Potential Use of Supercharging Agents for Improved Mass Spectrometric Analysis of Monoclonal Antibodies and Antibody-Drug Conjugates.

The addition of supercharging (SC) reagents in electrospray ionization coupled mass spectrometry (ESI-MS) has demonstrated several advantages for protein analysis such as reduced required mass range of the instrument, narrowed charge-state distribution, increased sensitivity, and adduct suppression. The potential use of SC reagents to improve analyses of larger and complex protein molecules such as monoclonal antibodies and antibody-drug conjugates (ADCs) has not been previously reported. In this study, the effect of seven SC reagents (meta-nitrobenzyl alcohol (m-NBA), dimethyl sulfoxide (DMSO), ortho-nitroanisole (o-NA), propane sultone (PS), ethylene carbonate (EC), propylene carbonate (PC), and sulfolane) on ESI-MS acquired spectra of deglycosylated, intact, and reduced trastuzumab and a vcMMAE-trastuzumab ADC was investigated under denaturing conditions. The addition of any of the SC reagents resulted in a higher average charge state observed for all tested reagents for both trastuzumab and the ADC and a narrower charge-state envelope for o-NA and 1% sulfolane for trastuzumab. However, improved peak shapes or increased sensitivity was observed for several reagents, overall increasing the spectra quality. Finally, it was shown that SC reagents can be safely used for ADC analysis without impacting the obtained drug-to-antibody (DAR) values, as all DAR values were within 0.1 from the control sample.

Investigating the Impact of Sample Preparation on Mass Spectrometry-Based Drug-To-Antibody Ratio Determination for Cysteine- and Lysine-Linked Antibody-Drug Conjugates.

Antibody-drug conjugates (ADCs) are heterogeneous biotherapeutics and differ vastly in their physicochemical properties depending on their design. The number of small drug molecules covalently attached to each antibody molecule is commonly referred to as the drug-to-antibody ratio (DAR). Established analytical protocols for mass spectrometry (MS)-investigation of antibodies and ADCs often require sample treatment such as desalting or interchain disulfide bond reduction prior to analysis. Herein, the impact of the desalting and reduction steps-as well as the sample concentration and elapsed time between synthesis and analysis of DAR-values (as acquired by reversed phase liquid chromatography MS (RPLC-MS))-was investigated. It was found that the apparent DAR-values could fluctuate by up to 0.6 DAR units due to changes in the sample preparation workflow. For methods involving disulfide reduction by means of dithiothreitol (DTT), an acidic quench is recommended in order to increase DAR reliability. Furthermore, the addition of a desalting step was shown to benefit the ionization efficiencies in RPLC-MS. Finally, in the case of delayed analyses, samples can be stored at four degrees Celsius for up to one week but are better stored at -20 °C for longer periods of time. In conclusion, the results demonstrate that commonly used sample preparation procedures and storage conditions themselves may impact MS-derived DAR-values, which should be taken into account when evaluating analytical procedures.

Magnetic Beads for Desalting of Monoclonal Antibodies and Antibody-Drug Conjugates.

Characterization of antibody-drug conjugates (ADCs) using mass spectrometry (MS) is important in drug discovery and formulation development and as part of the quality control processes. To facilitate electrospray ionization (ESI) and produce high-quality mass spectra, common components of storage solutions for monoclonal antibodies (mAbs) and ADCs, such as nonvolatile phosphate-buffered saline (PBS), should be replaced before analysis. Centrifugal spin-type kits are extensively used for the desalting or buffer-exchange of mAbs and ADCs samples. The commercially available kits commonly require at least 100 µL of a sample at 1 mg/mL for optimal recovery. However, most ESI-MS based analyses require no more than 25 µg of protein for triplicate injection. In this study, we present a novel method for desalting of ADCs and mAbs building on the SP3 approach with nonfunctionalized carboxylate coated magnetic beads without affinity ligands. The analytes bind to the hydrophilic beads upon the addition of organic solvent, and various solutions of volatile salts or acids can be used in the elution step. The optimized protocol allowed for 88% recovery of ADC at a 25 µL sample volume and 90% recovery at 100 µL. More than 90% of the salts were removed using a process of 20 min. The intra- and interday precision showed little variation with an RSD of 1% and 2%, respectively. The compatibility of this new workflow with low sample volumes is highly valuable since a smaller fraction of the sample is wasted for analysis of the expensive analytes, without compromising recovery.

Application of triple quadrupole mass spectrometry for the characterization of antibody-drug conjugates.

