Inhibition of Polyphosphate Degradation in Synechocystis sp. PCC6803 through Inactivation of the phoU Gene.

Phosphorus is an essential but non-renewable nutrient resource critical for agriculture. Luxury phosphorus uptake allows microalgae to synthesize polyphosphate and accumulate phosphorus, but, depending on the strain of algae, polyphosphate may be degraded within 4 hours of accumulation. We studied the recovery of phosphorus from wastewater through luxury uptake by an engineered strain of Synechocystis sp. with inhibited polyphosphate degradation and the effect of this engineered Synechocystis biomass on lettuce growth. First, a strain (ΔphoU) lacking the phoU gene, which encodes a negative regulator of environmental phosphate concentrations, was generated to inhibit polyphosphate degradation in cells. Polyphosphate concentrations in the phoU knock-out strain were maintained for 24 h and then decreased slowly. In contrast, polyphosphate concentrations in the wild-type strain increased up to 4 h and then decreased rapidly. In addition, polyphosphate concentration in the phoU knockout strain cultured in semi-permeable membrane bioreactors with artificial wastewater medium was 2.5 times higher than that in the wild type and decreased to only 16% after 48 h. The biomass of lettuce treated with the phoU knockout strain (0.157 mg P/m2) was 38% higher than that of the lettuce treated with the control group. These results indicate that treating lettuce with this microalgal biomass can be beneficial to crop growth. These results suggest that the use of polyphosphate-accumulating microalgae as biofertilizers may alleviate the effects of a diminishing phosphorous supply. These findings can be used as a basis for additional genetic engineering to increase intracellular polyphosphate levels.

Improvement of Lutein and Zeaxanthin Production in Mychonastes sp. 247 by Optimizing Light Intensity and Culture Salinity Conditions.

In this study, we sought to improve lutein and zeaxanthin production in Mychonastes sp. 247 and investigated the effect of environmental factors on lutein and zeaxanthin productivity in Mychonastes sp. The basic medium selection and N:P ratio were adjusted to maximize cell growth in one-stage culture, and lutein and zeaxanthin production conditions were optimized using a central composite design for two-stage culture. The maximum lutein production was observed at a light intensity of 60 µE/m2/s and salinity of 0.49%, and the maximum zeaxanthin production was observed at a light intensity of 532 µE/m2/s and salinity of 0.78%. Lutein and zeaxanthin production in the optimized medium increased by up to 2 and 2.6 folds, respectively, compared to that in the basic medium. Based on these results, we concluded that the optimal conditions for lutein and zeaxanthin production are different and that optimization of light intensity and culture salinity conditions may help increase carotenoid production. This study presents a useful and potential strategy for optimizing microalgal culture conditions to improve the productivity of lutein and zeaxanthin, which has applications in the functional food field.

Different Regulatory Modes of Synechocystis sp. PCC 6803 in Response to Photosynthesis Inhibitory Conditions.

Cyanobacteria are promising industrial platforms owing to their ability to produce diverse natural secondary metabolites and nonnative value-added biochemicals from CO2 and light. To fully utilize their industrial potency, it is critical to understand their photosynthetic efficiency under various environmental conditions. In this study, we elucidated the inhibitory mechanisms of photosynthesis under high-light and low-temperature stress conditions in the model cyanobacterium Synechocystis sp. PCC 6803. Under each stress condition, the transcript abundance and translation efficiency were measured using transcriptome sequencing (RNA-seq) and ribosome profiling, and the genome-wide transcription unit architecture was constructed by data integration of transcription start sites and transcript 3'-end positions obtained from differential RNA-seq and sequencing of 3'-ends (Term-seq), respectively. Our results suggested that the mode of photosynthesis inhibition differed between the two stress conditions; high light stress induced photodamage responses, while low temperature stress impaired the translation efficiency of photosynthesis-associated genes. In particular, poor translation of photosystem I resulted from ribosome stalling at the untranslated regions, affecting the overall photosynthetic yield under low temperature stress. Our comprehensive multiomics analysis with transcription unit architecture provides foundational information on photosynthesis for future industrial strain development. IMPORTANCE Cyanobacteria are a compelling biochemical production platform for their ability to propagate using light and atmospheric CO2 via photosynthesis. However, the engineering of strains is hampered by limited understanding of photosynthesis under diverse environmental conditions such as high-light and low-temperature stresses. Herein, we decipher the transcriptomic and translatomic responses of the photosynthetic efficiency to stress conditions using the integrative analysis of multiomic data generated by RNA-seq and ribosome profiling, respectively. Through the generated massive data, along with the guide of the genome-wide transcription unit architecture constructed by transcription start sites and transcript 3'-end positions, we identified the factors affecting photosynthesis at transcription, posttranscription, and translation levels. Importantly, the high-light stress induces photodamage responses, and the low-temperature stress cripples the translation efficiency of photosynthesis-associated genes. The resulting insights provide pivotal information for future cyanobacterial cell factories powered by the engineering toward robust photosynthesis ability.

