Development and evaluation of a novel dissolution apparatus for medicated chewing gum products.

A novel dissolution apparatus was developed for medicated chewing gum products. A prototype gum product containing phenylpropanolamine hydrochloride (PPA) was used to evaluate the apparatus. The apparatus consists of a conical Teflon base and a rotating, ribbed Teflon plunger suspended in a dissolution vessel. Parameters evaluated were rotation speed, plunger frequency, medium volume, medium type, medium sampling location, number of plunger ribs, and number of gum pieces. Samples were taken over a 20-min period and samples were analyzed by HPLC. Cumulative percentage released-versus-time profiles were obtained for each parameter evaluated. Statistical analysis of the gum product indicated that the only significant differences occurred at the lowest rotation speed and lowest plunger frequencies. A Level A correlation was found between the in vitro release profile for the 20-rpm and 30-cycles/min plunger frequency and the in vivo chew-out study.

Comparison of serum progesterone levels in dogs after administration of progesterone by vaginal tablet and vaginal suppositories.

Serum progesterone levels from a vaginal tablet formulation and six different vaginal suppository formulations, each containing 25 mg of progesterone, were evaluated in mongrel dogs. Bioavailabilities relative to an intravenous dose of progesterone were calculated. The vaginal tablet was found to have a significantly higher bioavailability compared with the vaginal suppositories.

An in vitro method of evaluating tolnaftate release from topical powder.

A dissolution apparatus was constructed to evaluate tolnaftate release from topical powders. It consisted of a mesh unit to support the powder, a receptor phase, and a sink. This report describes three parameters that were used to evaluate this technique. First, three different areas of contact were examined using 52-, 41-, or 30-µm mesh supports. Second, the effect of the pH on the dissolution rate was studied, using aqueous buffers of pH 3, 5, 7, or 8 as the receptor phase. Finally, different topical powder formulations containing different amounts of tolnaftate were tested. The results obtained showed that the percentage of tolnaftate released from topical powders increased at low pH levels and with the larger mesh support. The percentage released was greater in a starch-talc preparation than in a talc-only preparation. The mesh was replaced by a semipermeable membrane (2.5- to 4 nm pore size) to function as an in vitro model for intradermal diffusion. The results showed that a cream initially released more drug than powder formulations.

Development and evaluation of enteric-coated penicillamine tablets.

Commercially available 250-mg penicillamine tablets were converted into enteric-coated tablets. Based on in vitro dissolution and disintegration tests, tablets coated with five layers of a cellulose acetate phthalate formulation by a modified pan coating technique were judged to be superior to other coated tablets. These tablets resisted disintegration in simulated gastric fluid over a 4-h period and disintegrated in an average of 21 min in simulated intestinal fluid. Enteric-coated penicillamine tablets were tested in vivo in nine weanling pigs divided into three groups: a negative control group, a test group dosed with enteric-coated penicillamine tablets, and a positive control group dosed with uncoated tablets. The incidence of GI tract bleeding, as determined by daily occult blood tests of the stools, was significantly less in the animals receiving the enteric-coated tablets when compared with the positive control group. The enteric-coated dosage form appeared to decrease GI tract irritation caused by penicillamine. Plasma concentration-time curves for penicillamine in the pigs were similar in shape to those reported in humans. Atypical double peaks occur in both species. Relative bioavailability of the enteric-coated tablet was found to be 67% when compared with the uncoated tablet. This apparent reduction is probably due to a large intrasubject variation in areas under the plasma concentration-time curves and not to a dosage form effect.

Comparison of high-performance liquid chromatography and radioimmunoassay in the determination of content uniformity of digoxin tablets.

Digoxin 0.25-mg tablets were dissolved and assayed by the standard high-performance liquid chromatography (HPLC) method specified in USP XX and by a radioimmunoassay (RIA) method modified for the assay of tablet solutions. For the RIA method, the filtrate was diluted to a theoretical concentration of 5 ng/ml. Aliquots of this dilution were then assayed for digoxin content using a commercial digoxin 125I RIA kit. Results from both methods were extrapolated to total tablet content and compared with the labeled amount for 20 individual tablets. All tablet assay results were within the USP standards for content uniformity of individual tablets. The individual tablet deviations from labeled amount by the RIA method were smaller when compared with the USP XX-specified HPLC method. Comparison of individual tablet assays show the RIA method to be both as precise and as accurate as the USP XX-specified HPLC method.

Pharmacokinetic interactions of tolazamide and oxyphenbutazone in dogs.

The described pharmacokinetic analysis involved two separate studies on nine dogs randomly assigned to three groups of three dogs each. In the first study, the effect of varying the dosage of tolazamide was examined. The second study concerned the effect of varying the dosage of oxyphenbutazone on tolazamide. A 3 x 3 Latin square was used to study both effects. Each group received each treatment, with a minimum of 1 week separating each session. THe pharmacokinetics of tolazamide followed a two-compartment open model. The hybrid rate constants, alpha and beta, were not significantly different at the three dosages when measured by a three-way analysis of variance. The only significant difference at the three dosage levels of tolazamide was in the apparent volume of distribution. In the pharmacokinetic interaction associated with intravenous administration of one dose of tolazamide and three doses of oxyphenbutazone, the apparent volume of distribution and the hybrid rate constant alpha did not change significantly while the hybrid rate constant for tolazamide, beta, seemed to decrease with increasing oxyphenbutazone.

Effect of docusate sodium on drug release from a controlled-release dosage form.

This study was designed to determine the effect of a clinically used surfactant, docusate sodium, on the release of chlorpheniramine from a controlled-release dosage form (encapsulated coated pellets). In vivo treatments consisted of the controlled-release capsule alone or with 200 mg of docusate sodium. Plasma chlorpheniramine levels were determined, and the AUC was calculated. No significant difference in AUC values was observed between the two treatments. At a concentration below the CMC, docusate sodium enhanced the in vitro drug release rate. The surfactant exerted a greater effect on the release of the first one-third of the drug contained in nonwax-coated pellets. At the CMC, 0.02% (w/v), docusate sodium rapidly entrapped chlorpheniramine in micelles. The overall enhanced dissolution rate in vivo may have been offset by micellar drug entrapment.