Antibody-drug conjugates (ADCs) are an inherently heterogeneous class of biotherapeutics, the development of which requires extensive characterization throughout. During the earliest phases of preclinical development, when synthetic routes towards the desired conjugate are being assessed, the main interest lies in the determination of the average drug-to-antibody ratio (DAR) of a given batch as well as information about different conjugation species. There has been a trend in mass spectrometry (MS)-based characterization of ADCs towards the use of high-resolving mass spectrometry for many of these analyses. Considering the high cost for such an instrument, the evaluation of cheaper and more accessible alternatives is highly motivated. We have therefore tested the applicability of a quadrupole mass analyzer for the aforementioned characterizations. Eight ADCs consisting of trastuzumab and varying stoichiometries of Mc-Val-Cit-PABC-monomethyl auristatin E conjugated to native cysteines were synthesized and served as test analytes. The average DAR value and molecular weights (Mw) of all detected chains from the quadrupole mass analyzer showed surprisingly high agreement with results obtained from a time-of-flight (TOF) mass analyzer and hydrophobic interaction chromatography (HIC)-derived values for all investigated ADC batches. Acquired Mw were within 80 ppm of TOF-derived values, and DAR was on average within 0.32 DAR units of HIC-derived values. Quadrupole mass spectrometers therefore represent a viable alternative for the characterization of ADC in early-stage development. Graphical abstract.

Qualitative analysis of antibody-drug conjugates (ADCs): an experimental comparison of analytical techniques of cysteine-linked ADCs.

Antibody-drug conjugates (ADCs) are an emerging type of biotherapeutics that utilize multiple tissue-specific antibodies combined with a range of linker designs to enable the transportation and selective release of cytotoxic drugs in close proximity to tumours. Consisting of antibodies conjugated to small drug molecules through a variety of linkers, ADCs are chemically complex analytes. Here we present a unique experimental comparison of four techniques for ADC analysis: hydrophobic interaction chromatography (HIC-UV/Vis), reversed phase liquid chromatography mass spectrometry (RPLC-MS), using either a QToF or an Orbitrap analyser, and matrix-assisted laser desorption ionization time-of-flight mass spectrometry (MALDI-TOF-MS). Four different ADCs consisting of Trastuzumab, monomethyl auristatin E (MMAE) and a peptidic linker moiety differing in their respective stoichiometric ratios in regard to drug-to-antibody ratio (DAR) were used for the comparison. We found that the determined DAR from all techniques was comparable, while the accuracy of the molecular weights for the conjugated light and heavy chain differed more extensively. This indicates that the choice of a mass analyser is more crucial for determining the accurate weights of the light and heavy chains than to evaluate the DAR of a given batch. However, ambiguous DAR assignment in HIC-UV/Vis or bias for either the light or heavy chain fragments in the mass spectrometry-based techniques can influence the obtained average DAR value and the use of complementary techniques is advisable. Out of the four techniques evaluated, HIC-UV/Vis and MALDI required less time to obtain an average DAR value and would therefore be good for initial screenings in the early stages of the discovery phase of new ADCs.

Temporal characterization of the non-structural Adenovirus type 2 proteome and phosphoproteome using high-resolving mass spectrometry.

The proteome and phosphoproteome of non-structural proteins of Adenovirus type 2 (Ad2) were time resolved using a developed mass spectrometry approach. These proteins are expressed by the viral genome and important for the infection process, but not part of the virus particle. We unambiguously confirm the existence of 95% of the viral proteins predicted to be encoded by the viral genome. Most non-structural proteins peaked in expression at late time post infection. We identified 27 non-redundant sites of phosphorylation on seven different non-structural proteins. The most heavily phosphorylated protein was the DNA binding protein (DBP) with 15 different sites. The phosphorylation occupancy rate could be calculated and monitored with time post infection for 15 phosphorylated sites on various proteins. In the DBP, phosphorylations with time-dependent relation were observed. The findings show the complexity of the Ad2 non-structural proteins and opens up a discussion for potential new drug targets.

A comparative study of phosphopeptide-selective techniques for a sub-proteome of a complex biological sample.

Phosphorylation of proteins is important for controlling cellular signaling and cell cycle regulatory events. The process is reversible and phosphoproteins normally constitute a minor part of the global proteome in a cell. Thus, sample preparation techniques tailored for phosphoproteome studies are continuously invented and evaluated. This paper aims at evaluating the performances of the most popular techniques for phospho-enrichments in sub-proteome analysis, such as viral proteomes expressed in human cells during infection. A two-species sample of Adenovirus type 2 infected human cells was used, and in-solution digestion, strong cation exchange (SCX), and electrostatic repulsion hydrophilic interaction chromatography (ERLIC) fractionation, and subsequent enrichment by TiO2, were compared with SDS-PAGE fractionation and in-gel digestion. Evaluation was focused on phosphopeptide detection in the sub-proteome. The results showed that the SCX+TiO2 or ERLIC+TiO2 combinations had the highest enrichment efficiencies, but SDS-PAGE fractionation and in-gel digestion resulted in the highest number of identified proteins and phosphopeptides. Furthermore, the study demonstrates the usefulness of applying as many orthogonal techniques as possible in deep phosphoproteome analysis, since the overlap between approaches was low.