The survival of Salmonella enterica serovar Typhimurium DT104 and total viable counts on beef surfaces at different relative humidities and temperatures.

AIMS: The aim of this study was to investigate changes in Salmonella and total viable count (TVC) survival on beef carcass surfaces stored for 72 h under different combinations of relative humidity (i.e. RH 75% or 96%) and temperature (5 degrees C or 10 degrees C). METHODS AND RESULTS: The influence of low water activity (a(w)) and temperature on the survival and growth of Salmonella enterica serovar Typhimurium DT104 and the aerobic mesophilic flora on meat pieces from different sites on beef carcasses was investigated, under controlled conditions (75% or 96% RH; 5 or 10 degrees C) in an environmental cabinet. Salmonella counts declined during storage at low a(w) (75% RH) conditions at 5 degrees C or 10 degrees C. Salmonella counts increased during storage at high a(w) (96% RH) at 10 degrees C only. At 5 degrees C, TVCs increased during storage at high a(w), but not at low a(w). TVCs increased on all samples from carcasses stored at high or low a(w) at 10 degrees C, except those samples taken from areas of surface fat. CONCLUSIONS: This suggests that substrate composition dictates growth rates under low a(w) conditions. The results are discussed in terms of the possible protective effects of substrate osmolyte accumulation in bacterial survival and/or growth. SIGNIFICANCE AND IMPACT OF THE STUDY: The data obtained in this study provides useful insights on the influence of a(w) and temperature on pathogen survival on meat surfaces at chill temperature.

The influence of attachment to beef surfaces on the survival of cells of Salmonella enterica serovar Typhimurium DT104, at different a(w) values and at low storage temperatures.

This study investigated the influence of attachment to beef surfaces on the survival, injury and death of stationary phase cells of Salmonella enterica serovar Typhimurium DT104, compared to cells free in solution. The effects on cells are considered at different a(w) values and low temperatures in relation to osmotic and cold temperature shock effects. Attachment of cells to meat surfaces prevented cell injury and death from hyperosmosis and low temperatures, compared to meat solutions. Storage of cells for 72h resulted in higher levels of cell death on cells attached to meat surfaces. The improved survival of cells in solutions was considered to be related to adaptation to osmotic stress as a result of exposure to a previous hyperosmotic shock and the ability of the cells to produce cold shock proteins. Pathogen cell growth at low temperatures is discussed in relation to the presence of low levels of NaCl. Finally the data is discussed in relation to pathogen survival on beef carcass surfaces during refrigeration.

Impact of a novel spray-chilling system on surface microflora, water activity and weight loss during beef carcass chilling.

Commercially slaughtered and dressed beef carcass sides (n=30) were followed through a standard commercial chill unit fitted with a new "Jasca" air humidification system adjusted to provide intermittent water spraying of carcass sides (spray cycle 2 min on, 1 min off) for 15 h. Immediately after dressing, and after 24h in the chill unit, the surface water activity, and the weight of each side was measured, and 5 cm2 samples were recovered from four locations, i.e. rump, flank, brisket and neck on the surface of each side. These samples, and similar samples from control sides (n=30) processed in a standard commercial chill unit, were subjected to microbiological examination by direct and resuscitation counts on plate count agar (PCA), MacConkey agar (MAC) and violet red bile glucose agar (VRBGA). No significant differences were observed between bacterial numbers on test and control samples on each of the above agars, at each sample point/occasion. Comparison of direct and resuscitation counts suggested the presence of substantial numbers of injured cells, at both stages (pre- and post-chill), on test and control sides. After 24 h in chill units, test sides exhibited an average weight loss of 1.36% (+/-0.36%), which is significantly less (P<0.001) than the average weight loss (1.55%+/-0.24%) from control sides. These results suggest that the Jasca spray-chilling system can limit carcass shrinkage (on average by 0.19%) without significantly increasing the surface populations of selected bacterial groups.