease. The intradermal test was performed to contribute to the diagnosis of the disease, where a significant increase in volume was found between measurements on animals that developed the disease. It is believed that the disease is produced due to a food hypersensitivity as a consequence of the high protein level in DRB. The results of the intradermal test indicate that the animals developed hypersensitivity and reaction to proteins, and further research is required to determine the protein fraction leading to hypersensitivity reactions. Discussion: In the present study, acute lesions in hind limbs in a significant number of animals of the same batch in a short period of time after supplementation with a diet containing defatted rice bran, enabled a clinical diagnosis suggestive of dermatitis associated with DRB consumption. Through epidemiological data, reactive intradermal test, associated with the findings of the histopathological exam, which showed characteristic lesions of the disease (alopecia, erythema, epidermis thickening, with the formation of thick crusts, usually on hind limbs in the region of the hoof coronary band, progressing to pastern and fetlock), it was possible to establish the clinical-pathological diagnosis of dermatitis associated with the consumption of defatted rice bran.

Avaliação do desempenho de oleogéis estruturados com ceras vegetais como base lipídica reduzida em ácidos graxos saturados aplicados em cream cheeses / Performance evaluation of structured oleogels with vegetable waxes as a reduced lipid base in saturated fatty acids applied in cream cheeses

Diante das exigências crescentes das agências regulatórias do mundo todo quanto à redução/eliminação de ácidos graxos trans nos alimentos industrializados, bem como da conscientização do consumidor sobre a relação entre alimentação e saúde, o desenvolvimento de alternativas mais saudáveis aos óleos parcialmente hidrogenados e a outras fontes lipídicas com alto grau de saturaçã o se faz necessário. O oleogel, um sistema composto por um óleo preso em uma rede tridimensional formada por um agente estruturante, se apresenta como uma solução promissora. Dentre os diversos agentes estruturantes, as ceras vegetais se destacam por sua excelente capacidade de gelificação de óleos. Contudo, apresentam uma desvantagem sob o aspecto sensorial, pois podem conferir cerosidade e sabor residual desagradável aos alimentos. Com o objetivo de viabilizar o uso das ceras como agentes estruturantes em oleogéis face ao seu excelente desempenho tecnológico, este projeto propõe o estudo e a aplicação de oleogéis à base de óleo de soja (SBO) estruturado com ceras de farelo de arroz (RBW) a 2 e 4 % (m/m) ou carnaúba (CBW) a 3 e 6% (m/m), isoladamente. As matérias-primas foram caracterizadas e o comportamento de gelificação de cada cera foi avaliado por análises de textura por penetração de cone, estabilidade à perda de óleo por centrifugação, energia coesiva por parâmetro de solubilidade de Hansen (HSP) e comportamento de cristalização e fusão por calorimetria exploratória diferencial (DSC). Os resultados mostraram que ambas as ceras são capazes de formar oleogéis estruturalmente estáveis, contudo, o oleogel com 2% de RBW apresentou maior firmeza a 20 °C (190,4 gf/cm2) do que o oleogel com 6% de CBW a 5 °C (186,1 gf/cm2). Ao final de 5 dias, a capacidade de retenção de óleo do oleogel preparado com RBW foi de 100% às concentrações de 2 e 4% (m/m), contra 61 e 99,3% do oleogel elaborado com CBW às concentrações de 3 e 6% (m/m), respectivamente. Esses resultados podem ser explicados pela diferença entre as energias coesivas, ou seja, do grau de interação molecular entre o solvente e o soluto de cada oleogel. De acordo com os resultados de distância, que prevê se o gel formado será forte, fraco ou se não haverá formação de gel, o soluto CBW apresentou menor interação com o óleo (3,3 MPa1/2) do que o soluto RBW (3,7 MPa1/2). Os oleogéis foram aplicados como ingredientes em diferentes formulações de cream cheese, que foram analisados quanto a diferentes parâmetros de textura e esses resultados foram comparados a uma referência comercial. Nenhuma das amostras produzidas obteve resultados de textura estatisticamente iguais aos do cream cheese comercial (CC), o que pode ser explicado pelas diferenças de formulação e processamento dos produtos. Face aos resultados para textura e estabilidade à perda de óleo dos oleogéis de RBW, este agente estruturante apresenta ria maior potencial de aplicação, porém o oleogel CBW6 obteve alta capacidade de retenção de óleo (99,3%) e quando aplicado na formulação de cream cheese (CCBW6) apresentou resultados de firmeza e espalhabilidade mais próximos da amostra de referência, feita com gordura do leite (CMF)

