Effects of digestate-encapsulated biochar on plant growth, soil microbiome and nitrogen leaching.

The increasing amount of food waste and the excessive use of mineral fertilizers have caused detrimental impacts on soil, water, and air quality. Though digestate derived from food waste has been reported to partially replace fertilizer, its efficiency requires further improvement. In this study, the effects of digestate-encapsulated biochar were comprehensively investigated based on growth of an ornamental plant, soil characteristics, nutrient leaching and soil microbiome. Results showed that except for biochar, the tested fertilizers and soil additives, i.e., digestate, compost, commercial fertilizer, digestate-encapsulated biochar had positive effects on plants. Especially, the digestate-encapsulated biochar had the best effectiveness as evidenced by 9-25% increase in chlorophyll content index, fresh weight, leaf area and blossom frequency. For the effects of fertilizers or soil additives on soil characteristics and nutrient retention, the digestate-encapsulated biochar leached least N-nutrients (<8%), while the compost, digestate and mineral fertilizer leached up to 25% N-nutrients. All the treatments had minimal effects on the soil properties of pH and electrical conductivity. According to the microbial analysis, the digestate-encapsulated biochar has the comparable role with compost in improving the soil immune system against pathogen infection. The metagenomics coupling with qPCR analysis suggested that digestate-encapsulated biochar boosted the nitrification process and inhibited the denitrification process. This study provides an extensive understanding into the impacts of the digestate-encapsulated biochar on an ornamental plant and offers practical implications for the choice of sustainable fertilizers or soil additives and food-waste digestate management.

Bioaugmentation of Methanosarcina thermophila grown on biochar particles during semi-continuous thermophilic food waste anaerobic digestion under two different bioaugmentation regimes.

This study presents the effect of bioaugmentation of thermophilic anaerobic digestion of food waste with Methanosarcina thermophila grown on a wood-derived biochar. Two different supplementation regimes were tested, namely a single bioaugmentation (SBABC) in which 10% v/v of the microbes grown on biochar (1 g/L) is added at setup of the reactors, versus a routine bioaugmentation (RBABC) wherein the same amount of supplements were added over 10 feeding cycles. The optimally performing 'R' and 'S' reactors had increased methane yields by 37% and 32% over their respective controls while reactors SBABC 2 and 3 produced 21.89% and 56.09% higher average methane yield than RBABC 2 and 3, respectively. It appears that a single dose bioaugmentation is advantageous for improving AD as analysed in terms of average methane yield and VFA production. This study provides the basis for understanding how biochar and bioaugmentation can be used for engineering sustainable pilot-scale AD processes.

Methanosarcina thermophila bioaugmentation and its synergy with biochar growth support particles versus polypropylene microplastics in thermophilic food waste anaerobic digestion.

Both biochar supplementation as well as bioaugmentation have been shown in literature to improve the methane yield of anaerobic digestion. In this study, the combination of both are evaluated by growing Methanosarcina thermophila on biochar support particles prior to augmentation of thermophilic food waste anaerobic digestion. Biochar stand alone, bioaugmentation solely, a combination of both added separately or grown together, and utilizing polypropylene (PP) microplastics as growth support instead were all tested when starting up a thermophilic process from mesophilic inoculum. Methanosarcina thermophila and biochar supplementation displayed synergy, with 5% M. thermophila on 1 g/L biochar presenting a 32% increase in specific methane yield over the control. Double the bioaugmentation dosage/concentration was also trialled with a thermophilic inoculum, and 10% M. thermophila grown on 2 g/L biochar displayed the best results with a 20% increase specific methane yield from its control standard.

Enhancing microbial lipids yield for biodiesel production by oleaginous yeast Lipomyces starkeyi fermentation: A review.

The enhanced production of microbial lipids suitable for manufacturing biodiesel from oleaginous yeast Lipomyces starkeyi is critically reviewed. Recent advances in several aspects involving the biosynthetic pathways of lipids, current conversion efficiencies using various carbon sources, intensification strategies for improving lipid yield and productivity in L. starkeyi fermentation, and lipid extraction approaches are analyzed from about 100 papers for the past decade. Key findings on strategies are summarized, including (1) optimization of parameters, (2) cascading two-stage systems, (3) metabolic engineering strategies, (4) mutagenesis followed by selection, and (5) co-cultivation of yeast and algae. The current technical limitations are analyzed. Research suggestions like examination of more gene targets via metabolic engineering are proposed. This is the first comprehensive review on the latest technical advances in strategies from the perspective of process and metabolic engineering to further increase the lipid yield and productivity from L. starkeyi fermentation.

Food-waste anaerobic digestate as a fertilizer: The agronomic properties of untreated digestate and biochar-filtered digestate residue.

Anaerobic digestion produces large quantities of digestate as a by-product, which can potentially be applied as an organic fertilizer, but untreated anaerobic digestate (AD) may contain phytotoxins and the large volume of AD makes transportation and storage difficult. This study explored two relatively inexpensive processing methods to improve the agronomic performance of AD as a fertilizer via vegetable cultivation experiments. We first investigated the effect of dilution on AD's performance using four leafy vegetables (Chinese spinach, water spinach, Chinese cabbage and lettuce). The optimal concentrations of the AD were 20-40% (v/v in 250 mL applications per single-plant pot) for all four vegetables based on shoot fresh weight and comparable to the control treatment using commercial fertilizer. AD application also introduced Synergistetes bacteria into the growing medium, but the overall bacterial diversity and composition were similar to those of the control treatment. Considering the nutrient separation in the liquid and solid fractions of AD and the need to reduce the volume, we then experimented with the recovery of nutrients from both the liquid and solid fractions by filtering AD using two types of wood-based biochar (100 g biochar: 1 L AD) before applying the AD-biochar residues as side dressing at 1% (w/w). Both types of biochar achieved yields comparable to the treatment using a commercial fertilizer for the three vegetables tested (kale, lettuce and rocket salad). Our results show that dilution and biochar filtration can improve the agronomic performance of AD, making it a sustainable substitute for commercial fertilizer.

