Effect of a whey protein and rapeseed oil gel feed supplement on milk fatty acid composition of Holstein cows.

Isoenergetic replacement of dietary saturated fatty acids (SFA) with cis-monounsaturated fatty acids (MUFA) and polyunsaturated fatty acids (PUFA) can reduce cardiovascular disease risk. Supplementing dairy cow diets with plant oils lowers milk fat SFA concentrations. However, this feeding strategy can also increase milk fat trans fatty acids (FA) and negatively affect rumen fermentation. Protection of oil supplements from the rumen environment is therefore needed. In the present study a whey protein gel (WPG) of rapeseed oil (RO) was produced for feeding to dairy cows, in 2 experiments. In experiment 1, four multiparous Holstein-Friesian cows in mid-lactation were used in a change-over experiment, with 8-d treatment periods separated by a 5-d washout period. Total mixed ration diets containing 420 g of RO or WPG providing 420 g of RO were fed and the effects on milk production, composition, and FA concentration were measured. Experiment 2 involved 4 multiparous mid-lactation Holstein-Friesian cows in a 4 × 4 Latin square design experiment, with 28-d periods, to investigate the effect of incremental dietary inclusion (0, 271, 617, and 814 g/d supplemental oil) of WPG on milk production, composition, and FA concentration in the last week of each period. Whey protein gel had minimal effects on milk FA profile in experiment 1, but trans-18:1 and total trans-MUFA were higher after 8 d of supplementation with RO than with WPG. Incremental diet inclusion of WPG in experiment 2 resulted in linear increases in milk yield, cis- and trans-MUFA and PUFA, and linear decreases in SFA (from 73 to 58 g/100 g of FA) and milk fat concentration. The WPG supplement was effective at decreasing milk SFA concentration by replacement with MUFA and PUFA in experiment 2, but the increase in trans FA suggested that protection was incomplete.

Effect of blending Jersey and Holstein-Friesian milk on Cheddar cheese processing, composition, and quality.

The effect of Jersey milk use solely or at different inclusion rates in Holstein-Friesian milk on Cheddar cheese production was investigated. Cheese was produced every month over a year using nonstandardized milk consisting of 0, 25, 50, 75, and 100% Jersey milk in Holstein-Friesian milk in a 100-L vat. Actual, theoretical, and moisture-adjusted yield increased linearly with percentage of Jersey milk. This was also associated with increased fat and protein recoveries and lower yield of whey. The composition of whey was also affected by the percentage of Jersey milk, with lower whey protein and higher whey lactose and solids. Cutting time was lower when Jersey milk was used, but the cutting to milling time was higher because of slower acidity development. Hence, overall cheesemaking time was not affected by the use of Jersey milk. Using Jersey milk increased cheese fat content in autumn, winter, and spring and decreased cheese moisture in spring and summer. Cheese protein, salt, and pH levels were not affected. Cheese was analyzed for texture and color, and it was professionally graded at 3 and 8mo. The effect of Jersey on cheese sensory quality was an increase in cheese yellowness during summer and a higher total grading score at 3mo in winter; no other difference in cheese quality was found. The study indicates that using Jersey milk is a valid method of improving Cheddar cheese yield.

Short communication: Estimation of the financial benefit of using Jersey milk at different inclusion rates for Cheddar cheese production using partial budgeting.

Partial budgeting was used to estimate the net benefit of blending Jersey milk in Holstein-Friesian milk for Cheddar cheese production. Jersey milk increases Cheddar cheese yield. However, the cost of Jersey milk is also higher; thus, determining the balance of profitability is necessary, including consideration of seasonal effects. Input variables were based on a pilot plant experiment run from 2012 to 2013 and industry milk and cheese prices during this period. When Jersey milk was used at an increasing rate with Holstein-Friesian milk (25, 50, 75, and 100% Jersey milk), it resulted in an increase of average net profit of 3.41, 6.44, 8.57, and 11.18 pence per kilogram of milk, respectively, and this additional profit was constant throughout the year. Sensitivity analysis showed that the most influential input on additional profit was cheese yield, whereas cheese price and milk price had a small effect. The minimum increase in yield, which was necessary for the use of Jersey milk to be profitable, was 2.63, 7.28, 9.95, and 12.37% at 25, 50, 75, and 100% Jersey milk, respectively. Including Jersey milk did not affect the quantity of whey butter and powder produced. Although further research is needed to ascertain the amount of additional profit that would be found on a commercial scale, the results indicate that using Jersey milk for Cheddar cheese making would lead to an improvement in profit for the cheese makers, especially at higher inclusion rates.

