Optimal Inhalation Profile of Pressurized Metered Dry Powder Inhaler Using a Valved Holding Chamber: A Dynamic Analysis.

Background: The combined use of a pressurized metered-dose inhaler and valved holding chamber (pMDI+VHC) is recommended to improve efficiency and safety; however, aerosol release is likely to vary with the inhalation maneuver. This in vitro study investigated the aerodynamic characteristics and aerosol release features of pMDI+VHC (Aerochamber, Trudell Medical International). Methods: The static and dynamic changes in the airway resistance (Raw) during inhalation (withdrawal) through pMDI+VHC were measured. Subsequently, the aerosol released from pMDI+VHC was measured using simplified laser photometry during withdrawal with either fast ramp-up then steady or slow ramp-up followed by gradual decrement at different intensities and times to peak flow (TPWF). Results: Raw increased linearly with changes in the withdrawal flow (WF) rate between 10 and 50 L/min. The slope was steep in the low WF range (<50 L/min) and became milder in the higher range. The aerosol mass tended to increase with an increase in the peak WF (PWF) of slow ramp-up profile. When three different WF increment slopes (TPWF: 0.4, 1.4, and 2.4 seconds) were compared, the released aerosol mass tended to decrease, and the aerosol release time was prolonged at longer TPWF. When the PWF was increased, the aerosol release time became shorter, and the withdrawn volume required for 95% aerosol release became larger; however, it did not exceed 0.4 L at suitable TPWF (0.4 seconds). Conclusion: Raw analysis suggests that inhalation at 30-50 L/min is suitable for pMDI+VHC in this setting. Rapid (TPWF, 0.4 seconds) inhalation, but not necessarily long (maximum 2.0 seconds) and deep (but larger than 0.55 L), is also recommended. Practically, direct inhalation to be weaker than usual breathing, as fast as possible, and far less than 2.0 seconds.

Dynamic Analysis of Aerosol Release from a Pressurized Metered Dose Inhaler Combined with a Valved Holding Chamber Using Simplified Laser Photometry.

Background: A pressurized metered dose inhaler combined with a valved holding chamber (pMDI+VHC) is used to prevent upper airway complications and improve the efficiency of inhaled drug delivery; however, the aerodynamic behavior of the released particles has not been well investigated. This study aimed at clarifying the particle release profiles of a VHC using simplified laser photometry. Methods: An inhalation simulator comprised a computer-controlled pump and a valve system that withdrew aerosol from a pMDI+VHC using a jump-up flow profile. A red laser illuminated the particles leaving VHC and evaluated the intensity of the light reflected by the released particles. Results: The data suggested that the output (OPT) from the laser reflection system represented particle concentration rather than particle mass, and the latter was calculated as OPT × instantaneous withdrawn flow (WF). Summation of OPT hyperbolically decreased with flow increment, whereas summation of OPT × instantaneous flow was not influenced by WF strength. Particle release trajectories consisted of three phases, namely increment with a parabolic curve, flat, and decrement with exponential decay phases. The flat phase appeared exclusively at low-flow withdrawal. These particle release profiles suggest the importance of early phase inhalation. The hyperbolic relationship between WF and particle release time revealed the minimal required withdrawal time at an individual withdrawal strength. Conclusions: The particle release mass was calculated as laser photometric output × instantaneous flow. Simulation of the released particles suggested the importance of early phase inhalation and predicted the minimally required withdrawal time from a pMDI+VHC.

Safety and Immunogenicity of mRNA Vaccines Against Severe Acute Respiratory Syndrome Coronavirus 2 in Patients With Lung Cancer Receiving Immune Checkpoint Inhibitors: A Multicenter Observational Study in Japan.

INTRODUCTION: Patients with cancer have been prioritized for vaccination against severe acute respiratory syndrome coronavirus 2. Nevertheless, there are limited data regarding the safety, efficacy, and risk of developing immune-related adverse events (irAEs) associated with mRNA vaccines in patients with lung cancer, especially those being actively treated with immune checkpoint inhibitors. METHODS: This multicenter observational study was conducted at nine hospitals in Japan. Patients with lung cancer (≥20 y) actively treated with immune checkpoint inhibitors between 4 weeks prefirst vaccination and 4 weeks postsecond vaccination were enrolled. The primary end point was the incidence of irAEs of any grade on the basis of an assumed incidence without vaccination rate of 35%. Immunogenicity was assessed by measuring anti-spike (S)-IgG antibody levels against severe acute respiratory syndrome coronavirus 2. RESULTS: A total of 126 patients with lung cancer (median age, 71 y; interquartile range, 65-74) were enrolled from May to November 2021 and followed up until December 2021. There were 26 patients (20.6%, 95% confidence interval: 13.9%-28.8%) and seven patients (5.6%, 95% confidence interval: 2.3%-11.1%) who developed irAEs of any grade pre- and postvaccination, respectively, which was lower than the predicted incidence without vaccination. None of the patients experienced exacerbation of preexisting irAE postvaccination. S-IgG antibodies were seroconverted in 96.7% and 100% of the patients with lung cancer and controls, respectively, but antibody levels were significantly lower in patients with lung cancer (p < 0.001). CONCLUSIONS: Patients with lung cancer who were actively treated with ICIs were safely vaccinated without an increased incidence of irAEs; however, their vaccine immunogenicity was lower. This requires further evaluation.

Antibody Responses to the BNT162b2 mRNA Vaccine in Healthcare Workers in a General Hospital in Japan: A Comparison of Two Assays for Anti-spike Protein Immunoglobulin G.

Objective This study assessed severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) antibody responses to the BNT162b2 mRNA vaccine in Japanese healthcare workers. Methods In this prospective cohort study, participants received two doses of the BNT162b2 mRNA vaccine on days 0 and 21 and provided blood for anti-SARS-CoV-2 antibody testing before the first vaccine and on days 21 and 35 after vaccination. Anti-spike protein immunoglobulin G (S-IgG) was measured using Abbott and Fujirebio chemiluminescent immunoassays. Patients One hundred healthcare workers (median age: 39 years old, interquartile range: 30-48 years old), including 6 who had been previously infected with SARS-CoV-2 and 3 individuals taking immunosuppressive drugs, participated in the study. Results The S-IgG antibody titers (AU/mL) measured using both the Abbott and Fujirebio assays increased significantly (p<0.001) over time, both with a prevalence of 100% at 35 days after the first vaccination. The multivariate log-normal linear regression analysis indicated the effect of immunosuppressant medication using both the Abbott (p=0.013) and Fujirebio (p=0.039) assays on S-IgG levels after complete vaccination. Pearson's correlation coefficient between the Abbott and Fujirebio S-IgG results in all 300 samples collected before and after vaccination and 50 positive controls from patients with coronavirus disease 2019 were 0.963 [95% confidence interval (CI): 0.954-0.970, p<0.001] and 0.909 (95% CI: 0.845-0.948, p<0.001), respectively. Conclusion The BNT162b2 mRNA vaccine was effective at increasing S-IgG levels in Japanese immunocompetent healthcare workers. The Fujirebio S-IgG assay showed high diagnostic accuracy, using the Abbott S-IgG assay as the reference test.