RESUMO
Sour cherry pomace filling (SCPF) and commercial sour cherry filling (CSCF) produced on a semi-industrial scale were tested and compared in terms of food safety, chemical composition, bioactivity, quality, sensory properties and thermal stability. Both samples were safe for human consumption, thermally stable and there was a lack of syneresis. SCPF had a significantly higher fiber concentration (3.79 g/100 g) due to higher skin fraction and is considered a "source of fibers". The higher skin fraction in SCPF also resulted in a higher mineral quantity (Fe-3.83 mg/kg fw) in comparison to CSCF (Fe-2.87 mg/kg fw). Anthocyanins concentration was lower in SCPF (7.58 mg CGE/100 g fw), suggesting that a significant amount of anthocyanins was removed from SC skin during juice extraction. However, there was a lack of statistical differences in antioxidant activity between the two fillings. CSCF was more spreadable, not as firm and less sticky, with lower storage and loss modulus values than SCPF. However, both fillings exhibited acceptable rheological and textural behaviour for fruit fillings. According to the consumer pastry test, 28 participants preferred each pastry; thus, there was a lack of preference toward any of the tested samples. SCP could be used as a raw material for the bakery fruit fillings industry, which leads to the valorization of food industry by-products.
RESUMO
In this study, levan from Bacillus licheniformis NS032 was modified in an aqueous medium by octenyl succinic anhydride (OSA), and the properties of the obtained derivatives were studied. The maximum efficiency in the synthesis reaction was achieved at 40 °C and a polysaccharide slurry concentration of 30 %. Increasing the reagent concentration (2-10 %) led to an increase in the degree of substitution (0.016-0.048). Structures of derivatives were confirmed by FTIR and NMR. Scanning electronic microscopy, thermogravimetry, and dynamic light scattering analyses showed that the derivatives with degrees of substitution of 0.025 and 0.036 retained levan's porous structure and thermostability and showed better colloidal stability than the native polysaccharide. The intrinsic viscosity of derivatives increased upon modification, while the surface tension of the 1 % solution was lowered to 61 mN/m. Oil-in-water emulsions prepared with sunflower oil (10 % and 20 %) by mechanical homogenization and 2 and 10 % derivatives in the continuous phase showed mean oil droplet sizes of 106-195 µm, while the distribution curves exhibited bimodal character. The studied derivatives have a good capacity to stabilize emulsions, as they have a creaming index ranging from 73 % to 94 %. The OSA-modified levans could have potential applications in new formulations of emulsion-based systems.
Assuntos
Amido , Anidridos Succínicos , Emulsões/química , Amido/química , Anidridos Succínicos/química , FrutanosRESUMO
BACKGROUND: Knowledge about specific functional characteristics, such as viscosimetric, conductometric, tensiometric and structural properties of polysaccharide aqueous solutions is highly important in the successful and adequate application in food emulsion formulation. For the first time detailed characterization of sugar beet fibers aqueous solutions in comparison to high molecular weight (sugar beet pectin) and low molecular weight [octenyl succinic anhydride (OSA) maltodextrin] hydrocolloids/stabilizers was performed through viscometry, conductometry, tensiometry and component analysis. RESULTS: Sugar beet fibers and its water-soluble fraction were investigated. All sugar beet fiber samples showed substantial surface-active properties but different effect on the viscosity values of aqueous solutions. Sugar beet pectin had higher impact on aqueous solutions viscosity values compared to sugar beet fiber samples. Structural bonding between investigated polysaccharides were evaluated through conductometric measurements. Intermolecular linking and probable embedding of OSA maltodextrin molecules into the sugar beet fiber complex structure was detected in conductometric studies. The increased concentration of sugar beet fibers in the presence of sugar beet pectin led to the accelerated increase in specific conductivity values indicating effects of 'macromolecular crowding', intermolecular and intramolecular conformation changes and charge formation. CONCLUSIONS: Detailed characterization of sugar beet fibers provided scientific insight towards fundamental characteristics of sugar beet fiber aqueous solutions. The presented characteristics are particularly applicable in the field of food emulsion stabilization due to the presented surface-active properties of sugar beet fibers as well as specific characteristics of investigated multi-polysaccharide systems. © 2022 Society of Chemical Industry.