Heat stability of milk supplemented with calcium chloride.

Calcium chloride (0-25 mM) was added to skim milk powder that was reconstituted to 9% total solids. Heat stability was evaluated between 60 and 120°C for different times by observing whether samples had coagulated, and by measuring the amount of sediment and residual protein in the centrifuged supernatant. Milk samples were also dialyzed during their respective heat treatments to recover the soluble phase at different temperatures to measure pH and ionic calcium. The transition conditions between good and poor heat stability were established for different calcium chloride concentrations and temperatures. As temperature increased, coagulation occurred at lower levels of added calcium chloride. The transition was quite distinct at higher temperatures but less so at lower temperatures; it was initiated by an increase in sediment formation before a firm coagulum was formed. Both pH and ionic calcium decreased in dialysates as temperature increased. No coagulation was observed if Ca(2+) was <0.5 mM and pH was >6.3 in dialysates taken at their respective coagulation temperatures. Being able to measure pH and ionic calcium at high temperatures will allow better understanding of factors affecting heat stability. Electrophoresis of the supernatants permitted identification of the protein fractions participating in the coagulation process. When coagulation was observed below 80°C, substantial amounts of undenatured ß-lactoglobulin and α-lactalbumin were found in the supernatant, as well as some soluble casein fractions. All the major whey protein and casein fractions were found in the sediment.

Comparison of heat stability of goat milk subjected to ultra-high temperature and in-container sterilization.

Goat milk with and without stabilizing salt was subjected to in-container and UHT sterilization. Heat stability was assessed by measuring the amount of sediment in the milk. Without stabilizing salts, goat milk usually produced less sediment when subjected to in-container sterilization compared with UHT processing. Addition of stabilizing salts up to 12.8mM resulted in a progressive increase in sediment for in-container sterilization. In contrast, adding stabilizing salts at 6.4mM initially reduced sediment formation in UHT-treated milk but addition of stabilizing salts at 12.8mM increased sediment formation. Adding stabilizing salts to goat milk increased pH, decreased ionic calcium, and increased ethanol stability. Adding up to 2mM calcium chloride increased sediment formation more after UHT treatment than after in-container sterilization. These results suggest that no single mechanism or set of reactions causes milk to produce sediment during heating and that the favored pathway is different for UHT and in-container sterilization processes. Poor heat stability could be induced both by increasing ionic calcium and by decreasing it. Ethanol stability is not a good indicator of heat stability for in-container sterilization, but it may be for UHT sterilization, if milk does not enter the region of poor heat stability found at low concentrations of ionic calcium.

Feasibility of using dialysis for determining calcium ion concentration and pH in calcium-fortified soymilk at high temperature.

Dialysis was performed to examine some of the properties of the soluble phase of calcium (Ca) fortified soymilk at high temperatures. Dialysates were obtained while heating soymilk at temperatures of 80 and 100 °C for 1 h and 121 °C for 15 min. It was found that the pH, total Ca, and ionic Ca of dialysates obtained at high temperature were all lower than in their corresponding nonheated Ca-fortified soymilk. Increasing temperature from 80 to 100 °C hardly affected Ca ion concentration ([Ca²âº]) of dialysate obtained from Ca chloride-fortified soymilk, but it increased [Ca²âº] in dialysates of Ca gluconate-fortified soymilk and Ca lactate-fortified soymilk fortified with 5 to 6 mM Ca. Dialysates obtained at 100 °C had lower pH than dialysate prepared at 80 °C. Higher Ca additions to soymilk caused a significant (P≤ 0.05) reduction in pH and an increase in [Ca²âº] of these dialysates. When soymilk was dialyzed at 121 °C, pH, total Ca, and ionic Ca were further reduced. Freezing point depression (FPD) of dialysates increased as temperature increased but were lower than corresponding soymilk samples. This approach provides a means of estimating pH and ionic Ca in soymilks at high temperatures, in order to better understand their combined role on soymilk coagulation.