Multi-Omic Analyses Reveal Habitat Adaptation of Marine Cyanobacterium Synechocystis sp. PCC 7338.

Cyanobacteria are considered as promising microbial cell factories producing a wide array of bio-products. Among them, Synechocystis sp. PCC 7338 has the advantage of growing in seawater, rather than requiring arable land or freshwater. Nonetheless, how this marine cyanobacterium grows under the high salt stress condition remains unknown. Here, we determined its complete genome sequence with the embedded regulatory elements and analyzed the transcriptional changes in response to a high-salt environment. Complete genome sequencing revealed a 3.70 mega base pair genome and three plasmids with a total of 3,589 genes annotated. Differential RNA-seq and Term-seq data aligned to the complete genome provided genome-wide information on genetic regulatory elements, including promoters, ribosome-binding sites, 5'- and 3'-untranslated regions, and terminators. Comparison with freshwater Synechocystis species revealed Synechocystis sp. PCC 7338 genome encodes additional genes, whose functions are related to ion channels to facilitate the adaptation to high salt and high osmotic pressure. Furthermore, a ferric uptake regulator binding motif was found in regulatory regions of various genes including SigF and the genes involved in energy metabolism, suggesting the iron-regulatory network is connected to not only the iron acquisition, but also response to high salt stress and photosynthesis. In addition, the transcriptomics analysis demonstrated a cyclic electron transport through photosystem I was actively used by the strain to satisfy the demand for ATP under high-salt environment. Our comprehensive analyses provide pivotal information to elucidate the genomic functions and regulations in Synechocystis sp. PCC 7338.

Photosynthetic production of biodiesel in Synechocystis sp. PCC6803 transformed with insect or plant fatty acid methyltransferase.

Biodiesel contains methyl or ethyl esters of long-chain fatty acids and has recently attracted increasing attention. Microalgae have emerged as a sustainable biodiesel production system owing to their photosynthetic potential. However, the conversion of microalgal biomass to biodiesel requires high energy and is costly. This study aimed to overcome the high cost of the pretreatment process by generating cyanobacteria converting fatty acids to fatty acids methyl ester (FAME) in vivo by introducing the fatty acid methyl ester transferase (FAMT) gene. Two FAMT genes from Drosophila melanogaster and Arabidopsis thaliana were selected and their codons were optimized for insertion in the Synechocystis sp. PCC6803 genome through homologous recombination, respectively. FAMT mRNA and protein expression levels were confirmed through reverse-transcription PCR and western blot analysis, respectively. Furthermore, heterologous expression of the FAMT genes yielded FAME, which was analyzed by gas chromatography. We found that FAMT transformants can be further metabolically optimized and applied for commercial production of biodiesel.

Enhanced Production of Photosynthetic Pigments and Various Metabolites and Lipids in the Cyanobacteria Synechocystis sp. PCC 7338 Culture in the Presence of Exogenous Glucose.

