Production of Pleurotus sajor-caju crude enzyme broth and its applicability for the removal of bisphenol A.

Bisphenol A is an endocrine interfering compound, produced and used on a large scale worldwide. Chemical and biologic methods can be used to remove it from the environment. Biological methods are considered less costly, safer and, according to green chemistry definitions, an environmentally correct method. Considering the use of a crude enzyme broth, without any downstream process, the costs could be mostly reduced. Thus, the removal of bisphenol A by Pleurotus sajor-caju crude enzyme broth was investigated. Initially, the agro-industrial wastes were characterized and, the composition of the culture medium and the bioreactor culture conditions were defined. The enzyme produced in the highest concentration was characterized and the crude broth used in the bisphenol A removal assays. The OXI45 culture medium presented the highest laccase activity (1,850.7 U L-1, 350 rpm). Greater laccase stability was observed at 20 - 40 oC and pHs 5 - 7. Vanillin and ferulic acid (considered mediator compounds) were identified in the crude broth, probably helping on the obtention of the high value of removal effectiveness (0.052 mg U-1 h-1). The results indicate the potential use of the Pleurotus sajor-caju crude enzyme broth to obtain an enzymatic formulation for application in the environmental area.

The influence of Tween 80 on laccase production by Pleurotus sajor-caju and the efficiency of crude enzyme broth in the removal of bisphenol-A / Influência do Tween 80 na produção de lacases de Pleurotus sajor-caju e eficiência do caldo enzimático bruto na remoção de bisfenol-A

Bisphenol-A is currently considered an environmental pollutant, capable of interfering in the endocrine system of organisms and causing alterations in its development and reproductive system. An alternative method to the chemical treatment of this pollutant has been the use of oxidative enzymes, especially laccases produced by fungi. In order to reduce production costs, agro-industrial waste can be used in the culture medium composition. Nonionic surfactants, which are only slightly toxic to biological membranes, can be applied, as well as Tween 80, to facilitate the excretion of these enzymes into the culture medium. The objectives of this work were: a) characterize the immersion water of banana straw used in the formulation of the culture medium; b) evaluate laccase production by Pleurotus sajor-caju in culture medium with and without addition of Tween 80, through shaken flasks; c) evaluate the efficiency of the crude enzyme broth in degrading bisphenol-A. The shaken flasks were incubated at 30°C for 12 days. The immersion water had a C:N ratio of 13.8, ash percentage of 28.6%, and pH close to neutrality. The addition of Tween 80 on the culture medium (7.5%, m/v) yielded laccase activity and productivity values equal to 3,016.47 U L-1 and 502.7 U L-1 day-1, respectively. These values were 50 and 33.5 times higher than those obtained in the culture medium without addition of Tween 80 for laccase activity and productivity, respectively. The crude enzyme broth degraded 100% of bisphenol-A after 48 hours, regardless of concentration (500, 750 and 1,000 mg L-1).(AU)

O bisfenol-A é considerado um poluente ambiental capaz de interferir no sistema endócrino dos organismos, ocasionando alterações em seu desenvolvimento e sistema de reprodução. Um método alternativo ao tratamento químico desse tipo de poluente tem sido a utilização de enzimas oxidativas, especialmente as lacases, produzidas por fungos. A fim de diminuir custos de produção, resíduos agroindustriais podem compor o meio de cultivo. Assim, surfactantes não iônicos e pouco tóxicos para as membranas biológicas, como o Tween 80, podem ser utilizados para facilitar a excreção dessas enzimas para o meio de cultivo. Os objetivos deste trabalho foram: caracterizar quimicamente o resíduo água de imersão de palha de bananeira, usado na formulação do meio de cultivo; avaliar a produção de lacase por Pleurotus sajor-caju em meio de cultivo líquido (frascos Erlenmeyer) com e sem adição de Tween 80; e avaliar a eficiência do caldo enzimático bruto em degradar bisfenol-A. Os frascos foram incubados a 30°C, por 12 dias. A água de imersão apresentou relação C:N 13,8, percentual de cinzas 28,6% e pH próximo da neutralidade. O cultivo adicionado de Tween 80 (7,5%, m/v) propiciou valores de atividade e produtividade em lacase iguais a 3.016,47 U L-1 e 502,7 U L-1 dia-1, respectivamente. Esses valores são 50 e 33,5 vezes maiores que os obtidos no cultivo sem adição de Tween 80, para atividade e produtividade em lacase, respectivamente. O caldo enzimático bruto degradou 100% do bisfenol-A após 48 horas, independentemente da concentração (500, 750 e 1.000 mg L-1).(AU)

