Pelleting and particle size reduction of corn increase net energy and digestibility of fiber, protein, and fat in corn-soybean meal diets fed to group-housed pigs.

BACKGROUND: Reduction of the particle size of corn increases energy digestibility and concentrations of digestible and metabolizable energy. Pelleting may also reduce particle size of grain, but it is not known if there are interactions between particle size reduction and pelleting. The objective of this experiment was to test the hypothesis that particle size reduction and pelleting, separately or in combination, increase N balance, apparent total tract digestibility (ATTD) of fiber and fat, and net energy (NE) in corn-soybean meal diets fed to group-housed pigs. METHODS: Six corn-soybean meal-based diets were used in a 3 × 2 factorial design with 3 particle sizes of corn (i.e., 700, 500, or 300 µm) and 2 diet forms (i.e., meal or pelleted). Pigs were allowed ad libitum access to feed and water. Twenty-four castrated male pigs (initial weight: 29.52 kg; standard diviation: 1.40) were allotted to the 6 diets using a 6 × 6 Latin square design with 6 calorimeter chambers (i.e., 4 pigs/chamber) and 6 periods. Oxygen consumption and CO2 and CH4 productions were measured during fed and fasting states and fecal and urine samples were collected. RESULTS: Regardless of particle size of corn, the ATTD of gross energy (GE), N, and acid-hydrolyzed ether extract (AEE), and the concentration of NE were greater (P < 0.05) in pelleted diets than in meal diets. Regardless of diet form, the ATTD of GE, N, and AEE, and the concentration of NE were increased (linear; P < 0.05) by reducing the particle size of corn, but the increase was greater in meal diets than in pelleted diets (interaction; P < 0.05). CONCLUSIONS: Both pelleting and reduction of corn particle size increased nutrient digestibility and NE, but increases were greater in meal diets than in pelleted diets.

Influence of particle size and origin of field peas on apparent ileal digestibility of starch and amino acids and standardized ileal digestibility of amino acids when fed to growing pigs.

The objective was to test the hypothesis that particle size and origin of field peas influence the apparent ileal digestibility (AID) of starch, crude protein (CP), and amino acids (AA) and the standardized ileal digestibility (SID) of AA. Three sources of field peas were procured. One source was from the United States and two sources were from Canada. The U.S. source and one of the sources from Canada (i.e., Canada 1) were each divided into two batches and ground to achieve a target particle size of 250 or 450 µm, whereas the other source from Canada (i.e., Canada 2) was only ground to a target particle size of 250 µm. Each batch of field peas was included in one diet as the only source of AA. An N-free diet was used to determine the basal endogenous losses of CP and AA. Six barrows (initial weight: 50.5 kg; SD = 3.7) that had a T-cannula installed in the distal ileum were randomly allotted to a 6 × 6 Latin square design with six diets and six 7-d periods. Ileal digesta from pigs were collected for 2 d after 5 d of adaptation. Data were analyzed using a statistical model that included batch of field peas as the fixed effect and animal and period as the random effects. Contrast statements were used to analyze the effects of particle size, origin, and the interaction between particle size and origin. Results indicated that the AID of starch was increased by reducing the particle size in the U.S. source of field peas, but that was not the case for the Canada 1 source (interaction; P < 0.001). Particle size did not influence the AID of CP or AA, but the Canada 2 source of field peas had greater (P < 0.05) AID of Trp, Ala, Cys, Gly, and Tyr than the field peas from the United States. The SID of CP and AA was also not affected by the particle size of field peas. The SID of CP and Trp was greater (P < 0.05), and the SID of His, Ile, and Thr tended (P < 0.10) to be greater in the Canada 2 source compared with the U.S. source, but no differences between the two Canada sources were observed. In conclusion, a few differences in SID of AA between field peas produced in the United States and peas produced in Canada were observed, but there was no effect on SID of AA of reducing the particle size of field peas from 450 to 250 µm, whereas the AID of starch increased by reducing the particle size only in the field peas from the United States.

Digestibility of calcium in calcium-containing ingredients and requirements for digestible calcium by growing pigs.

The concentration of Ca in plant feed ingredients is low compared with the requirement for pigs and most Ca in diets for pigs is provided by limestone and Ca phosphate. To determine digestibility values for Ca that are additive in mixed diets, the standardized total tract digestibility (STTD) of Ca needs to be calculated, and the STTD of Ca by growing pigs in most Ca-containing ingredients has been reported. Although Ca is an inexpensive nutrient compared with P and amino acids, excess Ca needs to be avoided because excess dietary Ca results in reduced P digestibility, reduced feed intake, and reduced growth performance of pigs. Recent data indicate that most diets produced for pigs in the United States and Europe contain ~0.20 percentage units more Ca than formulated, which likely is because of the use of limestone as a carrier in feed additives or as a flow agent in other ingredients. An excess of this magnitude without a corresponding excess of P will result in a reduction in daily gain of growing pigs by 50 to 100 g. Greater emphasis, therefore, needs to be placed on determining the concentration of Ca in diets for pigs. Microbial phytase increases the digestibility of both Ca and P and it is, therefore, important that the release of both Ca and P by phytase is considered in diet formulation. However, due to the relationship between Ca and P in postabsorptive metabolism, diets need to be formulated based on a ratio between digestible Ca and digestible P. To maximize average daily gain, this ratio needs to be less than 1.40:1.0 in diets for weanling pigs, and the ratio needs to be reduced as the body weight of pigs increases. In contrast, to maximize bone ash, the digestible Ca to digestible P ratio needs to increase from 1.67:1.0 in 11 to 25 kg pigs to 2.33:1.0 in finishing pigs. Gestating sows have reduced STTD and retention of Ca and P compared with growing pigs and formulation of diets for sows based on digestibility values obtained in growing pigs will result in inaccuracies in the provision of Ca and P. There is, however, a lack of data for the digestibility of Ca and P by gestating and lactating sows, and responses to microbial phytase by sows are not fully understood. There is, therefore, a need for research to generate more data in this area. In the present review, a summary of data for the digestibility of Ca in feed ingredients for pigs and estimates for the requirement for digestible Ca by growing and finishing pigs are provided.