Given the growing demands of regulatory agencies around the world regarding the reduction/elimination of trans fatty acids in processed foods, as well as consumer awareness about the relationship between food and health, the development of healthier alternatives to partially hydrogenated oils and others lipid sources with a high degree of saturation are necessary. Oleogel, a system composed of an oil trapped in a three-dimensional network formed by a structuring agent, presents itself as a promising solution. Among the various structuring agents, vegetable waxes stand out for their excellent oil gelling capacity. However, they have a sensory disadvantage, as they can give waxy and unpleasant aftertaste to foods. Aiming at enabling the use of waxes as structuring agents in oleogels in view of their excellent technological performance, this study proposes the evaluation and application of oleogels based on soybean oil (SBO) structured with rice bran wax (RBW) at 2 and 4% (m/m) or carnauba (CBW) at 3 and 6% (m/m). The raw materials were characterized and the gelling behavior of each wax was evaluated by analysis of texture by cone penetration, stability to oil loss by centrifugation, cohesive energy by Hansen solubility parameter (HSP) and crystallization and melting behavior. by differential scanning calorimetry (DSC). The results showed that both waxes are able to form structurally stable oleogels, however, oleogel with 2% RBW showed greater firmness at 20 °C (190.4 gf/cm2) than oleogel with 6% CBW at 5° C (186.1 gf/cm2). At the end of 5 days, the oil retention capacity of oleogel prepared with RBW was 100% at concentrations of 2 and 4% (m/m), against 61 and 99.3% of oleogel prepared with CBW at concentrations of 3 and 6% (m/m), respectively. These results can be explained by the difference between the cohesive energies, that is, the degree of molecular interaction between the solvent and the solute of each oleogel. According to the distance results, which predicts if the formed gel will be strong, weak or if there will be no gel formation, the CBW solute showed less interaction with the oil (3.3 MPa1/2) than the RBW solute (3 ,7 MPa1/2). Oleogels were applied as ingredients in different cream cheese formulations, which were analyzed for different texture parameters and these results were compared to a commercial reference. None of the samples produced had texture results statistically equal to those of commercial cream cheese (CC), which can be explained by the differences in formulation and processing of the products. Given the results for texture and oil binding capacity of RBW oleogels, this structuring agent would present greater application potential, but CBW6 oleogel obtained high oil biding capacity (99.3%) and when applied in cream cheese formulation (CCBW6) showed firmness and spreadability results closer to the reference sample, made with milk fat (CMF)

Antioxidant, Angiotensin-Converting Enzyme Inhibitory Properties and Blood-Pressure-Lowering Effect of Rice Bran Protein Hydrolysates.

This research aimed to investigate the biological properties of different hydrolysates derived from industrial and laboratory defatted rice bran proteins. Industrial and laboratory defatted rice bran protein concentrates were hydrolyzed with alcalase or flavorzyme. The degree of hydrolysis (DH), oxygen radical absorbance capacity (ORAC), reducing power, total phenolic compounds (TPC), and angiotensin-converting enzyme (ACE) inhibitory activity, were determined in the hydrolysates and the molecular fractions lower than 3 kDa. Systolic blood pressure (SBP) was measured using the tail-cuff method before and after oral administration of 80 mg/kg of different rice bran protein hydrolysate (RBPH) fractions lower than 3 kDa in male spontaneously hypertensive rats (SHR) and normotensive Wistar-Kyoto (WKY) rats. The highest values of in vitro antioxidant activity and TPC were observed in RBPH with alcalase defatted by industry (RBPH2A), and, in all cases, these bioactivities were higher in the molecular fractions lower than 3 kDa. Once again, fractions lower than 3 kDa obtained with alcalase showed a potent ACE inhibitory activity (RBPH1A<3 and RBPH2A<3). The administration of RBPH1A<3 caused a significant decrease in the SBP in SHR, where the maximum decrease was reached at 8 h after administration. SBP in WKY rats was not modified after the administration of RBPH1A<3. These results suggest that the rice bran protein hydrolysates obtained from industry after treatment with alcalase could be an interesting source of bioactive peptides, with potential action on hypertension and other related pathologies.