Emulsifying, rheological and physicochemical properties of exopolysaccharide produced by Bifidobacterium longum subsp. infantis CCUG 52486 and Bifidobacterium infantis NCIMB 702205.

The rheological, emulsification and certain physicochemical properties of purified exopolysaccharides (EPS) of Bifidobacterium longum subsp. infantis CCUG 52486 and Bifidobacterium infantis NCIMB 702205 were studied and compared with those of guar gum and xanthan gum. The two strains were grown in skim milk supplemented with 1.5% (w/v) casein hydrolysate at 37 °C for 24h; they both produced heteropolysaccharides with different molecular mass and composition. The carbohydrate content of both polymers was more than 92% and no protein was detected. The EPS of B. longum subsp. infantis CCUG 52486 showed highly branched entangled porous structure under scanning electron microscopy. Higher intrinsic viscosity was observed for the EPS of B. longum subsp. infantis CCUG 52486 compared to the EPS of B. infantis NCIMB 702205 and guar gum. Both polymers showed pseudoplastic non-Newtonian fluid behaviour in an aqueous solution. The EPS of B. infantis NCIMB 702205 and B. longum subsp. infantis CCUG 52486 produced more stable emulsions with orange oil, sunflower seed oil, coconut oil and xylene compared to guar and xanthan gum. The EPS of B. longum subsp. infantis CCUG 52486 is the most promising one for applications in the food industry, as it had higher intrinsic viscosity, higher apparent viscosity in aqueous solution, porous dense entangled structure and good emulsification activity.

Measurement of ionic calcium, pH, and soluble divalent cations in milk at high temperature.

Dialysis and ultrafiltration were investigated as methods for measuring pH and ionic calcium and partitioning of divalent cations of milk at high temperatures. It was found that ionic calcium, pH, and total soluble divalent cations decreased as temperature increased between 20 and 80 degrees C in both dialysates and ultrafiltration permeates. Between 90 and 110 degrees C, ionic calcium and pH in dialysates continued to decrease as temperature increased, and the relationship between ionic calcium and temperature was linear. The permeabilities of hydrogen and calcium ions through the dialysis tubing were not changed after the tubing was sterilized for 1h at 120 degrees C. There were no significant differences in pH and ionic calcium between dialysates from raw milk and those from a range of heat-treated milks. The effects of calcium chloride addition on pH and ionic calcium were measured in milk at 20 degrees C and in dialysates collected at 110 degrees C. Heat coagulation at 110 degrees C occurred with addition of calcium chloride at 5.4mM, where pH and ionic calcium of the dialysate were 6.00 and 0.43mM, respectively. Corresponding values at 20 degrees C were pH 6.66 and 2.10mM.

Challenge testing the lactoperoxidase system against a range of bacteria using different activation agents.

Lactoperoxidase (LP) exerts antimicrobial effects in combination with H(2)O(2) and either thiocyanate (SCN(-)) or a halide (e.g., I(-)). Garlic extract in the presence of ethanol has also been used to activate the LP system. This study aimed to determine the effects of 3 LP activation systems (LP+SCN(-)+H(2)O(2); LP+I(-)+H(2)O(2); LP + garlic extract + ethanol) on the growth and activity of 3 test organisms (Staphylococcus aureus, Pseudomonas aeruginosa, and Bacillus cereus). Sterilized milk was used as the reaction medium, and the growth pattern of the organisms and a range of keeping quality (KQ) indicators (pH, titratable acidity, ethanol stability, clot on boiling) were monitored during storage at the respective optimum growth temperature for each organism. The LP+I(-)+ H(2)O(2) system reduced bacterial counts below the detection limit shortly after treatment for all 3 organisms, and no bacteria could be detected for the duration of the experiment (35 to 55 h). The KQ data confirmed that the milk remained unspoiled at the end of the experiments. The LP + garlic extract + ethanol system, on the other hand, had no effect on the growth or KQ with P. aeruginosa, but showed a small retardation of growth of the other 2 organisms, accompanied by small increases (5 to 10 h) in KQ. The effects of the LP+SCN(-)+H(2)O(2) system were intermediate between those of the other 2 systems and differed between organisms. With P. aeruginosa, the system exerted total inhibition within 10 h of incubation, but the bacteria regained viability after a further 5 h, following a logarithmic growth curve. This was reflected in the KQ indicators, which implied an extension of 15 h. With the other 2 bacterial species, LP+SCN(-)+H(2)O(2) exerted an obvious inhibitory effect, giving a lag phase in the growth curve of 5 to 10 h and KQ extension of 10 to 15 h. When used in combination, I(-) and SCN(-) displayed negative synergy.