Concentration of Ca in most plant feed ingredients is low compared with the requirement for pigs and dietary Ca is, therefore, mostly provided by limestone and calcium phosphates. Although Ca is an inexpensive nutrient compared with P and amino acids, excess dietary Ca may result in reduced P digestibility, feed intake, and growth performance of pigs. Excretion of P from pigs is increased if dietary Ca is provided above the requirement, which may increase environmental pollution. Therefore, determination of the digestibility of Ca in dietary sources of Ca and formulation of diets based on the ratio between digestible Ca and digestible P are needed to reduce Ca and P excretions. This review provides a summary of values for the digestibility of Ca in feed ingredients and also provides estimates for the requirement for digestible Ca by weanling and growing-finishing pigs. Summarized data from experiments that determined the requirement for digestible Ca demonstrated that there are linear correlations between body weight of growing-finishing pigs and digestible Ca to digestible P ratios needed to maximize growth or bone ash.

Metabolizable energy and apparent total tract digestibility of energy and nutrients differ among samples of sunflower meal and sunflower expellers fed to growing pigs.

An experiment was conducted to test the hypothesis that there are no differences among samples of sunflower coproducts in apparent total tract digestibility (ATTD) of gross energy (GE), crude protein (CP), and acid hydrolyzed ether extract (AEE), total dietary fiber (TDF), insoluble dietary fiber, soluble dietary fiber (SDF), or in metabolizable energy (ME) regardless of where the ingredient was produced. Six samples of sunflower meal (SFM) were obtained from the United States (two samples), Ukraine (two samples), Hungary, and Italy. A sample of sunflower expellers (SFE) from the United States was also used. A corn-based control diet and 7 diets containing corn and each sample of sunflower coproducts were formulated. Sixty-four barrows (initial weight = 31.5 ±â€…3.2 kg) were allotted to 8 diets using a randomized complete block design with four blocks of pigs from four different weaning groups. Pigs were housed individually in metabolism crates and feed was provided at three times energy requirement for maintenance. Feces and urine were collected for four days after seven days of adaptation to diets. Results indicated that the ATTD of GE and CP in SFE was less (P < 0.05) than in SFM, but ATTD of AEE in SFE was greater (P < 0.05) compared with SFM. No difference in ME between SFM and SFE was observed. The ATTD of GE and TDF in SFM from Ukraine and Hungary was greater (P < 0.05) than in SFM from the United States or Italy. The ATTD of AEE did not differ among SFM samples with the exception that ATTD of AEE in the U.S. 2 sample was greater (P < 0.05) than in the other samples. The ATTD of SDF was less (P < 0.05) in the U.S. 1 sample and the sample from Italy than in the other samples. The ATTD of TDF was greater in the Ukraine 2 sample of SFM (P < 0.05) than in the two U.S. samples. The ME in the SFM samples from Ukraine and in the SFM from Hungary was greater (P < 0.05) than in the U.S. 1 sample and the SFM from Italy. In conclusion, ATTD of GE and nutrients differed between SFM and SFE, but the ATTD of TDF and the ME in SFM was not different from value for SFE. Among SFM samples, relatively small variations in ATTD of GE, AEE, and CP were observed, but ME and digestibility of TDF varied.

Global oilseed production has been increasing due to the increased demand for oil as well as the increased demand for amino acids for livestock feeding. In addition to providing amino acids, sunflower meal (SFM) and sunflower expellers (SFE) also provide energy and other nutrients to the diets. Because the concentration of residual oil is less in SFM than in SFE, it is expected that SFE provides more energy to diets than SFM. However, data for the digestibility of nutrients and gross energy and concentrations of digestible energy and metabolizable energy in different samples of SFM or SFE are limited. Therefore, the objective of this research was to test the null hypothesis that there are no differences in the apparent total tract digestibility of nutrients and gross energy and concentration of digestible energy and metabolizable energy among SFM and SFE when fed to growing pigs. Results demonstrated that values for apparent total tract digestibility of nutrients and gross energy differed among samples of SFM produced in different countries. However, concentrations of digestible energy and metabolizable energy were not different in SFE compared with SFM despite a greater concentration of fat in SFE.

- Invited Review - Mineral composition and phosphorus digestibility in feed phosphates fed to pigs and poultry.

Phosphorus (P) is a macro mineral needed for bone mineralization and cell membrane structure and P is also involved in several fundamental pathways of metabolism in the body. Because of the low concentration and digestibility of P in plant ingredients that are the main components of diets for poultry and pigs, feed phosphates are usually included in diets in addition to the P contributed by plant ingredients. The most widely used feed phosphates in poultry and swine diets are dicalcium phosphate (DCP) and monocalcium phosphate (MCP), but tricalcium phosphate (TCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) may be used as well. Because feed phosphates are mostly produced from rock phosphate, feed phosphates have impurities that contain minerals other than P. Concentrations of P in feed phosphates range from 14.8% (MgP) to 25.7% (MSP). The standardized total tract digestibility (STTD) of P in pigs ranges from 71% (TCP) to 95% (MSP). The STTD of Ca and the standardized ileal digestibility (SID) of P and Ca in feed phosphates fed to pigs and poultry have been determined only in a few experiments. Available data indicate that the STTD of Ca and SID of P in MCP are greater than in DCP in both poultry and pigs, but the SID of Ca is similar between DCP and MCP fed to broilers. Information on mineral concentrations and digestibility values in feed phosphates is needed in diet formulation for pigs and poultry, but if diets are formulated to contain equal concentrations of digestible P and Ca, it is unlikely that animal performance will be impacted by the source of feed phosphates used in the diet.