The influence of Tween 80 on laccase production by Pleurotus sajor-caju and the efficiency of crude enzyme broth in the removal of bisphenol-A / Influência do Tween 80 na produção de lacases de Pleurotus sajor-caju e eficiência do caldo enzimático bruto na remoção de bisfenol-A

Bisphenol-A is currently considered an environmental pollutant, capable of interfering in the endocrine system of organisms and causing alterations in its development and reproductive system. An alternative method to the chemical treatment of this pollutant has been the use of oxidative enzymes, especially laccases produced by fungi. In order to reduce production costs, agro-industrial waste can be used in the culture medium composition. Nonionic surfactants, which are only slightly toxic to biological membranes, can be applied, as well as Tween 80, to facilitate the excretion of these enzymes into the culture medium. The objectives of this work were: a) characterize the immersion water of banana straw used in the formulation of the culture medium; b) evaluate laccase production by Pleurotus sajor-caju in culture medium with and without addition of Tween 80, through shaken flasks; c) evaluate the efficiency of the crude enzyme broth in degrading bisphenol-A. The shaken flasks were incubated at 30°C for 12 days. The immersion water had a C:N ratio of 13.8, ash percentage of 28.6%, and pH close to neutrality. The addition of Tween 80 on the culture medium (7.5%, m/v) yielded laccase activity and productivity values equal to 3,016.47 U L-1 and 502.7 U L-1 day-1, respectively. These values were 50 and 33.5 times higher than those obtained in the culture medium without addition of Tween 80 for laccase activity and productivity, respectively. The crude enzyme broth degraded 100% of bisphenol-A after 48 hours, regardless of concentration (500, 750 and 1,000 mg L-1).(AU)

O bisfenol-A é considerado um poluente ambiental capaz de interferir no sistema endócrino dos organismos, ocasionando alterações em seu desenvolvimento e sistema de reprodução. Um método alternativo ao tratamento químico desse tipo de poluente tem sido a utilização de enzimas oxidativas, especialmente as lacases, produzidas por fungos. A fim de diminuir custos de produção, resíduos agroindustriais podem compor o meio de cultivo. Assim, surfactantes não iônicos e pouco tóxicos para as membranas biológicas, como o Tween 80, podem ser utilizados para facilitar a excreção dessas enzimas para o meio de cultivo. Os objetivos deste trabalho foram: caracterizar quimicamente o resíduo água de imersão de palha de bananeira, usado na formulação do meio de cultivo; avaliar a produção de lacase por Pleurotus sajor-caju em meio de cultivo líquido (frascos Erlenmeyer) com e sem adição de Tween 80; e avaliar a eficiência do caldo enzimático bruto em degradar bisfenol-A. Os frascos foram incubados a 30°C, por 12 dias. A água de imersão apresentou relação C:N 13,8, percentual de cinzas 28,6% e pH próximo da neutralidade. O cultivo adicionado de Tween 80 (7,5%, m/v) propiciou valores de atividade e produtividade em lacase iguais a 3.016,47 U L-1 e 502,7 U L-1 dia-1, respectivamente. Esses valores são 50 e 33,5 vezes maiores que os obtidos no cultivo sem adição de Tween 80, para atividade e produtividade em lacase, respectivamente. O caldo enzimático bruto degradou 100% do bisfenol-A após 48 horas, independentemente da concentração (500, 750 e 1.000 mg L-1).(AU)

A polysaccharide fraction extracted from Pleurotus ostreatus mycelial biomass inhibit Sarcoma 180 tumor.