Synechocystis strains are cyanobacteria that can produce useful biomaterials for biofuel and pharmaceutical resources. In this study, the effects of exogenous glucose (5-mM) on cell growth, photosynthetic pigments, metabolites, and lipids in Synechocystis sp. PCC 7338 (referred to as Synechocystis 7338) were investigated. Exogenous glucose increased cell growth on days 9 and 18. The highest production (mg/L) of chlorophyll a (34.66), phycocyanin (84.94), allophycocyanin (34.28), and phycoerythrin (6.90) was observed on day 18 in Synechocystis 7338 culture under 5-mM glucose. Alterations in metabolic and lipidomic profiles under 5-mM glucose were investigated using gas chromatography-mass spectrometry (MS) and nanoelectrospray ionization-MS. The highest production (relative intensity/L) of aspartic acid, glutamic acid, glycerol-3-phosphate, linolenic acid, monogalactosyldiacylglycerol (MGDG) 16:0/18:1, MGDG 16:0/20:2, MGDG 18:1/18:2, neophytadiene, oleic acid, phosphatidylglycerol (PG) 16:0/16:0, and PG 16:0/17:2 was achieved on day 9. The highest production of pyroglutamic acid and sucrose was observed on day 18. We suggest that the addition of exogenous glucose to Synechocystis 7338 culture could be an efficient strategy for improving growth of cells and production of photosynthetic pigments, metabolites, and intact lipid species for industrial applications.

Enhanced lipid productivity in AGP knockout marine microalga Tetraselmis sp. using a DNA-free CRISPR-Cas9 RNP method.

A marine green microalga, Tetraselmis sp., has been studied for the production of biomass and lipids in seawater culture. Since carbohydrate and lipid biosynthesis are competitive metabolic pathways, we attempted to increase lipid synthesis in Tetraselmis by inhibiting carbohydrate synthesis. The main regulatory enzyme in the starch synthesis pathway is ADP-glucose pyrophosphorylase (AGP). AGP loss-of-function mutants were developed using the CRISPR-Cas9 ribonucleoprotein (RNP) delivery system. AGP mutants showed a slight decrease in growth. However, the lipid content in two AGP mutants was significantly enhanced by 2.7 and 3.1 fold (21.1% and 24.1% of DCW), respectively, compared to that in the wild type (7.68% of DCW) under nitrogen starvation. This study is an example of metabolic engineering by genetic editing using the CRISPR-Cas9 RNP method in marine green microalgae. Consequently, starchless Tetraselmis mutants might be considered potential producers of lipids in seawater cultures.

Isolation and genome analysis of Winogradskyella algicola sp. nov., the dominant bacterial species associated with the green alga Dunaliella tertiolecta.

Microalgae and bacteria are known to be closely associated in diverse environments. To isolate dominant bacterial species associated with a green alga, Dunaliella tertiolecta, a photoreactor culture of the microalga was investigated using culture-based and culture-independent approaches. The bacterial community structure of the algal culture showed that the most abundant bacterial species under the culture conditions was related to the genus Winogradskyella. The closely related amplicon sequences, showing ≥ 99.5% 16S rRNA gene sequence similarity to one of the isolates, designated IMCC-33238T, constituted > 49% of the bacterial community and was therefore regarded as the most dominant species in the algal culture. Strain IMCC33238T was characterized by Gramstaining-negative and orange-colored rods. Phylogenetic analyses of the 16S rRNA genes as well as whole genome sequences revealed that strain IMCC33238T belonged to Winogradskyella and shared more than 97.2% 16S rRNA gene sequence similarity with Winogradskyella species. The strain contained iso-C15:1 G, iso-C15:0, iso-C15:0 3-OH, and summed feature 3 (C16:1ω6c and/or C16:1ω7c) as major fatty acids and MK-6 as the predominant quinone. The polar lipids found in strain IMCC33238T were phosphatidylethanolamine, two unidentified aminolipids, and three unidentified lipids. The genome of strain IMCC33238T was 3.37 Mbp in size with 33.9 mol% G + C content and proteorhodopsin. Many genes encoding folate and vitamin production are considered to play an important role in the bacteria-algae interaction. On the basis of phylogenetic and phenotypic characteristics, strain IMCC33238T represents a novel species in the genus Winogradskyella, for which the name Winogradskyella algicola sp. nov. is proposed. The type strain is IMCC33238T (= KACC 21192T = NBRC 113704T).

Phycobiliproteins Production Enhancement and Lipidomic Alteration by Titanium Dioxide Nanoparticles in Synechocystis sp. PCC 6803 Culture.