Effects of microbial phytase on standardized total tract digestibility of phosphorus in feed phosphates fed to growing pigs.

An experiment was conducted to test the hypothesis that the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P in feed phosphates are increased by microbial phytase when fed to growing pigs. Monocalcium phosphate (MCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) from volcanic deposits were used in the experiment. Three corn-soybean meal based diets that contained 0, 500, or 4,000 units of microbial phytase (FTU), but no feed phosphates, were formulated. Nine additional diets were formulated by adding each of the three feed phosphates to the three basal diets. A P-free diet was also formulated to estimate the basal endogenous loss of P, and therefore, 13 diets were used in the experiment. A total of 117 growing barrows (initial body weight: 15.56 ±â€…1.68 kg) were allotted to the 13 diets with 9 pigs per diet. Pigs were housed individually in metabolism crates equipped with a feeder and a nipple drinker. Installation of a screen floor under the slatted floor allowed for collection of feces. Diets were fed for 10 d, with the initial 5 d being a period of adaptation to the diet followed by a collection period of 4 d. During the experiment, pigs were fed equal amounts of feed twice daily at 0800 and 1600 h. Results indicated that the ATTD and STTD of P in all diets increased with the inclusion of 500 or 4,000 FTU, but the ATTD and STTD of P in the feed phosphates were not affected by the inclusion of phytase. This indicates that the increases in ATTD and STTD of P that were observed in the mixed diets when phytase was used were due to the release of P from phytate in corn and soybean meal and not from an increase in digestibility of P in feed phosphates. However, MgP had a lower (P < 0.05) ATTD and STTD of P than MCP and MSP. In conclusion, microbial phytase does not increase the digestibility of P in MCP, MSP, or MGP, but the digestibility of P in MgP is less than in MCP and MSP.

Microbial phytase increases the digestibility by pigs of phytate-bound P in feed ingredients of plant origin, but digestible P can also be increased in diets by the addition of feed phosphates due to their high digestibility of P and lack of phytate. However, it is possible that the phytate from plant ingredients complexes with P from feed phosphates, resulting in a lower digestibility of P, but research to address this possibility has not been reported. Therefore, the hypothesis was that phytase can increase the digestibility of P in feed phosphates fed to pigs. Monocalcium phosphate (MCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) were the three feed phosphates used in the experiment and the three ingredients were included in corn-soybean meal based diets. Results indicated that the inclusion of phytase increased the digestibility of P in the diets, but there was no indication that phytase affected the digestibility of P from any of the three feed phosphates, which indicates that the increase in digestibility of P likely was due to the release of P from plant ingredients in the diets. However, the digestibility of P was lower in MgP compared with MCP and MSP.

Effects of 25-hydroxycholecalciferol (25-OH-D3) and 1-hydroxycholecalciferol (1-OH-D3) on serum bone biomarkers and calcium and phosphorus balance and concentrations of energy in diets without or with microbial phytase fed to sows in late gestation.

The objective was to test the hypothesis that supplementation of diets for gestating sows with 25-hydroxycholecalciferol (25-OH-D3) or 1-hydroxycholecalciferol (1-OH-D3) affects serum biomarkers for bone and increases Ca and P balance and the apparent total tract digestibility (ATTD) of gross energy (GE), and the concentrations of digestible energy (DE) and metabolizable energy (ME) in diets without or with microbial phytase. Sixty multiparous sows were allotted to 1 of 6 diets. Diets were formulated using a 3 × 2 factorial with 3 inclusions of supplemental vitamin D metabolite (no metabolite, 25-OH-D3, or 1-OH-D3) and 2 inclusion levels of microbial phytase (0 or 1,000 units). Sows were housed individually in metabolism crates and feces and urine were collected quantitatively. Results indicated that there was no difference in the ATTD of dry matter (DM) and GE and concentration of DE among the 3 diets containing microbial phytase, but the ATTD of DM and GE and concentration of DE was greater (P < 0.05) in diets containing 1-OH-D3 compared with the diet without a vitamin D metabolite if phytase was not used (interaction; P < 0.05). In diets without microbial phytase, ME was greater in diets containing either one of the 2 vitamin D metabolites than in the diet without a vitamin D metabolite, but among diets with microbial phytase, the ME of the 1-OH-D3 diet was less than of the 25-OH-D3 diet (interaction; P < 0.05). No effect of microbial phytase on concentrations of DE and ME was observed. There was no interaction between supplementation of microbial phytase and vitamin D metabolites for Ca and P balances, and regardless of metabolite supplementation, use of microbial phytase increased (P < 0.05) the ATTD and retention of Ca and P. Regardless of dietary phytase, the ATTD and retention of Ca and P increased (P < 0.05) for sows fed a diet containing one of the vitamin D metabolites compared with sows fed the diet without a vitamin D metabolite. Serum biomarkers for bone resorption or bone tissue synthesis were not affected by experimental diets. In conclusion, the ATTD of DM and GE, concentrations of DE and ME, and Ca and P balance in phytase-free diets fed to sows in late gestation were increased by supplementation with 1-OH-D3 or 25-OH-D3, but no differences between the 2 vitamin D metabolites were observed. Supplementation of diets with microbial phytase increased Ca and P balance, but did not affect DE and ME of diets.

The role of vitamin D is to increase absorption of calcium and phosphorus in the gastrointestinal tract and maintain serum concentrations of calcium, but dietary vitamin D needs to be converted to an active form by 2-hydroxylation steps that take place in the liver and the kidneys. The conversion efficiency to active vitamin D may be increased if pre-hydroxylated metabolites rather than vitamin D are provided, which also increases calcium and phosphorus utilization. In a previous experiment it was also demonstrated that a vitamin D metabolite increases energy absorption in gestating sows. It is possible that use of a vitamin D metabolite and phytase have additive effects and the hypothesis, therefore, was that supplementation of a vitamin D metabolite increases calcium and phosphorus balance and energy digestibility in diets fed to gestating sows without or with microbial phytase. Results indicated that in diets without phytase, the 2 vitamin D metabolites increased energy concentration in diets by increasing apparent energy digestibility. There was no interaction between supplementation of phytase and vitamin D metabolites for calcium and phosphorus balances. Use of phytase and vitamin D metabolites increased calcium and phosphorus digestibility and retention.