Fungi of Pleurotus genus have attracted a great interest due to their medicinal properties such as anti-inflammatory, antimicrobial and antitumor. These properties are attributed mainly to polysaccharides synthesized by Pleurotus. This work aimed to study the mycelial growth of P. ostreatus in submerged culture, evaluating the influence of the initial concentration of substrate (20 and 40 g/L of glucose) and the pH (4 and 6) on kinetic parameters of production of biomass. The effectiveness of different doses (10, 30 and 50 mg/kg) of a mycelium polysaccharide fraction extracted from P. ostreatus in reducing Sarcoma 180 development in mice was also verified. In the range of this study, maximum concentration of mycelial biomass (about 12.8 g/L) was obtained using 40.0 g/L of glucose, at pH 4.0. The total biomass productivity (Px) was not significantly affected by substrate concentration and pH, reaching values of 0.034 g/L.h. Sarcoma 180 tumor weight was reduced in 74.1, 75.5 and 53.7% when 10, 30 and 50 mg/kg were administered, respectively. These results show the high antitumor potential of intracellular polysaccharide fraction of mycelial biomass of P. ostreatus, particularly at lower doses of 10 and 30 mg/kg.

A polysaccharide fraction extracted from Pleurotus ostreatus mycelial biomass inhibit Sarcoma 180 tumor

ABSTRACT Fungi of Pleurotus genus have attracted a great interest due to their medicinal properties such as anti-inflammatory, antimicrobial and antitumor. These properties are attributed mainly to polysaccharides synthesized by Pleurotus. This work aimed to study the mycelial growth of P. ostreatus in submerged culture, evaluating the influence of the initial concentration of substrate (20 and 40 g/L of glucose) and the pH (4 and 6) on kinetic parameters of production of biomass. The effectiveness of different doses (10, 30 and 50 mg/kg) of a mycelium polysaccharide fraction extracted from P. ostreatus in reducing Sarcoma 180 development in mice was also verified. In the range of this study, maximum concentration of mycelial biomass (about 12.8 g/L) was obtained using 40.0 g/L of glucose, at pH 4.0. The total biomass productivity (Px) was not significantly affected by substrate concentration and pH, reaching values of 0.034 g/L.h. Sarcoma 180 tumor weight was reduced in 74.1, 75.5 and 53.7% when 10, 30 and 50 mg/kg were administered, respectively. These results show the high antitumor potential of intracellular polysaccharide fraction of mycelial biomass of P. ostreatus, particularly at lower doses of 10 and 30 mg/kg.

Maintenance culture medium and inoculum based on peach palm leaves for Pleurotus spp. production / Meio de manutenção e inóculo a partir de folhas de pupunheira para a produção de Pleurotus spp

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.(AU)

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus , que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.(AU)

Maintenance culture medium and inoculum based on peach palm leaves for Pleurotus spp. production / Meio de manutenção e inóculo a partir de folhas de pupunheira para a produção de Pleurotus spp

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus, que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.

Maintenance culture medium and inoculum based on peach palm leaves for Pleurotus spp. production / Meio de manutenção e inóculo a partir de folhas de pupunheira para a produção de Pleurotus spp.