This study aimed to improve the production of phycobiliproteins using TiO2 nanoparticles (NPs) in Synechocystis sp. PCC 6803. The growth characteristics of Synechocystis cells were not affected by TiO2 NPs treatment, but this treatment increased the chlorophyll content significantly by 62.2% (14.6 mg/L) compared to that of control (9.0 mg/L) on day 16. Phycocyanin production was increased by 33.8% (29.3 g/L) compared to that of control (21.9 g/L) on day 8. Allophycocyanin production was increased by 55.0% (6.2 g/L) compared to that of control (4.0 g/L) on day 8, and by 22.4% (16.4 g/L) compared to that of control (13.4 g/L) on day 16. Direct infusion mass spectrometry revealed that TiO2 NPs treatment significantly increased the levels of major thylakoid membranes of monogalactosyldiacylglycerols (18:2/18:3, 18:2/18:2, 18:1/18:2), phosphatidylglycerol (16:0/16:1), and sulfoquinovosyldiacylglycerols (16:0/16:1, 16:0:18:4) on day 8. These findings indicate that TiO2 NPs have potential for commercial applications in Synechocystis species or other microalgal strains.

Label-free non-invasive quantitative measurement of lipid contents in individual microalgal cells using refractive index tomography.

Microalgae are promising candidates for biofuel production due to their high lipid content. To facilitate utilization of the microalgae for biofuel, rapid quantification of the lipid contents in microalgae is necessary. However, conventional methods based on the chemical extraction of lipids require a time-consuming destructive extraction process. Here, we demonstrate label-free, non-invasive, rapid quantification of the lipid contents in individual micro-algal cells measuring the three-dimensional refractive index tomograms. We measure three-dimensional refractive index distributions within Nannochloropsis oculata cells and find that lipid droplets are identifiable in tomograms by their high refractive index. In addition, we alter N. oculata under nitrogen deficiency by measuring the volume, lipid weight, and dry cell weight of individual cells. Characterization of individual cells allows correlative analysis between the lipid content and size of individual cells.

Enhanced Production of Fatty Acids via Redirection of Carbon Flux in Marine Microalga Tetraselmis sp.

Lipids in microalgae are energy-rich compounds and considered as an attractive feedstock for biodiesel production. To redirect carbon flux from competing pathways to the fatty acid synthesis pathway of Tetraselmis sp., we used three types of chemical inhibitors that can block the starch synthesis pathway or photorespiration, under nitrogen-sufficient and nitrogen-deficient conditions. The starch synthesis pathway in chloroplasts and the cytosol can be inhibited by 3-(3,4-dichlorophenyl)-1,1-dimethylurea and 1,2-cyclohexane diamine tetraacetic acid (CDTA), respectively. Degradation of glycine into ammonia during photorespiration was blocked by aminooxyacetate (AOA) to maintain biomass concentration. Inhibition of starch synthesis pathways in the cytosol by CDTA increased fatty acid productivity by 27% under nitrogen deficiency, whereas the blocking of photorespiration in mitochondria by AOA was increased by 35% under nitrogen-sufficient conditions. The results of this study indicate that blocking starch or photorespiration pathways may redirect the carbon flux to fatty acid synthesis.

Genome-wide transcriptome analysis revealed organelle specific responses to temperature variations in algae.

Temperature is a critical environmental factor that affects microalgal growth. However, microalgal coping mechanisms for temperature variations are unclear. Here, we determined changes in transcriptome, total carbohydrate, total fatty acid methyl ester, and fatty acid composition of Tetraselmis sp. KCTC12432BP, a strain with a broad temperature tolerance range, to elucidate the tolerance mechanisms in response to large temperature variations. Owing to unavailability of genome sequence information, de novo transcriptome assembly coupled with BLAST analysis was performed using strand specific RNA-seq data. This resulted in 26,245 protein-coding transcripts, of which 83.7% could be annotated to putative functions. We identified more than 681 genes differentially expressed, suggesting an organelle-specific response to temperature variation. Among these, the genes related to the photosynthetic electron transfer chain, which are localized in the plastid thylakoid membrane, were upregulated at low temperature. However, the transcripts related to the electron transport chain and biosynthesis of phosphatidylethanolamine localized in mitochondria were upregulated at high temperature. These results show that the low energy uptake by repressed photosynthesis under low and high temperature conditions is compensated by different mechanisms, including photosystem I and mitochondrial oxidative phosphorylation, respectively. This study illustrates that microalgae tolerate different temperature conditions through organelle specific mechanisms.

Effect of Ethephon as an Ethylene-Releasing Compound on the Metabolic Profile of Chlorella vulgaris.

