Effect of heat treatment and milling on the seed, flour, rheology and baking quality of some amaranth ecotypes.

Forty-five harvests corresponding to the two predominating domestic species of amaranth in Mexico were studied. The proximate analysis revealed some statistically significant differences throughout three years of observation. The Ca, P and Fe content did not vary greatly in 15 samples. No chemical differences were either manifested in the Mercado and Aztec types of A. hypochondriacus, nor in the Mexican type of A. cruentus. The latter exhibits a higher grain yield and a shorter life cycle; however, its baking quality is apparently inferior to that of the Mercado type of A. hypochondriacus. The heat treatment of the seeds (toasting, popping and cooking) affected protein and lysine contents as does in cereals and leguminous seeds although toasting in particular improves its sensory characteristics without altering digestibility and PER. Popping only improves PER. Heating at 90 or 170 degrees C for three to five minutes, at the usual seed's moisture rate of 6 to 15%, does not affect protein content and does so only slightly in the case of the fatty acids content. Amylographic and farinographic values of the starchy fractions indicate similarities to C. quinoa and differences with respect to wheat. In the case of "amaranth milk", viscosity and gelatinization temperature produced satisfactory values. The extension of amaranth cultivation in the country is hereby suggested in view of the seed's nutritional quality, and considering the behavior of whole amaranth flour and its fractions.

Milling procedures and air classification of amaranth flours.

The different milling characteristics of Amaranthus cruentus, a domestic variety prevailing in Mexico, selected as representative sample, are herein discussed. This was subjected to proximate analysis, which confirmed its good quality. Milling trials were carried out for the preparation of whole flour by means of conventional mills and by combining some of these with the Raymond and Alpine separators for air classification. Results were then compared to those obtained with a Strong-Scott pearler. Grits and bran contained the highest protein concentration. After comparing overall results, it may be concluded that the best operating conditions are the following: a) seed pearling using five passes, in a pearler, with variable yields of approximately 22% containing 36% protein, and b) combining the Miag mill and Raymond air separator, with variable yields of approximately 32% and a protein content of 30-36%. Proximate analysis of the fractions as well as farinographic and amylographic characteristics--different from those of whole wheat and amaranth flours--suggest their use in the preparation of nutritionally-enriched food products.