Selective separation of the major whey proteins using ion exchange membranes.

Synthetic microporous membranes with functional groups covalently attached were used to selectively separate beta-lactoglobulin, BSA, and alpha-lactalbumin from rennet whey. The selectivity and membrane performance of strong (quaternary ammonium) and weak (diethylamine) ion-exchange membranes were studied using breakthrough curves, measurement of binding capacity, and protein composition of the elution fraction to determine the binding behavior of each membrane. When the weak and strong anion exchange membranes were saturated with whey, they were both selective primarily for beta-lactoglobulin with less than 1% of the eluate consisting of alpha-lactalbumin or BSA. The binding capacity of a pure beta-lactoglobulin solution was in excess of 1.5 mg/cm2 of membrane. This binding capacity was reduced to approximately 1.2 mg/cm2 when using a rennet whey solution (pH 6.4). This reduction in protein binding capacity can be explained by both the competitive effects of other whey proteins and the effect of ions present in whey. Using binary solution breakthrough curves and rennet whey breakthrough curves, it was shown that alpha-lactalbumin and BSA were displaced from the strong and weak anion exchange membranes by beta-lactoglobulin. Finally, the effect of ionic strength on the binding capacity of individual proteins for each membrane was determined by comparing model protein solutions in milk permeate (pH 6.4) and a 10 mM sodium phosphate buffer (pH 6.4). Binding capacities of beta-lactoglobulin, alpha-lactalbumin, and BSA in milk permeate were reduced by as much as 50%. This reduction in capacity coupled with the low binding capacity of current ion exchange membranes are 2 serious considerations for selectively separating complex and concentrated protein solutions.

Selenium supplementation of lactating dairy cows: effects on milk production and total selenium content and speciation in blood, milk and cheese.

Forty multiparous Holstein cows were used in a 16-week continuous design study to determine the effects of either selenium (Se) source, selenised yeast (SY) (derived from a specific strain of Saccharomyces cerevisiae CNCM I-3060) or sodium selenite (SS), or Se inclusion rate in the form of SY in the diets of lactating dairy cows on the Se concentration and speciation in blood, milk and cheese. Cows received ad libitum a total mixed ration (TMR) with a 1 : 1 forage : concentrate ratio on a dry matter (DM) basis. There were four diets (T1 to T4), which differed only in either source or dose of Se additive. Estimated total dietary Se for T1 (no supplement), T2 (SS), T3 (SY) and T4 (SY) was 0.16, 0.30, 0.30 and 0.45 mg/kg DM, respectively. Blood and milk samples were taken at 28-day intervals and at each time point there were positive linear effects of Se in the form of SY on the Se concentration in blood and milk. At day 112, blood and milk Se values for T1 to T4 were 177, 208, 248 and 279 ± 6.6 and 24, 38, 57 and 72 ± 3.7 ng/g fresh material, respectively, and indicate improved uptake and incorporation of Se from SY. In whole blood, selenocysteine (SeCys) was the main selenised amino acid and the concentration of selenomethionine (SeMet) increased with the increasing inclusion rate of SY. In milk, there were no marked treatment effects on the SeCys content, but Se source had a marked effect on the concentration of SeMet. At day 112, replacing SS (T2) with SY (T3) increased the SeMet concentration of milk from 36 to 111 ng Se/g and its concentration increased further to 157 ng Se/g dried sample as the inclusion rate of SY increased further (T4) to provide 0.45 mg Se/kg TMR. Neither Se source nor inclusion rate affected the keeping quality of milk. At day 112, milk from T1, T2 and T3 was made into a hard cheese and Se source had a marked effect on total Se and the concentration of total Se comprised as either SeMet or SeCys. Replacing SS (T2) with SY (T3) increased total Se, SeMet and SeCys content in cheese from 180 to 340 ng Se/g, 57 to 153 ng Se/g and 52 to 92 ng Se/g dried sample, respectively. The use of SY to produce food products with enhanced Se content as a means of meeting the Se requirements is discussed.

