Does the initial C/N ratio interfere with the performance of sewage sludge composting and cotton waste?

The effects of the initial C/N ratio on the composting of sewage sludge and cotton residues are not reported in the literature. Understanding the main composting control parameters is essential for the good stabilization of these wastes. Therefore, this study sought to evaluate different initial C/N ratios for the composting of sewage sludge and cotton waste, aiming to find the ranges with the best performance for the process and quality of the final organic compost. In this sense, five mixtures of sewage sludge (S) and cotton residues (C) were prepared and composted with three replications for each treatment in a completely randomized design. Physicochemical parameters were evaluated during composting and in the final organic compounds. A Multivariate Principal Component Analysis (PCA) was applied to evaluate the agronomic quality of organic compounds. The thermal behaviour of the mixtures presented differences. The treatments 90C10S, 80C20S and 67C33S showed the highest EXI² index (3566.64, 3448.39 and 2738.89), longer duration of thermophilic phase (12 and 13 days) and better potential for maximum degradation (A) of organic matter (67.5, 61.2 and 65.6%C). The final compounds of 90C10S and 80C20S showed higher pH values (7.9 and 7.5) and higher CEC (123.6 and 114.0 meq/100 g OM). PCA showed similarity in the agronomic quality of organic compounds for 90C10S, 80C20S and 67C33S. The treatment 28C72S (initial C/N ratio of 16.6) presented final pH of 5.3 and did not meet the minimum limit required by Brazilian regulations. Initial C/N relations between 24.9 and 35.2 showed better stabilization of waste and final organic compound with better agronomic quality.

Combining pre-treatment strategies for broilers industry waste valorization.

aiming at expanding the possibilities for broiler slaughter wastes valorization, composting piles were submitted, at different time points (T0, T10, T20, T30 and Control) representing the treatments, to a solid-liquid fraction separation (FS), after being submerged in water (2:1, water:compost, in the fresh weight). After FS, solid material separated with a strain was again placed in piles for the final stage of composting, being evaluated the organic composts obtained after the stabilization phase (65 days) and maturation (95 days), in the different treatments. Reductions in mass (60-62%) and volume (56-64%) were greater in piles submitted to FS in comparison to control piles (52% and 54%). On the other hand, the FS induced greater losses of C (70.3-71.3%), N (55-62%), P (41.7-54.4%) and K (62.3-72.1%) in comparison to the control (65.2%, 48.0%, 28.1%, and 37.6%, respectively). We conclude that, as a way of integrating bioprocesses, FS does not have negative effects on the composting process. Moreover, compost mixtures from FS-treated piles, when used as substrate, yield better seedlings in comparison to mixtures from control.

Semi-continuous anaerobic co-digestion of flotation sludge from broiler chicken slaughter and sweet potato: Nutrients and energy recovery.

Energy production based on the proper allocation of environmental liabilities is in line with the concept of sustainability. Flotation sludge (S) is a type of waste derived from the physical treatment of the wastewater generated in significant quantities during chicken slaughter in Brazil. If not treated, this wastewater may contribute to pollution, but further treatment provides clean energy and nutrient recycling. The present study aimed at evaluating the reduction of (S) organic load by means of mono and co-digestion with sweet potatoes (P) while promoting its conversion into energy (methane) and nutrients (digestate). Semi-continuous reactors (60 L capacity) were used with a hydraulic retention time of 25 days. The reactors were fed daily with 2.4 L consisting of 60% digestate recirculation, 40% non-chlorinated water and 4.5% total solids (TS). Using nine reactors and six progressive periods, eleven conditions were evaluated with three replicates each. The percentages of (P) and (S) varied from 0 to 100. The best observed condition in terms of energy recovery and TS removal was 60% of P + 40% of S (p ≤ 0.05), as it presented values of at least an increase of 92% in total biogas volume, an increase of 123% in specific methane production, an increase of 98% in specific methane yield and an increase of 44% in TS removal efficiency compared to mono-digestions. The fertilizer potential of the digestate generated in the different conditions was calculated and evaluated according to the area of (P) production. The results varied from 3.6 to 10.8 ha of (P) using 100 m3 of digestate. A multivariate analysis showed that higher amounts of (P) in substrate composition favor energy recycling while higher concentrations of (S) enhance the production of a digestate with valuable agronomic characteristics.