Este trabalho avaliou a utilização da água de imersão das folhas de pupunheira como componente do meio de cultivo para manutenção da cepa fúngica e a produção de inóculo de Pleurotus spp. utilizando como suporte folhas de pupunheira, um resíduo agrícola. Ainda, para verificar a capacidade do inóculo à base de folhas de pupunheira (FP) de produzir corpos frutíferos, foi realizado um experimento comparando FP com o inóculo à base de grãos de trigo (GT). Para tanto, realizou-se a comparação das velocidades de crescimento radial entre o meio de cultivo TDA (extrato de trigo, dextrose e ágar) utilizado para a manutenção de fungos do gênero Pleurotus e o meio FPDA (água de imersão de folhas de pupunheira, dextrose e ágar), e a comparação das velocidades de crescimento linear entre os grãos de trigo, utilizados como suporte para o inóculo de fungos do gênero Pleurotus e as folhas de pupunheira. O meio de cultivo TDA apresentou velocidade radial superior ao meio FPDA para as duas espécies, no entanto, o tipo de suporte não influenciou significativamente a velocidade de crescimento linear de P. ostreatus, que apresentou 6,71 mm/dia em grãos de trigo e 6,18 mm/dia em folhas de pupunheira. Assim, quando o inóculo à base de folhas de pupunheira é utilizado, a água de imersão deste suporte pode ser aproveitada para a confecção do meio de cultivo de manutenção (FPDA), diminuindo os custos produção. Observou-se que Pleurotus sajor-caju , quando cultivado em folhas de pupunheira utilizando inóculo FP, apresentou cerca de 47% de rendimento, 3% de eficiência biológica e 0,2 g/dia de produtividade, sem diferença significativa com o inóculo GT.(AU)

This study evaluated the use of immersion water from peach palm leaves (PPLDA) as a component of the culture medium for the maintenance of Pleurotus spp. and the use of agricultural waste, peach palm leaves, as inoculum support for the fungi. The performance of the inoculum based on peach palm leaves (PPL) for the production of Pleurotus spp. fruiting bodies was compared with that using wheat grains (WG) as inoculum support. PPLDA culture medium (immersion water of peach palm leaves, dextrose, and agar) showed a lower radial velocity of mycelial growth for both fungi than that obtained with the culture medium WDA (wheat extract, dextrose and agar), commonly used as maintenance medium for Pleurotus spp. However, the type of inoculum support does not significantly influence the linear velocity of P. ostreatus mycelial growth, reaching 6.71 mm/day on wheat grains and 6.18 mm/day on peach palm leaves. Thus, when the inoculum based on peach palm leaves is utilized, the immersion water used for preparing this support can be used for preparing the PPLDA maintenance culture medium, diminishing the production costs of Pleurotus mushrooms. Data also showed that when Pleurotus sajor-caju was cultivated on peach palm leaves, using PPL as inoculum support, the fruiting bodies production parameters (Y = 47%, BE = 3% and Pr = 0.2 g/day) did not differ from that obtained using WG.(AU)

Exopolysaccharide produced by Pleurotus sajor-caju: its chemical structure and anti-inflammatory activity.

Edible mushrooms are high nutritional value foods, which contain proteins, fibers, minerals, vitamins, and carbohydrates. Among their carbohydrates are some polysaccharides with recognized therapeutic effects. It was reported in this manuscript the structural characterization and antinociceptive and anti-inflammatory activities of an exopolysaccharide (EPS) produced by Pleurotus sajor-caju. The purified EPS was a mannogalactan (PEIsR), which was composed by mannose (37.0%), galactose (39.7%), and 3-O-methyl-galactose (23.3%). The polysaccharide was purified by freeze-thawing and dialysis, and it was characterized by GC-MS analysis and NMR spectroscopy. The mannogalactan is constituted by a main chain of (1 → 6)-linked α-D-Galp and 3-O-methyl-α-D-Galp units. Some of the α-D-Galp units were substituted at O-2 by non-reducing end units of ß-D-Manp. According to the literature review conducted, this is the first time that a methylated polysaccharide was observed on EPS of P. sajor-caju. The mannogalactan was able to reduce the nociception, in vivo, in the writhing and formalin tests and also reduced the carrageenan-induced paw edema, which indicates that it could be an effective antinociceptive and anti-inflammatory agent.

Structural characterization and anti-inflammatory activity of a linear ß-D-glucan isolated from Pleurotus sajor-caju.