Microbial phytase reduces basal endogenous loss of calcium in pigs fed diets containing phytate phosphorus at commercial levels.

The objective of this experiment was to test the hypothesis that increasing dietary phytase reduces basal endogenous loss of Ca and increases P balance in pigs. Seventy barrows (initial body weight: 17.66 ± 1.69 kg) were allotted to seven Ca-free diets using a randomized complete block design with two blocks and five pigs per diet in each block. All diets were based on corn, potato protein concentrate, and full-fat rice bran. A positive control (PC) diet was formulated to contain P at the requirement for standardized total tract digestible (STTD) P by 11 to 25 kg pigs. Six negative control (NC) diets were formulated by reducing the provision of digestible P by 0.15% and adding 0, 250, 500, 1,000, 2,000, or 4,000 phytase units/kg diet. Pigs were housed individually in metabolism crates that allowed for total, but separate, collection of urine and feces. Daily feed allowance was 3.0 times the maintenance requirement for metabolizable energy and was divided into two equal meals. Diets were fed for 12 d with the first 5 d considered the adaptation period. Urine collections started on day 6 in the morning and ceased on day 10 in the morning. Fecal markers were also included in the morning meals on day 6 and day 10 and feces were collected according to the marker-to-marker procedure. Results indicated that the apparent total tract digestibility of dry matter was not affected by dietary P or phytase levels. The basal endogenous loss of Ca was not affected by dietary P, but exponentially decreased (P = 0.030) as phytase level increased in the diets. Phosphorus retention (g/d) and standardized total tract digestibility of phosphorus were greater (P < 0.05) in pigs fed the PC diet compared with pigs fed the NC diet with no phytase. The STTD of P exponentially (P < 0.001) increased as phytase level increased in the diets, but because of the lack of Ca, retention of P (% of absorbed) linearly decreased (P = 0.006) as phytase increased. In conclusion, basal endogenous loss of Ca decreased as dietary phytase increased demonstrating that endogenous Ca can be bound to phytate in the intestinal tract of pigs. However, STTD of P increased as phytase level in the diets increased.

Phytate in plant-based ingredients limits the amount of phosphorus available for absorption and can form indigestible complexes with endogenous calcium. However, breakdown of the phytate molecule by phytase increases digestibility of phosphorus and may also reduce endogenous loss of calcium. Therefore, the objective of this experiment was to test the hypothesis that level of phytase influences the utilization of phosphorus and basal endogenous loss of calcium in growing pigs fed calcium-free diets. Results demonstrated that total tract digestibility of phosphorus increased as phytase increased in the diets, but not all of the absorbed P was retained in the pigs due to a lack of calcium. Dietary concentration of phosphorus did not affect basal endogenous loss of calcium, but increasing concentrations of microbial phytase reduced basal endogenous loss of calcium. These results demonstrate that some endogenous calcium is bound to phytate, but including microbial phytase in diets helps release this calcium and therefore reduce endogenous loss of calcium.

Reduced concentrations of limestone and monocalcium phosphate in diets without or with microbial phytase did not influence gastric pH, fecal score, or growth performance, but reduced bone ash and serum albumin in weanling pigs.

An experiment was conducted to test the hypothesis that reducing limestone and monocalcium phosphate in diets for weanling pigs by lowering the concentration of Ca and P or by including microbial phytase in the diet will reduce stomach pH and fecal score and will improve growth performance of pigs. A total of 160 weanling pigs (5.75 ± 1.04 kg) were allotted to four corn-soybean meal-based diets in a completely randomized design with five pigs per pen. Diets for phase 1 (d 1 to 15) were formulated using a 2 × 2 factorial design with 2 concentrations of Ca and P (adequate or deficient levels of total Ca and digestible P) and 2 inclusion levels of phytase (0 or 2,000 units/kg feed). Phytase was assumed to release 0.16% total Ca and 0.11% digestible P. Common diets were fed in phases 2 (d 16 to 21) and 3 (d 22 to 35). Fecal scores were recorded in phase 1 and on d 15, gastric pH was measured and a blood sample and the right femur were collected from one pig per pen. Growth performance data were recorded within each phase. Results indicated that in phase 1, at deficient dietary Ca and P, pigs fed the diet with phytase had greater (P < 0.05) average daily gain (ADG) and gain to feed (G:F) compared with pigs fed the diet without phytase, but in diets with adequate levels of Ca and P, no effect of phytase inclusion was observed (interaction, P < 0.05). Without phytase, pigs fed the diet with deficient Ca and P had reduced (P < 0.05) G:F compared with pigs fed the diet with adequate Ca and P, but if phytase was included, there was no effect of Ca and P on G:F (interaction, P < 0.05). For phases 2 and 3, and from d 1 to 35, no differences among dietary treatments were observed for ADG or G:F. Bone ash was greater (P < 0.05) in pigs fed diets with adequate Ca and P than in pigs fed diets with deficient Ca and P, but no effect of phytase inclusion was observed on bone ash. Concentrations of Ca and P did not affect stomach pH or fecal score, but pigs fed diets with phytase tended (P < 0.10) to have reduced stomach pH and fecal score compared with pigs fed diets without phytase. Pigs fed diets with adequate Ca and P had greater (P < 0.05) albumin in serum than pigs fed the Ca- and P-deficient diets. In conclusion, phytase inclusion in phase 1 diets may reduce diarrhea, but lowering Ca and P does not reduce stomach pH or fecal score and decreases bone ash, although growth performance during the entire weanling period is not affected.