Assuntos
Beta vulgaris , Condutometria , Pectinas/química , Beta vulgaris/química , Anidridos Succínicos , Emulsões/química , Água/química , Fibras na Dieta , AçúcaresRESUMO
The effect of convective hot air and vacuum drying alone and combined with germination on alfalfa seeds' proximate composition, techno-functional, thermal and structural properties was investigated. Corresponding properties of treated alfalfa samples were compared with those of commercially available alfalfa sprouts. Both drying and combined germination and drying treatments resulted in increased carbohydrates (41.99-48.82 %), TDF (10.51-12.51 %) and Mg contents (789.49-2119.24 mg/kg), while the reduction in ash, lipid and Fe content compared to raw alfalfa seeds was observed. Alfalfa seeds subjected to combined germination and drying treatment exhibited higher water and oil binding capacities, as well as emulsions with smaller volume mean droplet diameters compared to the raw and dried samples. Conducted treatments resulted in greater thermal stability of globulins and a slight decrease in crystallinity index, although alfalfa seeds' structure did not change significantly according to FTIR analysis. Differences in applied drying techniques on alfalfa seeds' properties were not observed.
Assuntos
Microbiologia de Alimentos , Medicago sativa , Vácuo , Contagem de Colônia Microbiana , Sementes , Água/química , Lipídeos/farmacologia , Carboidratos , GerminaçãoRESUMO
The aim of this study was to test the suitability of three different ancient wheat varieties (emmer, spelt and khorasan) to produce spontaneously fermented sourdough bread and to evaluate the impact on the dough rheological properties, ultrastructure and baking quality. Modern wheat sourdough bread and bakery yeast fermented bread were used as controls. Sourdoughs produced from modern and ancient wheats exerted different effects on dough viscoelastic properties, bread specific volume, texture, firming rate, colour and sensory properties, while there was no influence on bread water activity. Both khorasan sourdough, being characterised with the highest dough strength and dense gluten protein matrix, and emmer sourdough, with loose and thin gluten strands of low strength, yielded breads characterised by low specific volume and hard crumb texture. Spelt and modern wheat sourdough were characterised by foam-like dough structures with entrapped gas cells leading to breads of similar specific volume and texture. Although the yeast-fermented wheat flour exerted a higher specific volume and the lowest firmness, the sourdough wheat flour bread had a lower firming rate. A comparison of sourdough bread prepared with modern and ancient wheats revealed that breads based on ancient varieties possess a less noticeable sour taste, odour and flavour, thus contributing to more sensory-appealing sourdough bread.
RESUMO
Gluten-free cookies based on rice and chickpea flour with reduced-fat and increased protein content compared with conventional commercial gluten-free cookies were developed and used as a base for further vegetable fat replacement with chia seed hydrogel. Rheological properties of chia seed hydrogel revealed that 8% gels exhibited the optimal properties as a fat substitute. Designed cookie samples were characterized for their chemical composition, fatty acid profile, mineral content, physical, textural and color parameters, and sensory properties. All gluten-free cookies developed in this study could be labeled as "a source of iron and potassium", while those with chia seed hydrogel and cocoa powder could bear the additional claim "high in zinc and magnesium". Fat replacement with chia seed hydrogel resulted in a more favorable fatty acid composition with a PUFA/SFA ratio over 0.40 and nonsignificant changes in the cookies' hardness, weight, eccentricity, and specific volume, indicating that the chia seed hydrogel addition did not disturb the cookie structure and texture. The results of the sensory analysis confirmed that it is possible to apply chia seed hydrogel to produce reduced-fat cookies with sensory properties comparable to their full-fat counterpart and available commercial samples, and they are more appealing than commercial reduced-fat gluten-free cookies.