Glucans comprise an important class of polysaccharides present in basidiomycetes with potential biological activities. A (1 → 3)-ß-D-glucan was isolated from Pleurotus sajor-caju via extraction with hot water followed by fractionation by freeze-thawing and finally by dimethyl sulfoxide extraction. The purified polysaccharide showed a (13)C-NMR spectrum with six signals consisting of a linear glucan with a ß-anomeric signal at 102.8 ppm and a signal at 86.1 ppm relative to O-3 substitution. The other signals at 76.2, 72.9, 68.3, and 60.8 ppm were attributed to C5, C2, C4, and C6, respectively. This structure was confirmed by methylation analysis, and HSQC studies. The ß-d-glucan from P. sajor-caju presented an immunomodulatory activity on THP-1 macrophages, inhibited the inflammatory phase of nociception induced by formalin in mice, and reduced the number of total leukocytes and myeloperoxidase levels induced by LPS. Taken together, these results demonstrate that this ß-d-glucan exhibits a significant anti-inflammatory activity.

Antitumor activity of Pleurotus ostreatus polysaccharide fractions on Ehrlich tumor and Sarcoma 180.

The medicinal properties of fungi of the genus Pleurotus have attracted great interest due to their therapeutic properties. Polysaccharides synthesized by Pleurotus, including the ß-glucans are considered the main responsible for its therapeutic properties. This study aimed to evaluate the efficacy of polysaccharidic fractions extracted from mycelial biomass of Pleurotus ostreatus DSM 1833 in inhibiting the development of Ehrlich Tumor (ET) and Sarcoma 180 (S-180). FC, FI and FII fractions provided 60.6, 76.5 and 73.6% of ET inhibition, respectively (mean value of about 70%) while FS, FIII-1 and FIII-2 showed no inhibition against ET. FII and FIII-2 resulted in 85.6 and 93.6% (mean value of about 90%) while FIII-1, FC and FS resulted in 54.1 and 0%, respectively, of S-180 inhibition. The yields of the fractions FS, FI, FII, FIII-1 and FIII-2 obtained from P. ostreatus mycelial biomass were 11.6, 1.3, 0.4, 0.65 and 0.35%, respectively. FII fraction (30mg/kg) apparently had no toxic effect on healthy animals, since no difference between the body weights of animals in substance control (SC) and negative control (NC) groups was observed.

Extracellular polysaccharide production by a strain of Pleurotus djamor isolated in the south of Brazil and antitumor activity on Sarcoma 180

Polysaccharides with medicinal properties can be obtained from fruiting bodies, mycelium and culture broth of several fungus species. This work was carried out in batch culture using a stirred tank reactor with two different initial glucose concentrations (40-50 g/L) and pH values (3.0-4.0) to enhance extracellular polysaccharides production by Pleurotus djamor UNIVILLE 001 and evaluate antitumor effect of intraperitonial administration of Pleurotus djamor extract on sarcoma 180 animal model. According to factorial design, the low pH value (pH 3.0) led to a gain of 1.6 g/L on the extracellular polysaccharide concentration, while glucose concentration in the tested range had no significant effect on the concentration of polysaccharide. With 40 g/L initial glucose concentration and pH 3.0, it was observed that yield factor of extracellular polysaccharide on substrate (Y P/S = 0.072) and maximum extracellular polysaccharide productivity (Q Pmax = 11.26 mg/L.h) were about 188% and 321% respectively higher than those obtained in the experiment performed at pH 4.0. Under these conditions, the highest values of the yield factor of biomass on substrate (Y X/S = 0.24) and maximal biomass productivity (Q Xmax = 32.2 mg/L.h) were also reached. In tumor response study, mean tumor volume on the 21th day was 35.3 cm³ in untreated group and 1.6 cm³ in treated group (p = 0.05) with a tumor inhibition rate of 94%. These impressive results suggests an inhibitory effect of P.djamor extract on cancer cells.