Sunflower expellers have greater ileal digestibility of amino acids than sunflower meal, but there are only minor variations among different sources of sunflower meal when fed to growing pigs.

The objective was to test the hypothesis that there is no effect of origin or processing procedure on the standardized ileal digestibility (SID) of amino acids (AA) and crude protein (CP) in sunflower coproducts. Six sources of sunflower meal (SFM) and one source of sunflower expellers (SFE) were obtained from Ukraine, Italy, Hungary, and the United States. Each source of SFM or SFE was the only source of CP and AA in one diet, and an N-free diet was also used for a total of eight diets. Eight barrows (body weight: 28.5 ± 2.4 kg) had a T-cannula installed in the distal ileum and were allotted to one of the eight diets using an 8 × 8 Latin square design with eight periods. The Lys:CP ratio in the six sources of SFM ranged from 3.10% to 3.96% with CP concentrations ranging from 27.34% to 36.75%. CP in SFE was 26.87% and the Lys:CP ratio was 3.51%. Concentrations of acid-hydrolyzed ether extract in the six sources of SFM ranged from 0.60% to 3.11%, but SFE contained 8.77%. Results indicated that the SID of CP was lower (P < 0.05) in SFM from Hungary compared with all other sources of SFM except for one of the sources from Ukraine. There were no differences in the SID of Lys, Met, and Trp among sources of SFM, but for most of the remaining indispensable AA, the SFM from Hungary had less (P < 0.05) SID than the other sources. However, only a few differences in the SID of indispensable AA were observed among the other sources of SFM, but the SID of CP and all AA except Trp was greater (P < 0.05) in SFE compared with SFM. In conclusion, there were only a few differences in the SID of the first-limiting AA among SFM obtained from Ukraine, Hungary, Italy, and the United States, but the SID of CP and AA was greater in SFE than in SFM indicating that processing of sunflower seeds influence the nutritional value.

Quantities of ash, Ca, and P in metacarpals, metatarsals, and tibia are better correlated with total body bone ash in growing pigs than ash, Ca, and P in other bones.

The objective was to determine correlations between individual bones and total body bone ash to identify the bone that is most representative of total body bone ash in growing pigs. Twenty growing pigs were allotted to 1 of 2 diets that were formulated to contain 60% or 100% of the requirement for standardized total tract digestible (STTD) P. Both diets had an STTD Ca to STTD P ratio of 1.90:1. Growth performance and carcass weights were determined. Metacarpals, metatarsals, femur, tibia, fibula, 3rd and 4th ribs, and 10th and 11th ribs, and all other bones from the left half of the carcass were collected separately. Each bone was defatted and ashed. Pigs fed the diet containing 100% of required Ca and P had greater (P < 0.05) average daily gain, gain to feed, and ash concentration (%) in total and all individual bones except femur and fibula compared with pigs fed the diet containing 60% of required Ca and P. Calcium and P concentrations in bone ash were not affected by dietary treatments. Weights (g) of bone ash, bone Ca, and bone P were greater (P < 0.05) or tended to be greater (P < 0.10) for pigs fed the diet containing 100% of required Ca and P. Correlation coefficients between the weight of ashed metacarpals, metatarsals, and tibia and the weight of total bone ash were >0.95. In conclusion, metacarpals, metatarsals, and tibia were more representative of total body bone ash compared with other bones.

Growth performance and carcass quality are not different between pigs fed diets containing cold-fermented low-oil DDGS and pigs fed conventional DDGS, but pelleting improves gain to feed ratio regardless of source of DDGS.

The objective of this study was to test the hypothesis that growth performance and carcass characteristics of pigs fed diets containing cold-fermented, low oil distillers dried grains with solubles (DDGS) is not different from that of pigs fed diets containing conventional DDGS regardless of the physical form of the diets. A total of 160 barrows and gilts were used. There were 4 diets, 10 pens per diet, and 4 pigs per pen. Pigs were weaned at 21 d of age and fed a common phase 1 diet that did not contain DDGS during the initial 7 d post-weaning. Pigs were then allotted to the four diets that were arranged in a 2 × 2 factorial design with two sources of DDGS (cold-fermented and conventional DDGS) and two diet forms (meal and pellets). Pigs were fed phase 2 diets from day 7 to 21 and phase 3 diets from day 21 to 43 post-weaning. All diets were based on corn and soybean meal, but phase 2 diets also contained 15% DDGS and phase 3 diets contained 30% DDGS. From day 43, pigs were fed grower diets for 38 d, early finisher diets for 38 d, and late finisher diets for 18 d and these diets also contained 30% DDGS. Feed was provided on an ad libitum basis and daily feed allotments were recorded. Pigs were weighed at the beginning of each phase and at the conclusion of the experiment. On the last day of the experiment, the pig in each pen with a body weight that was closest to the pen average was slaughtered and carcass measurements were determined. Combined results for the two nursery phases indicated that feeding meal diets instead of pelleted diets increased (P < 0.001) average daily feed intake and decreased (P < 0.05) gain to feed ratio (G:F). However, no differences between the two sources of DDGS were observed for the overall growth performance of weanling pigs. For the entire growing-finishing period, the source of DDGS did not affect growth performance, but pigs fed meal diets had reduced (P < 0.001) G:F compared with pigs fed the pelleted diets. There were no differences between the two sources of DDGS for carcass characteristics. Back fat was greater (P < 0.05) for pigs fed pelleted diets than for pigs fed meal diets. In conclusion, no differences in growth performance or carcass characteristics between pigs fed cold-fermented DDGS and pigs fed conventional DDGS were observed. However, pigs fed pelleted diets had greater G:F and greater back fat than pigs fed meal diets.

Formulation of diets for pigs based on a ratio between digestible calcium and digestible phosphorus results in reduced excretion of calcium in urine without affecting retention of calcium and phosphorus compared with formulation based on values for total calcium.