Effects of calcium chloride and sodium hexametaphosphate on certain chemical and physical properties of soymilk.

Soymilks with sodium hexametaphosphate (SHMP) (0% to 1.2%) and calcium chloride (12.50, 18.75, and 25.00 mM Ca) were analyzed for total Ca, Ca ion concentration, pH, kinematic viscosity, particle diameter, and sediment after pasteurization. Higher added Ca led to significant (P

Changes in physical properties of bovine milk from the colostrum period to early lactation.

The aim of this study was to analyze individual cows' samples from the colostrum, postcolostrum, and early lactation periods to investigate how milk composition, physical properties, stability, and suitability for processing change throughout this period. Attention was paid to the first week postpartum in which the composition of bovine mammary secretion can change markedly. Properties including pH, titratable acidity, ethanol stability (ES), rennet clotting time, and casein micelle size were analyzed, together with some compositional factors such as fat, total protein, lactose, total and ionic calcium, magnesium, citrate, phosphorus, sodium, and potassium. Total Ca (36.2 mM) and free ionic Ca (2.58 mM), Mg (5.9 mM), P (32.2 mM), and Na (24.1 mM) appeared to be high on d 5 postpartum, having decreased substantially over the first 5 d; they gradually decreased thereafter. The average pH on d 5 was only 6.49, compared with 6.64 at 1 mo postpartum. Stability measurements showed that the average ES on d 5 was 70% and the rennet clotting time was 12.2 min, which were significantly lower than values at later stages. A number of milk properties including ES, pH, protein content, and Ca2+ concentration could be useful for identifying the point of transition from colostrum to the early lactation period. Knowing the composition and physical properties of colostrum and postcolostrum secretions will help establish when such milk is suitable for processing and determine the best use for that milk.

In vitro study on gas generation and prebiotic effects of some carbohydrates and their mixtures.

This study was carried out to examine the effect of inulin (IN), fructooligosaccharide (FOS), polydextrose (POL) and isomaltooligosaccharides (ISO), alone and in combination, on gas production, gas composition and prebiotic effects. Static batch culture fermentation was performed with faecal samples from three healthy volunteers to study the volume and composition of gas generated and changes in bacterial populations. Four carbohydrates alone or mixed with one another (50:50) were examined. Prebiotic index (PI) was calculated and used to compare the prebiotic effect. The high amount of gas produced by IN was reduced by mixing it with FOS. No reduction in gas generation was observed when POL and ISO mixed with other substrates. It was found that the mixture of IN and FOS was effective in reducing the amount of gas produced while augmenting or maintaining their potential to support the growth of bifidobacteria in faecal batch culture as the highest PI was achieved with FOS alone and a mixture of FOS and IN. It was also found that high volume of gas was generated in presence of POL and ISO and they had lower prebiotic effect. The results of this study imply that a mixture of prebiotics could prove effective in reducing the amount of gas generated by the gut microflora.

Examination of the persistency of milk fatty acid composition responses to fish oil and sunflower oil in the diet of dairy cows.