Production of bioactive compounds with antitumor activity against sarcoma 180 by Pleurotus sajor-caju.

This work studied the influence of culture medium composition and pH on exopolysaccharide (EPS) production by Pleurotus sajor-caju and validates the antitumor activity of the produced EPSs and of the mycelial biomass (intracellular polysaccharides [IPSs]) against Sarcoma 180 (S180) cells. The effect of the initial concentrations of (NH4)2SO4, yeast extract and soy peptone on EPS production by P. sajor-caju was studied in shake flasks. A bioreactor was used to evaluate the pH values and the initial CaCO3 and glucose concentrations. Extracts of EPSs (PE1) and IPSs obtained through two different separation processes (PM1 and PM2) were tested on mice inoculated with S180 cells. A medium containing 2.5, 1.0, and 1.0 g/L of (NH4)2SO4, yeast extract and soy peptone, respectively, provided the highest EPS concentration (0.6 g/L). The use of pH 4.0, 1.0 g/L CaCO3 and 20 g/L initial glucose concentration enhanced EPS productivity (3.84 g/L per hour). The PE1 extract promoted the highest reduction of S180 growth (86%), followed by the PM2 extract (80%); growth reduction was dose-independent for both substances. This work provides information about culture medium and conditions that enhanced the production of extracellular polysaccharides by P. sajor-caju. The results can contribute to the search for new bioactive products bringing novel aspects to the medical and pharmaceutical areas.

Extracellular polysaccharide production by a strain of Pleurotus djamor isolated in the south of Brazil and antitumor activity on Sarcoma 180.

Polysaccharides with medicinal properties can be obtained from fruiting bodies, mycelium and culture broth of several fungus species. This work was carried out in batch culture using a stirred tank reactor with two different initial glucose concentrations (40-50 g/L) and pH values (3.0-4.0) to enhance extracellular polysaccharides production by Pleurotus djamor UNIVILLE 001 and evaluate antitumor effect of intraperitonial administration of Pleurotus djamor extract on sarcoma 180 animal model. According to factorial design, the low pH value (pH 3.0) led to a gain of 1.6 g/L on the extracellular polysaccharide concentration, while glucose concentration in the tested range had no significant effect on the concentration of polysaccharide. With 40 g/L initial glucose concentration and pH 3.0, it was observed that yield factor of extracellular polysaccharide on substrate (YP/S = 0.072) and maximum extracellular polysaccharide productivity (Q(Pmax) = 11.26 mg/L.h) were about 188% and 321% respectively higher than those obtained in the experiment performed at pH 4.0. Under these conditions, the highest values of the yield factor of biomass on substrate (YX/S = 0.24) and maximal biomass productivity (Q(Xmax) = 32.2 mg/L.h) were also reached. In tumor response study, mean tumor volume on the 21th day was 35.3 cm(3) in untreated group and 1.6 cm(3) in treated group (p = 0.05) with a tumor inhibition rate of 94%. These impressive results suggests an inhibitory effect of P.djamor extract on cancer cells.

Extracellular polysaccharide production by a strain of Pleurotus djamor isolated in the south of Brazil and antitumor activity on Sarcoma 180

Polysaccharides with medicinal properties can be obtained from fruiting bodies, mycelium and culture broth of several fungus species. This work was carried out in batch culture using a stirred tank reactor with two different initial glucose concentrations (40-50 g/L) and pH values (3.0-4.0) to enhance extracellular polysaccharides production by Pleurotus djamor UNIVILLE 001 and evaluate antitumor effect of intraperitonial administration of Pleurotus djamor extract on sarcoma 180 animal model. According to factorial design, the low pH value (pH 3.0) led to a gain of 1.6 g/L on the extracellular polysaccharide concentration, while glucose concentration in the tested range had no significant effect on the concentration of polysaccharide. With 40 g/L initial glucose concentration and pH 3.0, it was observed that yield factor of extracellular polysaccharide on substrate (Y P/S = 0.072) and maximum extracellular polysaccharide productivity (Q Pmax = 11.26 mg/L.h) were about 188% and 321% respectively higher than those obtained in the experiment performed at pH 4.0. Under these conditions, the highest values of the yield factor of biomass on substrate (Y X/S = 0.24) and maximal biomass productivity (Q Xmax = 32.2 mg/L.h) were also reached. In tumor response study, mean tumor volume on the 21th day was 35.3 cm³ in untreated group and 1.6 cm³ in treated group (p = 0.05) with a tumor inhibition rate of 94%. These impressive results suggests an inhibitory effect of P.djamor extract on cancer cells.