An experiment was conducted to test the hypothesis that formulating diets for pigs based on a ratio between standardized total tract digestible (STTD) Ca and STTD P instead of total Ca and STTD P does not decrease Ca retention, but increases P utilization. Forty barrows (59.4 ± 3.8 kg) were individually housed in metabolism crates and allotted to four corn-soybean meal-based diets in a randomized complete block design with two blocks and five pigs per diet in each block. Diets were formulated using a 2 × 2 factorial design with two diet formulation principles (total Ca or STTD Ca) and two inclusion levels of microbial phytase (0 or 500 units per kg of feed). Phytase was assumed to release 0.11% STTD P and 0.16% total Ca. Diets were formulated based on requirements for total Ca and STTD P or a ratio between STTD Ca and STTD P of 1.25:1. Diets were fed for 11 d and fecal and urine samples were collected from feed provided from day 6 to day 10. Interactions (P < 0.05) between diet formulation principle and phytase level were observed for Ca intake, Ca in feces, Ca absorbed, Ca retained, P digestibility, P absorbed, and P in urine. Phytase increased (P < 0.05) the digestibility of Ca in both total Ca and STTD Ca diets. Without phytase, Ca intake, Ca in feces, and Ca absorbed was greater (P < 0.05) from pigs fed total Ca diets than from pigs fed STTD Ca diets, but P absorbed, P digestibility, and P in urine was greater (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. However, in the presence of phytase, no differences between diet formulation principles were observed in these variables. Regardless of phytase, Ca in urine was lower (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. There were no differences in Ca retention between pigs fed STTD Ca diets and total Ca diets, but pigs fed total Ca diets retained less (P < 0.05) Ca if diets contained phytase. No differences in P retention were observed between diet formulation principles, but pigs fed non-phytase diets retained more (P < 0.05) P than pigs fed diets with phytase. In conclusion, because diets formulated based on STTD Ca contain less Ca than total Ca diets, pigs fed STTD Ca diets excreted less Ca in urine, but retention of Ca was not affected. Formulating non-phytase diets based on STTD Ca instead of total Ca increased P absorption, which confirms the detrimental effect of excess Ca on P digestibility. However, P retention was not improved if pigs were fed STTD Ca diets.

Addition of hydrochloric acid to collection bags or collection containers did not change basal endogenous losses or ileal digestibility of amino acid in corn, soybean meal, or wheat middlings fed to growing pigs.

OBJECTIVE: The hypothesis was that apparent ileal digestibility (AID), basal endogenous losses, and standardized ileal digestibility (SID) of amino acids (AA) are not affected by adding acid to collection containers or bags used to collect ileal digesta from pigs. METHODS: Twenty-four growing barrows (initial body weight: 77.8±4.5 kg) that were fitted with a T-cannula in the distal ileum were fed diets for three 7-d periods. An N-free diet and 3 diets containing corn, soybean meal, or wheat middlings as the sole source of AA were used. Within each period, each of the 4 diets were fed to 6 pigs. Among the 6 pigs, digesta from 3 pigs were collected in bags containing no HCl, whereas 40 mL of 3 N HCl was included in the bags used to collect digesta from the remaining 3 pigs. Every other bag collected from each pig was emptied into a container without adding HCl, whereas the remaining bags were added to a container along with 40 mL of 3 N HCl for each bag. All digesta were stored at -20°C immediately after collection. Data were analyzed using a model that included feed ingredient, HCl in bags, HCl in containers, and all 2-way and 3-way interactions as fixed effects. No 3-way interactions were significant, and data were, therefore, reanalyzed independently for each diet as a 2×2 factorial. RESULTS: There were no interactions between adding HCl to collection bags and to containers, and no effects of adding HCl to collection bags or containers for AID, basal endogenous losses, or SID of most AA were observed. CONCLUSION: It is not necessary to add acid to digesta collection bags or collection containers if ileal digesta are stored at -20°C immediately after collection.

Formulating diets based on digestible calcium instead of total calcium does not affect growth performance or carcass characteristics, but microbial phytase ameliorates bone resorption caused by low calcium in diets fed to pigs from 11 to 130 kg.

An experiment was conducted to test the hypothesis that the requirement for Ca expressed as a ratio between standardized total tract digestible (STTD) Ca and STTD P obtained in short-term experiments may be applied to pigs fed diets without or with microbial phytase from 11 to 130 kg. In a 5-phase program, 160 pigs (body weight: 11.2 ± 1.8 kg) were randomly allotted to 32 pens and 4 corn-soybean meal-based diets in a 2 × 2 factorial design with 2 diet formulation principles (total Ca or STTD Ca), and 2 phytase inclusion levels (0 or 500 units/kg of feed) assuming phytase released 0.11% STTD P and 0.16% total Ca. The STTD Ca:STTD P ratios were 1.40:1, 1.35:1, 1.25:1, 1.18:1, and 1.10:1 for phases 1 to 5, and STTD P was at the requirement. Weights of pigs and feed left in feeders were recorded at the end of each phase. At the conclusion of phase 1 (day 24), 1 pig per pen was euthanized and a blood sample and the right femur were collected. At the end of phases 2 to 5, a blood sample was collected from the same pig in each pen. At the conclusion of the experiment (day 126), the right femur of 1 pig per pen was collected and carcass characteristics from this pig were measured. No interactions were observed between diet formulation principle and phytase inclusion for growth performance in any phase and no differences among treatments were observed for overall growth performance. Plasma Ca and P and bone ash at the end of phase 1 were also not influenced by dietary treatments. However, on day 126, pigs fed nonphytase diets formulated based on total Ca had greater bone ash than pigs fed STTD Ca-based diets, but if phytase was used, no differences were observed between the 2 formulation principles (interaction P < 0.05). At the end of phases 2 and 3, pigs fed diets without phytase had greater (P < 0.05) plasma P than pigs fed diets with phytase, but no differences were observed at the end of phases 4 and 5. A negative quadratic effect (P < 0.05) of phase (2 to 5) on the concentration of plasma Ca was observed, whereas plasma P increased (quadratic; P < 0.05) from phases 2 to 5. However, there was no interaction or effect of diet formulation principle or phytase inclusion on any carcass characteristics measured. In conclusion, STTD Ca to STTD P ratios can be used in diet formulation for growing-finishing pigs without affecting growth performance or carcass characteristics and phytase inclusion ameliorates bone resorption caused by low dietary Ca and P.

