Analytical quality by design development of an ecologically acceptable enantioselective HPLC method for timolol maleate enantiomeric purity testing on ovomucoid chiral stationary phase.

Official method in Ph. Eur. for evaluation of timolol enantiomeric purity is normal-phase high performance liquid chromatography (NP-HPLC) method. Compared to other HPLC modes, NP is depicted as quite expensive with high consumption of organic solvents which leads to chronic exposure of analysts to toxic and carcinogenic effects. In order to overcome above-mentioned drawbacks, the aim of this study was to develop new method with better eco-friendly features. This was enabled by using protein type Chiral Stationary Phase (CSP) in reversed-phase mode that required up to 10 % (v/v) of organic solvent. Therefore, an enantioselective HPLC method was developed and validated for quantification of (S)-timolol and its chiral impurity, (R)-isomer. Optimized separation conditions on ovomucoid column were set using Analytical Quality by Design (AQbD) approach in method development. Optimization step was performed following the Box-Behnken experimental plan and the influence of three critical method parameters (CMPs) towards enantioseparation of the above-mentioned peak pair was examined. CMPs included variation of acetonitrile content in the mobile phase (5-10 %, v/v), pH value of the aqueous phase (6.0-7.0) and ammonium chloride concentration in the aqueous part of the mobile phase (10-30 mmol L-1). The most relevant critical method attributes (CMAs) in this case were the separation criterion between studied critical pair and retention factor of the second eluting peak, (S)-timolol. Qualitative Design Space (DS) was defined by Monte Carlo simulations providing adequate assurance of method's qualitative robustness (π = 95 %). The selected working point situated in the middle of the DS was characterized by following combination of CMPs: acetonitrile content in the mobile phase 7 % (v/v), pH value of the aqueous phase 6.8 and concentration of ammonium chloride in aqueous phase 14 mmol L-1. In the next step, the quantitative robustness was tested by Plackett-Burman experimental design. The validation studies confirmed adequacy of the proposed method for its intended purpose. Finally, Analytical Eco-Scale metric tool was applied to confirm that developed method represents excellent green analytical method compared to the official one.

Enantioseparation of Timolol on a Novel ß-Cyclodextrin Derivative Chiral Stationary Phase in HPLC.

A novel chiral stationary phase was prepared by bonding a novel ß-cyclodextrin derivative on silica gel, and it was used for the separation of timolol in high efficiency liquid phase. In the reverse mode, the factors such as the proportion of chiral additives, flow rate, column temperature, repeatability and stability were investigated. The optimum chromatographic conditions are as follows: column temperature was 25°C, flow rate was 0.6 mL min(-1) and mobile phase was methanol-25 mM KH2PO4 (80/20, v/v). The chiral column has good reproducibility (Rs = 4.49, 4.51 and 4.40, respectively) and a certain degree of stability (Rs = 4.49, 3.01 and 0.72, respectively). This chiral stationary phase presented good chiral recognition performance toward timolol with good resolution (Rs = 4.49).

Simultaneous determination of dorzolomide and timolol in aqueous humor: a novel salting out liquid-liquid microextraction combined with HPLC.

A Snovel method for the simultaneous separation and determination of two antiglaucoma drugs namely, dorzolamide hydrochloride (DOR) and timolol maleate (TIM) in aqueous humor samples (AH) was developed by using salting-out assisted liquid-liquid microextraction (SALLME) combined with HPLC-UV method. Box-Behnken experimental design and response surface methodology were employed to assist the optimization of SALLME conditions, including salt concentration, the pH of sample solution and vortex time as variable factors. The optimal extraction conditions were as follows: to 50 µL of AH sample, 100 µL of phosphate buffer (100 mmol L(-1), pH 11.9), 90 µL of acetonitrile (ACN) and 0.11 g of (NH4)2SO4 salt were added into an Eppendorf vial (1 mL) then vortexed for 1.1 min. As an effort to miniaturize SALLE system, a 1 mL syringe adapted with a capillary tube was employed as the phase separation device. Once the phase separation occurred, the upper layer could be narrowed into the capillary tube by pushing the plunger; thus, the collection of the upper layer solvent was simple and convenient. By miniaturization, the consumption of the organic solvent was decreased as low as possible. The chromatographic separation was achieved on Gemini C18 column using a mobile phase of ACN: 30 mmol L(-1) potassium dihydrogen phosphate buffer containing 0.1% triethylamine, pH 3.5 (20:80, v/v) at a flow rate of 1 mL min(-1) and UV detection at 254 and 295 nm for DOR and TIM, respectively. Mepivacaine hydrochloride was used as an internal standard. The described method showed better separation with enhanced sensitivities than the previously reported methods with limits of quantitation of 8.75 and 10.32 ng mL(-1) in aqueous solution and 15.97 and 23.53 ng mL(-1) in AH for DOR and TIM, respectively. The simple, rapid and eco-friendly SALLME-HPLC method has been successfully applied for the simultaneous pharmacokinetic studies of DOR and TIM in rabbit AH.