Extracellular polysaccharide production by a strain of Pleurotus djamor isolated in the south of Brazil and antitumor activity on Sarcoma 180

Polysaccharides with medicinal properties can be obtained from fruiting bodies, mycelium and culture broth of several fungus species. This work was carried out in batch culture using a stirred tank reactor with two different initial glucose concentrations (40-50 g/L) and pH values (3.0-4.0) to enhance extracellular polysaccharides production by Pleurotus djamor UNIVILLE 001 and evaluate antitumor effect of intraperitonial administration of Pleurotus djamor extract on sarcoma 180 animal model. According to factorial design, the low pH value (pH 3.0) led to a gain of 1.6 g/L on the extracellular polysaccharide concentration, while glucose concentration in the tested range had no significant effect on the concentration of polysaccharide. With 40 g/L initial glucose concentration and pH 3.0, it was observed that yield factor of extracellular polysaccharide on substrate (Y P/S = 0.072) and maximum extracellular polysaccharide productivity (Q Pmax = 11.26 mg/L.h) were about 188% and 321% respectively higher than those obtained in the experiment performed at pH 4.0. Under these conditions, the highest values of the yield factor of biomass on substrate (Y X/S = 0.24) and maximal biomass productivity (Q Xmax = 32.2 mg/L.h) were also reached. In tumor response study, mean tumor volume on the 21th day was 35.3 cm³ in untreated group and 1.6 cm³ in treated group (p = 0.05) with a tumor inhibition rate of 94%. These impressive results suggests an inhibitory effect of P.djamor extract on cancer cells.

Production of bio-inseticide Bacillus thuringiensis var. israelensis in semicontinuous processes combined with batch processes for sporulation

The aim of this work was to study the production of the bioinsecticide using the aerobic cultivation. Two-stage cultivation process was used: aerobic vegetative growth and end-phase of sporulation (with aeration and without aeration). The cuts of working volume evaluated were 20, 40, 60 and 80 percent. The highest value of spore concentration (2.17x10(9) CFU/mL) and spore productivity (7.2x10(7) CFU/mL.h) were observed using SP60. The lethal concentration (CL50) obtained through the aeration process and non-aeration process were 0.21 and 0.05 mg/L, respectively. The specific potential of the bioinsecticide produced without aeration (0.025 mg/10-12 CFU) was two times higher than that obtained with aeration (0.05 mg/10-12 CFU).

Cultivation of Agaricus blazei on Pleurotus spp. spent substrate

The aim of this work was the use of Pleurotus ostreatus and Pleurotus sajor-caju for the previous lignocellulolytic decomposition of banana tree leaf straw and the further use of the degraded straw as substrate for the culture of Agaricus blazei. For optimising the production of A. blazei in terms of yield (Y percent) and biological efficiency (BE percent), adjustments to the composition of the substrate were evaluated in a 2(5) experimental design. The following components were tested in relation to percent of substrate dry mass: urea (1 and 10 percent), rice bran (10 or 20 percent) or ammonium sulphate (0 or 10 percent), inoculum (10 or 20 percent) and the casing material (subsoil or burned rice husks). The best results (79.71 Y percent and 6.73 BE percent) were found when the substrate containing 10 percent of rice bran, without ammonium sulphate, inoculated with 20 percent and covered with subsoil was used.