Based on the potential benefits of cis-9, trans-11 conjugated linoleic acid (CLA) for human health, there is a need to develop effective strategies for enhancing milk fat CLA concentrations. Levels of cis-9, trans-11 CLA in milk can be increased by supplements of fish oil (FO) and sunflower oil (SO), but there is considerable variation in the response. Part of this variance may reflect time-dependent ruminal adaptations to high levels of lipid in the diet, which lead to alterations in the formation of specific biohydrogenation intermediates. To test this hypothesis, 16 late lactation Holstein-British Friesian cows were used in a repeated measures randomized block design to examine milk fatty acid composition responses to FO and SO in the diet over a 28-d period. Cows were allocated at random to corn silage-based rations (8 per treatment) containing 0 (control) or 45 g of oil supplement/kg of dry matter consisting (1:2; wt/wt) of FO and SO (FSO), and milk composition was determined on alternate days from d 1. Compared with the control, the FSO diet decreased mean dry matter intake (21.1 vs. 17.9 kg/d), milk fat (47.7 vs. 32.6 g/kg), and protein content (36.1 vs. 33.3 g/kg), but had no effect on milk yield (27.1 vs. 26.4 kg/d). Reductions in milk fat content relative to the FSO diet were associated with increases in milk trans-10 18:1, trans-10, cis-12 CLA, and trans-9, cis-11 CLA concentrations (r(2) = 0.74, 0.57, and 0.80, respectively). Compared with the control, the FSO diet reduced milk 4:0 to 18:0 and cis 18:1 content and increased trans 18:1, trans 18:2, cis-9, trans-11 CLA, 20:5 n-3, and 22:6 n-3 concentrations. The FSO diet caused a rapid elevation in milk cis-9, trans-11 CLA content, reaching a maximum of 5.37 g/100 g of fatty acids on d 5, but these increases were transient, declining to 2.35 g/100 g of fatty acids by d 15. They remained relatively constant thereafter. Even though concentrations of trans-11 18:1 followed the same pattern of temporal changes as cis-9, trans-11 CLA, the total trans 18:1 content of FSO milk was unchanged because of the concomitant increases in the concentration of other isomers (Delta(4-10) and Delta(12-15)), predominantely trans-10 18:1. In conclusion, supplementing diets with FSO enhances milk fat cis-9, trans-11 CLA content, but the high level of enrichment declines because of changes in ruminal biohydrogenation that result in trans-10 replacing trans-11 as the major 18:1 biohydrogenation intermediate formed in the rumen.

Chemical, physical, and sensory properties of dairy products enriched with conjugated linoleic acid.

Recent studies have illustrated the effects of cis-9,trans-11 conjugated linoleic acid (CLA) on human health. Ruminant-derived meat, milk and dairy products are the predominant sources of cis-9,trans-11 CLA in the human diet. This study evaluated the processing properties, texture, storage characteristics, and organoleptic properties of UHT milk, Caerphilly cheese, and butter produced from a milk enriched to a level of cis-9,trans-11 CLA that has been shown to have biological effects in humans. Forty-nine early-lactation Holstein-British Friesian cows were fed total mixed rations containing 0 (control) or 45 g/kg (on dry matter basis) of a mixture (1:2 wt/wt) of fish oil and sunflower oil during two consecutive 7-d periods to produce a control and CLA-enhanced milk, respectively. Milk produced from cows fed the control and fish and sunflower oil diets contained 0.54 and 4.68 g of total CLA/100 g of fatty acids, respectively. Enrichment of CLA in raw milk from the fish and sunflower oil diet was also accompanied by substantial increases in trans C18:1 levels, lowered C18:0, cis-C18:1, and total saturated fatty acid concentrations, and small increases in n-3 polyunsaturated fatty acid content. The CLA-enriched milk was used for the manufacture of UHT milk, butter, and cheese. Both the CLA-enhanced butter and cheese were less firm than control products. Although the sensory profiles of the CLA-enriched milk, butter, and cheese differed from those of the control products with respect to some attributes, the overall impression and flavor did not differ. In conclusion, it is feasible to produce CLA-enriched dairy products with acceptable storage and sensory characteristics.

Challenge testing of the lactoperoxidase system in pasteurized milk.

