Purification of R-phycoerythrin from Gracilaria lemaneiformis by centrifugal precipitation chromatography.

Centrifugal precipitation chromatography (CpC) is a powerful chromatographic technique invented in the year 2000 but so far very little applied. The method combines dialysis, counter-current and salting out processes. The separation rotor consists of two identical spiral channels separated by a dialysis membrane (6-8 K MW cut-off) in which the upper channel is eluted with an ammonium sulfate gradient and the lower channel with water, and the mixtures are separated according to their solubility in ammonium sulfate as a chromatographic technique. In the present study, the method was successfully applied for separation and purification of R-phycoerythrin (R-PE), a protein widely used as a fluorescent probe, from the red alga Gracilaria lemaneiformis. The separation was performed with the elution of ammonium sulfate from 50% to 0% in 21.5 h at a flow rate of 0.5 ml/min, while the lower channel was eluted with water at a flow rate of 0.05 ml/min after sample charge, and the column was rotated at 200 rpm. After a single run, the absorbance ratio A565/A280 (a criterion for the purity of R-PE) was increased from 0.5 of the crude to 6.5. The purified R-PE exhibited a typical "three peaks" spectrum with absorbance maximum at 497, 538 and 565 nm. The Native-PAGE showed one single protein band and 20 kDa (subunits α and ß) and 30 kDa (subunit γ) can be observed in SDS-PAGE analysis which were consistent with the (αß)6γ subunit composition of R-PE. The results indicated that CpC is an efficient method to obtain protein with the high purity from a complex source.

Isolation of sutherlandins A, B, C and D from Sutherlandia frutescens (L.) R. Br. by counter-current chromatography using spiral tubing support rotors.

Spiral countercurrent-chromatography has great potential for improving the capacity and efficiency of purification of secondary metabolites, and here we describe applications useful for the isolation of flavonoids from the widely used South African medicinal plant, Sutherlandia frutescens (L.) R. Br. In the spiral tubing support rotor, STS-4 for high-speed counter-current chromatography, several polar butanol aqueous solvent systems were selected using a logK plot, and the novel flavonol glycosides (sutherlandins A-D) were well separated by the optimized solvent system (ethyl acetate:n-butanol:acetic acid:water; 5:1:0.3:6 by vol.). The yield of purified flavonoids from 0.9g extract varied from 8.6mg to 54mg of the sutherlandins for a total of 85.3mg. The same extract was fractionated in the new STS-12 rotor of the same outside dimensions but with more radial channels forming 12 loops of the tubing instead of 4. The rotor holds more layers and increased length of tubing. From 0.9g extract the STS-12 rotor yielded more recovery of 110.4mg total with amounts varying from 11.2mg to 64mg of the sutherlandins and apparent increased separation efficiency as noted by less volume of each fraction peak. Thus from 1-g amounts of extract, good recovery of the flavonoids was achieved in the butanol aqueous solvent system.

Purification of semiconducting single-walled carbon nanotubes by spiral counter-current chromatography.

Over the last decade man-made carbon nanostructures have shown great promise in electronic applications, but they are produced as very heterogeneous mixtures with different properties so the achievement of a significant commercial application has been elusive. The dimensions of single-wall carbon nanotubes are generally a nanometer wide, up to hundreds of microns long and the carbon nanotubes have anisotropic structures. They are processed to have shorter lengths but they need to be sorted by diameter and chirality. Thus counter-current chromatography methods developed for large molecules are applied to separate these compounds. A modified mixer-settler spiral CCC rotor made with 3 D printed disks was used with a polyethylene glycol-dextran 2-phase solvent system and a surfactant gradient to purify the major species in a commercial preparation. We isolated the semi-conducting single walled carbon nanotube chiral species identified by UV spectral analysis. The further development of spiral counter-current chromatography instrumentation and methods will enable the scalable purification of carbon nanotubes useful for the next generation electronics.

Spiral Countercurrent Chromatography Enrichment, Characterization, and Assays of Carbon Nanotube Chiralities for Use in Biosensors.