In this study, Chlorella vulgaris (C. vulgaris) was treated with ethephon at low (50 µM) and high (200 µM) concentrations in medium and harvested at 0, 7, and 14 days, respectively. The presence of ethephon led to significant metabolic changes in C. vulgaris, with significantly higher levels of α-tocopherol, γ-aminobutyric acid (GABA), asparagine, and proline, but lower levels of glycine, citrate, and galactose relative to control. Ethephon induced increases in saturated fatty acids but decreases in unsaturated fatty acids. The levels of highly saturated sulfoquinovosyldiacylglycerol species and palmitic acid bound phospholipids were increased on day 7 of ethephon treatment. Among the metabolites, the productivities of α-tocopherol (0.70 µg/L/day) and GABA (1.90 µg/L/day) were highest for 50 and 200 µM ethephon on day 7, respectively. We propose that ethephon treatment involves various metabolic processes in C. vulgaris and can be an efficient way to enrich the contents of α-tocopherol and GABA.

Development of a floating photobioreactor with internal partitions for efficient utilization of ocean wave into improved mass transfer and algal culture mixing.

Culturing microalgae in the ocean has potentials that may reduce the production cost and provide an option for an economic biofuel production from microalgae. The ocean holds great potentials for mass microalgal cultivation with its high specific heat, mixing energy from waves, and large cultivable area. Suitable photobioreactors (PBRs) that are capable of integrating marine energy into the culture systems need to be developed for the successful ocean cultivation. In this study, prototype floating PBRs were designed and constructed using transparent low-density polyethylene film for microalgal culture in the ocean. To improve the mixing efficiency, various types of internal partitions were introduced within PBRs. Three different types of internal partitions were evaluated for their effects on the mixing efficiency in terms of mass transfer (k(L)a) and mixing time in the PBRs. The partition type with the best mixing efficiency was selected, and the number of partitions was varied from one to three for investigation of its effect on mixing efficiency. When the number of partitions is increased, mass transfer increased in proportion to the number of partitions. However, mixing time was not directly related to the number of partitions. When a green microalga, Tetraselmis sp. was cultivated using PBRs with the selected partition under semi-continuous mode in the ocean, biomass and fatty acid productivities in the PBRs were increased by up to 50 % and 44% at high initial cell density, respectively, compared to non-partitioned ones. The results of internally partitioned PBRs demonstrated potentials for culturing microalgae by efficiently utilizing ocean wave energy into culture mixing in the ocean.

Elucidation of the growth delimitation of Dunaliella tertiolecta under nitrogen stress by integrating transcriptome and peptidome analysis.

Dunaliella tertiolecta LB 999 is an oleaginous microalgae species that produces large quantities of lipid and starch during nitrogen starvation; however, nitrogen starvation also limits the cell growth. In order to understand the underlying mechanisms of this phenomenon, the transcriptome and peptidome of D. tertiolecta LB 999 grown under different nitrogen and light conditions were analyzed. Integration of the de novo assembly of transcriptome sequencing reads with peptidome analysis revealed 13,861 protein-coding transcripts, including 33 transcripts whose expression patterns were significantly altered along with the growth phenotypes. Interestingly, 21 of these genes, which were highly enriched in the plastid region, were associated with chlorophyll synthesis and tetrahydrofolate-mediated C1 metabolism. Furthermore, intracellular glutamate levels are predicted to be the main factor that acts as a switch for the regulation of cell growth and carbon accumulation. These data provide the genetic information of D. tertiolecta for its future applications.

Comparative lipidomic profiling of two Dunaliella tertiolecta strains with different growth temperatures under nitrate-deficient conditions.

The metabolic changes that occur in Dunaliella tertiolecta upon exposure to low temperatures and nitrate deficiency were analyzed by exploring the fatty acid composition and lipid profile of two strains that were acclimated to different temperatures. The results indicate that the levels of linolenic acid (C18:3) and diacylglyceryl-N,N,N-trimethylhomoserine (DGTS) were significantly higher in the low-temperature (15 °C) strain (SCCAP K-0591) than in a strain grown at 21 °C (UTEX LB999). In addition, DGTS accumulated in LB999 under nitrate-deficient conditions, while the levels of most lipids, including DGTS, remained almost consistent in K-0591. The higher levels of DGTS in K-0591 suggest that DGTS could play a role in adaptation to low temperatures and nitrate deficiency in this organism. The results of this research could be applied to the development of new microalgal strains with tolerance of low temperature and nitrate deficiency by metabolic engineering targeted to DGTS species.