Fermented and non-fermented whole rice bran in the production of the rotifer Brachionus plicatilis / Utilização do farelo de arroz com e sem fermentação na produção do rotífero Brachionus plicatilis

The objective of the present study was to evaluate the use of fermented and non-fermented whole rice bran for rotifer feeding, based on the effects on growth parameters, antioxidant and oxidative damage responses, and water quality. The study was based on three experiments, which compared the effect of different concentrations of non-fermented whole rice bran, the effect of different concentrations of fermented whole rice bran and the effect of the best concentrations of fermented and non-fermented whole rice bran, as well as the replacement of part of the baking yeast by rice bran. The results showed the best growth performances in treatments with 0.7 g yeast with 1.5 g fermented rice bran, 0.35 g yeast with 0.75 g whole rice bran, and 0.35 g yeast with 0.75 g fermented rice bran. Fermentation of rice bran for 6 hours did not induce oxidative stress in rotifers. This work revealed that the use of 1.5 g of fermented bran and replacement of 50% of yeast with fermented or non-fermented rice bran may be used for rotifer feeding, with the additional benefit of improving the environmental quality due to the lower amount of ammonia released in the water.(AU)

O objetivo do presente trabalho foi avaliar a utilização do farelo de arroz integral e fermentado na alimentação de rotíferos, baseado nos efeitos sobre os parâmetros de desempenho, respostas antioxidantes e de dano oxidativo, e qualidade de água. O estudo foi baseado em três experimentos, os quais compararam o efeito de diferentes concentrações de farelo de arroz integral na alimentação de rotíferos, o efeito de diferentes concentrações de farelo de arroz fermentado na alimentação de rotíferos e o efeito das melhores concentrações de farelo de arroz integral e fermentado, bem como a substituição de parte da levedura de panificação por esses farelos. Os resultados mostraram um melhor desempenho em crescimento nos tratamentos com 0,7 g de levedura, 1,5 g de farelo fermentado, 0,35 g de levedura + 0,75 g de farelo integral e 0,35 g de levedura +0,75 g de farelo fermentado. A fermentação do farelo de arroz por 6 horas não induziu estresse oxidativo nos rotíferos. Foi constatado que pode ser usado 1,5 g de farelo fermentado  e substituído 50% de levedura por farelo de arroz fermentado ou integral na alimentação de rotíferos, com a vantagem de apresentar melhor qualidade ambiental, devido a diminuição da amônia da água.(AU)

Feasibility of ultrasound-assisted optimized process of high purity rice bran protein extraction / Viabilidade do processo otimizado assistido por ultrassom para extração de proteína de farelo de arroz de alta pureza

Rice bran is a by-product of the rice milling process, found worldwide in abundance and highlighted due its protein content. This study optimized the conditions for ultrasonic-assisted extraction of protein from defatted rice bran (DRB) and characterized the rice bran protein concentrate (RBPC). A sequential strategy of experimental design was employed; the effect of pH, temperature, ultrasound exposure time, and amplitude were evaluated regarding the percentage of protein extraction by a Full factorial design (FFD) with a fixed frequencies (FFD-A: 37 kHz; FFD-B: 80 kHz). Subsequently, the percentage of protein extracted was optimized employing a Central composite rotatable design (variables: pH and ultrasound exposure time) and RBPC obtained was characterized regarding chemical and functional properties. The pH and ultrasound exposure time had positive effect (P 0.05) on percentage of protein extraction; moreover, 37 kHz frequency was more effective in protein extraction. The optimized condition (frequency: 37 kHz; temperature: 30 °C; pH: 10; ultrasound exposure time: 30 min; and amplitude: 100%) allowed 15.07% of protein recovery and the RBPC presented 84.76 g 100 g-1 of protein. Magnesium and copper were the main mineral in RBPC (34.4 and 25.5 µg g-1, respectively), while leucine was the limiting amino acid (0.42) and threonine presented the highest chemical score (1.0). The RBPC solubility was minimal at pH 4 and higher at pHs 6-10; the water and oil absorption capacity were higher than bovine serum albumin (BSA) and the emulsifying capacity was comparable to BSA, with a suitable stability. It was possible to obtain a higher purity RBPC than described in the literature, due to the optimization in the extraction process steps, with functional properties suitable for application in food products, especially emulsified ones.(AU)