RESUMO
This study aimed to determine the impact of ancient wheat varieties (emmer, spelt and khorasan) and spontaneous sourdough fermentation on the bioaccessibility of total phenolic content (TPC) and the DPPH antioxidant capacity evolution during breadmaking and in vitro digestion. Sourdough and yeast-fermented modern wheat breads were used as controls. After 6 h of fermentation, the total titrable acidity of the sourdough increased from 139 to 167%. The wheat variety, type of fermentation and processing affected TPC, antioxidant activity and bioaccessibility. Antioxidant activity and TPC were reduced by dough mixing, increased after sourdough fermentation and slightly decreased or remained the same after baking. Although wheat flour had the highest TPC, the modeling of TPC kinetic revealed that emmer and spelt sourdough exhibited a higher bound phenolics release rate due to the higher acidity, which contributed to increased phenolics solubility. Although wheat bread, both before and after digestion, had the lowest TPC, especially the one prepared with yeast, high TPC bioaccessibilities and antioxidant activities after the digestion suggested that, except phenolics, digestion process improved the release of additional compounds with different bioaccessibility and biological activity. The results of this study proved that the application of sourdough fermentation can increase the potential of ancient wheats in the developing of functional bakery products.
RESUMO
The aim of this study was to utilize grape pomace, as a polyphenol-rich by-product of wine production, in the manufacture of enriched cocoa spread. The formulation of the cocoa spread has been modified by substitution of refined sunflower oil with cold-pressed grape seed oil. The spread with grape seed oil (Cg) was further enriched with grape seed extract encapsulated on maltodextrins (E), where 10% and 15% of E was added to Cg obtaining the samples Cg10 and Cg15. The results showed an increase in volume-weighted mean in spread samples, from 19.17 µm in Cg to 19.71 µm in Cg10 and 21.04 µm in Cg15. Casson yield stress and Casson viscosity significantly (p Ë 0.05) increased from 16.41 Pa and 1.58 Pa·s in Cg to 29.45 Pa and 5.70 Pa·s in Cg15 due to the reduction of the fat-phase content in enriched spreads. The addition of E had no significant effect on the melting temperature (Tpeak) of the enriched spreads, while increasing the amount of E significantly (p Ë 0.05) increased their hardness. The incorporation of grape seed oil in the cocoa spread formulation contributed to an increase in total polyphenols and flavonoids. Moreover, the addition of 10% and 15% of E to Cg resulted in approximately 1.5× and 2× higher content of phenolic compounds in Cg10 and Cg15 compared to control spread with sunflower oil (Cs). Flavonoids increased from 0.43 mg CE/g in Cs to 0.74 mg CE/g in Cg 10 and 1.24 mg CE/g in Cg15. Encapsulates positively affected sensory characteristics of enriched spread samples by reducing their grape seed oil aroma and sweetness.
RESUMO
Whey protein and sourdough ferment were used in different combinations to prepare functional sponge cakes, and their mutual influence on batter rheological behaviour as well as product physico-chemical, textural, colour and sensory properties were evaluated. All samples containing whey protein concentrate could bear the nutrition claim 'a source of protein'. The substitution of wheat flour with whey protein significantly influenced batter viscoelastic behaviour, lowered cake-specific volume, increased product hardness, chewiness, gumminess, and browning index and modified its sensory characteristics. The incorporation of sourdough in protein-enriched sponge cakes improved product-specific volume and appearance compared to a protein-containing sample without sourdough. Although sourdough addition has less of a deteriorating effect on sponge cake rheological and textural properties, when combined with whey protein, it led to a significant reduction in batter elasticity and an increase in product hardness. It was also shown that spontaneously fermented sourdough cannot act as the only leavening agent in sponge cake production. In general, the results of this study have shown that sourdough addition can contribute to improvement in protein-enriched sponge cake quality and that further investigations are necessary in terms of different sourdough and flour type incorporation to minimize the negative effects of protein addition.
RESUMO
One of the major challenges in sustainable waste management in the agri-food industry following the "zero waste" model is the application of the circular economy strategy, including the development of innovative waste utilization techniques. The conversion of agri-food waste into carriers for the immobilization of enzymes is one such technique. Replacing chemical catalysts with immobilized enzymes (i.e., immobilized/heterogeneous biocatalysts) could help reduce the energy efficiency and environmental sustainability problems of existing chemically catalysed processes. On the other hand, the economics of the process strongly depend on the price of the immobilized enzyme. The conversion of agricultural and food wastes into low-cost enzyme carriers could lead to the development of immobilized enzymes with desirable operating characteristics and subsequently lower the price of immobilized enzymes for use in biocatalytic production. In this context, this review provides insight into the possibilities of reusing food industry wastes, namely, eggshells, coffee grounds, and brown onion skins, as carriers for lipase immobilization.
