Improvement of covalent immobilization procedure of ß-galactosidase from Kluyveromyces lactis for galactooligosaccharides production: Modeling and kinetic study.

Galactooligosaccharides (GOS) are prebiotics produced from lactose through an enzymatic reaction. Employing an immobilized enzyme may result in cost reductions; however, the changes in its kinetics due to immobilization has not been studied. This study experimentally determined the optimal reaction conditions for the production of GOS from lactose by ß-galactosidase (EC 3.2.1.23) from Kluyveromyces lactis covalently immobilized to a polysiloxane-polyvinyl alcohol (POS-PVA) polymer activated with glutaraldehyde (GA), and to study the transgalactosylation kinetics. Yield immobilization was 99 ± 1.1% with 78.5 ± 2.4% enzyme activity recovery. An experimental design 24 with 1 center point and 2 replicates was used. Factors were lactose [L], enzyme concentration [E], pH and temperature (T). Response variables were glucose and galactose as monosaccharides [G1], residual lactose [Lac]r and GOS as disaccharides [G2] and trisaccharides [G3]. Best conditions were pH 7.1, 40 °C, 270 gL-1 initial lactose concentration and 6 U mL-1 enzyme concentration, obtaining 25.46 ± 0.01 gL-1 yield of trisaccharides. Although below the HPLC-IR detection limit, tetrasaccharides were also identified after 115 min of reaction. The immobilization protocol was then optimized by diminishing total reactant volumes : support ratio, resulting in improved enzyme activity synthesizing 43.53 ± 0.02 gL-1 of trisaccharides and 13.79 ± 0.21 gL-1 of tetrasaccharides, and after four cycles remaining relative activity was 94%. A reaction mechanism was proposed through which a mathematical model was developed and rate constants were estimated, considering a pseudo steady-state hypothesis for two concomitant reactions, and from this simplified analysis, the reaction yield could eventually be improved. © 2017 American Institute of Chemical Engineers Biotechnol. Prog., 33:1568-1578, 2017.

The targeting of starch binding domains from starch synthase III to the cell wall alters cell wall composition and properties.

KEY MESSAGE: Starch binding domains of starch synthase III from Arabidopsis thaliana (SBD123) binds preferentially to cell wall polysaccharides rather than to starch in vitro. Transgenic plants overexpressing SBD123 in the cell wall are larger than wild type. Cell wall components are altered in transgenic plants. Transgenic plants are more susceptible to digestion than wild type and present higher released glucose content. Our results suggest that the transgenic plants have an advantage for the production of bioethanol in terms of saccharification of essential substrates. The plant cell wall, which represents a major source of biomass for biofuel production, is composed of cellulose, hemicelluloses, pectins and lignin. A potential biotechnological target for improving the production of biofuels is the modification of plant cell walls. This modification is achieved via several strategies, including, among others, altering biosynthetic pathways and modifying the associations and structures of various cell wall components. In this study, we modified the cell wall of A. thaliana by targeting the starch-binding domains of A. thaliana starch synthase III to this structure. The resulting transgenic plants (E8-SDB123) showed an increased biomass, higher levels of both fermentable sugars and hydrolyzed cellulose and altered cell wall properties such as higher laxity and degradability, which are valuable characteristics for the second-generation biofuels industry. The increased biomass and degradability phenotype of E8-SBD123 plants could be explained by the putative cell-wall loosening effect of the in tandem starch binding domains. Based on these results, our approach represents a promising biotechnological tool for reducing of biomass recalcitrance and therefore, the need for pretreatments.

Enzymatic synthesis of 2-aminoethyl ß-D-galactopyranoside catalyzed by Aspergillus oryzae ß-galactosidase.

Glycosidases provide a powerful resource for in vitro synthesis of novel anomerically pure glycosides. Generation of new low molecular weight galactosides is of interest since they are potential galectin inhibitors. Galectins are molecular targets for cancer therapy and thus their inhibitors are potential antitumor agents. Here we report the enzymatic synthesis and structural characterization of 2-aminoethyl ß-D-galactopyranoside. Critical parameters for transgalactosylation using either soluble or immobilized enzyme were investigated and optimized for the galactoside synthesis. We found that 0.2 M lactose, and 0.5 M 2-aminoethanol at 50 °C for 30 min were the optimal conditions for synthesis. 2-Aminoethanol proved to be an enzyme inhibitor, fitting a mixed inhibition model with inhibition constants, K(ic)=0.31±0.04 M and K(iu)=0.604±0.035 M.

