Chemical composition of barley and co-products from barley, corn, and wheat produced in South-East Asia or Australia.

OBJECTIVE: A study was conducted to determine the chemical composition of barley and co-products from barley, corn, and wheat produced in South-East Asia or Australia, and to test the hypothesis that production area or production methods can impact the chemical composition of wheat co-products. METHODS: Samples included seven barley grains, two malt barley rootlets, one corn gluten feed, one corn gluten meal, one corn bran, eight wheat brans, one wheat mill mix, and four wheat pollards. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid hydrolyzed ether extract, ash, minerals, starch, and insoluble dietary fiber and soluble dietary fiber. Malt barley rootlets and wheat co-products were also analyzed for sugars. RESULTS: Chemical composition of barley, malt barley rootlets, and corn co-products were in general similar across countries. Wheat pollard had greater (p<0.05) concentrations of tryptophan, magnesium, and potassium compared with wheat bran, whereas wheat bran had greater (p<0.05) concentration of copper than wheat pollard. There were no differences in chemical composition between wheat bran produced in Australia and wheat bran produced in Thailand. CONCLUSION: Intact barley contains more starch, but fewer AA, than grain co-products. There were only few differences in the composition of wheat bran and wheat pollard, indicating that the two ingredients are similar, but with different names. However, corn gluten meal contains more protein and less fiber than corn bran.

Chemical composition of banana meal and rice bran from Australia or South-East Asia.

OBJECTIVE: A study was conducted to determine the chemical composition of banana meal and rice bran from Australia or South-East Asia and test the hypothesis that there are no differences in rice bran produced in different countries, but there are differences between full-fat and defatted rice bran. METHODS: Two sources of banana meal and 22 sources of rice bran (full-fat or defatted) from Australia or South-East Asia were used. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid hydrolyzed ether extract (AEE), ash, minerals, total starch, insoluble dietary fiber, and soluble dietary fiber. Banana meal was also analyzed for sugars including glucose, fructose, maltose, sucrose, stachyose, and raffinose. RESULTS: Chemical analysis demonstrated that banana meal from the Philippines is primarily composed of starch. Full-fat rice bran from Australia had greater (p<0.05) concentrations of AEE, lysine, and glycine than samples from the Philippines and Vietnam. Full-fat rice bran from Australia and Thailand had greater (p<0.05) concentrations of gross energy and most AA than rice bran from Vietnam. Full-fat rice bran from Australia had greater (p<0.05) concentrations of tryptophan and manganese than all other sources, but full-fat rice bran from the Philippines contained less (p<0.05) zinc than all other sources of rice bran. Gross energy, AEE, and copper were greater (p<0.05) in full-fat rice bran compared with defatted rice bran, but defatted rice bran contained more (p<0.05) crude protein, ash, insoluble dietary fiber, total dietary fiber, AA, and some minerals than full-fat rice bran. CONCLUSION: Banana meal is a high-energy source that can be used as an alternative ingredient in livestock diets. Full-fat rice bran from Australia and Thailand contained more concentrations of AEE and AA than samples from the Philippines or Vietnam. Full-fat rice bran had more gross energy and AEE than defatted rice bran, whereas defatted rice bran contained more crude protein, ash, and total dietary fiber.

Chemical composition of copra, palm kernel, and cashew co-products from South-East Asia and almond hulls from Australia.

OBJECTIVE: Oilseeds and nut co-products can be used as alternative feed ingredients in animal diets because they may have a lower cost than traditional ingredients. A study was, therefore, conducted to determine the chemical composition of copra, palm kernel, and nut coproducts from South-East Asia or Australia. The hypothesis that country of production influences nutritional composition was tested. METHODS: Oilseed meals included 2 copra expellers, 3 copra meals, and 12 palm kernel expellers. One source of almond hulls and cashew nut meal were also used. Samples were obtained from suppliers located in South-East Asia or Australia. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid-hydrolyzed ether extract (AEE), ash, minerals, insoluble dietary fiber, and soluble dietary fiber. Copra and nut coproducts were also analyzed for total starch and sugars. RESULTS: Copra expellers had greater (p<0.05) concentrations of dry matter and AEE compared with copra meal. However, copra meal had greater (p<0.05) concentrations of total dietary fiber (soluble and insoluble) and copper than copra expellers. Palm kernel expellers from Indonesia had greater (p<0.05) concentration of histidine and tyrosine compared with palm kernel expellers from Vietnam. Almond hulls was high in dietary fiber, but also contained free glucose and fructose, whereas cashew nut meal was high in AEE, but low in all free sugars. CONCLUSION: Copra expellers have greater concentration of AEE, but less concentration of total dietary fiber when compared with copra meal, and except for a few AA, no differences in nutrient composition of palm kernel expellers produced in Indonesia or Vietnam were detected. According to the chemical composition of nut co-products, cashew nut meal may be more suitable for non-ruminant diets than almond hulls.