Single-walled carbon nanotubes (SWCNTs) are synthetic materials that hold great promise for electronics that are smaller and more versatile than the current silica-based technologies. But as-produced SWCNTs are generally a mixture of nanotubes with different structures that have vastly different properties. Separating these SWCNTs from multiwalled and metallic carbon nanotubes is vital to explore their individual properties and commercial utility ranging from optics to semiconductors. Compounding the problem of commercial investigation is that the semiconducting SWCNTs are also a mixture of different diameters and/or chiralities with different properties. Analyzing properties of enriched semiconducting SWCNT chiralities has only recently been possible through separation techniques such as aqueous two-phase solvent systems. Our study illustrates a semipreparative spiral countercurrent chromatography (CCC) separation of a commercial mixture of SWCNTs into distinct enriched fractions. A new mixer-settler spiral disk rotor was applied in this study, in which we compare the enriched SWCNTs for their effectiveness in biosensors with a high-throughput model assay, followed by antibody-mediated detection of Escherichia coli. Our results demonstrate that CCC-enriched responsive SWCNTs for biosensors can be used in our model assay, as well as for the detection of E. coli. To date, we believe that this is the first study along with Liu et al. [Chirality-controlled synthesis of single-wall carbon nanotubes using vapour-phase epitaxy. Nat. Commun.2012, 3, 1199] to demonstrate a specific utility of separated SWCNT species.

Isolation of Sutherlandioside B from Sutherlandia frutescens by Spiral Countercurrent Chromatography.

The introduction of spiral countercurrent chromatography in the last few years using new separation columns such as the spiral tubing support rotor has enabled the application of more polar volatile solvent systems for natural products separation. This method can be applied to water soluble compounds and their metabolites. We have used spiral countercurrent chromatography with the spiral tubing support rotor to fractionate n-butanol extracts of an African plant Sutherlandia frutescens and have determined conditions by which the predominant cycloartane glycoside (sutherlandioside B) can be purified in good yield. A solvent system of ethyl acetate, methanol, and water was modified by adding n-butanol to separate sutherlandioside B from other compounds. With the optimal amount of n-butanol in the two-phase solvent system with the lower aqueous phase mobile, the target compound was eluted well separated from the other components. The purity of sutherlandioside B was determined by high performance liquid chromatography/mass spectrometry analysis and the yield compares favorably with the content in bulk material.

High-throughput Peptide epitope mapping using carbon nanotube field-effect transistors.

Label-free and real-time detection technologies can dramatically reduce the time and cost of pharmaceutical testing and development. However, to reach their full promise, these technologies need to be adaptable to high-throughput automation. To demonstrate the potential of single-walled carbon nanotube field-effect transistors (SWCNT-FETs) for high-throughput peptide-based assays, we have designed circuits arranged in an 8 × 12 (96-well) format that are accessible to standard multichannel pipettors. We performed epitope mapping of two HIV-1 gp160 antibodies using an overlapping gp160 15-mer peptide library coated onto nonfunctionalized SWCNTs. The 15-mer peptides did not require a linker to adhere to the non-functionalized SWCNTs, and binding data was obtained in real time for all 96 circuits. Despite some sequence differences in the HIV strains used to generate these antibodies and the overlapping peptide library, respectively, our results using these antibodies are in good agreement with known data, indicating that peptides immobilized onto SWCNT are accessible and that linear epitope mapping can be performed in minutes using SWCNT-FET.

Spiral countercurrent chromatography.

For many years, high-speed countercurrent chromatography conducted in open tubing coils has been widely used for the separation of natural and synthetic compounds. In this method, the retention of the stationary phase is solely provided by the Archimedean screw effect by rotating the coiled column in the centrifugal force field. However, the system fails to retain enough of the stationary phase for polar solvent systems such as the aqueous-aqueous polymer phase systems. To address this problem, the geometry of the coiled channel was modified to a spiral configuration so that the system could utilize the radially acting centrifugal force. This successfully improved the retention of the stationary phase. Two different types of spiral columns were fabricated: the spiral disk assembly, made by stacking multiple plastic disks with single or four interwoven spiral channels connected in series, and the spiral tube assembly, made by inserting the tetrafluoroethylene tubing into a spiral frame (spiral tube support). The capabilities of these column assemblies were successfully demonstrated by separations of peptides and proteins with polar two-phase solvent systems whose stationary phases had not been well retained in the earlier multilayer coil separation column for high-speed countercurrent chromatography.