Synthesis of galacto-oligosaccharides by ß-galactosidase from Aspergillus oryzae using partially dissolved and supersaturated solution of lactose.

The effect of enzyme to substrate ratio, initial lactose concentration and temperature has been studied for the kinetically controlled reaction of lactose transgalactosylation with Aspergillus oryzae ß-galactosidase, to produce prebiotic galacto-oligosaccharides (GOS). Enzyme to substrate ratio had no significant effect on maximum yield and specific productivity. Galacto-oligosaccharide syntheses at very high lactose concentrations (40, 50 and 60%, w/w, lactose monohydrate) were evaluated at different temperatures (40, 47.5 and 55°C). Within these ranges, lactose could be found as a supersaturated solution or a heterogeneous system with precipitated lactose, resulting in significant effect on GOS synthesis. An increase in initial lactose concentration produced a slight increase in maximum yield as long as lactose remained dissolved. Increase in temperature produced a slight decrease in maximum yield and an increase in specific productivity when supersaturation of lactose occurred during reaction. Highest yield of 29 g GOS/100 g lactose added was obtained at a lactose monohydrate initial concentration of 50% (w/w) and 47.5°C. Highest specific productivity of 0.38 g GOSh(-1) mg enzyme(-1) was obtained at lactose monohydrate initial concentration of 40% (w/w) and 55°C, where a maximum yield of 27 g GOS/100 g lactose added was reached. This reflects the complex interplay between temperature and initial lactose concentration on the reaction of synthesis. When lactose precipitation occurred, values of yields and specific productivities lower than 22 g GOS/100 g lactose added and 0.03 gGOSh(-1) mg enzyme(-1) were obtained, respectively.

Influence of water activity in the synthesis of galactooligosaccharides produced by a hyperthermophilic beta-glycosidase in an organic medium.

The present study evaluated the influence of water activity and lactose concentration on the synthesis of galactooligosaccharides (GOS), by means of a hyperthermophilic beta-glycosidase in an organic system. The production of GOS gradually grew as water activity increased in the reaction system; later, their synthesis decreased as water activity increased. The authors used the response surface methodology to study how different water activities and different concentrations of lactose influenced the synthesis of GOS and their length. In every case, the variable that proved to have the greatest effect on GOS synthesis was water activity. Maximum GOS3 synthesis was reached at a water activity interval of 0.44-0.57, with lactose concentrations of 0.06%-0.1%, while GOS4 and GOS5 maxima were reached at water activity intervals of 0.47-0.57 and 0.49-0.60, respectively. The research showed that higher water activity was required to synthesize GOS of greater length. Synthesis of GOS would then depend on the flexibility of the enzyme, which in turn would depend on water activity of the reaction system. This hypothesis was supported by experiments in which the reaction temperature was modified in order to change the flexibility of the enzyme, thus leading to longer GOS.

Enzymes involved in carbohydrate metabolism and their role on exopolysaccharide production in Streptococcus thermophilus.

The role of the enzymes uridine-5'-diphospho-(UDP) glucose pyrophosphorylase and UDP galactose 4-epimerase in exopolysaccharide production of Gal- ropy and non-ropy strains of Streptococcus thermophilus in a batch culture was investigated. Growth of the ropy and non-ropy strains was accompanied by total release of the galactose moiety from lactose hydrolysis in modified Bellinker broth with lactose as the only carbon source. This was associated with a greater exopolysaccharide production by the ropy strain. The polymer produced by both strains in cultures with lactose or glucose as carbon sources contained glucose, galactose and rhamnose, indicating that glucose was used as a carbon source for bacterial growth and for exopolysaccharide formation. UDP-glucose pyrophosphorylase activity was associated with polysaccharide production during the first 12 h in a 20 h culture in the ropy strain, but not in the non-ropy strain. UDP-galactose 4-epimerase was not associated with exopolysaccharide synthesis in any strain. The evidence presented suggests that the glucose moiety from lactose hydrolysis is the source of sugar for heteropolysaccharide synthesis, due to a high UDP-glucose pyrophosphorylase activity.