Intrinsic phytase in hybrid rye increases the digestibility of phosphorus in corn and soybean meal in diets fed to growing pigs.

An experiment was conducted to test the hypothesis that inclusion of hybrid rye in diets containing corn and soybean meal (SBM) without or with microbial phytase improves the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P because of the intrinsic phytase activity in hybrid rye. Forty-eight growing barrows (initial body weight: 39.5 ± 7.7 kg) were allotted to six diets. A basal diet containing corn and SBM; a rye-based diet; and a diet containing corn, SBM, and rye were formulated. Each diet was formulated without and with microbial phytase (500 units/kg of diet) for a total of six diets. Fecal samples were collected for 4 d following a 5-d adaptation period according to the marker-to-marker procedure. Results indicated that no interactions between diets and concentration of phytase were observed for any of the response criteria measured. The ATTD and STTD of P and the ATTD of Ca differed (P < 0.05) among diets, but regardless of diet, the concentration of P in feces was reduced (P < 0.05) by adding microbial phytase to the diets. As a consequence, microbial phytase increased (P < 0.05) ATTD and STTD of P, and the ATTD of Ca was also increased (P < 0.05) by the use of microbial phytase. Measured values for the ATTD and STTD of P in the diets containing corn, SBM, and hybrid rye without or with phytase were greater (P < 0.05) than values that were predicted based on the ATTD and STTD of P for the corn-SBM and the hybrid rye diet. The observation that STTD predicted from the individual ingredients underestimated the STTD of P in the mixed diet indicates that the intrinsic phytase in hybrid rye resulted in increased digestibility of the P in the corn and SBM included in the corn-SBM-hybrid rye diet. In conclusion, microbial phytase increased the ATTD and STTD of P and the ATTD of Ca regardless of feed ingredients used in diets fed to pigs. In addition, the intrinsic phytase from hybrid rye increased the ATTD and STTD of P in corn and SBM.

Digestibility of amino acids, but not fiber, fat, or energy, is greater in cold-fermented, low-oil distillers dried grains with solubles (DDGS) compared with conventional DDGS fed to growing pigs.

Two experiments were conducted to test the hypothesis that the digestibility of gross energy (GE) and nutrients, and concentrations of digestible energy (DE) and metabolizable energy (ME) in two sources of distillers dried grains with solubles (DDGS) are not different despite different concentrations of fat in the two sources. Cold-fermented DDGS (6.82% fat) and a conventional DDGS (9.54% fat) were used. In experiment 1, 12 growing barrows (initial body weight = 55.2 ± 3.6 kg) that had a T-cannula installed in the distal ileum were allotted to one of three diets and two periods. Two diets contained either cold-fermented or conventional DDGS as the sole source of crude protein (CP) and amino acids (AA). The third diet was an N-free diet that was used to determine the basal endogenous losses of AA from the pigs. Each experimental period lasted 7 d and ileal digesta were collected on days 6 and 7 of each period. Results demonstrated that values for the standardized ileal digestibility (SID) of CP and most AA were greater (P < 0.05) or tended to be greater (P < 0.10) in cold-fermented than in conventional DDGS. In experiment 2, 24 barrows (initial body weight = 17.3 ± 1.3 kg) were randomly allotted to three diets with 8 replicate pigs per diet. A corn-based basal diet and two diets containing corn and either cold-fermented DDGS or conventional DDGS were formulated. Pigs were housed individually in metabolism crates and feces and urine were collected separately for 5 d after 7 d of adaptation. The apparent total tract digestibility (ATTD) of neutral detergent fiber (NDF), acid detergent fiber (ADF), and acid-hydrolyzed ether extract (AEE) was greater (P < 0.01) in conventional DDGS than in cold-fermented DDGS, but there was no difference in ATTD of GE between the two sources of DDGS. However, conventional DDGS contained more (P < 0.001) DE and ME than cold-fermented DDGS because of greater GE. In conclusion, the SID of AA was greater in cold-fermented DDGS than in the conventional DDGS that was evaluated in this experiment, but the ATTD of NDF, ADF, and AEE, and ME were greater in conventional DDGS than in cold-fermented DDGS.

Digestibility of amino acids and concentrations of metabolizable energy and net energy are greater in high-shear dry soybean expellers than in soybean meal when fed to growing pigs.

Soybean expellers may be produced by dry extrusion and mechanical oil pressing of soybeans, but there is limited information about the nutritional value of expellers produced via this procedure. Therefore, 2 experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of CP and amino acids (AA), apparent total tract digestibility (ATTD) of energy and total dietary fiber (TDF), and concentrations of DE, ME, and NE are greater in soybean expellers than in soybean meal (SBM) when fed to growing pigs. Pigs were the offspring of Line 359 boars mated to Camborough females (Pig Improvement Company, Hendersonville, TN). In experiment 1, nine growing barrows (initial BW: 55.98 kg ± 13.75 kg) with T-cannulas installed in the distal ileum were allotted to 1 of 3 diets using a triplicated 3 × 3 Latin square design with 3 periods. Two diets were formulated to contain 35% soybean expellers or 33% SBM as the sole source of AA. A N-free diet was used to determine basal endogenous losses of AA. Ileal digesta were collected on days 6 and 7 of each 7-d period. Results indicated that the SID of most indispensable and dispensable AA were greater (P < 0.05) or tended (P < 0.10) to be greater in soybean expellers than in SBM. In experiment 2, a corn-based diet and 2 diets based on corn and each of the 2 soybean products were formulated. Twenty-four growing barrows (initial BW: 44.88 kg ± 2.17 kg) were allotted to 1 of the 3 diets with 8 pigs per diet. Urine and fecal samples were collected for 4 d after 5 d of adaptation. Results indicated that the ATTD of energy and TDF was not different between soybean expellers and SBM, but the ATTD of TDF in the 2 soybean products was greater (P < 0.05) than in corn. Concentrations of DE and ME in soybean expellers were greater (P < 0.05) compared with corn or SBM. Soybean expellers had greater (P < 0.05) calculated NE compared with SBM, but there was no difference in NE between corn and soybean expellers. In conclusion, values for SID of most AA and DE, ME, and NE in soybean expellers were greater than in SBM.