AIMS: To determine the role of lactoperoxidase (LP) in inhibiting the growth of micro-organisms in pasteurised milk. METHODS AND RESULTS: Four micro-organisms of importance in the spoilage of pasteurized milk were challenged in lactoperoxidase (LP)-enriched ultra-heat treated (UHT) milk after subsequent pasteurization. Milk samples were stored at the optimum temperatures for growth of the individual bacteria. Pasteurization was carried out at 72 degrees C/15 s and 80 degrees C/15 s to determine the effect of the LP system on the micro-organisms. An active LP system was found to greatly increase the keeping quality (KQ) of milks inoculated with Pseudomonas aeruginosa, Staphylococcus aureus and Streptococcus thermophilus and pasteurized at 72 degrees C, but had little or no effect in milks heated at 80 degrees C, presumably due to virtual inactivation of LP at 80 degrees C. However, pasteurization temperature had no effect on the KQ of milks challenged with Bacillus cereus spores. CONCLUSIONS: This study suggests that the LP system, rather than heat-shocking of spores, is responsible for the greater KQ of milk pasteurized at 72 degrees C/15 s compared with 80 degrees C/15 s. SIGNIFICANCE AND IMPACT OF THE STUDY: The study emphasizes the care required in selecting pasteurization temperatures in commercial practice and to avoid the temptation to compensate for inferior quality of raw milk by increasing pasteurization temperature.

The effect of nisin on the keeping quality of reduced heat-treated milks.

Milk was subjected to a combination process involving reduced heat treatment (RHT) of 117 degrees C for 2 s and nisin (75 and 150 IU ml(-1)). The microbial activity and other quality aspects were compared with a RHT control (without nisin) and with a ultrahigh temperature (UHT) milk processed at 142 degrees C for 2 s. Nisin was found to inhibit microbial growth for products stored without refrigeration, and RHT-nisin samples stored at 30 degrees C showed very low spoilage rates during 150 days, although not low enough to satisfy requirements for commercial sterility. RHT-nisin samples could be distinguished from and were preferred to the UHT control. Significant browning occurred during storage at 30 degrees C and above but was less in the RHT-nisin milk samples compared with the UHT milk. In RHT-nisin milk samples stored at 20 and 10 degrees C, no microbial activity could be detected in most samples after storage for 1 year. The effectiveness of this combination of RHT, nisin, and low storage temperatures against gram-positive spore-forming bacteria suggests potential for use of nisin in extended shelf life products.

Contribution of the lactoperoxidase system to the keeping quality of pasteurized milk.

The lactoperoxidase system is a naturally occurring antimicrobial system found in milk, with lactoperoxidase, thiocyanate and hydrogen peroxide as its components. The keeping quality of milk pasteurized at 72 degrees C for 15 s was found to be better than that of milk heated at 80 degrees C for 15 s. This agrees with previous findings and is usually attributed to heat shocking of spores. However, complete deactivation of lactoperoxidase occurred at 80 degrees C-15 s, whereas at 72 degrees C-15 s residual lactoperoxidase activity was approximately 70%, which may provide an alternative explanation. Higher levels of hypothiocyanite (the major antimicrobial agent produced by the lactoperoxidase system) were also detected in milk processed at 72 than at 80 degrees C, which supports the theory that the lactoperoxidase system has a role in the keeping quality of pasteurized milk. Of all the methods evaluated, titratable acidity and alcohol stability gave the most consistent estimates of keeping quality, while dissolved oxygen was a good indication of the onset of spoilage. Lactoperoxidase activity decreased with temperature more rapidly between 70 and 80 degrees C than is usual for an enzyme over a 10 deg C range.

The effect of electron beam irradiation, combined with acetic acid, on the survival and recovery of Escherichia coli and Lactobacillus curvatus.

The preservation of food by ionising radiation may lead to undesirable sensory changes within the food. These changes can be reduced by combining irradiation with other treatments, for example the addition of organic acids. Late exponential phase cultures of Escherichia coli and Lactobacillus curvatus were irradiated, in a liquid medium, at doses of 0-1.8 kilograys (kGy), in the presence of acetic acid (0-2%) at pH 4.6. A synergistic effect occurred when E. coli was irradiated in the presence of acetic acid (0.02-1.0%) at all doses used (0.145-1.1 kGy). There is evidence to suggest that membrane disruption occurred in the cells as a result of the combined treatments and this may account, to some extent, for the synergism observed. The addition of acetic acid up to a concentration of 2.0% had no effect upon the radiation survival or upon the subsequent growth of L. curvatus.