Application of centrifugal precipitation chromatography and high-speed counter-current chromatography equipped with a spiral tubing support rotor for the isolation and partial characterization of carotenoid cleavage-like enzymes in Enteromorpha compressa (L.) Nees.

Centrifugal precipitation chromatography and a high-speed counter-current chromatography system equipped with a spiral tubing support rotor (spHSCCC) were successfully applied for the identification and isolation of carotenoid cleavage-like enzymes from Enteromorpha compressa (L.) Nees. This is the first study separating active enzymes from a complex natural matrix by spHSCCC. The target enzymes were identified after fractionation of the proteins in an acetone Tris-buffer gradient by centrifugal precipitation chromatography. Also, an aqueous two-phase solvent system consisting of PEG 1000 and mono- and dibasic potassium phosphate was used for the isolation of the enzymes by spHSCCC. The purified fractions contained two proteins of 65 and 72 kDa, respectively. The enzymes could cleave ß-carotene and ß-apo-8'-carotenal to produce ß-ionone.

Spiral counter-current chromatography of small molecules, peptides and proteins using the spiral tubing support rotor.

An important advance in countercurrent chromatography (CCC) carried out in open flow-tubing coils, rotated in planetary centrifuges, is the new design to spread out the tubing in spirals. More spacing between the tubing was found to significantly increase the stationary phase retention, such that now all types of two-phase solvent systems can be used for liquid-liquid partition chromatography in the J-type planetary centrifuges. A spiral tubing support (STS) frame with circular channels was constructed by laser sintering technology into which FEP tubing was placed in 4 spiral loops per layer from the bottom to the top and a cover affixed allowing the tubing to connect to flow-tubing of the planetary centrifuge. The rotor was mounted and run in a P.C. Inc. type instrument. Examples of compounds of molecular weights ranging from <300 to approximately 15,000 were chromatographed in appropriate two-phase solvent systems to assess the capability for separation and purification. A mixture of small molecules including aspirin was completely separated in hexane-ethyl acetate-methanol-water. Synthetic peptides including a very hydrophobic peptide were each purified to a very high purity level in a sec-butanol solvent system. In the STS rotor high stationary phase retention was possible with the aqueous sec-butanol solvent system at a normal flow rate. Finally, the two-phase aqueous polyethylene glycol-potassium phosphate solvent system was applied to separate a protein from a lysate of an Escherichia coli expression system. These experiments demonstrate the versatility of spiral CCC using the STS rotor.

Improved partition efficiency with threaded cylindrical column in vortex counter-current chromatography.

Type-I coil planet centrifuge produces a uniformly circulating centrifugal force field to produce vortex motion of two immiscible solvent phases in a cylindrical cavity of the separation column to perform efficient countercurrent chromatography. The partition efficiency obtained from the original vortex column was substantially improved by threading the cylindrical cavity to increase the area of mass transfer between the two phases. Partition efficiency of the threaded column was evaluated by three different two-phase solvent systems with a broad range of hydrophobicity each with a set of suitable test samples. Overall results of the present studies indicated that the threaded cylindrical column substantially improves the partition efficiency in terms of theoretical plate number, peak resolution, and height equivalent of one theoretical plate. The results also indicated that higher peak resolution is produced by eluting either the upper phase in the head to tail direction or the lower phase in the reversed direction. When there is a choice in the mobile phase, a better separation is achieved by using the less viscous phase as the mobile phase. Since the present system gives extremely low column pressure, it may be a potential alternative to the conventional type-J HSCCC system for a large-scale preparative separation.

Vortex counter-current chromatography.