O farelo de arroz é um subproduto do processo de moagem do arroz, encontrado em abundância em todo o mundo e destacado devido ao seu teor de proteínas. Este estudo otimizou as condições para a extração assistida por ultrassom da proteína do farelo de arroz desengordurado (DRB) e caracterizou o concentrado de proteína do farelo de arroz (RBPC). Uma estratégia sequencial de desenho experimental foi empregada; o efeito do pH, temperatura, tempo de exposição ao ultrassom e amplitude foram avaliados em relação à porcentagem de extração proteica por um Delineamento Fatorial Completo (FFD) com frequências fixas (FFD -A: 37 kHz; FFD-B: 80 kHz). Posteriormente, a porcentagem de proteína extraída foi otimizada empregando um Planejamento Composto Central (variáveis: pH e tempo de exposição ao ultrassom) e o RBPC obtido foi caracterizado quanto às propriedades químicas e funcionais. O pH e o tempo de exposição ao ultrassom tiveram efeito positivo (P 0,05) na porcentagem de extração proteica. Além disso, a frequência de 37 kHz foi mais eficaz na extração de proteínas. A condição otimizada (frequência: 37 kHz; temperatura: 30 °C; pH: 10; tempo de exposição ao ultrassom: 30 min; e amplitude: 100%) permitiu 15,07% de recuperação de proteínas e o RBPC apresentou 84,76 g 100 g-1 de proteína. Magnésio e cobre foram os principais minerais da RBPC (34,4 e 25,5 µg g-1, respectivamente), enquanto a leucina foi o aminoácido limitante (0,42) e a treonina apresentou o maior escore químico (1,0). A solubilidade do RBPC foi mínima em pH 4 e superior em pH 6-10; a capacidade de absorção de água e óleo foi maior que a albumina sérica bovina (BSA) e a capacidade de emulsificação foi comparável à BSA, com uma estabilidade adequada. Assim, foi possível obter um RBPC com elevada pureza, maior do que o descrito na literatura, devido à otimização nas etapas do processo de extração, com propriedades funcionais adequadas para aplicação em produtos alimentícios, principalmente emulsificados.(AU)

Fermented and non-fermented whole rice bran in the production of the rotifer Brachionus plicatilis / Utilização do farelo de arroz com e sem fermentação na produção do rotífero Brachionus plicatilis

The objective of the present study was to evaluate the use of fermented and non-fermented whole rice bran for rotifer feeding, based on the effects on growth parameters, antioxidant and oxidative damage responses, and water quality. The study was based on three experiments, which compared the effect of different concentrations of non-fermented whole rice bran, the effect of different concentrations of fermented whole rice bran and the effect of the best concentrations of fermented and non-fermented whole rice bran, as well as the replacement of part of the baking yeast by rice bran. The results showed the best growth performances in treatments with 0.7 g yeast with 1.5 g fermented rice bran, 0.35 g yeast with 0.75 g whole rice bran, and 0.35 g yeast with 0.75 g fermented rice bran. Fermentation of rice bran for 6 hours did not induce oxidative stress in rotifers. This work revealed that the use of 1.5 g of fermented bran and replacement of 50% of yeast with fermented or non-fermented rice bran may be used for rotifer feeding, with the additional benefit of improving the environmental quality due to the lower amount of ammonia released in the water.

O objetivo do presente trabalho foi avaliar a utilização do farelo de arroz integral e fermentado na alimentação de rotíferos, baseado nos efeitos sobre os parâmetros de desempenho, respostas antioxidantes e de dano oxidativo, e qualidade de água. O estudo foi baseado em três experimentos, os quais compararam o efeito de diferentes concentrações de farelo de arroz integral na alimentação de rotíferos, o efeito de diferentes concentrações de farelo de arroz fermentado na alimentação de rotíferos e o efeito das melhores concentrações de farelo de arroz integral e fermentado, bem como a substituição de parte da levedura de panificação por esses farelos. Os resultados mostraram um melhor desempenho em crescimento nos tratamentos com 0,7 g de levedura, 1,5 g de farelo fermentado, 0,35 g de levedura + 0,75 g de farelo integral e 0,35 g de levedura +0,75 g de farelo fermentado. A fermentação do farelo de arroz por 6 horas não induziu estresse oxidativo nos rotíferos. Foi constatado que pode ser usado 1,5 g de farelo fermentado  e substituído 50% de levedura por farelo de arroz fermentado ou integral na alimentação de rotíferos, com a vantagem de apresentar melhor qualidade ambiental, devido a diminuição da amônia da água.