Effect of the nature of the single-isomer anionic CD and the BGE composition on the enantiomeric separation of beta-blockers in NACE.

The separation of ten beta-blockers has been investigated in NACE systems using heptakis(2,3-di-O-methyl-6-O-sulfo)-beta-CD (HDMS-beta-CD) and heptakis(2,3-di-O-acetyl-6-O-sulfo)-beta-CD (HDAS-beta-CD). The influence on enantioresolution, mobility difference and selectivity of the nature of both anionic CD and BGE anion as well as their concentrations were studied by means of a multivariate approach. A D-optimal design with 25 experimental points was applied. For all studied analytes, the enantiomeric resolution was shown to be significantly influenced by both CD nature and concentration. Except for two compounds, HDAS-beta-CD was found to give higher enantioresolution values than HDMS-beta-CD. The best enantioseparation for all compounds was achieved in the presence of a high chiral selector concentration and for most of them at a low BGE anion concentration. For each investigated compound, operating conditions leading to the best enantiomeric resolution were deduced. A generic NACE system was then recommended, namely 10 mM ammonium acetate and 40 mM HDAS-beta-CD in methanol acidified with 0.75 M formic acid. This generic system was able to completely resolve the enantiomers of all beta-blockers, with a R(s) value of at least 4. Finally, the optimal conditions obtained modelling resolution, mobility difference and selectivity were compared.

Nonaqueous capillary electrophoresis method for the enantiomeric purity determination of S-timolol using heptakis(2,3-di-O-methyl-6-O-sulfo)-beta-cyclodextrin: validation using the accuracy profile strategy and estimation of uncertainty.

Nonaqueous capillary electrophoresis (NACE) was successfully applied to the enantiomeric purity determination of S-timolol maleate using heptakis(2,3-di-O-methyl-6-O-sulfo)-beta-cyclodextrin (HDMS-beta-CD) as chiral selector. With a background electrolyte made up of a methanolic solution of 0.75 M formic acid, 30 mM potassium camphorsulfonate and containing 30 mM HDMS-beta-CD, the determination of 0.1% of R-timolol in S-timolol could be performed with an enantiomeric resolution of 8.5. Pyridoxine was selected as internal standard. The NACE method was then fully validated by applying a novel strategy using accuracy profiles. It is based on beta-expectation tolerance intervals for the total measurement error which includes trueness and intermediate precision. The uncertainty of measurements derived from beta-expectation tolerance intervals was estimated at each concentration level of the validation standards. To confirm the suitability of the developed and validated method, several real samples of S-timolol maleate containing R-timolol maleate at different concentrations were analysed and the results were compared to those obtained by liquid chromatography.

Nonequivalence behavior studies for the direct determination of enantiomeric purity and absolute configuration of timolol by NMR.

Direct determination of both the enantiomeric purity and absolute configuration of timolol was accomplished utilizing 1H NMR (400 MHz) spectroscopy with fast diamagnetic chiral solvating agent to dissimilarly perturb the spectra of enantiomeric solutes. Nonequivalence behavior was studied for all variables that affect populations and intrinsic spectra of the diastereomeric solvates. Optimization of the experimental conditions in terms of probe temperature, substrate concentration and solvating agent to substrate molar equivalents provided resolved enantiomeric signals suitable not only for chiral recognition but also for quantification. Enantiomeric impurity was determined on the basis of relative intensities of the tert-butyl methyl protons resonances; the assignment of enantiomeric configuration was based on the relative field positions of these resonances. The analysis of synthetic mixtures of the enantiomers by the proposed NMR method resulted in assay values which agreed closely with the known quantities of each enantiomer in mixtures tested. The mean +/-SD recovery values for the (R)-(+)-enantiomer was 100.0+/-1.6% of added antipode (n = 8). The optically pure enantiomers were used to establish the minimum detection limits of0.1%. The developed methodology represents a rapid and powerful tool for regulatory analysis.

Direct separation and optimization of timolol enantiomers on a cellulose tris-3,5-dimethylphenylcarbamate high-performance liquid chromatographic chiral stationary phase.

A high-performance liquid chromatographic method was developed for the direct resolution and optimization of the separation of timolol enantiomers. The method involves the use of a cellulose tris-3,5-dimethylphenylcarbamate chiral stationary phase (OD-Chiralcel) column. The effects of concentration of 2-propanol, various aliphatic alcohols and diethylamine in the mobile phase and column temperature on the retention and enantioselectivity of timolol enantiomers were studied. The maximum resolution factor obtained was 4.00 when using the solvent system hexane-2-propanol (95:5) containing 0.4% (v/v) diethylamine at 5 degrees C.