Chemical composition of cassava-based feed ingredients from South-East Asia.

OBJECTIVE: Information about the chemical composition of cassava-based feed ingredients is needed to accurately formulate animal diets. A study was conducted to determine the chemical composition of cassava-based feed ingredients and to test the hypothesis that there is variation in chemical composition among cassava products originating from different South-East Asian countries. METHODS: Sources of dried peeled and unpeeled cassava roots, cassava chips, cassava meal, high-ash cassava meal, and cassava residue were used. All samples were analyzed for dry matter, gross energy, nitrogen, amino acids (AA), acid-hydrolyzed ether extract (AEE), ash, minerals, total starch, insoluble dietary fiber, and soluble dietary fiber. Samples of peeled and unpeeled cassava roots, cassava chips, and cassava meal were also analyzed for sugars. RESULTS: High-ash cassava meal had greater (p<0.05) dry matter and ash, but lower (p<0.05) total starch and gross energy than all other cassava products. Peeled cassava roots, unpeeled cassava roots, and cassava chips had greater (p<0.05) total starch than the other cassava-based ingredients. Cassava residue had greater (p<0.05) concentrations of lysine, insoluble dietary fiber, and soluble dietary fiber compared with the other cassava products, but tryptophan and glutamic acid were greater (p<0.05) in peeled cassava roots, cassava chips, and cassava meal samples compared with the other ingredients. Concentration of most minerals was greater (p<0.05) in high-ash cassava meal than in the other cassava products. CONCLUSION: Cassava-based ingredients sold as peeled roots, unpeeled roots, chips, or meal have chemical compositions that are not different from each other, and peeling has little impact on chemical composition. High-ash cassava meal has lower nutritional quality compared with other cassava products due to low starch and gross energy. The high fiber content in cassava residue makes this ingredient more suitable for ruminants and sows than for younger pigs or poultry.

Crystalline amino acids do not influence calculated values for standardized ileal digestibility of amino acids in feed ingredients included in diets for pigs.

An experiment was conducted to test the hypothesis that addition of crystalline amino acids (AA) to diets during the adaptation or collection periods will not influence calculated values for apparent ileal digestibility (AID) or standardized ileal digestibility (SID) of AA in corn and soybean meal (SBM). Seven ileal-cannulated barrows (initial body weight: 77.9 ± 2.6 kg) were allotted to a 7 × 7 Latin Square design with 7 dietary treatments and 7 periods. Dietary treatments included feeding diets based on corn or SBM without or with crystalline AA for the entire 7-d period or with crystalline AA during the adaptation period, but without crystalline AA during the collection period. An N-free diet was also used. Each experimental period consisted of 5 d of adaptation to the diets followed by 2 d of ileal digesta collection, with digesta being collected for 9 hr/d starting after feeding the morning meal. Thus, the entire experiment lasted 49 d. The AID and SID of crude protein (CP) and AA were calculated using values determined in corn or in SBM without or with crystalline AA to determine if crystalline AA influenced calculated values for AID or SID of CP and AA. Results indicated that addition of crystalline AA to diets fed during the entire 7-d period increased (P < 0.05) AID of some AA in corn and SBM. However, no differences in SID of CP and AA were observed between pigs fed the diets without crystalline AA and pigs fed the diets with crystalline AA if dietary crystalline AA were ignored in calculations of SID values. This indicates that crystalline AA were 100% absorbed before the distal ileum and did not affect calculated values for SID of AA if calculations were based only on the AA in corn or SBM. Therefore, it is concluded that crystalline AA may be added to experimental diets in digestibility experiments before and during collection periods without affecting results, if crystalline AA are disregarded in the calculation of AID or SID of AA in ingredients.

Structures and characteristics of carbohydrates in diets fed to pigs: a review.

The current paper reviews the content and variation of fiber fractions in feed ingredients commonly used in swine diets. Carbohydrates serve as the main source of energy in diets fed to pigs. Carbohydrates may be classified according to their degree of polymerization: monosaccharides, disaccharides, oligosaccharides, and polysaccharides. Digestible carbohydrates include sugars, digestible starch, and glycogen that may be digested by enzymes secreted in the gastrointestinal tract of the pig. Non-digestible carbohydrates, also known as fiber, may be fermented by microbial populations along the gastrointestinal tract to synthesize short-chain fatty acids that may be absorbed and metabolized by the pig. These non-digestible carbohydrates include two disaccharides, oligosaccharides, resistant starch, and non-starch polysaccharides. The concentration and structure of non-digestible carbohydrates in diets fed to pigs depend on the type of feed ingredients that are included in the mixed diet. Cellulose, arabinoxylans, and mixed linked ß-(1,3) (1,4)-d-glucans are the main cell wall polysaccharides in cereal grains, but vary in proportion and structure depending on the grain and tissue within the grain. Cell walls of oilseeds, oilseed meals, and pulse crops contain cellulose, pectic polysaccharides, lignin, and xyloglucans. Pulse crops and legumes also contain significant quantities of galacto-oligosaccharides including raffinose, stachyose, and verbascose. Overall, understanding the structure, characteristics and measurable chemical properties of fiber in feed ingredients may result in more accurate diet formulations, resulting in an improvement in the utilization of energy from less expensive high-fiber ingredients and a reduction in reliance on energy from more costly cereal grains.