Effects of light intensity and nitrogen starvation on glycerolipid, glycerophospholipid, and carotenoid composition in Dunaliella tertiolecta culture.

Time-course variation of lipid and carotenoid production under high light (300 µE/m²s) and nitrogen starvation conditions was determined in a Dunaliella tertiolecta strain. Nanoelectrospray (nanoESI) chip based direct infusion was used for lipid analysis and ultra-performance liquid chromatography (UPLC) coupled with a photodiode array (PDA) or atmospheric chemical ionization mass spectrometry (APCI-MS) was used for carotenoid analysis. A total of 29 lipids and 7 carotenoids were detected. Alterations to diacylglyceryltrimethylhomoserine (DGTS) and digalactosyldiacylglycerol (DGDG) species were significant observations under stress conditions. Their role in relation to the regulation of photosynthesis under stress condition is discussed in this study. The total carotenoid content was decreased under stress conditions, while ã-carotene was increased under nitrate-deficient cultivation. The highest productivity of carotenoid was attained under high light and nitrate sufficiency (HLNS) condition, which result from the highest level of biomass under HLNS. When stress was induced at stationary phase, the substantial changes to the lipid composition occurred, and the higher carotenoid content and productivity were exhibited. This is the first report to investigate the variation of lipids, including glycerolipid, glycerophospholipid, and carotenoid in D. tertiolecta in response to stress conditions using lipidomics tools.

Carotenogenesis in Haematococcus lacustris: role of protein tyrosine phosphatases.

In the present study, we examined the inhibitory effects of protein tyrosine phosphatase (PTPase) inhibitors, including sodium orthovanadate (SOV), ammonium molybdate (AM), and iodoacetamide (IA), on cell growth, accumulation of astaxanthin, and PTPase activity in the photosynthetic algae Haematococcus lacustris. PTPase activity was assayed spectrophotometrically and was found to be inhibited 60% to 90% after treatment with the inhibitors. SOV markedly abolished PTPase activity, significantly activating the accumulation of astaxanthin. These data suggest that the accumulation of astaxanthin in H. lacustris results from the concerted actions of several PTPases.

Proteomics of proteins associated with astaxanthin accumulation in the green algae Haematococcus lacustris under the influence of sodium orthovanadate.

An extensive proteomics analysis has identified proteins associated with astaxanthin accumulation in the green algae Haematococcus lacustris under oxidative stress induced by sodium orthovanadate (SOV). Measurement of total carotenoid accumulation per cell biomass showed an increase from 81 to 136 pg/cell after being exposed to 2.5 mM SOV, when compared to the control cells at day 3 of cultivation. A total of 83 proteins were differentially expressed in SOV-treated H. lacustris in comparison with control cells. They consisted of 34 down-regulated and 49 up-regulated proteins. Of these, 17 highly-expressed proteins were analyzed by MALDI-TOF-MS to identify the function of the differentially expressed proteins in response to oxidative stress in H. lacustris.

Statistical optimization of the growth factors for Chaetoceros neogracile using fractional factorial design and central composite design.

Statistical experimental designs; involving (i) a fractional factorial design (FFD) and (ii) a central composite design (CCD) were applied to optimize the culture medium constituents for production of a unique antifreeze protein by the Antartic microalgae Chaetoceros neogracile. The results of the FFD suggested that NaCl, KCl, MgCl2, and Na2SiO3 were significant variables that highly influenced the growth rate and biomass production. The optimum culture medium for the production of an antifreeze protein from C. neogracile was found to be Kalleampersandrsquor;s artificial seawater, pH of 7.0ampersandplusmn;0.5, consisting of 28.566 g/l of NaCl, 3.887 g/l of MgCl2, 1.787 g/l of MgSO4, 1.308 g/l of CaSO4, 0.832 g/l of K2SO4, 0.124 g/l of CaCO3, 0.103 g/l of KBr, 0.0288 g/l of SrSO4, and 0.0282 g/l of H3BO3. The antifreeze activity significantly increased after cells were treated with cold shock (at -5oC) for 14 h. To the best of our knowledge, this is the first report demonstrating an antifreeze-like protein of C. neogracile.