O cultivo de fungos comestíveis e medicinais utilizando resíduos da agroindústria vem se apresentando como uma alternativa econômica para o pequeno produtor rural, favorecendo a agricultura familiar do nordeste catarinense. Este trabalho avaliou o fungo Pleurotus para a decomposição lignocelulolítica de palha de folhas de bananeira e a utilização da palha residual como substrato para o cultivo de Agaricus blazei. Ajustes na composição do substrato residual de Pleurotus, tais como o tipo e a concentração da fonte de nitrogênio, a porcentagem de inóculo e a camada de cobertura, foram avaliadas. O substrato residual que mais favoreceu a produção de A. blazei em Eficiência Biológica (6,73 por cento), Rendimento (79,71 por cento) e menor tempo para emissão do primeiro primórdio (27 dias) foi o substrato residual de P. ostreatus inoculado com 20 por cento de inóculo (ms), 10 por cento de farelo de arroz (ms), sem sulfato de amônio e utilizando terra de subsolo como camada de cobertura.

Drying and rehydration of oyster mushroom

Dehydration and rehydration processes of Pleurotus ostreatus fruiting bodies were investigated in this work. Mushroom samples were dehydrated at 40, 50 and 60 ºC, using drying air with relative humidity of 75 percent. The rehydration was investigated at different temperatures of immersion water (25, 55 and 85 ºC) and different immersion times (30, 75 and 120 minutes). The best rehydration occurred for the samples dried at 40 ºC. The rehydration could be done in water at room temperature, during 30 minutes. Water sorption isotherms of samples were determined at 30, 40 and 50 ºC. Both GAB and BET models satisfactorily represented the experimental data of moisture sorption of dried mushrooms.

Processos de desidratação e de rehidratação de cogumelos da espécie Pleurotus ostreatus foram avaliados neste trabalho. Os cogumelos foram desidratados a 40, 50 e 60 ºC, com umidade relativa do ar de 75 por cento. O processo de rehidratação foi avaliado para diferentes temperaturas de água de imersão (25, 55 e 85 ºC) e diferentes tempos de imersão (30, 75 e 120 minutos). A melhor temperatura de secagem foi 40 ºC, levando em consideração a melhor rehidratação dos cogumelos desidratados nesta temperatura. A rehidratação pode ser feita em água a temperatura ambiente, por 30 minutos. Isotermas de sorção de umidade de amostras foram determinadas a 30, 40 e 50 ºC.Tanto o modelo de GAB quanto o de BET representaram satisfatoriamente os dados experimentais de isoterma de sorção de umidade.

Characterization and antineoplasic effect of extracts obtained from Pleurotus sajor-caju fruiting bodies.

Fungi of the Pleurotus genus present a great industrial interest due to their possibility of producing pharmacological compounds, pigments, aromas, organic acids, polysaccharides, enzymes, vitamins, amino acids, etc. Among the therapeutic products, we can highlight those with antineoplasic activity, attributed to the fungi cell wall components. Based on this, the objective of this work was to study the antineoplasic capacity of the polysaccharidic fractions obtained from Pleurotus sajor-caju fruiting bodies. Female Swiss mice were inoculated with the Ehrlich ascitic tumor (5 x 10(6) cells/animal) in ascitic form. The polysaccharidic fractions were administered intraperitoneally, during a 6-day period. Fractions FI and FII presented a lower volume of ascitic liquid (3.1 and 1.8 mL, respectively) and a higher reduction in the number of neoplasic cells present in the ascitic liquid (86.2% and 85%, respectively), when compared to the positive control (group inoculated with the tumor but without treatment). These fractions were characterized in terms of monosaccharide composition. Glucose was the major component detected, followed by galactose and mannose. The anomeric carbon configuration of the beta-glucan was confirmed by the (13)C NMR (delta 103.7). Substituted and free C3 and C6 were also detected. Protein bands were confirmed through infrared analysis.