RESUMO
Research background: Despite the growing trend of the gluten-free market and the presence of a wide range of gluten-free products, there are still some shortcomings in nutritional and sensory quality of these products. The commercially available gluten-free products are characterised as products of inferior nutritional quality, particularly in terms of protein and dietary fibre content and with high glycaemic index. On the other hand, from a sensory point of view, gluten-free products usually have inappropriate textural and mechanical properties, poor mouthfeel and flavour. This is a consequence of the limiting choice of raw materials that mainly possess large amount of carbohydrate components. Experimental approach: Chickpea flour and two types of pumpkin seed press cake flour (virgin and cold pressed), at two substitution mass fractions (20 and 35%), were blended to produce gluten-free crackers without the presence of conventional gluten-free starch-rich ingredients. This study aims to investigate the effect of these non-conventional flours on nutritional and physicochemical properties, sensory acceptability, antioxidant activity and glycaemic index of crackers. Results and conclusions: All produced crackers can bear nutritional claims 'high fibre', 'source of protein' and 'source of minerals'. Replacing chickpea flour with pumpkin seed press cake flour increased protein and total phenolic content and enhanced antioxidant activity. The selected combination of raw materials allows the production of gluten-free crackers with a moderate glycaemic index. Besides nutrient content, the addition of cold-pressed flour increased overall sensory acceptability, noticeably improving taste and flavour scores compared to the control and crackers with virgin pumpkin seed flour. Novelty and scientific contribution: To the best of our knowledge, there is no study investigating the use of chickpea and pumpkin seed press cake flour blend without using conventional gluten-free flour and starch. The used non-conventional flour represents complementary raw materials in terms of protein quality and valuable alternatives to produce nutrient-rich, health-promoting gluten-free crackers with reduced glycaemic response and acceptable sensory properties.
RESUMO
Research background: By tailoring dietary fibre's structural and physicochemical properties, their functionality and applicability can be remarkably increased. One of the approaches used in this respect is fibre particle size reduction. Accordingly, the present study explores the impact of short-time micronization in a planetary ball mill on structural and thermal changes of modified and commercial sugar beet fibre, inulin and sucrose for their potential application as food excipients. Experimental approach: Short-time micronization in a planetary ball mill (30 and 60 min) was applied for particle size reduction of modified and commercial sugar beet fibre, inulin and sucrose as less energy-consumptive and less destructive approach than long-time micronization. Dietary fibre and sucrose samples were characterised in terms of particle size, morphology, intermolecular bonds and presence of functional groups, crystallinity and thermal properties, before and after the short-time micronization. Results and conclusions: Particle size was successfully reduced to micron-scale already after 30 min of micronization in most of the samples without significant changes in thermal properties and crystallinity or present functional groups. An enhanced particle size decrease with prolonged micronization time (60 min) was noticed in modified sugar beet fibre with slightly wider particle size distribution than in other examined samples. Furthermore, morphology and exposure of the present functional groups in samples were altered by the micronization, which is favourable for their further application as excipients in the food matrix. Novelty and scientific contribution: The corresponding research reports the short-time micronization impact on sugar beet fibre and modified sugar beet fibre, inulin and sucrose for the first time, hence contributing to the widening of their application as excipients in diverse products.
RESUMO
Resistant starch (RS) is a part of insoluble dietary fiber, and it could be recognized as a functional food ingredient in some types of confectionery products that lack dietary fiber. Unlike dark and milk chocolate, white chocolate does not contain fat-free cocoa solids rich in dietary fiber. In the present study, 5%, 10%, and 15% of white chocolate were substituted with RS in order to improve the nutritional value of enriched white chocolate. The influence of RS on rheological, textural, and thermal properties of the chocolate fat phase was firstly investigated, and then further influence on physical properties, dietary fiber content, and sensory characteristics of enriched white chocolates were investigated. The obtained results showed that enriched chocolates had increased content of total dietary fiber and reduced total fats and protein content in accordance with the added amount of RS. At the same time, RS increased viscosity and reduced the hardness and volume mean diameter in enriched chocolates in accordance with the added amount. RS improved the nutritional composition of white chocolate by increasing the content of dietary fiber. At the same time, RS did not impair the color and sensory characteristics of enriched white chocolates.