A new source of high-protein distillers dried grains with solubles (DDGS) has greater digestibility of amino acids and energy, but less digestibility of phosphorus, than de-oiled DDGS when fed to growing pigs.

AbstractThree experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of amino acids (AA), concentration of metabolizable (ME), and standardized total tract digestibility (STTD) of P in a new source of distillers dried grains with solubles (DDGS; ProCap DDGS) are greater than in conventional de-oiled DDGS. In experiment 1, nine barrows (initial BW: 67.2 ± 6.4 kg) with a T-cannula in the distal ileum were allotted to a triplicated 3 × 3 Latin square design with three diets and three periods for a total of nine replicate pigs per diet. Two diets included ProCap DDGS or de-oiled DDGS as the sole source of crude protein (CP) and AA. An N-free diet was used to determine the basal endogenous losses of CP and AA. Ileal digesta were collected on days 5 and 6 of each period after 4 d of adaptation to diets. Results from experiment 1 indicated that ProCap DDGS contained more CP and AA compared with de-oiled DDGS. The SID of all AA in ProCap DDGS was greater (P < 0.001) compared with de-oiled DDGS with the exception that the SID of Pro was not different between the two sources of DDGS. In experiment 2, 24 growing barrows (initial BW: 32.7 ± 3.1 kg) were housed individually in metabolism crates and used in a randomized complete block design and fed a corn-based diet or two diets containing corn and each source of DDGS with eight replicate pigs per diet. Fecal and urine samples were collected for 4 d after 7 d of adaptation. Results from experiment 2 indicated that concentration of ME in ProCap DDGS was greater (P < 0.05) compared with corn or de-oiled DDGS. In experiment 3, 32 growing barrows (initial BW: 20.2 ± 0.9 kg) were placed in metabolism crates and allotted to four diets with eight pigs per diet using a 2 × 2 factorial treatment arrangement. The de-oiled DDGS and ProCap DDGS were both included in a diet without microbial phytase and a diet with microbial phytase (500 units/kg diet). Pigs were adapted to the diets for 5 d and fecal samples were collected for 4 d. Results from experiment 3 indicated that inclusion of phytase in the diet containing ProCap DDGS increased (P < 0.05) the STTD of P, but addition of phytase to the de-oiled DDGS diet did not increase STTD of P (interaction, P < 0.001), but the STTD of P was greater (P < 0.05) in de-oiled DDGS compared with ProCap DDGS. In conclusion, ProCap DDGS has greater SID of AA and contains more ME, but has reduced STTD of P compared with conventional de-oiled DDGS.

Increasing calcium from deficient to adequate concentration in diets for gestating sows decreases digestibility of phosphorus and reduces serum concentration of a bone resorption biomarker.

The objective of this experiment was to test the hypothesis that the concentration of Ca in diets fed to late gestating sows affects the apparent total tract digestibility (ATTD) and retention of Ca and P, serum concentrations of Ca and P, hormones, and blood biomarkers for bone formation and resorption. Thirty-six sows (average parity = 2.8) were housed in metabolism crates from day 91 to day 104 of gestation and fed 1 of 4 experimental diets containing 25, 50, 75, or 100% of the requirement for Ca. All diets met the requirement for P. The initial 5 d of each period were the adaptation period, which was followed by 4 d of quantitative collection of feces and urine. At the end of the collection period, a blood sample was collected from all sows. Results indicated that feed intake, weights of dried fecal and urine samples, and the ATTD of DM were not affected by dietary Ca, but ATTD of Ca increased (quadratic, P < 0.05) as Ca in diets increased. Urine Ca output was not affected by dietary Ca, but Ca retention increased (quadratic, P < 0.05) as Ca intake increased. Fecal P output increased (linear, P < 0.001) as dietary Ca increased, which resulted in a linear decrease (P < 0.001) in the ATTD of P. Urine P output also decreased (linear, P < 0.001) as dietary Ca increased, but P retention increased (linear, P < 0.05). Regressing the apparent total tract digestible Ca against dietary Ca intake resulted in a regression line with a slope of 0.33, indicating that true total tract digestibility of Ca in calcium carbonate was 33%. Serum concentrations of Ca and P and estrogen, calcitonin, and parathyroid hormone were not affected by dietary Ca. Serum concentration of carboxyterminal cross-linked telopeptide of type I collagen (CTX-I) decreased (linear, P < 0.05) as dietary Ca increased, which is a result of reduced bone resorption as dietary Ca increased. Serum bone-specific alkaline phosphatase tended to decrease (linear, P < 0.10) as Ca in diets increased, but the concentration of osteocalcin (OC) in serum was not affected by dietary Ca. The ratio between OC and CTX-I tended to increase (P < 0.10) as dietary Ca increased, which indicated that there was more bone formation than resorption in sows as dietary Ca increased. In conclusion, P digestibility in late gestating sows decreased, but retention of P increased, as dietary Ca increased from inadequate to adequate levels and blood biomarkers for bone resorption changed as Ca and P retention increased.