Timing of biochar dosage for anaerobic digestion treating municipal leachate: Altered conversion pathways of volatile fatty acids.

In this study, the anaerobic digestion (AD) applications of early & late biochar dosage were compared for municipal leachate treatment, with the objective of studying the flexible use of biochar as a mitigation measure for biomethane recovery. In two experimental phases, biochar was favourable for the immediate promotion of AD performances, as revealed by Gompertz's model of reduced lag phases, higher biomethane generation rates, and increased biomethane yields. Irrespective of late biochar dosage, it could still retrieve 89% of the ultimate biomethane potential. Comparing the residual VFAs (volatile fatty acids) compositions, it was found that the fraction of long-chain VFAs accounted for 81% of total VFAs in reactor set of early biochar dosage, while it was only 38% in the reactor of late one. Parallel evidence suggested that the schedule of biochar dosage not only could affect methanogenic responses but also the VFAs conversion pathways.

Biochar utilisation in the anaerobic digestion of food waste for the creation of a circular economy via biogas upgrading and digestate treatment.

A wood waste-derived biochar was applied to food-waste anaerobic digestion to evaluate the feasibility of its utilisation to create a circular economy. This biochar was first purposed for the upgrading of the biogas from the said anaerobic digestion, before treating and recovering the nutrients in the solid fraction of the digestate, which was finally employed as a biofertilizer for the organic cultivation of three green leafy vegetables: kale, lettuce and rocket salad. Whilst the amount of CO2 the biochar could absorb from the biogas was low (11.17 mg g-1), it could potentially be increased by modifying through physical and chemical methods. Virgin as well as CO2-laden biochar were able to remove around 31% of chemical oxygen demand, 8% of the ammonia and almost 90% of the total suspended solids from the digestate wastewater, which was better than a dewatering process via centrifugation but worse than the industry standard of a polytetrafluoroethylene membrane bioreactor. Nutrients were recovered in the solid fraction of the digestate residue filtered by the biochar, and utilised as a biofertilizer that performed similarly to a commercial complete fertilizer in terms of aerial fresh weight growth for all three vegetables cultivated. Contingent on the optimal upgrading of biogas, the concept of a circular economy based on biochar and anaerobic digestion appears to be feasible.

Influence of wet oxidation pretreatment with hydrogen peroxide and addition of clarified manure on anaerobic digestion of oil palm empty fruit bunches.

Food and energy requirements are increasing globally, and the challenge is to meet these demands in a sustainable manner. Oil palm has a relatively high productivity, but produces the lignocellulosic residue of empty fruit bunches (OPEFB). In this study, wet oxidation pretreatment is utilized to overcome the recalcitrance of OPEFB during semi-continuous anaerobic digestion (AD) with between 19.7 and 52.7% improvement over the control, and near total cellulose and hemicellulose content could be degraded. Clarified manure, the water phase of cattle and dairy manure after filtration, is further tested for its effect on methane production by providing necessary micronutrients and vitamins. An increase of 49% was found after addition of clarified manure to OPEFB compared to without this addition.

Closing the food waste loop: Food waste anaerobic digestate as fertilizer for the cultivation of the leafy vegetable, xiao bai cai (Brassica rapa).

The increasing world population necessitates the production of larger amounts of food in a safe and environmentally sustainable manner, while concomitantly managing an increasing amount of food waste similarly. These needs can theoretically be met by the recycling of the nutrients in food waste via anaerobic digestion, which also produces renewable energy. This hypothesis is proven by the growing of a commonly consumed leafy vegetable, xiao bai cai (Brassica rapa), by the addition of food waste anaerobic digestate in place of commercial fertilizer. Different concentrations of the digestate were tested, as well as different heat treatments to simulate hygienization, and the results for most part (aerial fresh weight, dry weight, chlorophyll content) are not significantly different from growth utilizing commercial inorganic 15:15:15 NPK fertilizer. Microbial analysis of the growth media was also carried out to explicate digestate effects and to show that some common foodborne disease pathogens were not detected.

Environmental impact comparison of four options to treat the cellulosic fraction of municipal solid waste (CF-MSW) in green megacities.

Megacities are characterized by a high urban population density, and timely solid waste management is crucial for the wellbeing of its citizens. In this study, the cellulosic fraction of municipal solid waste is the target for management in Singapore (which has one of the highest population densities in the world) using four pertinent options - incineration, anaerobic digestion, gasification and composting. The energy sustainability and environmental impacts in the form of greenhouse gas emissions are considered for each scenario together with the status quo to achieve the most favorable recommendation, with a sensitivity analysis in the case that no bio-fertilizers are allowed for use locally. In terms of GWP and energy profile for grass waste, AD is the most environmentally friendly option (2 kilo tonnes of CO2-eq and 23.3 GWh respectively), while for leaf waste, gasification is the best, with AD a close second.

Acclimatization of a mixed-animal manure inoculum to the anaerobic digestion of Axonopus compressus reveals the putative importance of Mesotoga infera and Methanosaeta concilii as elucidated by DGGE and Illumina MiSeq.

In this study, a multifarious microbial mix from different sources is acclimatized over a period of three months to digesting cowgrass, and the changes in the community structure are examined with both a traditional denaturing gradient gel electrophoresis method as well as a next generation sequencing MiSeq method. It is shown that the much more in depth analysis by Illumina gives more information about the relative abundance and thus putative importance of the role of various microbes, in particular the bacterium Mesotoga infera and the archaeon Methanosaeta concilii.