Natural faecal fluorophores and the potential of chlorophyll based markers to optimise fluorescence as a real-time solution for the detection of faecal contamination on carcasses.

More accurate and sensitive visualisation of faecal contamination in the abattoir would significantly reduce the risk posed by harbouring pathogenic micro-organisms. We carried out a preliminary investigation of the range of fluorophores found naturally in faeces from typical ruminant diets. Sixteen ewes were offered either: i) fresh forage (FF), ii) grass silage (GS), iii) grass hay (GH) or iv) concentrate and barley straw (CB). Animals offered FF diets had a greater concentration (P<0.001) of chlorophyll based compounds in their faeces and subsequent fluorescent emission spectra. In a second experiment we investigated a range of fluorescent markers against a basal concentrate and barley straw diet. Ten Cheviot sheep were split into five treatment groups during a duplicate 5 × 5 Latin square design. Four of the groups received a chlorophyll based marker at a rate of 2g/d: i) Mg-Chlorophyllin (MgC), ii) Fe-Chlorophyllin (FeC), iii) Zn-Chlorophyllin (ZnC) or iv) Spirulina (Chlorophyll a extract from blue green algae, Sp). The last group received no supplement as the control (Con). The appearance of chlorophyllin markers and their derivatives in faeces was similar with mean concentrations of 3.1 and 7.2 µg/g DM, respectively. The most intense fluorescent signal was shown with MgC followed by ZnC, FeC, Sp and Con at 685 nm. The use of markers in pre-slaughter diets would improve the accuracy of faecal detection as a result of greater fluorescence and specific emission wavelengths which do not overlap with natural meat components to help with visualisation.

Active photosensitizers in butter detected by fluorescence spectroscopy and multivariate curve resolution.

In this study, fluorescence excitation and emission matrices and multivariate curve resolution (PARAFAC) were used to detect and characterize active photosensitizers spectrally in butter. Butter samples were packed under high (air) and low oxygen (<0.05%) atmospheres and exposed to violet, green, or red light. Six photosensitizers were found: riboflavin, protoporphyrin, hematoporphyrin, a chlorophyll a-like molecule, and two unidentified tetrapyrrols. By estimation of relative concentrations, we could follow how each sensitizer was photodegraded as function of wavelength, oxygen level, and time. The degradation rate of protoporphyrin, hematoporphyrin, chlorophyll a, and one of the tetrapyrrols correlated well (0.83-0.91) with the formation of sensory measured oxidation. The results suggest that mainly type I photoreactions were responsible for the degradation of photosensitizers in both high and low oxygen atmosphere. Type II photoreactions (generation of singlet oxygen) were involved in the oxidation of butter stored in air. The study shows that PARAFAC modeling of fluorescence landscapes is an excellent tool for studying photooxidation in complex systems.

Nondestructive measurement of light-induced oxidation in dairy products by fluorescence spectroscopy and imaging.

The purpose of this paper is to demonstrate the potential of solid-sample fluorescence spectroscopy in nondestructive assessment of light-induced oxidation in different dairy products such as Swiss cheese, cream cheese, and sour cream. Analytical and quantitative spectral properties of fluorescence were elucidated by use of principal component analysis with designed experiments involving different levels of air and light exposure. A significant reduction in fluorescence intensity at approximately 525 nm, and a corresponding increase in the region 415 to 490 nm as a result of illumination was observed on all the products. The effect was ascribed to photodegradation of riboflavin. Variation in two smaller peaks at approximately 620 nm and 630 nm was an interaction effect between exposure to light and air. A pronounced interaction effect between light and air produced intense blue fluorescence and off-flavors on Swiss-like Jarlsberg cheese. High correlations (0.83 to 0.93) between fluorescence spectra and sensory measured off-flavors were obtained for cream cheese. Results indicate that solid-sample fluorescence can be used as a nondestructive and rapid tool to measure the degree of light-induced degradation of riboflavin as well as sensory properties connected to storage of dairy products. Images of fluorescence can be used to visualize the intensity and propagation of this process. The simplicity and rapidity of the method offer rich opportunities for efficient evaluation of factors affecting light-induced oxidation in dairy products, such as packaging materials, light sources, exposure time, and temperature.

The effect of evaporative air chilling and storage temperature on quality and shelf life of fresh chicken carcasses.

The effect of evaporative air chilling on quality of fresh chicken carcasses was compared with air chilling as reference method. Cooling efficiency and total heat loss were significantly higher for evaporative air chilling. The chilling method was of great importance for weight loss. Chicken chilled in cold air lost considerably more weight than chicken cooled by evaporative air chilling; the difference was 1.8%. The chilling method also affected the skin color and the amount of moisture on skin surface. After evaporative air chilling, the chicken carcasses had a lighter color and more water on the back and under the wings. The moisture content in skin and meat, cooking loss, and pH were not affected by chilling method. Odor attributes of raw chicken and odor and flavor attributes of cooked chicken did not show any significant differences between the two chilling methods. The shelf life of chicken stored at 4 and -1 C were not affected significantly by chilling method. Storage time and temperature appeared to be the decisive factors for sensory and microbiological quality of fresh chicken carcasses.