A novel counter-current chromatographic system is developed by mounting a vortex column on a type-I coil planet centrifuge. The column is fabricated from a high-density polyethylene disk (16 cm diameter and 5 cm thick) by making multiple holes of various diameters (3-12.5 mm) each arranged in a circle and connected with narrow transfer ducts. The performance of this vortex column is tested with three different two-phase solvent systems with a broad range in hydrophobicity. The results indicated that the smallest diameter column (3mm diameter, 120 units with 42.8 ml capacity) yielded the best separation with the height equivalent to a theoretical plate of 2 cm compared with 20 cm required by the conventional multilayer coil column of high-speed CCC. By avoiding the use of an Archimedean Screw Force, the system shows a low column pressure which would permit safe operation of a large preparative column without a risk of leakage of solvent and column damage.

Cardiovascular effects of prorenin blockade in genetically spontaneously hypertensive rats on normal and high-salt diet.

Recent reports have demonstrated a potential role of tissue prorenin in the pathogenesis of cardiovascular and renal damage. This study was designed to examine the role of prorenin in the pathogenesis of target organ damage in spontaneously hypertensive rats (SHRs), the best naturally occurring experimental model of essential hypertension. To this end, we studied 20-wk-old male SHRs receiving a normal diet and 8-wk-old male SHRs given food with 8% NaCl. One-half the rats in each group were given prorenin inhibitor (PRAM-1, 0.1 mg.kg(-1).day(-1)) via osmotic minipumps; the other half served as controls. Arterial pressure, left ventricular function, cardiovascular mass indexes, cardiac fibrosis, and renal function were examined at the end of the experiment. Arterial pressure was unaffected by PRAM-1 in rats on either regular or salt-excess diets. In those rats receiving a normal diet, the blockade of prorenin activation consistently reduced left ventricular mass but affected no other variable. Salt-loaded rats given PRAM-1 for 8 wk demonstrated (1) reduced serum creatinine level, (2) decreased left ventricular mass, (3) improved left ventricular function, and (4) reduced left ventricular fibrosis. These data demonstrated that the blockade of nonproteolytic activation of prorenin exerted significant cardiovascular and renal benefit in SHRs with cardiovascular damage produced by salt excess and suggested that the activation of cardiovascular or renal prorenin may be a major mechanism that mediates cardiac and renal damage in this form of accelerated hypertension.

Separations of hydrophobic synthetic peptides in counter-current chromatography.

Synthetic peptides with many aromatic, aliphatic and especially acidic amino acid residues are not very soluble and require strong solvents for useful partitioning. A chloroform-methanol-acidic solvent system fractionates neutral and basically charged 26-mers to provide high yields. An insoluble 15-mer with 5 Trp residues and 60% overall hydrophobic amino acid content was purified in pyridine-acetic acid and in another basic t-butyl methyl ether-n-butanol-acetonitrile solvent system with high recovery. Two instruments were used, the eccentric-multi-layer hybrid coil planet centrifuge and the new spiral disk planet centrifuge that were able to retain the stationary phase of these solvent systems, some of which have low interfacial tension.

Hemopressin, a hemoglobin fragment, dilates the rat systemic vascular bed through release of nitric oxide.

The present study was undertaken to investigate the effects of intravenous (i.v.) administration of rat hemopressin (rHP), 30-1000 microg/kg, on systemic arterial pressure (SAP), cardiac output (CO) and systemic vascular resistance (SVR) in the anesthetized rat. Bolus i.v. injections of rHP produced mild decreases in SAP that were dose-dependent. Since CO was not altered, the decreases in SAP reflect reductions in SVR. The systemic vasodilator response to rHP was not subject to tachyphylaxis. The systemic vasodilator response to rHP was abolished by L-nitro-arginine methylester (L-NAME) but was not altered by meclofenamate. In addition, rHP lacked direct contractile and relaxant activity on isolated rat aortic rings (AA) and pulmonary arterial rings (PA). The present data suggest rHP dilates the rat systemic vascular bed through the endogenous release of nitric oxide (NO) independent of the formation of cyclooxygenase products including prostacyclin. It is possible rHP acts as an endogenous vasodilator substance to regulate local blood flow during clinical states of altered red cell turnover, microvascular disease and hemolysis.