Degradation of dietary fiber in the stomach, small intestine, and large intestine of growing pigs fed corn- or wheat-based diets without or with microbial xylanase.

An experiment was conducted to test the hypothesis that microbial xylanases may contribute to the degradation of fiber in wheat and wheat-based diets and in corn and corn-based diets along the intestinal tract of pigs. Twenty-four growing barrows (initial BW: 28.51 ± 1.86 kg) were prepared with a T-cannula in the proximal duodenum and another T-cannula in the distal ileum and allotted to a replicated 12 × 4 Youden square design with 12 diets and four 18-d periods. Two diets based on corn and soybean meal (SBM) or corn, SBM, and 30% distillers dried grains with solubles (DDGS) were formulated and two diets based on wheat and SBM or wheat, SBM, and 30% wheat middlings were also formulated. The four diets were formulated without microbial xylanase, or with one of two microbial xylanases (xylanase A or xylanase B) for a total of 12 diets. Feces and urine were collected on days 8 to 13, ileal digesta were collected on days 15 and 16, and duodenal digesta were collected on days 17 and 18 of each period. The apparent duodenal digestibility (ADD), apparent ileal digestibility (AID), and apparent total tract digestibility (ATTD) of GE, nutrients, and dietary fiber were calculated. Results indicated that the AID of GE in corn-SBM or wheat-SBM diets was greater (P < 0.05) than in the corn-SBM-DDGS and wheat-SBM-wheat middlings diets, but no difference was observed for the AID of dietary fiber between wheat-SBM and wheat-SBM-wheat middlings diets. The ATTD of dietary fiber was also greater (P < 0.05) in corn-SBM and wheat-SBM diets compared with corn-SBM-DDGS and wheat-SBM-wheat middlings diets, which indicates that the concentration of dietary fiber may influence the degree of fermentation of fiber. Inclusion of xylanase A or B improved (P < 0.05) the ADD and the ATTD of dietary fiber in wheat-based diets, indicating activity of xylanase in the gastro-intestinal tract of pigs. Inclusion of xylanase A improved (P < 0.05) the concentration of DE and ME in wheat-SBM-wheat middlings diets and xylanase B improved (P < 0.05) the concentration of DE in wheat-based diets and improved (P < 0.05) the concentration of the ME in wheat-SBM diet. In conclusion, the xylanases used in this experiment improved the digestibility of dietary fiber in the stomach and hindgut and improved the energy status of pigs fed wheat-based diets, but not of pigs fed corn-based diets.

Non-antibiotic feed additives in diets for pigs: A review.

A number of feed additives are marketed to assist in boosting the pigs' immune system, regulate gut microbiota, and reduce negative impacts of weaning and other environmental challenges. The most commonly used feed additives include acidifiers, zinc and copper, prebiotics, direct-fed microbials, yeast products, nucleotides, and plant extracts. Inclusion of pharmacological levels of zinc and copper, certain acidifiers, and several plant extracts have been reported to result in improved pig performance or improved immune function of pigs. It is also possible that use of prebiotics, direct-fed microbials, yeast, and nucleotides may have positive impacts on pig performance, but results have been less consistent and there is a need for more research in this area.

Digestible indispensable amino acid score (DIAAS) and protein digestibility corrected amino acid score (PDCAAS) in oat protein concentrate measured in 20- to 30-kilogram pigs.

BACKGROUND: Oat protein concentrate is often used in human food, but the quality of this protein has not been characterized. Therefore, the objectives of this experiment were to determine the standardized ileal digestibility (SID) of crude protein (CP) and amino acids (AA) in oat protein concentrate and to determine differences in protein quality estimates between the protein digestibility-corrected AA score (PDCAAS) and the digestible indispensable AA score (DIAAS) when using growing pigs for both measurements. RESULTS: For infants, the most limiting AA in oat protein concentrate was the aromatic AA (Phe + Tyr), for which the DIAAS value was 41 and the PDCAAS was 43. For children (6 months to 3 years) and children older than 3 years, the most limiting AA in oat protein concentrate was Lys, for which the DIAAS was 56 and 67 and the PDCAAS was 58 and 69, respectively. CONCLUSION: The DIAAS value for oat protein concentrate was close to the calculated value for PDCAAS, but below the recommended intake for protein. Therefore, to satisfy the daily human AA requirement, oat protein needs to be complemented by other proteins of higher quality and specifically with greater lysine concentrations. © 2017 Society of Chemical Industry.